Loading vehicle data from NHTSA...
NHTSA recalls, safety ratings, and consumer complaints for the 2012 Ford Expedition.
| Overall Rating | |
| Frontal Crash | |
| Side Crash | |
| Rollover |
| Overall Rating | |
| Frontal Crash |
| Overall Rating | |
| Frontal Crash |
| Overall Rating | |
| Frontal Crash |
Component: POWER TRAIN:AUTOMATIC TRANSMISSION
Ford Motor Company (Ford) is recalling certain model year 2011-2012 Ford F-150 trucks, 2012 Ford Expedition, Lincoln Navigator, and Ford Mustang vehicles. The affected vehicles are equipped with an automatic transmission that may unexpectedly downshift to first gear, regardless of vehicle speed.
Consequence: An unexpected downshift into first gear can cause the vehicle to slow down suddenly without warning and the rear tires may slide or lock, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module with updated software, free of charge. The recall began on September 19, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S19.
Component: POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
FORD IS RECALLING CERTAIN MODEL YEAR 2011-2012 FORD F-150, 2012 EXPEDITION AND LINCOLN NAVIGATOR, AND 2012-2013 MUSTANG VEHICLES, FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NOS. 102, "TRANSMISSION SHIFT LEVER SEQUENCE, STARTER INTERLOCK, AND TRANSMISSION BRAKING EFFECT" AND 108 LAMPS, REFLECTIVE DEVICES AND ASSOCIATED EQUIPMENT. THESE VEHICLES MAY HAVE A TRANSMISSION RANGE SENSOR (TRS) THAT WAS CALIBRATED OUT OF SPECIFICATION FOR REVERSE GEAR.
Consequence: IF THIS CONDITION EXISTS, THE TRANSMISSION MAY NOT GO INTO REVERSE OR WHEN THE DRIVER PUSHES THE SHIFT LEVER IN THE REVERSE R POSITION AND THE VEHICLES TRANSMISSION DOES GO IN REVERSE, THE R MAY NOT ILLUMINATE ON THE DASHBOARD OF THE F-150, EXPEDITION, OR NAVIGATOR MODELS AND/OR THE BACKUP LAMP ON THE REAR OF THE F-150, EXPEDITION, NAVIGATOR, OR MUSTANG VEHICLES MAY NOT ILLUMINATE. THESE CONDITIONS INCREASE THE RISK OF A CRASH OR A PEDESTRIAN BEING STRUCK DUE TO THE VEHICLES NOT SIGNALING IT IS IN REVERSE.
The contact owns a 2012 Ford Expedition. The contact stated that while his wife was driving 30 MPH, the transmission unexpectedly downshifted, causing the occupants to lunge forward. The tires squealed and the wheels locked up. The vehicle was turned off but failed to restart. No warning light was illuminated. The contact stated the failure was associated with NHTSA Campaign Number: 16V248000 (Power Train). A tow truck company was contacted, and was able to restart the vehicle, but the failure persisted. The local dealer was contacted and confirmed that there was no recall coverage associated with the VIN. The vehicle was not diagnosed or repaired. An attempt was made to contact the manufacturer, but there was no response. The failure mileage was approximately 166,000.
While exiting the freeway at approximately 45 to 50 mph, the transmission downshifted to 1st gear locking up the tires.
The speedometer will quit working and the vehicle will not shift out of 1st gear, if you can work through it it will start throwing error messages such as zero miles to empty, tire moniter system fault, etc. This is a very dangerous situation especially in high traffic areas. There was a customer satisfaction program on it but only up to 150,000 miles. This program should last the life of the vehicle, also, if it was fixed before ownership, why did it go bad again
The 2012 Ford Expedition has 3 NHTSA recalls and 116 consumer complaints on file. It received an overall safety rating of 4 out of 5 stars in NHTSA crash testing. The high number of complaints suggests potential reliability concerns — review the complaint details above before purchasing. For the most detailed information about a specific vehicle, decode its VIN using our free decoder above.
Enter a specific VIN to get the full report — specs, recalls, safety ratings, complaints, investigations, and technical service bulletins.
| Side Crash |
| Rollover |
| Side Crash |
| Rollover |
| Side Crash |
| Rollover |
Remedy: FORD WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND REPLACE THE TRS AS NECESSARY, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 11, 2012. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Component: SEATS:MID/REAR ASSEMBLY
FORD IS RECALLING CERTAIN MODEL YEAR 2012 EXPEDITION AND LINCOLN NAVIGATOR VEHICLES, MANUFACTURED FROM NOVEMBER 19, 2011, THROUGH DECEMBER 2, 2011, FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 202, "HEAD RESTRAINTS." THESE VEHICLES MAY HAVE INADEQUATE WELDS ON THE HEAD RESTRAINT SUPPORT BRACKETS FOR THE SECOND ROW, RIGHT-HAND SEAT.
Consequence: IN THE EVENT OF A CRASH, THE SEAT HEAD RESTRAINT MAY NOT PROVIDE THE REQUIRED STRENGTH, INCREASING THE RISK OF INJURY.
Remedy: FORD WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE HEAD RESTRAINTS AS NECESSARY, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 21, 2012. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Over a period of time this problem is occurring more often. The vehicle will downshift into first gear. I pull over check engine light is on. I turn off wait turn back on and no problem for awhile. Within the last month this has occurred many times . Each time the check engine light comes on but also now the advance track light. Each time I have the same codes pulled. Driving on the highway with my daughter at 65mph it downshifted and the back tires locked up . Vehicles had to swerve to miss us. The check engine light was on advance track light same codes pulled. The dealership said it’s not in the recall even though it was built in Jefferson co Kentucky 9/2011. I don’t understand why this vehicle wasn’t recalled . I have to continue to drive it’s my only vehicle. I’m so scared for my life.
The contact owns a 2012 Ford Expedition. The contact stated that the image displayed on the back over prevention screen was either upside down, distorted, static only, or completely black. The failure was intermittent. During the failure, the contact was able to restart the vehicle to fix the image; however, the fix was intermittent. The vehicle was not taken to the dealer. The vehicle was not diagnosed or repaired. The contact researched and found information on NHTSA Campaign Number: 25V270000 (Back Over Prevention); however, the VIN and model year was not included. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 78,000.
I was driving my 2012 expedition and suddenly the vehicle went from doing 60 to 40 immediately the tires squealed and threw me into the right lane . This vehicle transmission has a recall for down shifting and power train issues. My vin number does not fit the Recall but my vehicle has all the symptoms of multiple recalls and is not safe to drive . Had i not known how to drive i and my daughter would be in the hospital due to the faulty transmission lead frame and power train . I contacted Ford head quarters they were no help even though there is clearly a recall . I also took the truck to ford of valparaiso and had to pay the 1,000 dollars for the lead frame to be replaced which was in the recall and I shouldn't have had to pay anything .. them replacing the lead frame did nothing the car is still not drive able and is extremely unsafe its my only vehicle and I am a single mother of 2 kids .
ABS CPU control system. Error Code B1342-EC. Antilock braking system electronic control unit defect.
JULY 2025 MY 2012 FORD EXPEDITION THREW A P0742 CODE FOR A STUCK TORQUE CONVERTER CLUTCH. THE VEHICLE HAD JUST UNDER 150K MILES AND STARTED TO JERK IN AND OUT OF GEAR AND THE WRENCH LIGHT ILLUMINATED SO I, THANKFULLY WAS GOING APPROXIMATELY 45 MPH WHEN IT HAPPENED AND WAS ABLE TO PULL THE VEHICLE OVER AS IT WAS IN LIMP MODE. WHEN I CLEARED THE DTC CODE THE PROBLEM WENT AWAY TEMPORARILY BUT EVENTUALLY LOCKED BACK UP AGAIN WITHIN A MILE FROM MY HOME. UNFORTUNATELY, FORD DEALERSHIPS WILL NOT STAND BEHIND THE CUSTOMER SERVICE NUMBER THAT THEY HAVE LISTED FOR A REPLACEMENT OF THE TRANSMISSION LEAD FRAME. I PROVIDED THE LOCAL DEALERSHIP WITH ALL OF THE NECESSARY INFORMATION AS WELL AS AN INDEPENDENT DIAGNOSIS BY A TRANSMISSION SPECIALIST. LOOKS LIKE I'LL JUST HAVE TO WAIT FOR THE DAY THAT IT CAUSES A MASSIVE ACCIDENT BY DOWNSHIFTING INTO 1ST GEAR AT 65MPH. TERRIBLE CUSTOMER SERVICE AND I CAN ONLY HOPE THIS DOESN'T COST SOMEONE THEIR LIFE.
I just purchased (2 months ago) a 2012 Ford Expedition EL 5.4l v8 from a private party. I wish I would have done more research as I am ALREADY EXPERIENCING TRANSMISSION ISSUES THAT I BELIEVE ARE DIRECTLY RELATED TO THE VEHICLES LEAD FRAME RECALL. IT THREW A P0742 CODE ON ME Torque Converter Clutch Circuit stuck on and decided that it would only drive in limp mode unless I cleared the code, pulled over, cycles the key, and restarted the vehicle. Even as dangerous as this UNEXPECTED SHIFTING INTO 1ST GEAR AT HIGHWAY SPEEDS IS, IT IS EQUALLY AS DANGEROUS TO BE GETTING OUT OF YOUR VEHICLE IN MOVING TRAFFIC DUE TO FORD'S TERRIBLE DESIGN ON THIS VEHICLES POWER TRAIN/TRANSMISSION SYSTEM. I HAVE SCHEDULED AN APPOINTMENT WITH THE LOCAL Ford DEALER AND AL CERTAIN I'LL GET THE RUNAROUND/BLAME GAME FOR THIS ONE. 150K MILES AND AS I said, I HAVE OWNED IT FOR 2 MONTHS AND HAVE ALREADY HAD TRANSMISSION ISSUES, BRAKE ISSUES, BELT TENSIONER PULLEY LITERALLY FELL OFF.. AND FROM WHAT I READ, WHAT'S NEXT??? THE CAM PHASERS?? THAT'S IF THE TRANSMISSION ISSUE IS EVEN FIXED AND IT BECOMES SAFELY DRIVE ABLE AGAIN. COME ON FORD, GET YOUR ACT TOGETHER, YOU'RE BETTER THAN THIS!
Campaign 19N01 Description Transmission molded leadframe extended coverage Next Steps Contact your dealer for next steps. Did this and was told that the vehicle was not covered due to it being after 10 years and barely over 150,000 miles. I am experiencing transmission issues where the torque converter clutch is now stuck on and the lead frame is more than likely the cause. Thanks FORD, NEVER AGAIN.
Transmission failed to engage after startup, and while driving will slip out like its in neutral without warning. There was a series of messages that rolled over and over as the vehicle slowed. When we first took it to have it serviced for this problem June of 2024, they optioned to flush, change the filter, and put in new transmission fluid. They could not reproduce the problem. That seemed to take care of it until May 17, 2025 when it started slipping again. Again, the service center cannot reproduce the problem. The sudden slowdown, puts us in a risk for an accident with other vehicles. The vehicle is available for inspection if needed.
While driving my vehicle, the transmission down shift on its on and the vehicle antilock brakes hit and suddenly stops on its on.
The contact owns a 2012 Ford Expedition. The contact stated while driving 45 MPH, the vehicle started jerking and downshifted unintendedly. The contact stated there were two unknown warning lights illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed that the output speed sensor had failed and needed to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 16V248000 (Power Train); however, the VIN was not included. The dealer was contacted and informed the contact there would be no assistance because the vehicle was out of warranty. The manufacturer was not notified of the failure. The failure mileage was approximately 203,000.
On [XXX] @ [XXX]. I was traveling [XXX] in Logan Co., OK in my 2012 Ford Expedition EL (purchased used Jan. 2020) at an approximate speed of 45 mph when the vehicle downshifted into 1st gear causing a rapid deceleration wherein the vehicle behind me had to take evasive action to avoid rear ending me. The engine rpms climbed significantly while the speedometer stopped working and the vehicle never shifted into any higher gears for the next five blocks wherein I was able to pull my vehicle into a safe place. Again, the vehicle continued only in 1st gear! After turning the vehicle off and letting it sit for a few minutes, it appeared everything had reset and I slowly drove it straight to my mechanics shop. (However, shop was closed until after Memorial Day, so I again drove it slowly back home). Total trip was approximate 12 miles. Issue took place approximate 5 miles from when I left my residence. Ironically, I had visited my mechanic the day before inquiring about an issue wherein the vehicle would beep and a "wrench symbol" would display on the instrument panel and the speedometer and instrument display would stop working. I advised this was the 2nd time that issue occurred within the past few days, however, once the vehicle was turned off and restarted, all seem to be okay. In responding to my inquiry, my mechanic seemed to think it was an instrument cluster issue. That if it persisted, return to have it checked out. Never during any of these two (2) prior occurrences did the vehicle downshift as it did on the [XXX] of May. As an attorney, I began researching potential causes and came across the NHTSA's previous investigation(s) into this issue. However, I am dumbfounded that as serious as this issue is, NO recall has been made. As to me, it is my understanding that Ford's Customer Service Program has even expired regarding fixing this life threatening issue. I am lucky that there was not a semi-truck behind me or it would have been serious. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The transmission jumps in and out of gear, the engine revs on its on. I was on the highway the first time and I going between 60 and 65 mph and it sounded like the whole bottom of the truck was just ripped out, the truck went from drive to either park or first gear it locked up the back tires and there was a truck behind me he tried to miss me but he hit the back passenger side of the truck. He was very very upset he threatening and cussing me because he thought I just slammed on my brakes for no reason. I explained to him what was happening and calmed down think God. It could have killed him or me or even several other people. When it locked up the tires then it jumped back in drive and tried tot take off, I threw it in neutral and cut the key off. That scared the sh.. out of me!! I have talked to other people that have around the same year model truck as mine and some of them are having the same issues with it jumping in and out of gear not wanting to shift gears revving up on its own and no engine light comes on I've tried to get a code scanner scan it no codes come up on the truck Ford needs to fix this truck they had a recall on certain models that were manufactured at different plants or something like that I heard but they won't fix my truck they said it's not under recall this truck is going to kill somebody it's the only truck I have and I have to go to work I'm just asking if you can please do something about this before people get killed in or I get killed I'm going to try to get a video of what it does I'm just asking if you can please do something about this Ford knows what the problem is I read stuff on it and they need to fix these trucks before it kills people they know what the problem is if I have a bad wreck and I live to it or this truck causing somebody to lose their life it's going to be a multi multi multi million dollar lawsuit because they refuse to fix the truck I'm just asking you if you can please do something about this thank you
Showing 15 of 116 complaints