Loading vehicle data from NHTSA...
NHTSA recalls, safety ratings, and consumer complaints for the 1998 Chevrolet Express.
NHTSA has not published 5-star crash-test ratings for the 1998 Chevrolet Express. New vehicles are often added to the NCAP rating program after initial release; check nhtsa.gov/ratings for the latest status.
Component: EXTERIOR LIGHTING
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Remedy: SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Component: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND MULTI-PURPOSE PASSENGER VEHICLES. ONE OR BOTH FRONT BRAKE ROTOR/HUBS WERE BUILT WITH AN OUT-OF-SPECIFICATION GRAY IRON THAT CAN FAIL DURING THE LIFE OF THE VEHICLE.
Consequence: IF A DRIVER CONTINUES TO DRIVE WITH A CRACKED ROTOR, THE CRACKS COULD CONTINUE AROUND THE WHEEL MOUNTING BOLT CIRCLE AND ULTIMATELY RESULT IN A WHEEL SEPARATION.
Remedy: DEALERS WILL INSPECT THE ROTORS FOR A CORE DATE OF "287" AND, IF FOUND, REPLACE THE ROTOR.
FAILURE OF INTAKE MANIFOLD GASKET CAUSING LOSS OF COOLANT AT 42000 MILES AND AGAIN AT 90008 MILES. *NM
THE PASSENGER SIDE DOOR HINGE BROKE COMPLETELY OFF WITHOUT EXCESSIVE FORCE BEING APPLIED. THE DEALERSHIP INDICATED THIS OCCURRED BECAUSE THE DOOR WAS NOT FREQUENTLY USED. IN AN ATTEMPT TO REPAIR THE HINGE, THE DEALERSHIP MADE THE PROBLEM WORSE. *AK THE DEALERSHIP STATED THE PIN SEIZED UP DUE TO NO LUBRICATION. *JB
THE DOOR HINGES FROZE UP AFTER A PERIOD OF TIME. THE CONSUMER HAD TO USE EXCESSIVE FORCE TO CLOSE THE DOOR WHICH CAUSED THE DOOR TO BE MISALIGNED. *JB PH *JB
CONSUMER STATES THAT WHEN TRYING TO APPLY THE BRAKES THE BRAKE PEDAL WILL GO TO THE FLOOR CAUSING THE VEHICLE TO HAVE EXTENDED STOPPING DISTANCE. DEALER NOTIFIED TS
The 1998 Chevrolet Express has 2 NHTSA recalls and 23 consumer complaints on file. For the most detailed information about a specific vehicle, decode its VIN using our free decoder above.
Enter a specific VIN to get the full report — specs, recalls, safety ratings, complaints, investigations, and technical service bulletins.
CONSUMER STATED THAT WHILE DRIVING AND WITHOUT WARNING THE REAR AXLE FAILED CAUSING OIL TO LINK FROM THE VEHICLE. DEALER NOTIFIED TS
SMELLED GASOLINE AND SAW FUEL DRIPPING FROM SIDE AND BOTTOM OF VAN...VAN SPUTTERED TO STOP, LOST POWER STEERING BUT WAS ABLE TO COAST TO CLOSED GARAGE PARKING LOT...DETERMINED PLASTIC FUEL LINE WAS PUNCTURED--THEY TOLD ME PART(FUEL LINE) WAS DISCONTINUED!??
I NOTICED A CONTINUOUS TIRE THUMP" AND STOPPED THE VEHICAL AND CHECKED THE TIRES. THE LEFT FRONT TIRE HAD A FLAT SPOT IN THE CENTER OF THE TREAD, ABOUT 2IN X 1.5 IN. THERE WERE NO OTHER ABNORMATITIES. AFTER TRAVELING ABOUT 30 MORE MILES THE "THUMP" GOT ALOT MORE APPARENT AND I HEARD A LOUD "CLINKING" NOISE. I STOPPED AND INSPECTED THE TIRE AND FOUND THE TREAD WAS SEPARATING FROM THE TIRE OVER ABOUT A 12 IN. OF LENGTH WHERE THE STEEL BELT STOPS AT THE SIDE WALL. THE TREAD WAS STILL INTACT. I BELEIVE THAT IF I HAD NOT STOPPED WHEN I DID THAT TOTAL SEPERATION OF THE TREAD WOULD HAVE OCCURED WITHIN THE NEXT MILE OR SO. I HAVE THE TIRE IF YOU NEED TO INSPECT IT AND/OR I CAN SEND YOU PHOTOS .*AK (DOT NUMBER: VN1181A098 TIRESIZE: LT 245/ 75)
AIR TEMPERATURE 100 DEGREES FAHRENHEIT, AIR PRESSURE IN TIRE CHECKED AT 80 PSI COLD, SPEED 60MPH. THIS IS THE THIRD TIRE OF THIS SIZE AND MAKE, MADE IN CANADA. THIS ONE AND OTHER TWO HAD ABOUT 9 TO 10 THOUSAND MILES ON THE ROAD. EACH SUFFERED A TREAD SEPARATION. OTHERS HAD ODI#735190. *AK (DOT NUMBER: TPC 2012MS TIRESIZE: 24575R16 E)
THE PROBLEM IS IN BUCKLE FAILURES AND RETRACTOR FAILURES. RIVERSIDE VANS (CONVERSION CO.) SAID THEY HAVE HAD NO PROBLEMS WITH THESE BELTS. I HAVE HAD 4 FAILURES. MFR. IS ATWOOD MOBILE PRODUCTS. *AK
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
WHILE TRAVELING AT HIGHWAY SPEED VEHICLE WAS SHAKING OUT OF CONTROL. PULLED OVER AND NOTICED TIRE HAD A BLOWOUT.*AK CONSUMER STATES TIRE PEELED BACK AND BELT SEPARATED.*JB
VARIOUS SEAT BELTS (RETRACTORS AND BUCKLES) HAVE FAILED. CONVERSION BY RIVERSIDE VANS, COLON, MI. *AK
ENGINE SHAKES AND RATTLES, ENGINE LIGHT ILLUMINATES, VEHICLE STALLED WHILE TRAVELING 60 MPH, VEHICLE HAS BEEN IN REPAIR SHOP DUE TO FUEL INJECTOR FAILURE, HOWEVER PROBLEM STILL PERSISTS. SIDE CARGO DOOR WILL NOT LATCH AT BOTTOM, DEALER STATED RIGHT SIDE REAR DOOR LATCH LINK WAS MISALIGNED. *SLC
I WAS DRIVING ON THE INTERSTATE WITH 14 PASSENGERS WHEN I FELT THE VAN START TO RIDE ROUGH AND THEN FELT A FLAPPING FROM REAR OF VEHICLE. I THEN PULLED OFF THE ROAD TO FIND THE TIRE HAD COMPLETELY SHREDDED THE OUTER LAYER, BUT DID NOT BLOW OUT.*AK (TIRESIZE: 245/75R16)( DOT NUMBER: TIRE SIZE: 245/75R16 )
MY WIFE WAS DRIVING ON THE FREEWAY BRING HER CAR POOL HOME WITH SIX CHILDREN. SHE HEARD A LOUD THUMPING SOUND OCCUR ALL OF A SUDDEN. THE TIRE DID NOT BURST BUT WE LOST A SIGNIFICANT PORTION OF THE TREAD. WE HAVE HAD THE TIRES REPLACED WITH GOODYEAR TIRES. THE SAME DAY THIS HAPPENED WE HEARD THESE TIRES WERE ALSO BEING INVESTIGATED. WE STILL HAVE THE TIRES IN OUR POSSESSION. (DOT NUMBER: VN11B1A307 TIRESIZE: LT245/75R1)
Showing 15 of 23 complaints