2021 Jeep Wrangler

Component: FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

Chrysler (FCA US, LLC) is recalling certain 2020-2022 Jeep Wrangler, Ram 1500, and 2021-2022 Jeep Gladiator vehicles equipped with 3.0L diesel engines. The high pressure fuel pump (HPFP) may fail, causing an engine stall.

Consequence: An engine stall can increase the risk of a crash.

Remedy: Dealers will replace the HPFP and inspect and replace additional fuel system components, as necessary, free of charge. Owner notification letters were mailed October 17, 2023. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is Z96.

Component: ENGINE

Chrysler (FCA US, LLC) is recalling certain 2021-2023 Jeep Wrangler 4xe vehicles equipped with 2.0L Plug-In Hybrid Electric Vehicle engines. A loss of communication may cause an engine shutdown.

Consequence: An engine shutdown can cause a loss of drive power, increasing the risk of a crash.

Remedy: There is more than one involved component and calibration software. Updating the calibration software in the Transmission Control Module, Hybrid Control Processor and Auxiliary Hybrid Control Processor that changes fail safe from shut down to limp home. Dealers will update the transmission control module software, Hybrid Control Processor and Auxiliary Hybrid Control Processor, free of charge. Owner notification letters were mailed December 22, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall ZB7.

Component: POWER TRAIN:CLUTCH ASSEMBLY

Chrysler (FCA US, LLC) is recalling certain 2018-2023 Jeep Wrangler, and 2020-2023 Jeep Gladiator vehicles equipped with manual transmissions. The clutch pressure plate may overheat and fracture.

Consequence: Overheated clutch components may increase the risk of a fire. Additionally, damage to other nearby components can result in debris falling onto the road or a loss of drive, increasing the risk of a crash.

Remedy: Dealers will replace the clutch assembly and update the software, free of charge. Owner notification letters were mailed from November 16, 2023 through July 25, 2024. Owners may contact (FCA US, LLC) customer service at 1-800-853-1403. FCA US LLC's number for this recall is 19A. This recall expands and replaces previous recall 21V-028. Vehicles previously repaired under recall 21V-028 will need to have the new remedy completed.

Component: STRUCTURE:FRAME AND MEMBERS

Chrysler (FCA US, LLC) is recalling certain 2020-2022 Jeep Wrangler vehicles. A stud on the frame assembly may puncture the fuel tank in a crash, which can result in a fuel leak.

Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire.

Remedy: Dealers will inspect and, if necessary, remove the frame stud and apply paint, free of charge. Owner notification letters were mailed April 6, 2023. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 28A.

Component: FUEL SYSTEM, DIESEL:DELIVERY:FUEL PUMP

Chrysler (FCA US, LLC) is recalling certain 2021-2023 Jeep Wrangler, Gladiator, and 2022-2023 Ram 1500 vehicles equipped with a 3.0L diesel engine. The high pressure fuel pump (HPFP) may fail.

Consequence: Fuel pump failure can result in an engine stall, increasing the risk of a crash.

Remedy: Dealers will replace the HPFP and replace additional fuel system components, as necessary, free of charge. Owner notification letters were mailed October 17, 2023. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 01A.

Component: ELECTRICAL SYSTEM:PROPULSION SYSTEM:TRACTION BATTERY

Chrysler (FCA US, LLC) is recalling certain 2021-2023 Jeep Wrangler Plug-In Hybrid Electric (PHEV) vehicles. The high voltage battery may fail internally and lead to a vehicle fire while parked or driving.

Consequence: A vehicle fire while parked or driving can increase the risk of injury.

Remedy: Owners are advised not to recharge their vehicles, and to park outside and away from structures, until they are repaired. Dealers will update the high voltage battery pack software and replace the battery pack assembly if necessary, free of charge. Owner notification letters were mailed March 7, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 89A. This recall is superseded by NHTSA Recall 24V-720.

Component: VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM

Chrysler (FCA US, LLC) is recalling certain 2021-2024 Jeep Wrangler and 2022-2024 Jeep Grand Cherokee vehicles. A hybrid control processor (HCP) software error may cause the defrosting and defogging system to be inoperative. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 103, "Windshield Defrosting and Defogging Systems."

Consequence: An inoperative windshield defrosting and defogging system may decrease the driver's visibility, increasing the risk of a crash.

Remedy: Dealers will update the HCP software, free of charge. Owner notification letters were mailed February 29, 2024. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is 04B.

Component: POWER TRAIN:MANUAL TRANSMISSION:CONTROL MODULE:SOFTWARE

Chrysler (FCA US, LLC) is recalling certain 2021 Jeep Wrangler and Jeep Gladiator vehicles that were previously remedied under NHTSA recall number 23V-116. The software for the powertrain control module may cause an engine stall, which can result in a loss of drive power.

Consequence: A loss of drive power increases the risk of a crash.

Remedy: Dealers will update the powertrain control module software, free of charge. Owner notification letters were mailed August 15, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US LLC's number for this recall is 92B. Vehicles previously repaired under recall 23V-116 will need to have the new remedy completed.

Component: ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

Chrysler (FCA US, LLC) is recalling certain 2020-2024 Jeep Gladiator and 2018-2024 Jeep Wrangler vehicles. The instrument panel cluster may experience an internal short circuit and fail. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 101, "Controls and Displays."

Consequence: An instrument panel that fails to display critical safety information, such as the speedometer or warning lights, can increase the risk of a crash.

Remedy: Dealers will replace the instrument panel cluster, free of charge. Owner notification letters were mailed between October 3, 2024, and January 23, 2025. Owners may contact FCA customer service at 1-800-853-1403. FCA's number for this recall is 30B.

Component: BACK OVER PREVENTION: SENSING SYSTEM: CAMERA

Chrysler (FCA US, LLC) is recalling certain 2018-2024 Jeep Wrangler vehicles. The wiring harness for the rearview camera and the center brake light may short circuit, which can disable the rearview camera image and center brake light. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 111, "Rear Visibility" and 108, "Lamps, Reflective Devices, and Associated Equipment."

Consequence: A rearview camera image that does not display decreases the driver's visibility, increasing the risk of a crash. Additionally, a center brake light that fails to illuminate can fail to indicate to other drivers that the vehicle is slowing down, increasing the risk of a crash.

Remedy: Dealers replaced the harness for the center brake light and rearview camera and/or the spare tire carrier/harness assembly, as necessary, free of charge. All vehicles were repaired by January 15, 2024. Owner notification letters were mailed September 26, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 77B.

Component: ELECTRICAL SYSTEM:PROPULSION SYSTEM:TRACTION BATTERY

Chrysler (FCA US, LLC) is recalling certain 2020-2025 Jeep Wrangler 4Xe and 2022-2026 Grand Cherokee 4Xe vehicles. The high voltage battery may fail internally and lead to a vehicle fire while parked or driving.

Consequence: A vehicle fire can increase the risk of injury.

Remedy: Owners are advised to park outside and away from structures and not to charge their vehicles until the remedy is completed. Dealers will update the high voltage battery software, and replace the high voltage battery, as necessary, free of charge. Some owner notification letters were mailed beginning December 17, 2025. The remaining owner notification letters will be mailed at a later date. Owners may contact Chrysler customer service at 800-853-1403. Chrysler's number for this recall is 68C. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning November 6, 2025. Vehicles that were previously recalled for the same issue under NHTSA Recalls 24V720 and 23V787 will need to have the new remedy performed.

What component or system failed or malfunctioned, and is it available for inspection upon request? -After the 68C recall update for the HV battery failures, the vehicle has not been able to consistently maintain or provide power due to the limitation of the battery introduced as part of the recall. This is most noticeable driving in Electric Mode below 60% charge. The throttle behavior is inconsistent and unpredictable due to the recent updated How was your safety or the safety of others put at risk? -I was merging onto a controlled access highway and unable to accelerate after pulling into the travel lane from the merging lane due to the limitations of the battery power. The engine did not respond in time to provide power to the vehicle. The occurrence of the loss of power is unpredictable. Some times the electric battery and motor can provide the necessary power, and in others it does not respond to the throttle demand at the same state of charge with no indication of the issue. Has the problem been reproduced or confirmed by a dealer or independent service center? -It has not yet Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? -It has not Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? -No warning lamps were provided

A recall repair was completed in 2023 related to an overheating warning. Recently, the same issue has returned. The engine cooling fan runs at a very high speed for several minutes and then shuts off, even when the vehicle is cold or operating under normal conditions. An overheating warning message appeared briefly while driving, but the temperature gauge remained within the normal range. This suggests the engine may not actually be overheating and that the issue may be related to a faulty sensor, electrical system, or control module. The problem has not yet been fully diagnosed by a dealer due to diagnostic costs, but the symptoms are consistent with the original issue that led to the recall repair. This condition could pose a safety risk because the driver may receive inaccurate overheating warnings or may not be alerted if a real overheating condition occurs. The issue is intermittent and has occurred both while driving and when the vehicle is stationary. Attempts were made to contact the manufacturer to report this as a repeat issue after a recall repair, but no resolution was provided and a formal case was not successfully established.

The high-pressure fuel pump (HPFP) failed internally while I was driving at night, causing the vehicle to suddenly stall and shut off completely while my children were in the vehicle. This resulted in an immediate loss of power and created a dangerous situation in traffic. The failure caused metal debris to spread throughout the entire fuel system, and the dealership confirmed that the system requires full replacement. I was quoted approximately $15,000 for repairs. This vehicle previously had a manufacturer recall related to the fuel pump that was completed in 2022 and is now listed as closed. Despite the recall repair, the same failure occurred again. This demonstrates that the recall remedy did not correct the defect. The sudden engine shutdown without warning presents a serious safety hazard, especially at night and with passengers in the vehicle. Its been at the dealer ship for a month.

The contact owns a 2021 Jeep Wrangler. The contact received notification of NHTSA Campaign Number: 25V741000 (Electrical System); however, the part to do the recall repair was not yet available. The contact stated that the vehicle was taken to a local dealer, where an engine oil replacement was performed, and the High-Voltage Battery was replaced. Upon further inspection, the local dealer diagnosed the High-Voltage Battery replacement as a failure. In addition, the contact stated that the vehicle remained at the local dealer for several months; however, the parts were not available for the recall repair. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 45,000.

While driving on roads I would characterize as good, Our 2021 Jeep Wrangle has exhibited what is widely know as the "death wobble". 1st time was when vehicle has approximately 10,000 miles and it was noted as being severe, dangerous and very scary. 2nd and 3rd time time and with the same road conditions, it occurred. Mileage was 20,000 and 21,000. On March 13th, and with 23,702 miles, we serviced the vehicle to address a known issue with water pump coolant leak and I explained the front wheel steering "wobble issue". They reviewed, test drove and found no issues with it. 3 miles after picking up vehicle, and at approximate 50 MPH, the unit went into a major wobble condition. I immediately returned to the dealership. Technician recommended steering stabilizer and I was told 9/10 times this fixes the "shake". Service team also explained this is a fairly widespread concern with Jeep Wrangler. I consider this a major risk to me, my family and other drivers around me/vehicle. Only my wife and I have experienced the condition. Dealer was unable to duplicate. No other warning lights or fail conditions are available. On YouTUBE, search Jeep Death Wobble and you will be able to see and witness the condition. Its spot-on. Links below. [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My 2021 Jeep Wrangler Rubicon (3.6L eTorque, automatic transmission) has had recurring drivetrain instability since about 2,000 miles while under factory warranty. It intermittently has high RPM flare during acceleration, delayed shifting, shuddering under load, and abrupt engagement. At low speeds (about 10–5 mph), it harshly downshifts, grabs suddenly, RPMs jump up and down, and it can feel like it will stall; it has stalled intermittently. Braking feels inconsistent, and at times it feels like the vehicle resists braking or surges before slowing. The forward collision warning/automatic emergency braking has activated with no obstacle present, and the power steering assist has been lost intermittently. There is also an engine tick and a high-pitched whining noise from the engine/drivetrain area. In January 2026, the transmission catastrophically failed and required replacement of the transmission, torque converter, cooler, and control module. The vehicle was out of service for over 24 days. After installation of a new Mopar remanufactured transmission and torque converter, the same symptoms returned. AAMCO has now found that the new torque converter failed, with metal shavings throughout the transmission, in the fluid, and at the bottom of the pan. I was advised that the vehicle should be sent to a Jeep dealership because no codes are currently present. I was also advised that the dealership may replace only the torque converter rather than the entire transmission, despite recurring failure and metal contamination. This presents a safety concern due to loss of acceleration, unpredictable torque engagement, stalling, unintended braking activation, power steering loss, engine/drivetrain noise, and repeated drivetrain failure. I have all the records if requested, file is too large to send in the upload area.

Vehicle stalled out. Then would not start. Daughter was stuck for 30 minutes until it finally turned over took it into dealership. Was told it’s the fuel pump. My issue is that now. These fuel pumps are back ordered indefinitely found out because all of the fuel pumps are going bad on the jeeps. Now we have a faulty part that the dealership is aware of that you cannot get replaced due to so many of them needing to be replaced, which tells me they know this part is faulty was told they’re not even sure if or when they would be able to get the part now you have all these people driving jeeps that can stall out on the road and get into a terrible accident. My daughter is [XXX] and this is not acceptable. She has a faulty car part and Jeep has no parts to replace this faulty part. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Glendale Dodge (CA) is actively using Federal Fire Risk Recall 68C to fraudulently conceal a separate, critical High-Voltage hardware failure on my 2021 Jeep Wrangler 4xe. Upon intake, my vehicle’s internal VIP diagnostic scan showed an active P0E15 code (Electric Coolant Heater Failure). Per Stellantis Technical Service Bulletins, this code indicates a severe failure requiring a physical hardware replacement to ensure the high-voltage system operates safely. To avoid performing this costly warranty repair, the dealership deliberately falsified the diagnosis on Final Invoice #31349. Under Line C (Customer States Check Engine Light is On), the dealership officially recorded the cause and correction as: 'DUE TO RECALL MODULE UPDATES AND BAD BATTERY.' This is an affirmatively false written diagnosis. A dead 12V battery and a recall software update do not cause, nor do they resolve, a P0E15 High-Voltage Electric Coolant Heater failure. The dealership lied on the legal invoice to scrub the hardware defect from the record. They then applied the 68C software patch as a smokescreen, falsified the 'Date Out' to 12/26/2025 to prematurely close the federal recall ticket, and attempted to return a vehicle that remains mechanically compromised and unsafe. This is intentional warranty fraud masking a high-voltage system failure. Stellantis and its authorized repair facility are refusing to properly remedy the vehicle. The vehicle is currently held at the dealership pending an active fraud investigation by the California Bureau of Automotive Repair (Case #6596-WS4PV6).

My vehicle is experiencing EV system failures, stalling, and system shutdown warnings that make the vehicle unsafe to operate. These symptoms began after a recall repair that was performed by the dealership. The dealership initially stated the recall was repaired, but the same symptoms have continued and have now worsened. The vehicle will display EV system warnings and will stall or shut down systems while driving. The air conditioning and other systems also shut down as the vehicle attempts to protect the electrical system. I have brought the vehicle back to the dealership multiple times regarding this issue. Despite the vehicle showing the same symptoms associated with the recall, I am now being told I may have to pay for additional teardown work unrelated to the EV system. This vehicle has become unsafe to drive, and I have requested assistance and escalation from dealership management but have not received a resolution. I am filing this complaint due to the safety risk posed by the vehicle stalling and shutting down systems while in operation.

I own a 2021 Jeep Wrangler Rubicon 392 with the 6.4L engine (VIN: [XXX] ). The vehicle has a dangerous condition where the engine stalls unexpectedly when the fuel level is approximately 1/4 tank or lower and the vehicle is traveling downhill. When the vehicle is positioned on a decline or downhill slope, the engine suddenly shuts off without warning. This appears to be fuel starvation on decline when the fuel level is below approximately 1/4 tank, resulting in engine stall and loss of power steering and braking assist after stall. This has occurred multiple times and creates a significant risk of crash due to the sudden loss of engine power and reduced steering and braking assistance while the vehicle is in motion. The issue is particularly concerning when descending hills or driving on angled terrain. The vehicle was taken to an authorized dealership (Carvana Jeep San Diego) where technicians determined the likely cause is a defective fuel pump module associated with the Wrangler Rubicon 392 6.4L fuel pump module. However, the dealership informed me the replacement fuel pump module is currently on national backorder from the manufacturer (Stellantis/Jeep). They stated there is no confirmed availability date and that many vehicles may be waiting for the same component. My vehicle has been awaiting repair for approximately four months due to the unavailable fuel pump module. Because the vehicle can stall unexpectedly while traveling downhill, this defect presents an ongoing safety hazard and potential risk of crash. This complaint is being submitted so the issue can be evaluated as a potential safety defect involving fuel delivery failure, fuel pump module malfunction, and engine stall under low fuel conditions in the Jeep Wrangler Rubicon 392. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

While driving higher speeds (45 mph+) I have had my vehicle start shaking very violently which results in me having to slam on my breaks to gain control of my vehicle. When this happens I have been traveling on the highway or interstate which puts other drivers at risk due to me unexpectedly having to come to a halt to gain control of my vehicle. I have taken my vehicle to the mechanic multiple times (dealership twice and local mechanic twice) and I have had everything replaced on the front end that could cause this and it is still happening. Steering dampener has been replaced twice in a year. Mechanic seems to believe that there is a design flaw in the vehicle that is causing it at this point. There is no warning message or anything that gives me any warning. I am scared to drive my vehicle on the highway or interstate.

The contact owns a 2021 Jeep Wrangler. The contact stated that while driving approximately 55 MPH, the vehicle drove over a bump in the road, and the vehicle started to wobble and shake violently. The contact slowed down and stopped the vehicle. The contact stated there was no warning light illuminated. The vehicle was taken to a local dealer, where it was diagnosed, and determined that the steering dampener needed to be replaced. The vehicle was not repaired. The contact stated had experienced the failure several years prior. The vehicle was repaired under warranty; however, the vehicle was no longer under warranty. The manufacturer was informed of the failure. The failure mileage was approximately 51,000.