2012 Volkswagen EOS

Component: AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2010-2014 Golf, 2007-2010 Passat sedans and wagon, 2012-2014 Passat sedan and Eos, 2009-2014 CC, 2009-2012 Audi Q5, 2010-2012 S5 Cabriolet and 2010-2012 Audi A5 Cabriolet vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to rupture.

Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.

Remedy: Volkswagen will notify owners, and dealers will replace the driver's frontal air bag inflators, free of charge. Volkswagen issued an interim notification to owners on April 12, 2016, and will send a second notification when parts are available. Volkswagen will notify owners again once parts are available. Volkswagen owners may contact Volkswagen customer service at 1-800-893-5298. Audi owners may contact Audi customer service at 1-800-253-2834.

Full recall detail →

Component: AIR BAGS:FRONTAL

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2010-2014 Volkswagen CC, and Passat, 2010-2013 Eos, 2011-2014 Golf, GTI, Jetta, and Tiguan, and 2012-2014 Jetta Sportwagen vehicles. In the affected vehicles, debris may contaminate the air bag clock spring, a spiral wound, flat cable that keeps the air bag powered while the steering wheel is being turned. This contamination may tear the cable and result in a loss of electrical connection to the driver's frontal air bag.

Consequence: A loss of electrical connection to the driver's frontal air bag will prevent the air bag from deploying in the event of a vehicle crash, increasing the risk of injury.

Remedy: Volkswagen will notify owners, and dealers will install a protective cover over the steering wheel clock spring if the air bag light is off. If the airbag light is on and the steering wheel clock spring requires replacement, dealers will install a new steering wheel clock spring. These repairs will be performed free of charge. The recall began on January 15, 2016. Owners may contact Volkswagen customer service at 1-800-822-8987.

Full recall detail →

Due to the cold weather I turned on the driver heated seat. I suddenly started feeling it extremely hot, I was wearing a quilted sweater. When I arrived at my work a coworker noticed that my sweater was burned from the back, it had a hole. Then I saw that the seat was burnt due to the extreme heat, the seat melted, it had three small holes and one bigger. I am just concerned that my car could’ve burned while I was driving, due to the malfunction of the heated seats.

My car goes into a false neutral and shifts out of gear while driving. The "PRNDS" indicator on dash had a blinking "D" alternating with a wrench. I have to come to a complete stop turn the car off and right back on and it goes away for about 5-10 minutes only to reoccur. This started happening when weather became hot, and only occurs after driving for an hour or more. Only when hot outside. I performed transmission fluid service with no resolve. There was no debris in the old fluid to indicate mechanical issues. I also get error code P2711- "unexpected mechanical failure". This has almost caused me to wreck several times putting my life and others at risk until I turn car off and immediatly restart engine which allows normal operation for a few minutes. It doesn't operate normally until car cools down. My engine is not overheating. My transmission fluid, and coolant services are current. NHTSA safety recall 09V333000 addressed this exact same issue on 20 August 2009 but it only covers model years 2009 and 2010. This is still a well known problem for the VW DSG transmission experienced by many others. VW said that they couldn't help me even though it's the same issue because my car is a 2012, and it only covers 2009-2010? I am a Disabled Veteran with a heart condition and can't afford to be on the side of the road in the heat without severe health issues.

The vehicle has 37444 miles on it and the front driver side coil spring was laying broken off partially by the front wheel well when I went to move vehicles around (The vehicle was sitting, not driving when the coil broke, which really is curious). I reported the issue to VW customer care tonight (9/6/22) and they said that it was outside of warranty-Essentially nothing they could do. The complaint number is 05384519, and the rep I spoke with is named Tara. This is not something that should happen with a front coil spring (maybe sagging at 100k+) and seems indicative of bad heat treat. There are other complaints filed with NHTSA regarding this same issue on VWs of the same era. If this had happened while driving, it could’ve caused a catastrophic failure and a pretty significant accident if the tire was hit.

While my wife was exiting off of I-75 approaching the traffic light to turn left, the sun roof exploded into pieces. Large and small pieces of glass were scattered throughout the car. The approximate speed was 40 MPH. Luckily she was not hurt or got any glass in her eyes. My name is [XXX] (Husband) and cell phone # is [XXX]. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

The motor abruptly shut off while driving. Within 20 seconds the inside of the car filled with smoke and shortly thereafter there were visible flames seen through the front grill. Fire spread and fully engulfed the car. Flames extended 20 feet. Fire dept and police responded. The vehicle was a total loss.

00927 - Terminal 30 (Right) 011 - Open Circuit 01516 - Terminal 30; Left 011 - Open Circuit - Intermittent I believe this is a major fire hazard and also will leave you stranded. Based on the codes and physical condition of the issue apparently many other people have had the same problem. http://wiki.ross-tech.com/wiki/index.php/00927_-_Terminal_30_(Right) The noticeable thing is the A/C turns off and once the car is turned off you will not be able to lock the doors or turn the car back on.

Broken front coil spring. It is available for inspection Broken spring can dislodge potentially causing a tire rupture and steering issue Also occurred on my other previously owned 2012 VW Eos where both front coil springs broke within 6 mo. of each other. That vehicle had around 60K miles. No No

VW RECALL69L2 AIRBAG -CLOCK SPRING FAILURE NHRSA CAMPAIN #15V483000

TIMING BELT ADJUSTER FAILED, LOST OIL PRESSURE AND AND DAMAGED VALVES. THE ENGINE NEEDS TO BE REPLACED. 69664 MILES.

I BOUGHT THE VEHICLE ON 02/15/2013 IT ONLY HAVE 10,000 MILES ON IT. THEN AS SOON AS IT HIT 68,500 MILES AND WENT OUT OF WARRANTY. I HAD JUST HAD IT SERVICED FOR THE LAST TIME UNDER WARRANTY ON 6/21/2019 AT 67,996 MILES. THE TIMING CHAIN SNAPPED AND BENT ALL THE VALVES. I HAD TO REBUILD THE ENGINE. WHICH COASTED A FORTUNE. I SAW THAT THEIR WERE A BUNCH OF CLASS ACTION SUITES GOING ON AGAINST VOLKSWAGEN FOR SIMILAR ISSUE BUT WAS DEALING WITH A FAMILY CRISIS THAT ENDED POORLY AND WENT INTO A STATE OF DEPRESSION FROM THE DEATH OF MULTIPLE FAMILY MEMBERS BACK TO BACK SO I NEVER FOLLOWED UP ON IT. NOW MY CAR IS AT 80,000 MILES AND SEEMS TO BE EXPERIENCING ELECTRICAL PROBLEMS AS WELL AS PROBLEMS WITH THE CD PLAYER IT PROGRESSED AND NOW ALL DISK SPACES SAY ERROR AND I CANT PLAY CDS. WHEN I COULD GET IT WORKING IT WAS FINE UNTIL TURNING OFF THE CAR THEN OPENING THE DOOR I HEARD NOISES FROM THE PLAYER WHEN STARTING THE CAR IT SAYS ERROR IN ALL THE DISK SPACES AND HALF THE TIME WONT EVEN LET ME LOAD THE DISK. THIS IS RIDICULOUS. THIS CAR IS MY BIGGEST REGRET OF MY LIFE. ITS A NIGHT MARE THERE HAVE BEEN MORE ISSUES BUT THESE ARE THE BIGGEST AND MOST RECENT ISSUES.

WHILE DRIVING A 2012 VW EOS, THE ENGINE STUMBLED AND UNLOADED TONS OF SMOKE OUT OF THE REAR OF THE CAR. THIS INCIDENT OCCURRED WHILE DRIVING THE CAR AT A HIGH RATE OF SPEED AND CAUSED A DANGEROUS SITUATION. THE DEALERSHIP REPLACED THE DEFECTIVE FUEL INJECTOR, WHICH HAPPENS TO BE UNDER WARRANTY FOR 120,000 MILES. THE ISSUE I HAVE IS THAT VW WILL NOT PROACTIVELY REPLACE THE DEFECTIVE FUEL INJECTORS, POTENTIALLY CAUSING 3 MORE DANGEROUS SITUATIONS. ADDITIONALLY, WHEN A FUEL INJECTOR FAILS THERE IS A HIGH PROBABILITY OF A CATALYTIC CONVERTER FAILURE DUE TO THE ENGINE MISFIRE. THIS HAPPENED TO ME AND VW WOULD NOT COVER THE FAILURE OF THE CATALYTIC CONVERTER - WHICH SEEMS UNFAIR, ESPECIALLY IN LIGHT OF VW'S ISSUE WITH ITS RECENT EMISSION SCANDAL. I HAD 2 INDEPENDENT MECHANICS VERIFY THE IMPACT A FAILED FUEL INJECTOR HAS, YET MY VOLKSWAGEN DEALERSHIP DID NOT AGREE MINE WAS CAUSED BY A FAILED INJECTOR.

TAKATA RECALL. RECALLED OCTOBER 2018 FOR REPLACING THE AIRBAG UNIT, RECALL COMPLETED. IN NOV. DEC. 2018 RECEIVED PHONE CALLS TELLING US THE WRONG PART HAD BEEN FITTED AND WE SHOULD RETURN TO THE DEALER JOSEPH VW 3813 MONTGOMERY ROAD, CINCINNATI OHIO 45212. RETURNED CAR TO DEALER WHO AFTER 2 1/2 HOURS COULD NOT GET THE WRONG PART OFF. DEALER TO CONTACT VW FOR INSTRUCTIONS. CAME BACK NEXT DAY TO COLLECT THE CAR. I FOUND THAT BACK IN OCTOBER A NEW AIR BAG ASSEMBLY HAD BEEN FITTED WHICH WAS THE CORRECT PART. THE WRONG PART WAS INFACT THAT ONLY A NEW IGNITER WAS TO BE FITTED. THE DEALER CLAIMED HE HAD KEPT THE OLD AIRBAG ASSEMBLY, REMOVED THE NEW ASSEMBLY FROM THE VEHICLE AND CHANGED THE IGNITER FROM THE NEW ASSEMBLY TO THE OLD ASSEMBLY AND REINSTALLED THE OLD ASSEMBLY. THE PROBLEM WAS THAT THE MECHANIC COULD NOT GET THE PART OFF WHICH WAS STUCK TO THE ASSEMBLY. TO REINSTALL THE NEW IGNITER IT NEEDED MODIFICATION WHICH THE MECHANIC UNDERTOOK AND REPLACED WITH AN UNCALIBRATED TORQUE WRENCH. I REFUSED TO SIGN THE ORIGINAL INVOICE AND ONLY SIGNED WHEN I CORRECTED THE WORDING. MY WIFE WHO DRIVES THE CAR IS CONCERNED THAT THIS MIS MATCH OF MODIFIED PARTS IS STILL LESS THAN 100% SAFE AND WILL NOT DRIVE OUR GRANDCHILDREN TO AND FROM SCHOOL. *TR THE DEALER STATED THAT THEY WOULD REPLACE THE AIRBAG AT NO CHARGE TO THE CONSUMER. *TR*JS