2016 Ford Expedition

Component: BACK OVER PREVENTION: SENSING SYSTEM: CAMERA

Ford Motor Company (Ford) is recalling certain 2015-2019 Lincoln MKC, Mustang, F-350 SD, F-250 SD, F-450 SD, 2015-2017 Lincoln Navigator, Expedition, 2015-2018 Edge, Transit Connect, 2016-2019 F-550 SD, Transit, 2017-2019 Econoline, and 2019 Ranger vehicles. The rearview camera may display a distorted, inverted, or blank image when the vehicle is in reverse.

Consequence: A rearview camera that displays an inverted, distorted, or blank image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.

Remedy: Dealers will inspect and replace the rearview camera as necessary, free of charge. Owner notification letters were mailed January 13, 2026. Ford owners will receive letters in phases, beginning January 2026 and May 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S89. This recall expands previous NHTSA recall number 25V270. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning September 8, 2025.

Full recall detail →

My expedition started stuttering and the speedometer, started fluctuating speeds which would also cause my cruise control to turn off. Then the speedometer quit working altogether and so did the odometer. If I turned the truck off and restarted it, it would reset everything for a few miles then it would start all over again. I went to the Ford dealership and got it fixed. It cost 2500. Later doing research, I discovered this is a problem with this transmission and can be very dangerous as the truck can downshift dramatically which our did once. If I’ve been on ice or pulling my trailer, it could’ve been catastrophic. I feel like this should be a recall. I also feel like Ford should have to pay for this.

The contact owns a 2016 Ford Expedition. The contact stated that while attempting to reverse(R), the rearview camera became inoperable. The contact stated that the rear-view camera image failed to function properly and appeared blurry and intermittently failed to operate as intended. The vehicle was taken to the dealer where it was diagnosed and determined that the camera module had failed and needed to be replaced. The vehicle was repaired; however, the failure reoccurred. The contact received notification of NHTSA Campaign Number: 25V572000 (Back Over Prevention); however, the part to do the recall repair was not yet available. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The approximate failure mileage was 200,000.

The contact owns a 2016 Ford Expedition. The contact received notification of NHTSA Campaign Number: 25V572000 (Back Over Prevention); however, the part to do the recall repair was not yet available. The local dealer was contacted and confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

The contact owns a 2016 Ford Expedition. The contact received notification of NHTSA Campaign Number: 25V572000 (Back Over Prevention); however, the part to do the recall repair was not yet available. The contact stated that while shifted into reverse(R), the rearview camera failed to display a clear image on the screen. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 80,000.

The contact owns a 2016 Ford Expedition. The contact stated that while attempting to reverse, the rearview camera became inoperable. The contact stated that the rearview camera image intermittently operated as needed. There was no warning light illuminated. The contact received notification of NHTSA Campaign Number: 25V572000 (Back Over Prevention); however, the part to do the recall repair was not yet available. The dealer was contacted; however, the vehicle was not diagnosed or repaired. The dealer informed the contact that parts were not yet available for the recall repair. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The approximate failure mileage was 117,000.

The contact 2016 Ford Expedition. The contact stated that while reversing, the rear-view camera displayed a foggy image. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact received notification of NHTSA Campaign Number: 25V572000 (Back Over Prevention); however, the part to do the recall repair was unavailable. The manufacturer was not made aware of the failure. The failure mileage was approximately 50,000.

The failed components are called "cam phasers." It is a known problem with the Ford 3.5 Ecoboost Engine (that even Ford is aware of). The cam phasers can fail, causing the timing chain to fail at any moment. They rattle upon startup of a cold engine. The failure of the original engineering is causing owners of this vehicle, along with the F150 and others, to have to spend anywhere from $3,000 to $5,000 in order to replace these. The problem has been confirmed by the Ford dealer. In order to visually examine the cam phasers, it requires something like 10+ hours to open the engine. You do not receive a warning light to replace cam phasers. It is merely an audio diagnosis. Ford SHOULD BE RESPONSIBLE for replacing these free of charge and replacing them with the newer versions of cam phasers, which apparently don't fail. Driving around with rattling cam phasers can leave you stranded!

The contact owns a 2016 Ford Expedition. The contact stated that while reversing at an undisclosed speed, the rearview camera was intermittently inoperative. While driving at an undisclosed speed, the accelerator pedal was depressed, and there was an abnormal sound coming from the engine compartment. The contact received notification of NHTSA Campaign Number: 25V572000 (Back Over Prevention); however, the part to do the recall repair was not yet available. The vehicle was taken to a dealer, where it was diagnosed and determined that the engine fan needed to be replaced; however, parts were not available for the repairs. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was unknown.

Rear-view camera is intermittently failing and often completely inoperative. Vehicle is under an active Ford safety recall for the rear-view camera, but there is currently no remedy available. The failure occurs while reversing and eliminates rear visibility, creating a clear safety risk of collision or injury to pedestrians or property. The issue has persisted without resolution despite the active recall. This vehicle is regularly driven and the defect materially impacts safe operation.

The contact owns a 2019 Ford Expedition. The contact received notification of NHTSA Campaign Number: 25V572000 (Back Over Prevention); however, the part to do the recall repair was not yet available. The contact stated that occasionally, while shifted into reverse, the rear-view camera intermittently failed to display a clear image, and the screen was black. An unknown message was displayed. The local dealer was contacted; however, parts for the recall repair were not yet available. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 144,000.

Rear camera is inoperable or intermittent. It has been for over a year. Ford finally issued a recall notice I believe in September 2025. They have still not corrected the problem or even sent a letter confirming when it will be completed. I feel there should be reasonable time limit for them to repair my car.

I receive a recall 22S56 for the climate control blower motor it was replaced under warranty on 12/17/2024 about a year latter I noticed blower stopped working on 12/13/2025 coming from San Francisco because visibility was affected when defroster stopped working, then I called dealer on 12/23 /25 and they gave me an appointment for them see the vehicle, I asked then to repaired under recall warranty and dealer denied it. dealer saying is something else o not related. I called manufacturer stating the safety concern that defroster been affected because blower not working and they said its been a year and they can not help, now blower some times works, other times does not work or works very slow. Ford manufacturer open a case number CXH-XXX. I am reporting for Ford to extend warranty on the recall. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

When merging on the highway in the rain the vehicle locked up on me and almost killed me. I could have been seriously injured I could not stop the car and it slid along the highway at high speeds . Luckily was able to get to the shoulder