1996 Ford Econoline

Component: VEHICLE SPEED CONTROL:CRUISE CONTROL

FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.

Consequence: AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.

Remedy: DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.

Full recall detail →

Component: PARKING BRAKE:CONVENTIONAL

THE PARKING BRAKE SYSTEMS MAY NOT HOLD THE VEHICLES ON A 20% GRADE WITH FOOT PEDAL EFFORTS OF 125 POUNDS OR LESS. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 105, "HYDRAULIC BRAKE SYSTEMS."

Consequence: THE VEHICLE MAY ROLL AFTER BEING PARKED INCREASING THE RISK OF A VEHICLE ACCIDENT.

Remedy: DEALERS WILL ADJUST THE PARKING BRAKE SYSTEM ON THE AFFECTED VEHICLES.

Full recall detail →

THIS ISSUE WAS ON A 1996 FORD F350 AMBULANCE ON ROUTE TO EMERGENCY CALL WHEN ENGINE SHUT DOWN AND LOST ALL POWER LIKE IT WAS OUT OF FUEL 7.3 LITER DIESEL AND TANK WAS FULL. HAD UNIT TOWED TO CROSS WOOD FORD IN KERNERSVILLE NC AND $2700.00 LATER AFTER NEW FUEL TANK FUEL PUMP 6 INJECTORS AND TURBO DUE TO LINER INSIDE OF TANK CAME OFF AND CLOGGED THE FUEL SYSTEM AND ENGINE FORD MOTOR COMPANY WAS NO HELP AND SAID SINCE THE VEHICLE WAS OUT OF WARRANTY THEY WOULD NOT DO ANYTHING TO RESOLVE THE COST ISSUES. *TR

VEHICLE WAS PARKED, AND UPON ENTERING NOTICED THE SMELL OF AN ELECTRICAL FIRE. STARTED THE VEHICLE, ODOMETER WAS INOPERABLE AND VEHICLE WOULD NOT SHIFT OUT OF PARK. UPON FURTHER INSPECTION, FOUND A BLOWN 15 AMP FUSE IN THE FUSE PANEL. REPLACED FUSE, ODOMETER CAME BACK ON AND VEHICLE SHIFTED OUT OF PARK. APPROXIMATELY 10 SECONDS LATER, THE SMELL OF BURNING WIRING WAS EVIDENT, AS WAS SMOKE FROM UNDER THE HOOD. PULLED THE FUSE BACK OUT, OPENED THE HOOD TO FIND THE BRAKE PRESSURE SWITCH ON FIRE, WHICH MELTED THE BRAKE FLUID RESERVOIR AS WELL AS THE BATTERY CASING ALSO. *TR

DRIVERS SIDE SEAT BELT LATCH DOES NOT LOCK. *TR

TL* THE CONTACT OWNS A 1996 FORD ECONOLINE. THE CONTACT STATED THE DOOR LATCH WOULD NOT RELEASE OPEN IN ORDER TO GAIN ACCESS OR EXIT THE VEHICLE DUE TO THE FAULTY DOOR CABLE. THE FAILURE INVOLVED BOTH SIDE DOORS AND REAR DOOR. THE CONTACT PURCHASED THE DOOR CABLE KIT AND PERFORMED THE REPAIR HIMSELF. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 50,000. UPDATED 01/20/12*LJ THE CONSUMER STATED THERE WAS A FLAW IN THE MECHANICS THAT OPERATES THE DOORS THAT CAN BECOME INOPERABLE WITHOUT WARNING. THE CABLES OPERATING THE LATCHES CAN AND DO FAIL BECAUSE THEY ARE MADE OF VINYL AND IN TIME FAIL. UPDATED 01/20/12

A CHROME COLOR GRILLE ABOUT 2.5 FEET WIDE AND 6" TALL FLEW OFF THE FRONT OF OUR 1996 F150 FORD VAN WHILE WE WERE DRIVING AT HIGHWAY SPEED. I NOTICED OTHER SIMILAR FORD VANS THAT HAVE ALSO LOST THE SAME FRONT GRILL PART. WE WERE GOING 55 MPH DOWN A 2 LANE HIGHWAY AND A LARGE TRUCK WAS GOING THE OTHER WAY. THE GUST OF AIR FROM THE PASSING TRUCK WAS SUFFICIENT TO TEAR OFF THE GRILL PART AND CAUSE IT TO FLY OVER THE TOP OF OUR VAN. *TR

DISCOVERY OF CRACKED FRONT ROTORS ON MY 1996 E-350 MOTORHOME. FIRST CRACKED ROTOR FOUND IN MAY 2007 WITH 35,000 MILES ON VEHICLE. SECOND CRACKED ROTOR FOUND IN SEPTEMBER 2009 WITH 41,000 MILES ON VEHICLE. *TR

TL*THE CONTACT OWNS A 1996 FORD E-150. WHENEVER THE CONTACT STARTS THE ENGINE AND DEPRESSES THE ACCELERATOR PEDAL, THE ENGINE BECOMES STUCK AT A HIGH RPM AND WILL NOT RETURN TO THE IDLE POSITION. THE FAILURE CAUSES THE VEHICLE TO EITHER SURGE FORWARD OR BACKWARDS DEPENDING ON WHAT GEAR IT IS IN AT THE TIME. THE ENGINE HAS TO BE TURNED OFF IN ORDER TO RESTORE THE VEHICLE TO A PROPER SPEED. IN ADDITION, THE BRAKES DO NOT HOLD OR STOP THE VEHICLE WHEN THEY ARE ENGAGED. THE FIRST TIME THIS FAILURE OCCURRED, THE VEHICLE CRASHED INTO A TREE AT 10 MPH. THERE WERE NO INJURIES; HOWEVER, THE REAR WINDOW WAS DAMAGED. THROUGH RESEARCH, THE CONTACT FOUND NUMEROUS ISSUES WITH THIS DEFECT ON THE SAME MAKE AND MODEL VEHICLES. THE VEHICLE WAS TAKEN TO A REPAIR SHOP TWICE. DURING THE FIRST VISIT, THE MECHANIC CLEANED OUT THE ENGINE, ENGINE THROTTLE, AND CABLES. THE FAILURE WAS CORRECTED FOR TWO MONTHS BEFORE IT RECURRED AGAIN. DURING THE SECOND VISIT, THE VEHICLE WAS TOWED TO THE SHOP AND THE MECHANIC CHECKED TO MAKE SURE THAT EVERYTHING WAS LUBRICATED PROPERLY. THE SHOP DID NOT GUARANTEE THAT THE FAILURE WOULD NOT RECUR. THE CONTACT BELIEVES THAT A RECALL SHOULD BE ISSUED. THE FAILURE MILEAGE WAS 150,000 AND CURRENT MILEAGE WAS 152,000.

FIRST MY ENGINE SEEMED TO OVERHEAT A BIT THEN EVERY ONCE IN A WHILE IT WOULD SOUND LIKE THE ENGINE WAS GRINDING ON SOMETHING AND WOULDN'T STOP.. SOUNDED LIKE A BUNCH OF CHAINS IN MY HOOD. BUT THEN ON OCCASIONS THE STUPID THING WOULDN'T SHUT OFF WHEN IT WAS MAKING THE CHAIN SOUND, EVEN WITH MY KEY OUT. IT JUST HAPPENED AGAIN AND NOW THE THING SMELLS LIKE SOMETHING IS BURNING AND I HAVE NO POWER WHAT SO EVER IN MY VEHICLE. BEFORE WHEN IT FINALLY SHUT OFF IT SOUNDED LIKE IT WAS ABOUT TO SPARK. THEN IT WAS MAKING A CLICKING NOISE THAT WASN'T COOL. *TR

I WAS STOPPED AT AN INTERSECTION WITH TRUCK IN GEAR AND CLUTCH PEDAL DOWN, ALL OF A SUDDEN THE CLUTCH RELEASED WITH THE PEDAL STILL DOWN CAUSING THE TRUCK TO LURCH INTO THE STREET ABOUT 15 FT BEFORE I COULD STOP WITH THE BRAKES. THE CARS IN THE STREET WERE ABLE TO AVOID ME BUT I WAS VERY SHAKEN. I FOUND THE PROBLEM WAS THE "CLUTCH ROD END PLASTIC BUSHING AND RETAINER" HAD FAILED ALLOWING THE CLUTCH TO RELEASE WITHOUT THE PEDAL. THIS WAS REPLACED BUT FAILED AGAIN 6 MONTHS LATER. FORTUNATELY I ALWAYS KEEP THE TRUCK IN NEUTRAL WHEN STOPPED NOW SO IT WAS ONLY AN INCONVENIENCE. CHECKING THE INTERNET FOR A FIX I FOUND SEVERAL COMPANIES THAT MAKE A REPLACEMENT ASSEMBLY FOR THIS BECAUSE OF ALL THE FAILURES. I HAVE BEEN KEEPING THE "ROD END" IN PLACE WITH WIRE AND ALWAYS KEEP IN NEUTRAL TO PREVENT ANOTHER FAILURE BUT HAVE ORDERED A REPLACEMENT ASSEMBLY AN EBAY COMPANY TO PREVENT THIS VERY DANGEROUS FAILURE FROM HAPPENING AGAIN. WHY HASN'T FORD NOTIFIED ANYONE ABOUT THIS POSSIBLE CATASTROPHIC AND LIFE THREATENING FAILURE AND AT LEAST SUPPLIED PARTS TO FIX THIS CORRECTLY. *TR

THERE IS A PRESSURE SWITCH ON MY MASTER CYLINDER OF THE BRAKING SYSTEM. THERE IS O LISTED RECALL FOR MY PICKUP TRUCK HOW EVER AFTER ABOUT $900.00 AND 2 DIFFERENT AUTO SHOPS I FOUND THIS SWITCH TO BE THE DEFECTIVE PART AND WHEN I WENT TO THE DEALER JIM CLICK OF TUSCON AZ AND THE PARTS GUY GAVE ME THE PART I REQUESTED I QUESTIONED THE WIRING HARNESS ADAPTOR AND WHY THE SWITCH WAS NOT THE SAME AS I BROUGHT HIM. HE STATED WELL THERE WAS A LOT OF FAILURES WITH THE OLD DESIGN AND IT WAS A RECALL I STATED WELL SHOULDN'T THE PART BE FREE NO RESPONSE - - THE DEFECT IN THE PART WAS AN AIR LEAK CAUSING ME TO CHASE IT FOR A YEAR ON AND OFF CONSTANTLY BLEEDING LITTLE AIR BUBBLES OUT WITH OVER A GALLON OF FLUID. I NOTICED IT WITH JUST THE EVER SO SLIGHT OF DIRT STICKING TO THE LEAK ON THE UNDER SIDE OF SWITCH WHICH COULD NOT BE SEEN. THIS LEAK RESULTED IN A CONSTANTLY SOFT PEDAL WITH A ABOUT A 1-2 SECOND BRAKING DELAY. I CHECKED TO FORD SITE AND THE ONLY EXISTING RECALL IS A SPEED SENSOR. NOT FOR THIS PART. *TR

TL*THE CONTACT OWNED A 1996 FORD ECONOLINE. THE CONTACT STATED THAT THE VEHICLE CAUGHT FIRE ON JANUARY 14, 2008 WHILE PARKED IN THE DRIVEWAY. SMOKE APPEARED FROM THE ENGINE AND FRONT PASSENGER SEAT. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE AND FILED A REPORT. THE VEHICLE WAS DESTROYED. THE CONTACT RECEIVED FORD RECALL NOTICE NUMBER 05S28 THE FIRST WEEK IN MAY OF 2008. THE CURRENT AND FAILURE MILEAGES WERE 122,000.

TL*THE CONTACT OWNS A 1996 FORD ECONOLINE. THE CONTACT RECEIVED A SAFETY RECALL NOTICE FOR THE VEHICLE SPEED CONTROL:ACCELERATOR PEDAL IN FEBRUARY OF 2008. SINCE THAT TIME, HE HAS CALLED THE DEALER FIVE TIMES AND WAS INFORMED TO CALL BACK THE FOLLOWING WEEK. ON APRIL 2, 2008, HE WAS INFORMED TO CALL BACK IN AUGUST. THERE HAD BEEN NO FAILURE TO DATE. THE PURCHASE DATE, POWERTRAIN, AND RECALL NUMBER WERE UNKNOWN. THE CURRENT MILEAGE WAS 124,000. UPDATED 04/16/08 *BF UPDATED 04/16/08 *TR