Loading vehicle data from NHTSA...
NHTSA recalls, safety ratings, and consumer complaints for the 2004 Toyota 4runner.
| Overall Rating | Not Rated |
| Frontal Crash | Not Rated |
| Side Crash | Not Rated |
| Rollover |
Component: AIR BAGS:SIDE/WINDOW
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2003-2006 Toyota Land Cruiser and Lexus LX470, 2005-2006 Toyota Tundra and Sequoia, 2004-2006 Toyota 4Runner and Lexus GX470 vehicles equipped with side curtain-shield-air bags. The affected vehicles have an air bag control module that may be improperly programmed, causing the side curtain-shield-air bags to deploy inadvertently.
Consequence: If the side curtain-shield-air bags deploy unexpectedly, it can increase the risk of occupant injury.
Remedy: Toyota will notify owners, and dealers will replace the air bag control module with one that has improved programming, free of charge. The recall began on December 1, 2016. Owners may contact Toyota customer service at 1-888-271-9371. Toyota's number for this recall is G0C and GLB.
Component: VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 LEXUS LX570, 2003 THROUGH 2009 TOYOTA 4RUNNER, AND 2006 THROUGH 2010 RAV4 VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: THE REMEDY IS NOW AVAILABLE. THE SAFETY RECALL BEGAN EARLY APRIL 2011. THE REMEDY WILL INVOLVE MODIFICATION OR REPLACEMENT OF THE ACCELERATOR PEDAL AND REPLACEMENT OF ANY TOYOTA ALL-WEATHER FLOOR MAT. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987.
What component or system failed or malfunctioned, and is it available for inspection upon request? Response: Frame, Suspension, Airbags / Yes it is available for inspection. How was your safety or the safety of others put at risk? Response: Safety was put at risk due to frame & suspension failure due to severe rust. Also due to failure of deployment of AirBags. Rusted Frame Failure subsequently caused safety of Injured Party and other motorists to be at risk due to the Injured Party’s 4Runner to dart across oncoming lane of traffic with no warning other than a swaying motion felt immediately before losing control. Once the Injured Party lost control of the 4Runner it crossed into oncoming traffic, progressing into the drainage ditch on the oncoming traffic side of highway. Once the 4Runner impacted the drainage ditch at a 90° angle, the 4Runners momentum dispersed by causing the 4Runner to overturn 3 times landing on its wheels in the adjoining field. Has the problem been reproduced or confirmed by a dealer or independent service center? Repaonse: Independent Service Center has confirmed the problem with the Rusted Frame, Rusted Suspension, and Air Bag failure. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Response : Yes Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? Repaint: No warning lamps prior to failure. Symptoms indicative of failure were an unknown minor swaying sensation while driving. Injured party was under the impression that there may have been a tire low on air, which was discovered to be incorrect later.
The body frame on this vehicle is almost completely rushed out. I don’t know what to do. If I should have the frame replaced I know there’s been a couple recalls on similar Toyota models.
The 2004 Toyota 4runner has 2 NHTSA recalls and 677 consumer complaints on file. It received an overall safety rating of Not Rated out of 5 stars in NHTSA crash testing. The high number of complaints suggests potential reliability concerns — review the complaint details above before purchasing. For the most detailed information about a specific vehicle, decode its VIN using our free decoder above.
Enter a specific VIN to get the full report — specs, recalls, safety ratings, complaints, investigations, and technical service bulletins.
The contact owns a 2004 Toyota 4Runner. The contact stated that while the vehicle was in for service, the independent mechanic discovered rust on the front driver's side subframe. Additionally, the subframe had developed holes due to rust. The cause of the failures was not yet determined, and the vehicle was not yet repaired. The manufacturer and local dealer were notified of the failure, but no assistance was offered. The failure mileage was 120,000.
The contact owns a 2004 Toyota 4-Runner. The contact stated that the frame was severely rusted. The vehicle was not diagnosed or repaired by an independent mechanic or a dealer. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 108,000.
2004 Toyota 4Runner SR5 - Frame rust: currently not drivable due to complete breakage from the rust. Driving 2 hours home on the highway I almost lost control, pressing/releasing the brake and/or gas pulls the steering side to side and sways the truck (fish tail) due to damage from the frame rust/breaking. There is no control of the rear end. Truck was in great condition prior to the frame snapping. Vehicle has been inspected by multiple mechanics (including Firestone, Welding/fabricating Auto Repair shops and small owned mechanic shops), possibly won’t be able to weld due to the amount of rust. Firestone won’t perform any service if the vehicle needs to go in the air (tires, oil..etc) due to frame rust. This has been a huge problem with Toyota, they addressed other models around the same year but excluded the 4Runner for unknown reasons. The dealership will not address the issue unless instructed by corporate. This problem jeopardized my safety and the safety of others around while I was driving at highway speeds, there was no warning when it occurred. Vehicle is available for inspection any time, as it currently is not going anywhere without a tow.
Rusting frame, no specific incident date. Used today’s date.
Frame rust. Huge problems on the 4th gen 4runners. Can't believe there's not a recall on this issue.
Excessive frame and suspension corrosion that could lead to serious accidents if not repaired at a very high cost for myself
The undercarriage is full of rust that the repair shop will not test drive or fix due to the issue. No warnings.
Extensive frame rust to the point of structural failure. Cannot support weight or force.
Rusty frame undercarriage. It’s not going to get any better due to the fact I have to drive on hwy 80 with all the construction, that’s a hazard itself, potholes everywhere that puts stress on your frame and the salt every winter.
Underbody of vehicle is rusting away from vehicle body, I was made aware of situation at a service appointment in April of 2022, no vehicle collision or wreck has happened because of it yet,
UNKNOWN: Excessive frame rust. frame is excessively rusting to the point where the brakes and suspensions is connected to the frame has been compromised. brake lines rusted to the point of failure, thus almost causing a wreck. Vehicle is now parked due to safety concerns involving the excessive rusting that is happening to the frame and any components that is attached to the frame.
Undercarriage frame rusted to the point where structural rust was formed in various places This rust has made a whole and cracks to the frame causing my vehicle to become a safety hazard on the road
I recently bought a 2004 Toyota 4 Runner and the frame of the vehicle has significant corrosion to the extent of holes, weld failures and more. I've never seen frame rust so bad on a vehicle like this. I'm a little uneasy about the safety of this situation. I think Toyota should replace the frame or give a good discount on the part and labor. I hope someone can help me out with this concern.
Showing 15 of 677 complaints