Loading vehicle data from NHTSA...
NHTSA recalls, safety ratings, and consumer complaints for the 2003 Toyota 4Runner.
| Overall Rating | Not Rated |
| Frontal Crash | Not Rated |
| Side Crash | Not Rated |
| Rollover |
Component: VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 LEXUS LX570, 2003 THROUGH 2009 TOYOTA 4RUNNER, AND 2006 THROUGH 2010 RAV4 VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: THE REMEDY IS NOW AVAILABLE. THE SAFETY RECALL BEGAN EARLY APRIL 2011. THE REMEDY WILL INVOLVE MODIFICATION OR REPLACEMENT OF THE ACCELERATOR PEDAL AND REPLACEMENT OF ANY TOYOTA ALL-WEATHER FLOOR MAT. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987.
Component: FUEL SYSTEM, GASOLINE
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH V6 ENGINES, THE FUEL PULSATION DAMPER, LOCATED ON THE FUEL RAIL, MAY HAVE BEEN IMPROPERLY ASSEMBLED, CAUSING A DIAPHRAGM IN THE PULSATION DAMPER TO BE DAMAGED. IF THE DIAPHRAGM FAILS, FUEL MAY LEAK.
Consequence: THIS COULD RESULT IN AN ENGINE COMPARTMENT FIRE IF A HEAT SOURCE OR AN IGNITION SOURCE IS PRESENT.
Remedy: DEALERS WILL REPLACE THE PULSATION DAMPER. OWNER NOTIFICATION BEGAN MAY 5, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT TOYOTA AT 1-800-331-4331.
Many things are happening to my truck that’s why I am contacting you people to see if I got any callback thank you so much
Severe frame rust. 2 large holes on the inside of the frame just back from the front wheels and 2 large holes at the ends of the rear crossmember.
Odometer Fraud. The contact investigated a 2003 Toyota 4 Runner. The contact stated that during the investigation, he discovered a fraudulent scheme of approximately 15 vehicles with odometer fraud. The contact stated that the suspects targeted Facebook Marketplace victims by spraying oil on the engine prior to test-driving the vehicle, and when the vehicle began smoking, the suspects would ask for a discount for the vehicle. The contact added that after the vehicle was purchased, the odometer was rolled back and the vehicle was resold. The vehicle was a private sale. At the time of purchase, the vehicle mileage was 150,000, and at the time of the vehicle being sold, it was discovered that the mileage was 306,000.
The 2003 Toyota 4Runner has 3 NHTSA recalls and 707 consumer complaints on file. It received an overall safety rating of Not Rated out of 5 stars in NHTSA crash testing. The high number of complaints suggests potential reliability concerns — review the complaint details above before purchasing. For the most detailed information about a specific vehicle, decode its VIN using our free decoder above.
Enter a specific VIN to get the full report — specs, recalls, safety ratings, complaints, investigations, and technical service bulletins.
Component: WHEELS
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH FIVE FACTORY ALLOY WHEELS (MODEL 6934 AND 6936), WITH FACTORY LLAT, AND WITH PORT INSTALLED WR4, FOUR ALLOY WHEEL UPGRADE PROCESSED AT THE JACKSONVILLE, FLORIDA PORT AND DISTRIBUTED BY SOUTHEAST TOYOTA DISTRIBUTORS IN THE STATES OF ALABAMA, FLORIDA, GEORGIA, NORTH AND SOUTH CAROLINA, WHEN THE VEHICLES WERE PROCESSED AT THE PORT, AN ALLOY TIRE/WHEEL UPGRADE WAS INSTALLED. THE UPGRADE INCLUDED 4 ALLOY WHEELS. THE ORIGINAL SPARE TIRE/ALLOY WHEEL WAS NOT CHANGED. THE SPARE TIRE REQUIRES THE USE OF A DIFFERENT STYLE OF WHEEL NUT TO ATTACH IT TO THE VEHICLE.
Consequence: IF THE SPARE TIRE/WHEEL IS INSTALLED ON THE VEHICLE USING THE WHEEL NUTS PROVIDED FOR THE UPGRADE ALLOY WHEEL, DAMAGE TO THE WHEEL COULD RESULT AND COULD EVENTUALLY LEAD TO A LOOSE WHEEL.
Remedy: OWNERS WILL BE PROVIDED WITH DIFFERENT STYLE LUG NUTS, A WARNING LABEL FOR THE SPARE RE/ALLOY WHEEL, AND AN OWNER'S MANUAL ADDENDUM.
While my mechanic was servicing a small exhaust leak on my vehicle he noticed that the chassis/frame of the vehicle was heavily corroded. He told me that he believe it was no longer safe to drive and that I contact Toyota. I had a local Toyota service center also look at it and they confirmed that the chassis/frame was heavily corroded and unsafe to drive.
My vehicle: 2003 4Runner SR5 2WD VIN: [XXX] Issue: Front driver's side door will not open. Electronic locks are operating, but the door release is not functioning. Safety Concern: What if I was in a situation where I did need to get out of the vehicle immediately? Such as a high-water incident, fire, etc. Especially for a person [XXX], as myself, this would be a big issue. When attempting to exit the car after pulling into the driveway, I could not open the driver's door. The locks would release, but the door latch would not. I had to crawl over the console to get out through the passenger side. This was not easy as I had back fusion surgery and 8 disc replaced, fused. I had to open the sunroof to help with get over and out. After I did get out, I tried the key in the driver's door, it would actuate the door locks on all doors, but the driver's side door latch would still not release. I even disconnected the battery and reconnected. No help. And after knowing more, it was not an electrical issue, but mechanical failure. I now have it at the repair shop after talking with Toyota Service manage who admitted it was a poor design as the repair for this is to destroy the door panel to get to the actuator to attempt to release the door latch. The estimate for this work is 1,150.00. I am beyond frustration, and especially when I see there is no recall for this issue. There are penty of conversations on this same issue on 4Runner forums as well as all over YouTube. Thank you for looking into this. You can reach me at: [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Toyota has had issues with their frames rusting out and the 4th generation 4Runner is not exempt from this issue. My 2003 is requiring extensive work to keep it on the road safely due to frame rust. A recall to replace frames should be in place.
There is major corrosion on the chassis, brake-power steering-transmission lines, and all metal brackets on the frame and engine. The corrosion is so bad there is holes on the chassis. Known issue, many complaints, Toyota Corp. says to keep calling back maybe something will be done in the future. Unable to upload photos!
Severe frame rust, there was a recall for tacomas but 4Runners have the issue just as bad
The contact owns a 2003 Toyota 4Runner. The contact stated that upon taking the vehicle to several independent mechanics for servicing, he was informed that the subframe was significantly corroded and needed to be replaced. The vehicle was not repaired. The dealer was not notified of the failure. The manufacturer was notified of the failure and informed the contact the vehicle was not covered under recall. The failure mileage was approximately 115,000.
The contact owns a 2003 Toyota 4Runner. The contact stated that while the vehicle was at the tire retailer for tire replacement, the technician informed him that the subframe was corroded. The vehicle was then taken to an independent mechanic, who diagnosed that the passenger's side front and rear subframes were severely corroded, as well as the cross member. The mechanic advised the contact to stop driving the vehicle. The dealer was made aware of the failure and informed the contact that there was no recall associated with the VIN. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 165,000.
The VSC system in the vehicle becomes disabled due to a firmware 'glitch' identified by Toyota when an emission system issue is detected by the onboard diagnostic system. The VSC system is listed as an 'essential safety feature,' so I'm curious why a recall was never ordered to patch defective firmware that can cause VSC to become disabled due to a completely unrelated emissions issue.
Extensive rust through out frame, resulting in holes in structural members. Leaving frame in a weak and vulnerable state.
I purchased this 2003 Toyota 4Runner in 2018 under what I assumed was prime condition, for a vehicle that spent the majority of its life in Nebraska/Kansas before I moved to Texas in 2021. At 87,400 miles at the time of purchase, the vehicle had no visible damage to the exterior besides a few paint chips, some minor hail damage and scratches, and some easily fixed surface rust in the paint on the tailgate. The previous owner had driven it leisurely and had kept the miles low after 15 years. The car has had some mechanical issues, but nothing out of the ordinary outside of some regular maintenance over the first few years. Being close to 100,000 miles, the timing belt and pump was replaced around 98,000 miles. Other issues have been fixed periodically, please reference the attached files. After joining a Toyota 4Runner 4th Generation Facebook group and seeing a post about another's issues with rust damage in October 2020, I decided to take a look at my own frame. I then inspected my own vehicle, and found significant frame rot damage. It is extensive, with significant rust to the frame, with large holes and soft patches that question the integrity of the frame and the safety of the vehicle on the road. Every time I hit a small bump or pothole, I fear the frame will crack and I will lose control as others have. I have not sought out professional repairs due to the extensive cost, and am awaiting the outcome of a current class action lawsuit by the Bell Legal Group. The 4th Generation Toyota 4Runner (2003-2009) is built on the exact same frame as the Toyota Tacoma of that era, yet while the Tacoma was recalled for frame rot, the 4Runner was not included, which I believe to be a gross oversight in previous legal proceedings. The 2003-2009 Toyota 4Runner is a reliable vehicle, but poses significant frame rot issues much earlier than should be expected.
Vehicle frame has rusted through and has holes affecting structural condition.
Showing 15 of 707 complaints