Loading vehicle data from NHTSA...
NHTSA recalls, safety ratings, and consumer complaints for the 1997 Chevrolet Express.
NHTSA has not published 5-star crash-test ratings for the 1997 Chevrolet Express. New vehicles are often added to the NCAP rating program after initial release; check nhtsa.gov/ratings for the latest status.
Component: EXTERIOR LIGHTING
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Remedy: SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Component: FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
PASSENGER VANS. THESE VANS EXPERIENCE FUEL ODORS OR LEAKAGE.
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A REVISED EVAPORATIVE EMISSION PIPE ASSEMBLY.
TL* THE CONTACT OWNS A 1997 CHEVROLET EXPRESS. THE CONTACT STATED THAT A FUEL ODOR CAME FROM THE VEHICLE AND THE VEHICLE LEAKED FUEL ONTO THE GROUND. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN. THE VIN WAS NOT AVAILABLE. UPDATED 04/22/16*LJ UPDATED 05/31/18*JB
DT*: THE CONTACT STATED THERE IS A HOOK ON THE REAR PASSENGER SIDE DOOR. THE CONTACT'S HEAD STRUCK THE HOOK, WHICH RESULTED IN THE CONTACT LOSING CONSCIOUSNESS AND HERNIATING TWO DISCS. THE MANUFACTURER SENT A REPRESENTATIVE, WHICH DETERMINED THIS IS HOW THE VEHICLE WAS DESIGNED.
DT*: THE CONTACT STATED WHILE TRAVELING 75 MPH, THE FRONT DRIVER SIDE TIRE BLEW OUT. THE VEHICLE WAS PULLED OVER INTO THE MEDIAN AND THE TIRE WAS CHANGED. TWO HUNDRED MILES LATER, THE PASSENGER SIDE REAR TIRE BLEW OUT. THE VEHICLE WAS PULLED OVER TO THE SHOULDER AND THE TIRE WAS REPLACED. THE TIRES WERE SENT TO THE MANUFACTURER WHICH DETERMINED THE BLOWOUTS WERE A RESULT OF ROAD HAZARDS. UPDATED 4/6/2006 - THE CONSUMER BELIEVES THE FAILURE WAS DUE TO TREAD SEPARATION. *NM
The 1997 Chevrolet Express has 2 NHTSA recalls and 30 consumer complaints on file. For the most detailed information about a specific vehicle, decode its VIN using our free decoder above.
Enter a specific VIN to get the full report — specs, recalls, safety ratings, complaints, investigations, and technical service bulletins.
THE TRANSMISSION HAD AN OVERHEATING PROBLEM THAT CAUSED THE VEHICLE TO SWITCH TO "SAFE" MODE. SAFE MODE COMPENSATED THE TRANSMISSION HEAT PROBLEM BY HARD SHIFTING. THE VEHICLE WAS TAKEN TO A TRANSMISSION SPECIALTY REPAIR SHOP WHERE I LEARNED THAT THE PROBLEM WAS IN THE DESIGN OF THE TRANSMISSION. IT WAS THE OPINION OF THE REPAIR SHOP THAT GM KNEW OF THE PROBLEM BUT WOULD NOT ISSUE A RECALL BECAUSE THE ISSUE WAS NOT LIFE THREATENING. COST OF MODIFICATION WAS $1,600.*JB
DT: WHILE DRIVING SERVICE ENGINE LIGHT ILLUMINATED ON THE DASH PANEL. THE CONSUMER TOOK THE VEHICLE TO A CHEVROLET DEALER, WHO PERFORMED A DIAGNOSTIC TEST WHICH SHOWED THAT TRANSMISSION WAS SLIPPING. THE DEALER NOTED THE NEXT STEP WOULD BE TO CHECK THE TRANSMISSION FLUID. DUE TO THE COLOR OF THE FLUID IT WAS DETERMINED A NEW TRANSMISSION WOULD BE NEEDED. THE DEALER REFERRED THE CONSUMER TO OTHER INDEPENDENT SHOPS, AND THEY TOO CONFIRMED WHAT THE DEALER SAID. THE CONSUMER TOOK THE VEHICLE HOME AND PARKED IT. NO CORRECTIONS OR REPAIRS WERE MADE. THE CONSUMER CALLED CHEVROLET MANUFACTURER, AND THEY SAID THERE WAS NOTHING THEY COULD DO. THE CONSUMER CONTACTED CHEVROLET AGAIN, AND THEY ESCALATED HIS CONCERNS BUT OFFERED NO FURTHER ASSISTANCE. *AK UPDATED 05/06/08 *BF THE CONSUMER STATED THE ABS AND MASS AIR FLOW SENSOR FAILED. UPDATED 05/06/08
TAIL LIGHT SOCKET FAILURE, NEW SOCKETS ARE GOING TO BE INSTALLED. *JB
DEFECTIVE SEAT BELT WAS MOUNTED ON MIDDLE CAPTIAN CHAIR, STARCRAFT CONVERSION VAN. CABLE BROKE FROM NORMAL USAGE?
WHILE SHIFTING TRANSMISSION DOWN SHIFTED ON ITS OWN. A LOUD NOISE WAS HEARD COMING FROM THE FRONT. CONSUMER DROVE VEHICLE TO THE DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT TRANSMISSION NEEDED TO BE REPLACED. *AK
FUEL GUAGE FAILURE ON MY 1997 EXPRESS VAN. GUAGE SHOWED FUEL TANK EMPTY. ESTIMATED REPAIRS= $600.00. THIS HAS HAPPENED TO FRIENDS WITH SAME YEAR CHEVROLETS. INTERNET FULL OF COMPLAINTS FOR 1997 AND 2000 YEARS. THIS IS A SERIOUS SAFETY ISSUE, AND A VERY COSTLY REPAIR THAT MANY CANNOT AFFORD. PLEASE, PLEASE HELP. I AM SUBMITTING THE SAME FUEL GUAGE FAILURE COMPLAINT FOR A 2000 CHEVROLET BLAZER REGARDING AN INCIDENT THAT PUT MY TEENAGER IN SERIOUS JEOPARDY!*AK
WHILE DRIVING THE VEHICLE'S RIGHT FRONT WHEEL CAME OFF WITH THE LUG NUTS STILL ATTACHED TO THE HUB. AS A RESULT THE VEHICLE JERKED TO THE RIGHT AND RAN INTO A WALL. THE MANUFACTURER HAS BEEN CONTACTED. PLEASE PROVIDE ANY ADDITIONAL INFORMATION. *NM
WHILE DRIVING THE VEHICLE'S RIGHT FRONT WHEEL CAME OFF WITH THE LUG NUTS STILL ATTACHED TO THE HUB. AS A RESULT THE VEHICLE JERKED TO THE RIGHT AND RAN INTO A WALL. THE MANUFACTURER HAS BEEN CONTACTED. PLEASE PROVIDE ANY ADDITIONAL INFORMATION. *NM
THIS PROBLEM AFFECTS 1996-2002 G-SERIES VANS (CHEVY EXPRESS AND GMC SAVANA). THE POWERTRAIN CONTROL MODULE/VEHICLE CONTROL MODULE (PCM/VCM) CORRODES OVER TIME AND THE CASE ENCLOSING THE COMPUTER SPLITS OPEN ALLOWING WATER TO ENTER THE VEHICLE'S ELECTRICAL SYSTEM. GM HAS ACKNOWLEDGED THIS PROBLEM IN TECHNICAL SERVICE BULLETIN 02-06-04-020, ATTRIBUTING IT TO LOCATION OF THE PCM/VCM AND DESIGN OF THE ENGINE WIRING HARNESS DEFLECTOR. THIS DEFLECTOR ACTS MUCH LIKE A "RAIN GUTTER" TO ROUTE WATER AWAY FROM THE COMPUTER. IT WAS POORLY DESIGNED AND INSTEAD DUMPS WATER DIRECTLY ON TO THE COMPUTER TRIGGERING CORROSION. THE CORROSION MAY ALSO BE THE RESULT OF GALVANIC ACTION (TWO DISSIMILAR METALS GENERATING AN ELECTRICAL CHARGE) AS THE COMPUTER CASE IS ALUMIONUM AND SCREWS HOLDING IT TOGETHER ARE STEEL. A SMALL CLAIMS COURT ACTION FILED AGAINST GM AND THE DEALERSHIP IMMEDIATELY RESULTED IN AN OFFER FROM GM TO PAY FOR ALL REPAIRS (PRIOR TO ANY HEARINGS). THIS LEADS US TO BELIEVE THEY ARE VERY AWARE OF THIS PROBLEM AND MAY IN EFFECT HAVE A "SECRET WARRANTY" IN PLACE. TOTAL REPAIR COST WAS $1,400 BUT IT COULD HAVE BEEN MUCH MORE SINCE WE CHOSE TO "DRY OUT" THE ELECTRICAL SYSTEM RATHER THAN REPLACE THE ENTIRE WIRING HARNESS (MORE THAN $2,000 PARTS AND LABOR).
ON 12-02-01 WHILE TRAVELING AT 70 MPH DOWN THE HIGHWAY AT 5 A.M. ON MY WAY TO WORK THERE WAS A VERY LOUD SCREECHING NOISE AND I LOST ALL POWER TO THE VAN, TRANSMISSION GONE . VEHICLE TOWED TO MARK BASS CHEVROLET DEALER IN COAL CITY,IL. MILEAGE AT 107060. NO LONGER COVERED UNDER WARRANTY, TRANSMISSION REPLACED AT A COST OF $1863.34 TO CONSUMER PLUS TOW BILL AND RENTAL CAR FOR 1 WEEK. ON 12-29-01 DRIVING DOWN THE HIGHWAY WITH THE CRUISE AGAIN SET AT 68 MPH I AGAIN LOST THE TRANSMISSION. MILEAGE NOW AT 108219 AND VEHICLE AGAIN TOWED TO DEALERSHIP FOR REPAIRS. VEHICLE IS EQUIPPED WITH A TRANS COOLER WHICH WAS INSTALLED UPON PURCHASE BY THE DEALERSHIP AND HAS TOWED A BOAT FOR A TOTAL OF 30 MILES. 99% OF THE MILES ARE INTERSTATE MILES DUE TO WORK DISTANCE OF 100 MILES PER DAY AND TRAVELING TO VISIT MY CHILDREN AND FATHER WHO LIVE IN TEXAS AND COLORADO. VEHICLE ALSO SEEMS TO GO THROUGH AN EXCESSIVE NUMBER OF BRAKES WHICH SEEM TO BE CONTINUELY GOING OUT AND HAVE BEEN REPLACED ABOUT 6 TIMES ALL THE WAY AROUND. I PURCHAED THIS VEHICLE BECAUSE OF THE NEED FOR COMFORT AND DEPENDABILITY IN MAKING LONG DISTANCE TRIPS WHERE I AM MOSTLY ALONE. IT HAS BEEN SERVICED ON A REGULAR BASIS AND IS IN VERY GOOD CONDITION. IT HAS ONLY BEEN DRIVEN BY ONE OTHER PERSON AND HAS NOT BEEN MIS-USED IN ANY WAY.*AK
OUTSIDE MIRRORS VIBRATE. BECAUSE OF VIBRATION DRIVER CANNOT SEE VEHICLE IN THE REAR. CONTACTED DEALER, AND DEALER STATED ITWAS A NON REPAIRABLE ITEM. PLEASE ADD VIN. *AK
FIRESTONE, 245 75 R16, DOT # AN11B1A517, ORIGINAL EQUIPMENT, 30000 MILES MOUNTED ON A 1996, CHEVROLET, EXPRESS. WHILE DRIVING AT HIGHWAY SPEEDS THERE WAS SOME TREAD SEPARATION ON BACK LEFT TIRE.*AK *SLC
Showing 15 of 30 complaints