2016 Fiat 500

Component: POWER TRAIN:MANUAL TRANSMISSION

Chrysler (FCA US LLC) is recalling certain model year 2012-2016 Fiat 500 vehicles manufactured June 21, 2010, through January 12, 2016, equipped with a manual transmission. The clutch diaphragm spring may fracture and fail, causing an inability to switch gears.

Consequence: If the clutch diaphragm spring fails, the driver may not be able to shift gears or the vehicle may lose motive power, increasing the risk of a crash.

Remedy: The remedy for this recall will include the installation of a clutch pedal limiter and a clutch pedal switch. The recall began on November 10, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S34.

Full recall detail →

Component: TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS

Chrysler (FCA US, LLC) is recalling certain 2014-2019 Fiat 500 vehicles. The tire pressure monitoring system (TPMS) warning light may not illuminate as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 138, "Tire Pressure Monitoring Systems."

Consequence: A TPMS warning light that fails to illuminate can result in the vehicle being driven with improperly inflated tires, increasing the risk of a crash.

Remedy: Dealers will reprogram the TPMS electronic control unit module, free of charge. Owners were mailed July 11, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 80B.

Full recall detail →

MY VEHICLE WAS T-BONED ON MY DRIVERSIDE DOOR. THE VEHICLE THAT HIT ME WAS GOING 50MPH ACCORDING TO THE POLICE REPORT. I WAS CROSSING THE STREET AT ABOUT 10-15MPH. NOT A SINGLE AIRBAG ENGAGED, SIDE CURTAIN, SEAT, ETC. IT WAS ON A CITY STREET AND THE CAR THAT HIT ME WAS SPEEDING.

FIAT 500E VEHICLE BRAKING BEHAVIOR IS UNEXPECTEDLY HARD, SUDDEN, OR UNPREDICTABLE UNTIL THE USER USES AN OBD SCAN TOOL WITH APPROPRIATE DIAGNOSTIC SOFTWARE- AND INITIATES BRAKE CONTROLLER SENSOR RE-CALIBRATION. THIS OPTION IS FOUND UNDER THE DIAGNOSTIC MENU UNDER: ABS>RENENERATIVE BRAKE CONTROLLER>ACTIVE DIAGNOSTICS, AND THEN SELECTING THE PROCEDURE TO START (RBC SENSOR CALIBRATION). ONLINE FORUM USERS (PLEASE SEE LINK BELOW) ARE CURRENTLY USING 3RD PARTY SOFTWARE, AT THEIR OWN EXPENSE, TO CORRECT THE BRAKING DEFICIENCY (APPROXIMATELY $49). MY PERSONAL VEHICLE WAS PURCHASED USED AND WAS EXHIBITING SUDDEN AND UNEXPECTED BRAKING ISSUES AT APPROXIMATELY 8,500 MILES; THIS IS IN MY OPINION A VERY LOW NUMBER OF MILES TO BE EXPERIENCING REGENERATE BRAKING AND CONTROL ISSUES. PLEASE REFERENCE THE ONGOING DISCUSSION THREAD AT FIAT 500E ONLINE FORUMS: HTTPS://WWW.FIAT500OWNERS.COM/THREADS/FIX-GRABBY-BRAKES-FOR-70.149282/#POST-1292483

TL* THE CONTACT OWNS A 2016 FIAT 500. WHILE DRIVING 45 MPH, THE MANUAL CLUTCH FAILED AND PREVENTED THE CONTACT FROM CHANGING GEARS. AS A RESULT, THE CONTACT DROVE INTO A CEMENT BARRIER TO AVOID TRAFFIC. THE DRIVER AND PASSENGER FRONTAL AIR BAGS FAILED TO DEPLOY, CAUSING THE CONTACT'S HEAD TO STRIKE THE STEERING WHEEL. THE CONTACT INJURED HER NECK, LEFT SHOULDER, AND LEFT FOOT. THE CONTACT WAS TRANSPORTED TO THE HOSPITAL BY FAMILY MEMBERS. A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS TOWED. THE MANUFACTURER WAS NOT CONTACTED. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE APPROXIMATE FAILURE MILEAGE WAS 12,000. *DT *TR *DT*JB

TL* THE CONTACT OWNS A 2016 FIAT 500. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE SHIFTED INTO NEUTRAL WITHOUT WARNING AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. AN INDEPENDENT MECHANIC DIAGNOSED THAT THE WIRE HARNESS AND POWER TRAIN CONTROL MODULE NEEDED TO BE REPAIRED. THE CONTACT SCHEDULED AN APPOINTMENT WITH ACADIANA DODGE CHRYSLER JEEP RAM FIAT (1700 SW EVANGELINE THRUWAY, LAFAYETTE, LA 70508, (337) 232-7361). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 67,000.

TL* THE CONTACT OWNS A 2016 FIAT 500. WHILE OPERATING THE VEHICLE, THE TRANSMISSION JERKED AND SHIFTED ROUGHLY. OCCASIONALLY, THE VEHICLE WOULD SHIFT OUT OF GEAR AND FAIL TO IMMEDIATELY ACCELERATE. THE VEHICLE WAS TAKEN TO THE DEALER (NYLE MAXWELL FIAT, 13049 RESEARCH BLVD, AUSTIN, TX) WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION WAS FAULTY. COMPUTER UPDATES WERE PERFORMED TO THE POWER TRAIN CONTROL MODULE AND THE TRANSMISSION CONTROL MODULE, BUT THE FAILURES CONTINUED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES, BUT NO ASSISTANCE WAS OFFERED. THE FAILURE MILEAGE WAS 28,000.

CAR SWITCHES INTO NEUTRAL UNEXPECTEDLY CREATING A DANGEROUS INOPERABLE VEHICLE SCENARIO WHERE THE CAR WILL NOT MOVE FOR SEVERAL SECONDS. THIS HAS HAPPENED TO ME SEVERAL TIMES ON THE OPEN ROAD AND ALMOST CAUSED ME TO GET HIT FROM BEHIND. THIS IS A REGULAR OCCURRENCE WHICH I HAVE TO PREDICTIVELY ALLOW FOR BY ANTICIPATING THIS MAY HAPPEN.

ON MULTIPLE OCCASIONS MY WIFE'S CARE HAS REFUSED TO SRMTART WITH NOW ANSWER FROM THE DEALERSHIP WHY, THE BRAKES HAVE BEEN REPLACED BY FIAT UNDER WARRANTY AND THEY STILL SQUEAK WHEN IN REVERSE, AND LATELY IT SAYS THERE IS A TIRE SENSOR THAT IS DAMAGED OR LOW ALONG WITH DRIVE MODE UNAVAILABLE, THIS KEEPS US FROM USING THE AWD SYSTEM EFFECTIVELY, AND FIAT SAID THEY FIXED THE ISSUE ONCE BEFORE AND IT CAME BACK WITHIN THE WEEK. THE CAR HAS HAD ELECTRICAL PROBLEMS FROM THE DAY SHE BOUGHT IT ALONG WITH MULTIPLE OCCASIONS WITH NOT STARTING AND MULTIPLE COMPUTER PROBLEMS WITH NOW HELP FROM THE DEALERSHIPS, THIS CAR IS STILL COVERED UNDER ALL WARRANTIES AND STILL CAUSES PROBLEMS WITH MY WIFE GOING TO WORK. ON TWO OCCASIONS THE DRIVE MODE UNAVAILABLE ERROR CAME UP WHILE DRIVING, THIS DOESN'T ALLOW THE CAR TO OPERATE THE AWD SYSTEM LIKE IT SHOULD

THE VEHICLE WAS APPROACHING A STOPLIGHT AT APPROXIMATELY 15 MPH AND SUDDENLY ACCELERATED WHILE THE BRAKE WAS DEPRESSED, CAUSING A MINOR ACCIDENT (LITTLE DAMAGE TO BUMPERS OF BOTH VEHICLES). CAR WAS RETURNED HOME (1 MILE AWAY) WITHOUT INCIDENT. UPON MOVING THE VEHICLE IN THE DRIVEWAY LATER THAT SAME AFTERNOON, THE VEHICLE SUDDENLY ACCELERATED AGAIN WHEN DEPRESSING THE BRAKE; HAD TO ENGAGE THE PARKING BRAKE TO BRING THE VEHICLE TO A COMPLETE STOP. *BF *TR

WHILE DRIVING ON THE FREEWAY AND AT FREEWAY SPEEDS THE FRONT PASSENGER SIDE SUSPENSION COMPLETELY SNAPPED WITH NO ACCIDENT OR ROAD DEBRIS INVOLVED. THE WHEEL TURNED SIDEWAYS AND LOST ALL CONTROL OF THE VEHICLE'S ABILITY TO TURN. THE ENGINE THEN GAVE A TRANSMISSION FAILURE WARNING AND THE ENGINE CUT OUT. WAS ABLE TO GET THE CAR TO THE SIDE LANE AND WAITED FOR TRIPLE A TO SHOW UP UNTIL 5AM. TOOK PICTURES OF THE FRONT PASSENGER SIDE WHEEL WHICH WAS BASICALLY DANGLING OFF OF THE VEHICLE. IT WAS EXCEPTIONALLY DANGEROUS.

TL* THE CONTACT OWNS A 2016 FIAT 500. THE CONTACT STATED THAT THE DOORS FAILED TO UNLOCK WHILE USING THE KEY FOB. THE VEHICLE WAS TAKEN TO THE DEALER ON SEVERAL OCCASIONS. THE TECHNICIAN WAS UNABLE TO DUPLICATE THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 4,000.

THE CAR STOPPED WORKING IN THE MIDDLE OF THE HIGHWAY, STARTED TO GIVE ERROR MESSAGES AND TURNED ON ENGINE SERVICE, TRANSMISSION AND PARKING BRAKES LIGHTS. A FEW SECONDS AFTER WE JUST GOT THE MESSAGE: DRIVE MODE UNAVAILABLE AND THE CAR STOPPED. IT WAS REALLY DANGEROUS AND MY FAMILY AND I WERE IN A TERRIBLE RISK OF HAVE A PRETTY BAD ACCIDENT. WE ARE REALLY LUCKY THAT NOTHING HAPPENED TO US, WE COULD DIE THAT NIGHT.