NHTSA recalls, safety ratings, and consumer complaints for the 2006 Hyundai Tucson.
| Overall Rating | Not Rated |
| Frontal Crash | Not Rated |
| Side Crash | Not Rated |
| Rollover |
Component: EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH
HYUNDAI IS RECALLING 532,633 MY 2006-2007 ACCENT, ENTOURAGE, SONATA, MY 2007 AZERA, ELANTRA AND SANTA FE, MY 2005-2007 TUCSON AND MY 2007-2008 VERACRUZ VEHICLES. THE STOP LAMP SWITCH IN THE AFFECTED VEHICLES MAY MALFUNCTION. A MALFUNCTIONING STOP LAMP SWITCH MAY CAUSE THE BRAKE LIGHTS TO NOT ILLUMINATE WHEN THE BRAKE PEDAL IS DEPRESSED OR MAY CAUSE THE BRAKE LIGHTS TO REMAIN ILLUMINATED WHEN THE BRAKE PEDAL IS RELEASED. A STOP LAMP SWITCH MALFUNCTION MAY ALSO AFFECT THE OPERATION OF THE BRAKE-TRANSMISSION SHIFT INTERLOCK FEATURE SO THE TRANSMISSION SHIFTER WOULD NOT BE ABLE TO BE SHIFTED OUT OF THE PARK POSITION. IT MAY ALSO CAUSE THE ELECTRONIC STABILITY CONTROL (ESC) MALFUNCTION LIGHT TO ILLUMINATE, AND IT MAY NOT DEACTIVATE THE CRUISE CONTROL WHEN THE BRAKE PEDAL IS DEPRESSED.
Consequence: ANY OF THESE MALFUNCTIONS, ALONE OR IN COMBINATION, MAY LEAD TO A CRASH.
Remedy: DEALERS WILL REPLACE THE STOP LAMP SWITCH FREE OF CHARGE. THE RECALL BEGAN ON JUNE 29, 2009. OWNERS MAY CONTACT THE HYUNDAI CUSTOMER ASSISTANCE CENTER AT 1-800-633-5151.
Component: EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH
Hyundai Motor Company (Hyundai) is recalling certain model year 2006-2009 Accent, model year 2007-2011 Azera, Sonata and Sante Fe,2006-2011 Tucson, 2009-2011 Elantra Touring, 2007-2010 Elantra, 2008-2011 Veracruz, 2009-2011 Genesis, 2010-2011 Genesis Coupe, 2007-2008 Entourage, and 2006-2008 Tiburon vehicles. Originally, in April 2013, Hyundai recalled 1,059,824 model year 2007-2009 Accent and Tucson, model year 2007-2010 Elantra, model year 2007-2011 Santa Fe, model year 2008-2009 Veracruz, model year 2010-2011 Genesis Coupe, and model year 2011 Sonata vehicles. In September 2013, Hyundai informed the agency that it was adding more vehicles to this campaign, representing an additional 652,512 units. The total number of vehicles being recalled is now 1,712,336. In the affected vehicles, the stop lamp switch may malfunction. A malfunctioning stop lamp switch may cause the brake lights to not illuminate when the brake pedal is depressed or may cause an inability to deactivate the cruise control by depressing the brake pedal. Additionally, a malfunctioning stop lamp switch may also result in intermittent operation of the push-button start feature, affect the operation of the brake transmission shift interlock feature, preventing the shifter from being moved out of the PARK position and cause the Electronic Stability Control (ESC) malfunction light to illuminate.
Rear subframe corrosion
The contact owns a 2006 Hyundai Tucson. The contact stated while the vehicle was parked, the contact noticed that the rear subframe had become inoperable and the contact noticed that the rear subframe was corroded. The vehicle was towed to an independent mechanic but was not diagnosed or repaired. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 180,000.
ESC OFF light does not turn off. I press it off and on while driving and nothing happens. It stays on all the time.
The contact owns a 2006 Hyundai Tucson. The contact stated that while attempting to start the vehicle, the vehicle hesitated. The vehicle was taken to an independent mechanic, where it was diagnosed; however, the cause of the failure was not yet determined. The contact stated while driving at an undisclosed speed, the vehicle stalled. The check engine warning light and the TPMS warning light were illuminated. Additionally, the engine overheated. The contact related the failure to an unknown recall and Technical Service Bulletin: 952. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 140,000.
The 2006 Hyundai Tucson has 5 NHTSA recalls and 135 consumer complaints on file. It received an overall safety rating of Not Rated out of 5 stars in NHTSA crash testing. The high number of complaints suggests potential reliability concerns — review the complaint details above before purchasing. For the most detailed information about a specific vehicle, decode its VIN using our free decoder above.
Enter a specific VIN to get the full report — specs, recalls, safety ratings, complaints, investigations, and technical service bulletins.
Consequence: Failure to illuminate the stop lamps during braking or inability to disengage the cruise control could increase the risk of a crash. Additionally, when the ignition is in the 'ON' position, the transmission shifter may be able to be moved out of Park without first applying the brake. This may lead to unintentional movement of the car which may increase the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will replace the stop lamp switch, free of charge. The safety recall began on April 22, 2013. Owners may contact Hyundai at 1-800-633-5151. Hyundai's recall campaign number is 110.
Component: EXTERIOR LIGHTING
HYUNDAI IS RECALLING 3,011 MODEL YEAR 2005-2007 ELANTRA, TUCSON, SONATA, AZERA AND ACCENT VEHICLES. A MALFUNCTIONING STOP LAMP SWITCH MAY CAUSE THE BRAKE LIGHTS TO FAIL TO ILLUMINATE WHEN THE BRAKE PEDAL IS DEPRESSED OR MAY CAUSE THE BRAKE LIGHTS TO REMAIN ILLUMINATED WHEN THE BRAKE PEDAL IS RELEASED. A DEFECTIVE STOP LAMP SWITCH MAY ALSO AFFECT THE OPERATION OF THE BRAKE-TRANSMISSION SHIFT INTERLOCK FEATURE SO THE TRANSMISSION WOULD NOT BE ABLE TO BE SHIFT OUT OF THE "PARK" POSITION. IT MAY ALSO CAUSE THE ELECTRONIC STABILITY CONTROL (ESC) MALFUNCTION LIGHT TO ILLUMINATE, AND IT MAY NOT DEACTIVATE THE CRUISE CONTROL WHEN THE BRAKE PEDAL IS DEPRESSED.
Consequence: ANY OF THESE MALFUNCTIONS COULD LEAD TO A CRASH.
Remedy: DEALERS WILL REPLACE THE STOP LAMP SWITCH FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 2, 2009. OWNERS MAY CONTACT HYUNDAI OF PUERTO RICO CUSTOMER SERVICE AT 1-787-999-4310.
Component: AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE
ON CERTAIN VEHICLES, STATIC AIR BAG DEPLOYMENT TESTING CONDUCTED BY NHTSA USING FIFTH PERCENTILE FEMALE DUMMIES INDICATED THAT A SMALL STATURE ADULT DRIVER NOT WEARING A SEAT BELT AND INVOLVED IN A FRONTAL OR NEAR FRONTAL CRASH, THE DEPLOYMENT OF THE DRIVER AIR BAG MAY NOT OCCUR.
Consequence: THIS CAN CAUSE INCREASED RISK OF INJURY TO THE DRIVER UNDER CERTAIN CRASH CONDITIONS.
Remedy: DEALERS WILL REPLACE THE DRIVER AIR BAG MODULE WITH ONE THAT IS DESIGNED TO PROVIDE AN INCREASED MARGIN OF COMPLIANCE FOR LOW RISK DEPLOYMENT FOR SMALL STATURE ADULTS WHO ARE NOT PROPERLY WEARING THE SEAT BELTS. THE RECALL BEGAN ON SEPTEMBER 6, 2007, AND WILL BE PERFORMED IN TWO MAILINGS. OWNERS MAY CONTACT HYUNDAI DE PUERTO RICO AT 1-800-981-0188.
Component: AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE
ON CERTAIN SPORT UTILITY VEHICLES, DURING STATIC AIR BAG DEPLOYMENT TESTING CONDUCTED BY NHTSA USING FIFTH PERCENTILE FEMALE DUMMIES INDICATED IF A SMALL STATURED ADULT DRIVER, NOT WEARING A SEAT BELT, IS INVOLVED IN A FRONTAL OR NEAR FRONTAL CRASH, DEPLOYMENT OF THE DRIVER AIR BAG MAY RESULT IN AN INSUFFICIENT MARGIN OF COMPLIANCE AS MEASURED BY THE TEST DUMMY USED IN THE NHTSA TEST.
Consequence: THIS CAN CAUSE INCREASED RISK OF INJURY TO THE DRIVER UNDER CERTAIN CRASH CONDITIONS.
Remedy: DEALERS WILL REPLACE THE DRIVER AIR BAG MODULE. THE RECALL BEGAN ON JANUARY 29, 2007, AND WILL BE CONDUCTED THROUGH SIX MAILINGS. OWNERS MAY CONTACT HYUNDAI AT 1-800-633-5151.
At first brakes were making noise so I went to replace them after getting parts and I noticed that the brake pedal went to the floor I was able to get it on concrete pad but when I jacked it up I say big chunks of rust falling when I looked under car rear axle subframe was pretty much gone after I say that I decided to order the replacement subframe but when it come in and I was getting ready to do it I body mount where it is bolted also needs replaced I was trying to find them when I come across a factory recall about this issue when I contacted them and the dealer about this issue dealer said it couldn't be done because there was nothing left and he refused to put on a lift because he said the rear subframe would fall on ground but manufacturer denied to repair or make any resolutions for it even though they had in past and they new about the problem I have found over 1000 issues listed and they have repaired a bunch of the same vehicles for the same issue I told them I never received anything about the issue and they said it was my responsibility not there's so not only did they not do or even try to do what they have on recall but they refused to do anything for me and I was glad I didn't try driving after I heard noise because I could of caused a major accident and been severely injured in process not to mention someone else due to rear frame and brakes falling and falling out of car
Rear cross member frame broke in 2 spots due to rust. I’ve searched this and found numerous vehicles with same problem contacted dealer and they said they can’t do anything about it. What steps should I take. I called there corporate office left They don’t don’t return calls callsor or texts complaints.
Driver side rear unibody sub frame rusted through
Rear control arm mount broke away from subframe while on the highway going 65mph. Violent shaking and steering malfunction occurred immediately. Passed WV inspection just a few months ago.
The contact owned a 2006 Hyundai Tucson. The contact stated that after parking his vehicle in the driveway, he looked through the window of his residence and noticed that the vehicle had caught fire from underneath the hood. The contact related the fire to an electrical system failure. The fire department was able to extinguish the fire. Police and fire department reports were filed. The vehicle was towed to a tow yard and deemed totaled by the insurance company. The manufacturer was not made aware of the failure. The failure mileage was approximately 198,000.
When I drive my car and right after I put gas in my car I smell gas to the point that my husband and I are coming home with headaches and we're sick to her stomach I've taken it to a mechanic and they say there's nothing wrong the engine check engine light keep on coming on and then it will go off after it sit for a couple minutes turned off I'm about ready to have a baby in June and I'm so worried to have the baby in the car the brakes have stopped working to the point that I've gone in through lights and I can hardly put the brakes on I have to use emergency brake sometimes and nobody will help me get it taken care of I have had almost couple wrecks because I cannot get the brakes to stop take a lock on me and it's scary when you're having a baby and you know your seatbelt your brakes are locking but you for your seat belt to keep safe and my brakes locked to the point I cannot get them after the kick hit them with all my might just to unlock them and nobody will help me fix it
When it rains my steering wheel locks up when I drive thru a puddle I have brought my car to used car dealer where I bought it from and they say nothing is wrong but steering wheel locks when driving that to me is major problem they checked belt water is getting somewhere and causing a short hence power steering to lock it only happens when it rains
The contact owns a 2006 Hyundai Tucson. The contact stated while driving at various speeds, he noticed that the air bag warning light was illuminated. The vehicle was taken to an independent mechanic and diagnosed with the air bag module needing to be replaced. The independent mechanic cleaned the contacts for the seat sensors however, the failure recurred. The manufacturer was not informed of the failure. The contact related the failure to an unknown recall. The failure mileage was approximately 100,000.
TL* THE CONTACT OWNS A 2006 HYUNDAI TUCSON. THE CONTACT STATED THAT WHILE DRIVING 5 MPH AND ATTEMPTING TO STOP THE VEHICLE, THE BRAKE PEDAL WAS DEPRESSED AND THE VEHICLE STALLED. AFTER THE FAILURE, THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO SHAKER'S FAMILY HYUNDAI (674 STRAITS TPKE, WATERTOWN, CT 06795, (860) 631-4200) TO BE DIAGNOSED. THE CONTACT WAS INFORMED BY THE DEALER THAT THE ADAPTIVE VALUES WERE RESET AND THE VEHICLE SHOULD PERFORM AS DESIGNED. THE CONTACT RETRIEVED THE VEHICLE AND WHILE DRIVING INTO HER DRIVEWAY, THE OIL WARNING LIGHT ILLUMINATED. THE CONTACT STATED THAT THE VEHICLE WAS PREVIOUSLY TAKEN TO AN INDEPENDENT MECHANIC WHO REPLACED THE THROTTLE BODY AND MAS AIR FLOW SENSORS HOWEVER, THE FAILURE PERSISTED. THE VEHICLE WAS NOT YET REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 190,000.
HYUNDAI NEVER NOTIFIED US OF THE SUBFRAME RUST RECALL. OUR MECHANIC JUST POINTED OUT THAT OUR'S. HE SAID THE CAR IS UNSAFE TO DRIVE. GETTING IT REPLACED AT OUR EXPENSE. BRAKE LINES HAVE ALREADY FAILED AND HAD TO BE REPLACED AT OUR EXPENSE. ALTERNATOR AND POWER STEERING PUMP, FRONT SUSPENSION ALL AT OUR EXPENSE. HYUNDAI UNRESPONSIVE.
DAY 1:I PULLED INTO A LANE LEADING TO A PARKING LOT. ON A 90 DEGREE TURN, I LOST POWER STEERING AND THE ENGINE LIGHT CAME ON. THE HYUNDAI STILL WAS IDLING WHEN I LOST THE POWER STEERING. I CAME TO A STOP AND THE POWER STEERING STARTED WORKING AGAIN. THERE WAS SOME WATER ON THE PAVEMENT. DAY 2: SAME AS DAY ONE IN SAME LOCATION ON THE SAME TURN. DAY 5: TOOK VEHICLE TO SERVICE CENTER AND EXPLAINED THE PROBLEM. THEY CAME BACK AND SAID THEY CHECKED THE COMPUTER FOR ERROR CODES AND NONE WERE FOUND. THE CHECKED THE UNDER CARRIAGE FOR LOOSE WIRES, NONE WERE FOUND. THEY CHECKED THE SERPENTINE BELT AND IT WAS ALSO FOUND IN GOOD CONDITION. PROBLEM COULD NOT BE FOUND. NO INSURANCE SAFE DRIVING SENSOR WAS PLUGGED INTO THE COM PORT. THERE IS A SENSOR ON THE WINDSHIELD THAT IS STUCK ON. NO PHYSICAL CONNECTION TO THE VEHICLE.
Showing 15 of 135 complaints