Loading vehicle data from NHTSA...
NHTSA recalls, safety ratings, and consumer complaints for the 1991 Jeep Wrangler.
NHTSA has not published 5-star crash-test ratings for the 1991 Jeep Wrangler. New vehicles are often added to the NCAP rating program after initial release; check nhtsa.gov/ratings for the latest status.
Component: EXTERIOR LIGHTING
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Remedy: PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Component: ELECTRICAL SYSTEM:IGNITION:SWITCH
SALT CORROSION PRODUCTS BETWEEN THE STARTER SOLENOID WIRE AND THE ADJACENT BATTERY FEED IN THE BULKHEAD CONNECTOR MAY SHORT THESE CONNECTIONS, CAUSING THE CIRCUIT TO BYPASS THE IGNITION KEY CONTROL OF THE STARTER MOTOR SOLENOID. THE CAR CAN START WITHOUT THE STARTER SEQUENCE BEING INITIATED BY THE IGNITION KEY IN THE IGNITION LOCK.
Consequence: THE UNINTENDED START OF A VEHICLE WITH A MANUALTRANSMISSION LEFT IN A DRIVE GEAR CAN RESULT IN A RUNAWAY VEHICLE.
Remedy: THE STARTER SOLENOID WIRING WILL BE SEPARATED FROM THE BATTERY FEED WIRE BY RELOCATING IT WITHIN THE BULKHEAD CONNECTOR ON AFFECTED VEHICLES.
Component: EQUIPMENT
BESTOP AFTERMARKET REAR SHELL ROOF RACKS,MANUFACTURED BETWEEN APRIL 27 AND MAY 20, 2004, DESIGNED FOR USE WITH THE BESTOP HARDTOP MADE FOR THE 1986-1995 AND 1997-2003 JEEP WRANGLER. THE COCKPIT COVER MAY NOT STAY LATCHED TO THE ROOF RACK BECAUSE THE LATCH BRACKET MISPOSITIONS THE ROTARY LATCH TO THE COCKPIT COVER. AS A RESULT, THE COCKPIT COVER MAY NOT STAY LATCHED TO THE ROOF RACK AND COULD SEPARATE FROM THE ROOF RACK. THIS RECALL ONLY PERTAINS TO AFTERMARKET REAR SHELL ROOF RACKS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON JEEP WRANGLER VEHICLES BY DAIMLERCHRYSLER.
Consequence: SHOULD THIS OCCUR, THE COCKPIT COULD CAUSE INJURY BY STRIKING PERSONS OUTSIDE THE VEHICLE OR COULD BECOME A DISTRACTION OR AN OBSTACLE TO OTHER DRIVERS, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy: BESTOP WILL NOTIFY ITS CUSTOMERS AND PROVIDE A REPAIR KIT AND INSTALLATION INSTRUCTIONS FREE OF CHARGE. OWNER NOTIFICATION BEGAN JUNE 16, 2004. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BESTOP CUSTOMER SERVICE DEPARTMENT AT (800) 845-3567.
Component: PARKING BRAKE:CONVENTIONAL
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH MANUAL TRANSMISSIONS, THE PARKING BRAKE CAN SELF-RELEASE WITHOUT WARNING.
Consequence: THIS COULD ALLOW THE VEHICLE TO ROLL AWAY, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL A PARKING BRAKE ASSEMBLY WITH A STRONGER PAWL RETURN SPRING. OWNER NOTIFICATON BEGAN SEPTEMBER 30, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Component: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
VEHICLE DESCRIPTION: PASSENGER AND MULTI-PURPOSE VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, ILLINOIS, INDIANA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, OR WISCONSIN, AND THE DISTRICT OF COLUMBIA. THE FRONT DISC BRAKE ROTORS CAN EXPERIENCE SEVERE CORROSION IF OPERATED FOR AN EXTENSIVE PERIOD IN THE "SALT BELT." IF THE ROTORS ARE NOT REPLACED, THE CORROSION CAN EVENTUALLY COMPROMISE THE STRUCTURAL INTEGRITY OF THE STAMPED STEEL CENTER HUB SECTION OF THE ROTOR.
Consequence: THE REDUCED STRENGTH CAN ALLOW THE CAST IRON WEAR SURFACE TO SEPARATE FROM THE HUB, REDUCING THE BRAKE EFFECTIVENESS OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THESE ROTORS WITH ROTORS THAT ARE COATED WITH A CORROSION PROTECTION.
Component: FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
VEHICLE DESCRIPTION: MULTIPURPOSE PASSENGER VEHICLES EQUIPPED WITH PLASTIC FUEL TANKS. THE FUEL TANK SENDING UNIT GASKET CAN CRACK CAUSING FUEL AND FUEL VAPOR LEAKS.
Consequence: FUEL AND FUEL VAPOR LEAKED FROM THE FUEL TANK CAN RESULT IN FIRE WHEN EXPOSED TO A SOURCE OF IGNITION.
Remedy: REPLACE THE FUEL TANK SENDING UNIT GASKET.
Component: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
ON 1987 THROUGH EARLY 1990 MODELS, BOTH FRONT BRAKE HOSES CAN WEAR DUE TO DIRECT CONTACT WITH THE WHEEL OPENING SPLASH SHIELDS. ON THE LATE 1990 THROUGH 1992 MODELS, PERIODIC RUBBING CONTACT OF THE LEFT FRONT BRAKE HOSE CAN OCCUR DUE TO MOVEMENT OF THE SPLASH SHIELD IN CERTAIN VEHICLE OPERATING CONDITIONS.
Consequence: EITHER CONDITION CAN CAUSE LOSS OF FRONT BRAKE SYSTEMFUNCTIONS, RESULTING IN INCREASED STOPPING DISTANCES AND AN INCREASED RISK OFVEHICLE ACCIDENT.
Remedy: THE 1987 TO 1990 MODEL VEHICLES WILL HAVE BOTH SPLASH SHIELDS REPLACED AND BOTH FRONT BRAKE HOSES REPLACED AS NECESSARY. ALL AFFECTED LATE 1990 THROUGH 1992 MODEL YEAR VEHICLES WILL HAVE ADDITIONAL FASTENERS INSTALLED TO FURTHER SECURE THE LEFT SIDE SPLASH SHIELD. ALSO, THE LEFT FRONT BRAKE HOSE WILL BE INSPECTED AND REPLACED AS NECESSARY.
Component: EQUIPMENT:OTHER:LABELS
CERTIFICATION LABEL DOES NOT CONTAIN REQUIRED TIRE AND WHEEL INFORMATION.
Consequence: VEHICLES WOULD NOT COMPLY WITH FMVSS 120.
Remedy: INSTALL SUPPLEMENTAL TIRE INFORMATION LABELS ADJACENT TO CERTIFICATION LABELS.
The contact owns a 1991 Jeep Wrangler. The contact received notification of NHTSA Campaign Number: 02V041000 (Parking Brake), 94V106000 (Fuel System, Gasoline) however, the part to do the recall repair was not available at the contacts local dealer. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and directed her to another dealer where the parts were not available. The contact had experienced a failure. VIN tool confirms parts available. Failure Mileage was 115,000.
I WAS DRIVING ON THE HIGHWAY AT 55 MPH AND MY LEFT REAR TIRE EXPERIENCED A SUDDEN LOSS OF AIR PRESSURE AND THE SIDEWALL BLOW OUT. THERE IS NO VISIBLE HOLES IN TREAD. TREAD RECENTLY PASSED STATE INSPECTION. I HAVE A SPECIAL ORDER TIRE 35X12.5 15LT. THESE ARE BF ALL TERRAN T/A TIRES.
TL* THE CONTACT OWNS A 1991 JEEP WRANGLER. WHILE REFUELING THE VEHICLE, FUEL LEAKED FROM THE BOTTOM OF THE VEHICLE. THE FAILURE RECURRED SEVERAL TIMES. THE FUEL TANK WAS REPLACED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 70,000.
The 1991 Jeep Wrangler has 8 NHTSA recalls and 94 consumer complaints on file. The high number of complaints suggests potential reliability concerns — review the complaint details above before purchasing. For the most detailed information about a specific vehicle, decode its VIN using our free decoder above.
Enter a specific VIN to get the full report — specs, recalls, safety ratings, complaints, investigations, and technical service bulletins.
JEEP WRANGLER YJ OVERFILLS THE TANK WHEN PUMPING GAS AND CAUSES FUEL TO SPILL OUT OF THE HOLE AND CAUSES HAZARDOUS CONDITIONS. *TR
GAS TANK DOES NOT REGISTER PROPER AMOUNT. *TR
I'M THE ORIGINAL OWNER OF A STOCK 1991 JEEP WRANGLER WITH 2.5 LITER ENGINE AT 106,000 MILES. THE FUEL RAIL HAS FAILED AND IS LEAKING AT FACTORY INSTALLED PLUGGED END OF THE RAIL AT THE OPPOSITE END FROM THE FUEL PRESSURE REGULAR. THE LEAK IS BETWEEN THE PLUG AND THE RAIL. THIS SHOULD HAVE BEEN A BRAZED SEALED END OR A THREADED PLUG INSTEAD OF A COMPRESSION FITTING OF A PLUG. THE LEAK PRODUCES A SPRAY OF GASOLINE NEAR THE EXHAUST MANIFOLD WHICH COULD LEAD TO A FIRE. BASED ON MY RESEARCH BY CONTACTING 3 DEALERSHIPS IN THE WASHINGTON, DC AREA, JEEP HAS STOPPED PRODUCING THIS PART AND THERE ARE NO STOCK AFTERMARKETS FUEL RAILS AVAILABLE. I'M LOOKING INTO JUNKYARD PARTS BUT QUESTION WHETHER IF THEY COULD BE DEFECTED, TOO. ALSO, AT JEEPFORUM.COM THERE WAS ALSO FAILURE ON A 1994 JEEP WRANGLER. PLEASE REVIEW THIS SUBJECT AND SEE IF THERE'S A JUSTIFICATION FOR RECALL. *JB
DRIVERS FEMALE SEAT BELT END RELEASES ON ITS OWN OR DOES NOT LATCH AT ALL. I STILL HAVE THE OLD PART. *NM
DT: 1991 JEEP WRANGLER. THE CONSUMER STATED THAT GAS POURED OUT OF THE PLASTIC TANK. IT CRACKED ON THE RIGHT LOWER CORNER. THE VEHICLE WAS NOT TAKEN TO THE DEALERSHIP. THE CONSUMER DID REPAIRS BY HIMSELF HIMSELF. BUT WHEN HE PUT MORE GAS IN THE VEHICLE IT BEGAN TO LEAK AGAIN. THE MANUFACTURER HAS NOT BEEN NOTIFIED. *AK
WHILE DRIVING AT ANY SPEED VEHICLE STALLED. CONSUMER TRIED TO RESTART VEHICLE AND WAS ABLE TO DO SO. CONSUMER DROVE VEHICLE TO THE DEALER FOR INSPECTION, AND DEALER WAS UNABLE TO RESOLVE THE PROBLEM. *AK
1991 JEEP WRANGLER PARKING BRAKE DISENGAGED AND VEHICLE ROLLED DOWN A HILL AND HIT A CAR. *MR THE CONSUMER REQUESTED TO BE REIMBURSED FOR THE DAMAGES THAT WERE CAUSED. *SC
AFTER PARKING THE VEHICLE, THE PARKING BRAKE RELEASED. THIS CAUSED THE VEHICLE TO ROLL BACKWARDS, INTO A LAKE. THE CONSUMER MANAGE TO RETRIEVE THE VEHICLE AND HAD VEHICLE TOWED. THE DEALERSHIP HAVE BEEN NOTIFIED. *PH
CONSUMER WILL PROVIDE MORE INFORMATION ON THE CATALYTIC CONVERTER PROBLEMS. *AK
DEALERSHIP WAS REFUSING TO PERFORM RECALL 02V041000 REPAIRS AS STATED IN THE RECALL NOTIFICATION FOR PARKING BRAKE FAILURE. *AK
SEAT BELTS ARE INOPERATIVE. CONSUMER IS NOT BEING RESTRAIND PROPERLY WHILE DRIVING. *AK
VEHICLE ROLLED BACKWARD WHILE PARKED ON A HILL WITH EMERGENCY PARKING BRAKES ENGAGED. CONSUMER STATED THAT POP WAS HEARD OUTSIDE THE VEHICLE. DEALER HAS BEEN NOTIFIED. PLEASE PROVIDE FURTHER INFORMATION. *AK
Showing 15 of 94 complaints