Loading vehicle data from NHTSA...
NHTSA recalls, safety ratings, and consumer complaints for the 2001 Chevrolet Express.
NHTSA has not published 5-star crash-test ratings for the 2001 Chevrolet Express. New vehicles are often added to the NCAP rating program after initial release; check nhtsa.gov/ratings for the latest status.
Component: EQUIPMENT ADAPTIVE/MOBILITY
RIFLED AIR CONDITIONING (RAC) IS RECALLING 6 MY 2001 CHEVROLET EXPRESS PRIVATE TRANSPORT, MY 2005 THOMAS BUILT FS65, MY 2006-2007 MONITOUR BUS, AND MY 2007 C-2 SCHOOL BUS VEHICLES BUILT ON FREIGHTLINER, AND GM CHASSIS AND EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403,"PLATFORM LIFT SYSTEM ACCESSIBLE FOR MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.
Consequence: A LIFT OCCUPANT CAN BE INJURED SHOULD THE LIFT BEGIN TO STOW UNINTENTIONALLY.
Remedy: RAC IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR RAC AT 1-800-627-1707.
Component: EQUIPMENT ADAPTIVE/MOBILITY
RIFLED AIR CONDITIONING (RAC) IS RECALLING 6 MY 2001 CHEVROLET EXPRESS PRIVATE TRANSPORT, MY 2005 THOMAS BUILT FS65, MY 2006-2007 MONITOUR BUS, AND MY 2007 C-2 SCHOOL BUS VEHICLES BUILT ON FREIGHTLINER, AND GM CHASSIS AND EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.
Consequence: THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.
Remedy: RAC IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR RAC AT 1-800-627-1707.
Vehicle shuts down during operation. I just saw there is a recall on your site saying same problem but mine didnt qualify. I have burned wires in harness to instrument panel. I found two wires at harness where code reader plugs into . O was able to ground them but now a couple months later same problem. I found burnt wires in harness and I cannot access to evaluate or replace. I've completed repairs myself, I am poor and dont know any honest affordable mechanics as I am capable of most reasonable repairs. I think my van falls under overheating panel warranty as described by this website. I still have 2 years of payments on van
ON FRIDAY JANUARY 29TH 2010 I WAS INVOLVED IN AN ACCIDENT. I REAR ENDED A SUV. MY 2001 CHEVROLET EXPRESS VAN WOULD NOT STOP DUE TO ANTI LOCK BRAKE FAILURE. WHEN I APPLIED THE BRAKES THE ANTI LOCK SYSTEM TOOK OVER AND THE BRAKE PEDAL WENT TO THE FLOOR. MY VEHICLE CONTINUED FORWARD NEVER SLOWING DOWN UNTIL I STRUCK THE VEHICLE AHEAD OF ME. I WOULD HAVE BEEN ABLE TO STOP IF THE ANTI LOCK BRAKES HAD NOT TAKEN OVER MY VEHICLE. I HAD A MORE THAN A FIVE SECOND SPACE BETWEEN THE VEHICLE IN FRONT OF ME. *TR
TL*THE CONTACT OWNS A 2001 CHEVROLET EXPRESS RV G1500. THE CONTACT STATED THAT THE FRONT DRIVER AND PASSENGER SEATS MOVED OUT OF PLACE WHILE DRIVING 30 MPH. THE VEHICLE HAS NOT BEEN DIAGNOSED BY THE DEALER. THE FAILURE MILEAGE WAS 179,000 AND CURRENT MILEAGE WAS 180,500.
The 2001 Chevrolet Express has 2 NHTSA recalls and 49 consumer complaints on file. For the most detailed information about a specific vehicle, decode its VIN using our free decoder above.
Enter a specific VIN to get the full report — specs, recalls, safety ratings, complaints, investigations, and technical service bulletins.
THIS RELATES TO EA06-016. I OWN A 2001 CHEVROLET 3500 , ENGINE DEFECT HAS NOT BEEN REPAIRED AS OF THIS DATE. THE VEHICLE STARTED TO STALL AS DESCRIBED IN THE DEFECT REPORT OF JULY OF 2006. I HAVE IN MY POSSESSION 6 WORK ORDERS FROM BRINGING THE VEHICLE TO MY LOCAL CHEVROLET DEALER-WHITEMAN CHEVROLET IN GLENS FALLS NY TO DIAGNOSE AND REPAIR THE STALL/START PROBLEM. THE OLDEST WORK ORDER WAS DATED 8/15/06 AND THE MOST RECENT ON 3/23/07. I HAVE ASKED FOR THEM TO CHECK SERVICE BULLETINS AND WITH GM'S MAINTENANCE HELP DEPARTMENT. ABOUT THIS PROBLEM. SO FAR THEY HAVE NOT BEEN ABLE TO DIAGNOSE OR REPAIR THE PROBLEM BECAUSE MY STALL/CRANK PROBLEM DOES NOT PRODUCE A CODE TO TRIGGER THE SERVICE WARNING LIGHT IN THE VEHICLE. AND THEY HAVE TOLD ME THAT GM HAS NO SERVICE BULLETIN OR ANY INFORMATION ON THIS ISSUE? MY PROBLEM SEEMS TO BE EXACTLY WHAT IS DESCRIBED IN THIS PRELIMINARY INVESTIGATION, VEHICLE WILL STALL WHILE DRIVING AND WILL CRANK WITHOUT STARTING. THIS HAPPENS ON AN INTERMITTENT BUT REGULAR BASIS, JUST NOT WHEN THE DEALERSHIP HAS THE VEHICLE IN ITS SERVICE DEPT. THE INCIDENT DATE LISTED BELOW IN THE APPROXIMATE DATE AND MILEAGE WHEN INCIDENT FIRST OCCURRED. THE NUMBER OF FAILURES LISTED IS JUST A GUESS, TOO MANY TO REALLY RECALL. JUST WANTED TO INDICATE THAT IT IS NOT A ONE TIME ONLY INCIDENT. THIS VEHICLE IS USED IN AS A WORK VEHICLE AND MAKES SHORT TRIPS, USED SEASONALLY-NOT IN THE WINTER MONTHS. *AK
DT: THE CONTACT STATED WHILE DRIVING THE VEHICLE IT STALLED INTERMITTENTLY. ALSO, IT STALLED WHEN SLOWING DOWN OR WHEN STOPPING. THE VEHICLE WAS TAKEN TO THE DEALERSHIP, AND THE FUEL INJECTOR PUMP WAS REPLACED. THIS REPAIRED THE VEHICLE.*AK
DT: THE CONTACT STATED WHILE DRIVING VEHICLE STALLED INTERMITTENTLY. THE VEHICLE STALLED WHEN SLOWING DOWN OR WHEN STOPPING. THE VEHICLE WAS TAKEN TO THE DEALERSHIP, AND THE FUEL INJECTOR PUMP WAS REPLACED. THIS REPAIRED THE VEHICLE.*AK UPDATED 12/07/05. *JB
DT: THE CONTACT STATED THE TREAD SEPARATED FROM THE LEFT REAR TIRE. THIS HAPPENED ON A RENTAL CAR THAT THE CONTACT'S HUSBAND WAS DRIVING. THE TIRE DEALER COULD NOT DETERMINE THE CAUSE OF THE FAILURE. *AK UPDATED- THE CONSUMER STRUGGLED TO MAINTAIN CONTROL OF THE VEHICLE, HOWEVER HE DID MANAGED TO BRING THE VEHICLE TO A SAFE STOP. *JB
SIDEWALLS OF TIRES SPLIT AFTER ONLY 38,000 MILES ON TIRES AND ARE ORIGINAL TIRES FOR MY 2001 CHEVY EXPRESS VAN . TIRE STYLE IS A STEELTEX RADIAL R45 ( LT 245/75R16)*JB
DT: CONTACT OWNS A 2001 CHEVROLET EXPRESS VAN. THE CONTACT STATED THE POWER PEDESTAL BRACKET FOR THE DRIVER'S SEAT BROKE. THE GENERAL MOTORS SERVICE DEALER STATED THAT THE THERE WAS NO REASON FOR THE BRACKET TO BREAK. THE GENERAL MOTORS MANUFACTURER STATED THAT THEY WILL NOT BE RESPONSIBLE FOR THE FAILURE OF THE AFTER MARKET PRODUCT INSTALLED BY MAJESTIC BECAUSE IT WAS NOT THE ORIGINAL EQUIPMENT OF THE VEHICLE. MAJESTIC STATED THAT THE BRACKET THAT BROKE WAS A GENERAL MOTORS PRODUCT, AND II WAS THE RESPONSIBILITY OF GENERAL MOTORS TO REPAIR IT. *AK
DT:CONSUMER BOUGHT VEHICLE NEW. AFTERWARDS, CONSUMER STARTED HAVING PROBLEM WITH THE DOOR HANDLES WHICH BROKE OFF. CONSUMER BOUGHT ANOTHER VAN, LATER AND THE HANDLES WERE THE SAME. THE VAN JUST PURCHASED HAD THE SAME PROBLEM. EACH TIME CONSUMER HAD HANDLES REPLACED. CONSUMER PAYS ABOUT $160 PER DOOR. CONSUMER CONTACTED GENERAL MOTORS A FEW TIMES, BUT GENERAL MOTORS REFUSED TO ANSWER TO CONSUMER'S SATISFACTION.*AK
LOST POWER STEERING AND BRAKES, THE POWER STEERING PUMP HAD BROKEN
WHILE PARKED A FIRE ERUPTED AND FLAMES CAME FROM BETWEEN THE DASHDOARD AND WINDSHIELD. *NM THE COMPLAINANT HAS A FLEET OF 50 DELIVERY VANS, INCLUDING THIRTY-NINE CHEVROLET VANS, SEVEN OF WHICH ARE THE SAME MAKE, MODEL AND YEAR AS THE ONE THAT CAUGHT ON FIRE.
THE CONSUMER HAD COME TO A STOP SIGN AND ATTEMPTED TO TURN LEFT AND DID SO WITH GREAT DIFFICULTY. THE CONSUMER NOTICED THAT EACH TURN HAD BECOME MORE DIFFICULT AND WAS ACCOMPANIED BY GRINDING NOISES. *SC THE CONSUMER HAD THE VEHICLE TOWED AND IT WAS DISCOVERED THAT THE STEERING GEAR BOX HAD SEIZED INTERNALLY. *JB
INTERMITTENTLY ACCELERATOR PEDAL WOULD BE STIFF/HARD FOR THE CONSUMER TO DEPRESS. *AK WHEN ACCELERATING FROM A STANDING POSITION OR A VERY SLOW SPEED THE PEDAL WOULD NOT GO DOWN GRADUALLY WHEN PUSHED HARDER, THE VEHICLE WOULD LURCH FORWARD. THE CABLE WAS FOUND FRAYED INSIDE THE CABLE SHREATH AND WAS REPLACED. *SC *JB
WHILE DRIVING REAR DRIVER'S TIRE TREAD SEPARATED. CONSUMER PULLED AND CHANGED THE TIRE. DEALERSHIP WILL BE NOTIFIED. FIRESTONE, LT24575R16. *AK
Showing 15 of 49 complaints