2011 Toyota Sequoia

Component: VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.

Consequence: If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.

Remedy: Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is C0M.

Full recall detail →

Component: AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE-INACTIVE

Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.

Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.

Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.

Full recall detail →

Component: TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 FJ CRUISER, LAND CRUISER, TACOMA, SEQUOIA AND TUNDRA VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 138, "TIRE PRESSURE MONITORING SYSTEM (TPMS)." WHEN FACTORY-INSTALLED WHEELS AND TIRES WERE REPLACED WITH TOYOTA AUTHORIZED ACCESSORY WHEELS AND LT TIRES PRIOR TO FIRST SALE, THE TIRE PRESSURE MONITORING SYSTEMS WERE NOT RE-CALIBRATED CORRECTLY AND THEREFORE DO NOT START ILLUMINATING THE LOW TIRE PRESSURE WARNING TELLTALE AT THE REQUIRED MINIMUM ACTIVATION PRESSURE.

Consequence: FAILURE TO WARN OF TIRE DEFLATIONS IS A NON-COMPLIANCE WITH FMVSS 138 AND COULD LEAD TO TIRE FAILURE INCREASING THE RISK OF A CRASH.

Remedy: FOR THE LAND CRUISER, SEQUOIA, TACOMA AND TUNDRA VEHICLES, THE DEALER WILL RE-CALIBRATE THE TIRE PRESSURE MONITORING SYSTEM ON AFFECTED VEHICLES AND INSTALL AN UPDATED TIRE AND LOADING INFORMATION LABEL AT NO CHARGE. FOR THE FJ CRUISER VEHICLES, THE TPMS CANNOT BE RESET SO THE ELECTRONIC CONTROL UNIT (ECU) FOR THE TPMS WILL BE REPLACED. TOYOTA IS CURRENTLY DEVELOPING THE REMEDY ECU. IF AN OWNER IS NOT CERTAIN WHETHER HIS OR HER VEHICLE IS EQUIPPED WITH THESE ACCESSORIES, PLEASE CONTACT ANY TOYOTA DEALER FOR AN INSPECTION AT NO CHARGE. THE SAFETY RECALL BEGAN ON MARCH 31, 2011. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

Full recall detail →

Component: STEERING:HYDRAULIC POWER ASSIST SYSTEM

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2008-2022 Sequoia and 2007-2021 Tundra vehicles. The power steering gear assembly may have been manufactured incorrectly, which can result in an oil leak.

Consequence: An oil leak may cause a sudden loss of power steering assist, increasing the risk of a crash.

Remedy: Dealers will inspect and replace the power steering gear assembly as necessary, free of charge. Owner notification letters were mailed on January 21, 2022. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are 21TB10 and 21TA10.

Full recall detail →

Component: STEERING:HYDRAULIC POWER ASSIST SYSTEM

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain JTEKT power steering gear assembly service parts for 2007-2021 Tundra and 2008-2022 Sequoia, part numbers 44250-0C160, 44250-0C131, 44250-0C170, and 11250-0C121. The power steering gear assembly may have been manufactured incorrectly, which can result in an oil leak.

Consequence: An oil leak may cause a sudden loss of power steering assist, increasing the risk of a crash.

Remedy: Dealers will inspect and replace the power steering gear assembly, free of charge. Owner notification letters were mailed on February 17, 2022. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is 21TH01.

Full recall detail →

The contact owns a 2011 Toyota Sequoia. The contact stated that while driving approximately 60 MPH, the rear liftgate opened unintendedly. The vehicle was taken to an independent mechanic to be diagnosed. The contact was informed that the liftgate latch assembly was rusted and needed to be replaced. The vehicle was not yet repaired. The local dealer was notified of the failure. The manufacturer was not made aware of the failure. The failure mileage was 178,000.

While returning home from a vacation, the glass over our sunroof suddenly exploded. We were traveling about 50 MPH and just heard a sudden bang. We pulled over to investigate and it looked like it had exploded outward. We had a luggage carrier on top of the car that covered most of the sunroof, so I am confident that it was not struck by any objects.

THE REAR HATCH HAS A RUST SPOT NEXT TO THE LATCH THAT IS RUSTED THRU AND BREAKING CHUNKS OF METAL FROM AROUND IT. THE LATCH MECHANISM MAY SPLIT FROM THE REAR DOOR ASEEMBLY AND FAIL TO REMAIN CLOSED AND OPEN UNEXPECTEDLY ON THE HIGHWAY ALLOWING ALL CONTENTS TO FLY OUT OF THE VEHICLE. SOURCE OF PROBLEM MAY BE IMPROPER WELDS ALLOWING WATER TO GET INSIDE THE TAILGATE FRAME.

TOYOTA HAS A FAULTY DESIGN ON 5.7 LITER SEQUOIAS AND TUNDRAS WHERE THE ENGINE CAMSHAFT TOWER SEALANT LEAKS OIL TOWARDS THE CABIN. SINCE THE ENGINE IS TILTED BACK, THE ENGINE OIL IS DIRECTED TO A HEAT SHIELD AND THEN DIRECTLY TO THE EXHAUST PIPE. UPON REACHING THE EXHAUST IT CAUSES SMOKE. THE SMOKE WILL ENTER INTO THE CABIN CAUSING ENGINE FUMES WHICH OCCUR WHEN DRIVING OR PARKED UNTIL THE ENGINE COOLS. THE ENGINE COULD HAVE CAUGHT FIRE, BASED ON THE AMOUNT OF SMOKE THAT CAME OUT. UPON FURTHER RESEARCH, THIS ISSUE HAS CAUSED FIRES. EVIDENCE OF THIS PROBLEM IS READILY AVAILABLE SEARCHING "TOYOTA TUNDRA CAM LEAK FIRE", FURTHERMORE, CHANGE.ORG PETITION HAS OVER 5,178 SIGNATURES REQUESTING THE RECALL. THIS ISSUE HAS OCCURRED IN VEHICLES FROM 1,000 MILES AND UP. TOYOTA NOW USES A DIFFERENT SEALANT TO PREVENT THIS LEAKING, SO THEY MUST HAVE RECOGNIZED THE ISSUE BUT HAVE REMAINED SILENT. UPON CONTACTING TOYOTA, THE CUSTOMER SERVICE REPRESENTATIVE STATED THAT HE "HAD NEVER HEARD OF THIS PROBLEM". THE DEALERSHIP THAT IS FIXING THIS HAS A NUMBER OF EXPERIENCED MECHANICS THAT DO SEE THIS OFTEN. IT IS UNSAFE TO DRIVE WITH THIS CONDITION AND THE COST TO REPAIR IS OVER $3,000!

THE DOOR LOCK ACTUATOR ON EACH OF THE DOORS ON THE SUV HAVE FAILED. THE DOORS WILL NOT LOCK/UNLOCK WITHOUT USING THE KEY, AND THE ONLY DOOR WITH KEY ACCESS IS THE DRIVER'S DOOR. THE DOORS CAN BE LOCKED/UNLOCKED FROM INSIDE. THE REPLACEMENT PARTS SEEM EXCESSIVELY HIGH, AND IT APPEARS THAT THIS IS A COMMON OCCURRENCE ON TOYOTA VEHICLES. SINCE THE ACTUATOR IS PART OF THE DOOR LATCH, I AM CONCERNED THAT THE ACTUATOR FAILURE MAY LEAD TO A LATCH PROBLEM. THIS OCCURS WHEN THE VEHICLE IS AT REST.

REAR WINDOW RANDOMLY SHATTERED WHILE DRIVING IN TOWN- 10 MPH. NO CHIPS, NO ISSUES WITH WINDOW PRIOR, JUST BLEW. IT WAS WINTER HERE, AND THE REAR DEFROST WAS ON. MY FRIEND RECEIVED A RECALL NOTICE FOR HIS RAV 4, FOR THIS EXACT SAME ISSUE. I'VE SEEN OTHERS COMPLAINING ONLINE ABOUT THE EXACT SAME THING AS WELL

PURCHASED THE VEHICLE NEW. BRAKE ROTORS SEVERELY WARPED AT12,572 MILES CREATING SEVERE VIBRATION/SHAKING THROUGHOUT THE VEHICLE WHEN BRAKES APPLIED. PROBLEM IS PARTICULARLY SEVERE WHEN UTILIZING BREAKS ON A DOWNHILL GRADE. THE SEVERE VIBRATION CREATED A SIGNIFICANT SAFETY HAZARD AS IT IMPAIRS BREAK PERFORMANCE PARTICULARLY WHEN ROADS ARE WET OR ICY. CAR WAS UNDER WARRANTY. TOYOTA'S SOLUTION WAS TO RESURFACE/GRIND THE ROTORS BACK TO SMOOTH. UNFORTUNATELY THIS PROCESS REMOVES METAL, AND MASS, FROM THE BRAKE ROTORS WHICH EXACERBATES THE PROBLEM. LESS MASS, LESS ABILITY TO DISSIPATE HEAT. THE SAME PROBLEM OCCURRED AGAIN AT 22,391 MILES. DEALERSHIP REFUSED TO ACKNOWLEDGE THE VIBRATION. RETURNED TO DEALERSHIP AT 24,564 MILES. DEALERSHIP NOW ACKNOWLEDGED THE PROBLEM AS IT WAS SO SEVERE IT WAS IMPOSSIBLE TO IGNORE. ONCE THE PROBLEM WAS ACKNOWLEDGED THE DEALERSHIP INFORMED ME I WOULD HAVE TO PAY TO HAVE THE ROTORS RESURFACED AS THE CAR WAS NOW OUT OF WARRANTY. INFORMED THEM I BELIEVE THIS IS A WARRANTY ISSUE AS IT STARTED DURING THE WARRANTY, BUT WAS INFORMED THEY LOOK AT THE ROTOR ISSUES AS INDIVIDUAL OCCURRENCES. ROTORS ONCE AGAIN TURNED, FURTHER REDUCING MASS AND FURTHER EXACERBATING PROBLEM. NOW A MATTER OF TIME UNTIL ISSUE RETURNS. BRAKE ROTORS ARE CLEARLY MADE OF MATERIALS INSUFFICIENT TO HANDLE THE WEIGHT OF THE VEHICLE. THIS ISSUE ALSO CAUSES SEVERE TIRE WEAR, FURTHER IMPAIRING STOPPING PERFORMANCE OF THE VEHICLE. TOYOTA REFUSES TO ACKNOWLEDGE TIRE WEAR CAUSED BY ROTOR ISSUE.

2011 TOYOTA SEQUOIA. CONSUMER WRITES IN REGARDS TO VEHICLE AIR PUMP REPAIR PROBLEMS. *SMD THE DEALER INFORMED THE CONSUMER, THE VEHICLE NEEDED A NEW AIR PUMP AND A NEW AIR PUMP DRIVER AT A COST OF $ 2643 BEFORE TAXES. THE DEALER NOTED THE PROBLEM WAS CAUSE BY POSSIBLY WATER INTRUSION. *JB MA 10/21/15 UPDATED 10/12/2017*CN

WHILE APPROACHING A RED LIGHT I APPLIED BRAKE MY TRUCK BUT INSTEAD MY SEQUOIA THRUST FORWARD CAUSING ME TO HIT THE CAR STOPPED AT THE LIGHT IN FRONT OF ME, CAUSING DAMAGE TO BOTH VEHICLES. *TR

MY CHILDREN (5 AND 6 YEARS OLD) WERE IN THE THIRD ROW SEAT IN BACKLESS BOOSTER SEATS WITH SEATBELTS ON. AFTER PULLING OUT OF A PARKING LOT ONTO THE MAIN ROAD, I HEARD MY 5 YEAR OLD SCREAMING FROM THE BACK OF THE CAR. MY 6 YEAR OLD (WHO REMAINED IN HIS BOOSTER WITH THE SEATBELT FASTENED), MANAGED TO PUSH THE BUTTON NEAR THE SIDE DOOR TO RAISE/LOWER THE SEAT IN THE THIRD ROW. AS HE DID THIS, MY 5 YEAR OLD'S HEAD BECAME WEDGED BETWEEN THE THIRD ROW SEATS. I PULLED OVER AND GAINED ACCESS TO HIM FROM THE REAR HATCH. THE SEAT WOULD NOT MOVE BACK ANYMORE FOR ME TO GET HIS HEAD OUT. I HAD TO FORCE HIS HEAD OUT WITH MY HANDS. HE HAS SOME SERIOUS BRUISING ON THE SIDE OF HIS FACE. AFTER THE INCIDENT, I COULD NOT FIND ANY WAY TO DISABLE THEIR SEAT CONTROLS (LIKE I CAN FOR THE WINDOWS) TO PREVENT THIS FROM HAPPENING AGAIN. IT WAS VERY SCARY AND I CAN ONLY HOPE THAT TOYOTA WILL BE ABLE TO ADDRESS THIS SAFETY ISSUE IN THE FUTURE. *TR

TL* THE CONTACT OWNS A 2011 TOYOTA SEQUOIA. WHILE PARKED ON AN INCLINE, THE CONTACT UTILIZED THE PARKING BRAKE BUT THE VEHICLE CONTINUED TO ROLL FORWARD. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC. THE TECHNICIANS STATED THE VEHICLE WAS PERFORMING AS DESIGNED AND COULD NOT BE REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 3,000.

TL* THE CONTACT OWNS A 2011 TOYOTA SEQUOIA. WHILE DRIVING APPROXIMATELY 70 MPH, THE CONTACT NOTICED THAT THE DIGITAL SPEED READER WAS PROVIDING A DIFFERENT READING FROM THE SPEEDOMETER READING. THE DIFFERENCE WAS APPROXIMATELY 3 MPH GREATER ON THE SPEEDOMETER. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTICS WHERE THE TECHNICIAN STATED TO THE CONTACT THAT THE SPEEDOMETER WAS WITHIN SPECIFICATIONS ACCORDING TO THEIR SERVICE MANUAL. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND SENT AN ENGINEER TO INSPECT THE VEHICLE. THE ENGINEER DETERMINED THAT THE SPEEDOMETER WAS WORKING AS DESIGNED AND A DEFECT WAS NOT FOUND WITHIN THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 3,000.

AS EVIDENCED IN THE 11-9-11 NEW TOYOTA COMMERCIAL, THIS IS EXACTLY WHY TOYOTA WENT TO CONGRESS TO REMOVE 8 TO 10 LEAKING CYLINDERS OF TOXIC, FLAMMABLE INFLATORS VOLUNTARILY FROM THEIR VEHICLES. AS WE ALL KNOW ALL INFLATORS IN THE AIRBAG ARE MADE THE SAME, YOU SHOULD NEVER SEE A FOREIGN RECALL WITHOUT ITS AMERICAN MODEL. WITH THE NEW "UPPER CUT" DESIGN DISPLAYED IN THE COMMERCIAL, ALL THE PREVIOUS DEFECTS HAVE BEEN RECREATED IN THIS MODEL. THIS WILL MAKE "INSERT & DEPLOY" AND "BLOW IT OUT OF THE WOMB" WORSE. THIS MODEL WILL HIT THE SOFT TISSUE JUST UNDER THE PROTECTIVE RIB CAGE AND DEPLOY THE EXPLOSIVE UP INTO THE SPLEEN AND DIAPHRAM. IT IS STILL A "SOFT TISSUE ISSUE". THEY DESIGNED THIS FROM THE MODEL WITH CHAMBER BREACH WHILE A SOLID ROCKET GENERANT, NOW IT IS FILLED WITH GAS MIX UNIDENTIFIED. EVERY YEAR WE HAZ THIS PROBLEM, FROM OCTOBER TO JANUARY THEY DECIDE WHAT HAZ WHOOPING GAS THEY WILL FILL WITH IN THE NEW MODEL RELEASED IN JANUARY. NEXT THEY WILL DECIDE THE SOLID ROCKET GENERANT FROM JANUARY TO MARCH. AUTOLIV HAS INCREASE THE SIZE OF THE LEAKING CYLINDER IN THE PASSENGER SEAT. AS TRENDED PREVIOUSLY, SIDE CURTAIN GUILLOTINES TRAP THE HEAD IN THE FORCE AND DIRECTION OF THE CRASH AND REPEATEDLY WHIP CUSTOMERS WHEN DOOR STRUCTURE HAZ BEEN COMPROMISED. THEY DO NOT TEST OR FILE MSDS FOR THE PROPRIETARY MIX. IN PREVIOUS YEARS IT HAZ BEEN ARGON, HELIUM, XEON, AND NEON. ALL TOXIC AND FLAMMABLE AS HELL AND MIXED TOGETHER WITHOUT REACTIVE TESTS PERFORMED OR TEMPERATURE TESTS PERFORMED. THESE MODELS HAVE RELEASED FROM THE PLANT YEAR AFTER YEAR WITH A 100% FAILURE RATE ON THE INFLATOR COMPONENT. THE CYLINDERS LEAK IN EXTREME TEMPERATURES IN WINTER AND SUMMER, AND THE INFLATOR CASINGS HAVE NEVER BEEN ABLE TO CONTAIN THE SOLID LOAD. SPONTANEOUS DEPLOYMENT IS POSSIBLE 100% OF THE TIME IN BOTH SOLID AND GAS MODELS. THE INTERIM I LEFT WILL NOT WORK. INERT. *TR