2024 Chevrolet Tahoe

Component: FUEL SYSTEM, DIESEL:STORAGE:TANK ASSEMBLY

General Motors, LLC (GM) is recalling certain 2021 Cadillac Escalade, 2021, 2023-2024 Chevrolet Tahoe, and 2022 and 2024 GMC Yukon vehicles equipped with a 6-cylinder diesel engine. The original fuel tank may have been replaced with an incorrect fuel tank, which can allow fuel to leak in a rollover crash.

Consequence: A fuel leak in the presence of an ignition source increases the risk of a vehicle fire.

Remedy: Dealers will inspect for the correct fuel tank and replace it, if necessary, free of charge. Owner notification letters were mailed November 5, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252512770. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on September 18, 2025.

The contact owns a 2024 Chevrolet Tahoe. The contact stated that on four occasions while in reverse (R), the "Service Transmission" message was displayed, and the vehicle failed to reverse. The contact was able to shift into drive(D). The vehicle was taken to a dealer on four separate occasions, where it was diagnosed and determined that the transmission shifter had failed and needed to be replaced. The vehicle was repaired all four times, but the failure reoccurred. The manufacturer was not notified of the failure. The failure mileage was approximately 4,293.

SUV states brake system failure, tell driver not to drive over 43 miles per hour, attempted to have repairs continue to have repeat service with same issues, notified gm customer service of concerns regarding safety of vehicle with no brakes or steering control however vehicle states owner can drive, this is not safe to general public nor myself and family, gm staff stated could have towed did not seemed concerned for safety of the alert given as there is no current recall on this vin

Dealer checked the 6.2L motor for known defects. It "passed" inspection on 11/20/25 and got the thicker oil (OW-40). The engine lost propulsion ("died") 3 times on a 55mph State Highway on 02/09/26 with my 4 year old in the car with me. It died and came to a complete stop in one lane and would not re-start initially with cars almost rear ending us and needing to aggressively swerve to avoid hitting us. After 4 or 5 attempts it started again (making terrible grinding noises) so I could get it off the road before it died again. It started again to drive home on the back roads approximately 1 mile. Low oil pressure and check engine lights came on. I also received notifications from onstar and from the my Chevy app that there were severe motor or transmission problems. I scanned it with an OBD II Scanner and it has code P00016 (Camshaft Position Correlation - Bank 1 Sensor A). It got towed to the dealer and is now confirmed it is in need of a full motor replacement less than 3 months after they told me the motor passed inspection! This is not acceptable. To be told it's fine and then have it fail with my child in the car is extremely unsafe. Now I'm stuck trying to get a comparable loaner vehicle from the dealer to drive in the snow and mountains with my family safely while they expect to have the vehicle at minimum of 6 weeks. So far they have not found a loaner potentially putting my family in further danger by not having a 4X4 vehicle in a snowy climate.

I have a 2024 Tahoe that was purchased new from the dealer and has 13,700mi. The first service was completed as required in December with no issues identified. Less than 2 months later the front wheels started making a squeaking sound intermittently when accelerating, coasting or breaking. There were no warning messages. The dealership/mechanic looked over the car & said that the front brakes were measuring 2mm (completely worn out) but no other issues. Before drop off the car computer said above 75% or more for front and rear breaks (green). I have been driving the car in normal condition in southern ca. It seems that the break pads were defective and degraded at an alarming/unsafe rate or that a different component on the car caused them the continuously rub and wear down. The dealership blamed it on owner operation even though they supposedly checked them 2 months before and didn't see abnormal signs of wear. I am very concerned with the QUALITY, RELIABILITY & SAFETY of the front breaking system due to the fact that the breaks wore out so fast. I am worried that the problem has not been properly identified and that that breaks will continue to have this problem if it wasn't caused by faulty pads. I have never had a break wear problem like this before on any of the other 5 new cars that I have owned. This is the first American brand car I have owned and hopefully it's not a sign of things to come.

Driving on the New jersey Turpike I passed through the ez pass tolls traveling west bound on Bayview Ave bridge, the vehicle shut off without warning. No check engine light or noise, just no propulsion or anything. Dead in the water. Vehicle would not restart.

Vehicle lost all braking capability while in motion. Vehicle rolled to a stop with no brakes with warnings for brake system failure, no front collision active. Upon restarting the vehicle the warnings didnt not go way for 1hr. 2 hours later the warnings cleared from the information system but codes remains. Vehicle was taken to Uptown Chevrolet, Slinger WI and was informed of a bad battery as the "cause" of the issue. A bad battery should not result in the loss of braking capability on any vehicle!

Front passenger wheel has a fracture. The structural integrity of the wheel is compromised and is causing the tire to leak air, which is dangerous and can cause loss of vehicle control and damage to suspension or brakes. It could also cause dangerous blowouts, which causes a safety concern for me and others on the road if that happens. The problem has been confirmed by the dealership where the vehicle was purchased. Photos were taken and submitted to GM for warranty. The warranty was denied. The vehicle has not been inspected by anyone else other than the dealership where the vehicle was purchased. The only warning lamps were low tire pressure warning. The fracture was found during inspection as to the cause of the low tire pressure.

The vehicle in question had approximately 5000 miles when low oil light came on, it was 2 quarts low. this was after the first oil change at around 3500 miles. I had the dealer do an oil consumption evaluation. They check the oil every 500 miles and confirmed it was using 2 quarts every 2500 miles. They informed me GM says this is normal. I cannot disagree more with that claim. GM knows they have a problem with the 6.2-liter engine. I have researched the issue and found they have a problem with the crankshaft machining and the oil delivery port beveling that delivers lubrication to the connecting rod bearing appears to be too large that causes the motor oil not to consistently keep the bearing lubricated. This causes the engine to be an "oil burner" and premature failure of the bearing. They think putting a heavier viscosity of oil in will delay the inevitable engine failure, which makes me believe they are aware of the faulty manufacturing and want to run from their warranty responsibilities.

See attached document for complaint. We are writing to express our concerns regarding ongoing and unresolved issues with our 2024 Chevrolet Tahoe High Country Deluxe Package, which we purchased on [XXX] from Titus-Will Chevrolet in Olympia, Washington. Our vehicle was ordered on [XXX] and delivered with 12 miles on the odometer [XXX]. The total purchase price was $97,889.61. This vehicle is equipped with a 6.2-liter Ecotec VB engine and a 10-speed automatic transmission. Since shortly after purchase, we have experienced intermittent audio output problems. With these problems, there is no audio for the radio, phone calls or mapping directions from any of the apps. Incoming phone calls do not connect and outgoing calls cannot be made. Despite multiple service visits-[XXX] as well as documented audio output issues my wife recorded and dated due to the fact that the dealership is 50 miles away: [XXX] We have also driven our vehicle into the Titus Will dealership service department twice when the audio output was not working so the service techs were able to see exactly what was not working-the issues are still unresolved even after updates from the service department and over the air updates that were to "FIX" the issues per GMC/Chevrolet. Our dealership has been unable to identify or correct the defect. Additionally, we received a Safety Recall Notice (N252494000) on May 20, 2025, concerning a potential loss of propulsion in the 6.2-liter engine, which may lead to catastrophic engine failure and increased risk of a crash or harm. We were surprised to learn that this recall was issued on April 24, 2025-prior to our purchase date-yet was not disclosed by the dealer at the time of sale, which also appears to be deceitful on GMC's part. We would not have accepted the vehicle knowing there were catastrophic engine problems as we travel the highways often visiting family in Idaho and Spokane as well as taking care of our elderly parents this last year with their medical care transports. When we contacted Titus-Will Chevrolet about the recall, they informed us that they could not inspect my engine until further instruction was received from GM Corporate. We also requested to trade in our vehicle for a comparable model equipped with a smaller, unaffected engine (5.3L), but was told by both Titus-Will Chevrolet and Whitney Chevrolet in Montesano, Washington, that GM Corporate had instructed dealers not to buy back or trade these affected vehicles at this time. As a result, we are now left with a new vehicle that: - Has persistent, unresolved defects in the audio system; - Is subject to an active safety recall with potential for serious catastrophic failure including crashes; and - Have suffered a significant diminished value of our new vehicle due to these unresolved issues and restrictions on resale or trade-in. Given these circumstances, we respectfully request that Chevrolet replace our 2024 Tahoe with a new, comparable model equipped with a 5.3-liter engine (or another engine not subject to the recall) and the extended warranty we had purchased with the current Tahoe we own. We have been a loyal Chevrolet customer, having bought six new Chevy Tahoe's over the years as well as Chevy Pickups, and have always been satisfied- until this vehicle. We hope this matter can be resolved promptly and fairly. Please contact me at your earliest convenience to discuss the next steps, but we expect a written response no more than 40 days of receiving this letter. Thank you for your attention and understanding. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Purchased new vehicle in September 2024, immediately after purchasing the vehicle the engine had a clanking noise. Took the car back to the dealership where they explained the noise was normal. The car continue to make clanking noise, but noise continued to get louder, took the vehicle back to the dealership for first oil change, verify the noise, and discuss safety recall received on the vehicle. Dealer told me the car was ok to drive. In October 2025, the vehicle loss power during acceleration with immediate re-start. After this incident, took the vehicle to another dealer where they inspected the vehicle again. The test failed and the car now needs a new engine. Car has now 10K miles in the odometer and has been sitting in the dealership for 3 weeks now waiting for an engine replacement.

The contact owns a 2024 Chevrolet Tahoe. The contact stated that while driving approximately 35 MPH, there was an abnormal knocking sound coming from the vehicle. The vehicle stalled, and the message to "Press the Start Button” was displayed. The contact was able to restart and drive the vehicle. The contact stated that the following day, while driving and depressing the accelerator pedal, the vehicle hesitated before accelerating, with a rattling and tapping sound coming from the vehicle. The contact continued driving; however, the vehicle stalled with the message to “Press Start Button” displayed. The contact attempted to restart the vehicle however, the check engine warning light illuminated. The vehicle was towed to a dealer, but was not diagnosed. The vehicle was not repaired. The contact stated that prior to the failure the contact experienced failures with the vehicle related to NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling). The contact had taken the vehicle to the same dealer approximately 3 months prior for the recall inspection. The dealer stated that the engine had passed the inspection, and an oil change to a higher viscosity oil was performed. The contact then noticed the abnormal engine ticking sound and became aware that the engine was not responsive while depressing the accelerator pedal following the inspection. Additionally, the engine was idling roughly. The dealer was contacted, but informed the contact that the engine had passed the inspection. The contact stated that the recall had been removed from the VIN and was listed as completed; however, the vehicle experienced engine failure and was currently at the dealer. The manufacturer was informed of the failure. The failure mileage was approximately 25,000.

On October 23 I was driving my vehicle and the airbag light and a message service safety restraint appeared. On October 24 I was in route to take the vehicle to the dealership and as I was merging going to the highway the vehicle turned off, lost complete power threw itself into neutral. I had to drive it over to the shoulder to keep from getting hit. I was able to get the vehicle to turn back on and got it to the dealership. This would be the third time that the vehicle has lost power and completely turned off while driving the first time I took it to the dealership. They said they couldn’t find anything wrong. The second time this happened. I took it to the dealership. They said they replaced the gateway module this third time I took it to the dealership they have called me and said they need to replace the OnStar telecommunication module. The vehicle is unsafe. It is a brand new 2024 Tahoe I purchased it new. The vehicle should not be turning off while I’m driving The same messages consistently pop up the airbag in the service safety restraint. They replaced some kind of console at the top and say that that would fix the issue, but it didn’t because the message came back on again the vehicle idols as if it’s gonna turn off whenever I go to stop the vehicle The transmission stutters are like it’s going into a downshift and it acts like he wants to turn off, but it doesn’t it’s only turned off when I’m driving and then it will just shut off.