1994 Chevrolet Caprice

Component: EXTERIOR LIGHTING

CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Consequence: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

Remedy: PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.

Full recall detail →

Component: WHEELS:LUGS/NUTS/BOLTS/STUDS

PAINT ON THE WHEEL MOUNTING SURFACES CAN ACT AS A SHIM BETWEEN THE WHEEL AND THE ROTOR/DRUM. AS THE VEHICLE IS DRIVEN, THE WHEEL IMBEDS INTO THE PAINT, LOOSENING THE LUG NUT AND CAUSING A LOSS OF CLAMP LOAD.

Consequence: ONCE CLAMP LOAD IS LOST, ALL TIRE LOADS ARE TAKEN BY THE WHEEL STUDS RESULTING IN A FRACTURE OF THE WHEEL STUDS. THIS COULD CAUSE THE WHEEL TO SEPARATE FROM THE VEHICLE AND COULD RESULT IN A VEHICLES CRASH WITHOUT PRIOR WARNING.

Remedy: DEALERS WILL CLEAN THE WHEEL MOUNTING SURFACES FOR ALL FOUR WHEELS. ALSO, THE WHEEL STUDS WILL BE INSPECTED FOR DAMAGE AND WILL BE REPLACED AS NECESSARY.

Full recall detail →

Component: SUSPENSION:REAR

THE REAR LOWER CONTROL ARM CAN CRACK AT THE REAR STABILIZER BAR ATTACHMENT.

Consequence: THIS CONDITION CAN BE AGGRAVATED BY THE SEVERE DUTY CYCLE OF THESE VEHICLES AND EVENTUALLY CAUSE THE LOWER CONTROL ARM TO FRACTURE COMPLETELY CAUSING A LOSS OF VEHICLE CONTROL WITHOUT PRIOR WARNING.

Remedy: DEALERS WILL REPLACE BOTH REAR LOWER CONTROL ARMS AND REAR STABILIZER BAR ATTACHMENTS.

Full recall detail →

Component: SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT

DEFECTIVE LOWER CONTROL ARM BALL JOINT ATTACHMENT NUTS WERE NOT PROPERLY TORQUED AND CAN LOOSEN.

Consequence: IF THE LOWER CONTROL ARM BALL JOINT LOOSENS, FATIGUES AND SEPARATES FROM THE FRONT SUSPENSION KNUCKLE, IT COULD CAUSE LOSS OF VEHICLE CONTROL.

Remedy: DEALERS WILL INSPECT BOTH FRONT LOWER CONTROL ARM BALL JOINT ATTACHMENT NUTS FOR PROPER TORQUE. IF THE BALL JOINT HAS LOOSENED FROM THE KNUCKLE, BOTH THE BALL JOINT AND THE KNUCKLE WILL BE REPLACED.

Full recall detail →

Component: ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSES/LINES/PIPING/FITTINGS

THE ENGINE OIL COOLER INLET HOSE MAY HAVE BEEN INSTALLED TOO CLOSE TO THE STEERING GEAR CAUSING CHAFING. THE CHAFING CAN EVENTUALLY WEAR THROUGH THE HOSE'S PROTECTIVE SLEEVE RESULTING IN ENGINE OIL LEAKING ONTO THE ENGINE.

Consequence: IF THIS OCCURS, THE OIL LEAK ONTO THE ENGINE CAN RESULT IN AN ENGINE COMPARTMENT FIRE.

Full recall detail →

Component: FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING

THE FUEL TANK ATTACHMENT STRAP FASTENERS WERE NOT PROPERLY TIGHTENED. THE FASTENERS CAN COMPLETELY DETACH, EVENTUALLY ALLOWING THE FUEL TANK TO SAG AND THE BOTTOM OF THE TANK TO STRIKE THE ROADWAY.

Consequence: THIS CAN RESULT IN A FUEL TANK LEAK AND FIRE IF THE LEAKING FUEL IS EXPOSED TO A SOURCE OF IGNITION.

Remedy: DEALERS WILL RETIGHTEN THE FUEL TANK STRAP FASTENERS.

Full recall detail →

Component: VEHICLE SPEED CONTROL:SPRINGS

THESE VEHICLES FAIL TO CONFORM TO FMVSS NO. 124, "ACCELERATOR CONTROL SYSTEMS." AT LOW TEMPERATURES, EXCESSIVE FRICTION CAN OCCUR IN THE ACCELERATOR PEDAL ASSEMBLY.

Consequence: CONSEQUENCE OF NON-COMPLIANCE: IN THE EVENT OF A FAILURE OF THE TROTTLE RETURN SPRING, IF THERE IS EXCESSIVE FRICTION IN THE PEDAL ASSEMBLY, THE ENGINE SPEED MAY NOT RETURN TO IDLE INCREASING THE POTENTIAL FOR A VEHICLE CRASH.

Remedy: DEALERS WILL REPLACE THE ACCELERATOR PEDAL ASSEMBLY.

Full recall detail →

DIGITAL DASH SPEEDOMETER GOES AWAY, DOES NOT SHOW SPEED OF TRAVEL. WHEN THIS HAPPENS OPPERATOR DOES NOT KNOW THE RATE OF SPEED BEING TRAVELED. I HAVE REPLACED THE UNIT ONCE BEFORE AT 99,000 MILES WITH A RECONDITIONED UNIT AT A COST OF $300.00. RECENTLY AT 140,000 MILES THIS UNIT HAS FAILED ALSO. THIS RECONDITIONED UNIT IS THE ORIGIONAL UNIT FROM THE CAR THAT HAD BEEN SENT IN FOR REPAIR THE FIRST TIME.*AK

DT: CABLE FROM BATTERY TO JUNCTION BOX OVERHEATED AND STARTED A FIRE. IT MELTED THE STUD THAT BATTERY CABLE WAS CONNECTED TO, THE JUNCTION BOX AND THE AREA AROUND THE JUNCTION BOX. CALLER WAS AT A CAR WASH AND THE ATTENDENT SAW SMOKE AND ALERTED CONSUMER. THEY OPENED THE HOOD AND DISCONNECTED THE BATTERY. VEHICLE WAS TOWED TO DEALER. MANUFACTURER SAID THEY HAD NO RECALL. *AK *NM

DT: GENERAL MOTORS REFUSED TO HONOR A RECALL 94-C-59 ON 1994 CHEVROLET CAPRICE CLASSIC. CAR OVERHEATED IN THE ELECTRICAL CENTER, THE COVER MELTED. THIS CAN HAPPEN AT ANY TIME, AND NO INDICATOR LIGHTS CAME ON PRIOR TO THE CAR STALLING. THE CAR LOST POWER COMPLETELY THE CAR WILL NOT START BACK UNTIL THE ELECTRICAL HOUSING HAS BEEN MANIPULATED IN SOME WAY. THE CAR WILL START BACK THEN. GENERAL MOTORS SAID CAR WAS NOT UNDER THIS RECALL. THEY SAY THIS RECALL IS NOT IN THERE SYSTEM. THE CONSUMER WITH 2 REPRESENTATIVES A GM. THE CONSUMER HAD A MECHANIC LOOK AT VEHICLE THE AND HE SAID THIS WAS THE SAME PROBLEM AS THE RECALL. THIS HAS HAPPENED AT LEAST 12-15 TIMES. *AK

VEHICLE PURCAHSED USED FROM A CHEVY DEALER. EXPERIENCED COMPLETE LOSS OF ELECTRICAL POWER, EVEN HAZARD LIGHTS INOPERATIVE. MECHANIC THOUGHT IT WAS ALTERNATOR, PROBLEM EXPERIENCED AGAIN. MECHANIC FOUND "BATTERY STUD" LOCATED AT "ELECTRICAL CENTER" WAS LOOSE. HE "PATCHED" IT UP. I HAVE FOUND THROUGH "ALLDATA" THAT THIS WAS A PROBLEM INDENTIFIED IN "CAMPAIGN 94-C-59" & A RECALL WAS ORDERED. CHEVROLET CLAIMS THERE ARE "NO OPEN RECALLS" FOR MY VEHICLE.

I STARTED MY 1994 CHEVY CAPRICE CLASSIC AND BEFORE I COULD GET IT INTO GEAR, MY CAR TOOK OFF AND SLAMMED INTO THE BACK OF A HONDA.

VEHICLE LOST POWER AND STALLED DUE TO BATTERY CABLE CONNECTION OVERHEATING AT THE UNDER HOOD ELECTRICAL CENTER STUD. THIS OCCURRED BECAUSE THE BATTERY CABLE PLASTIC COVER, T PLASTIC STUD HOUSING, AND/OR THE STUD ITSELF MELTED. THERE WAS GENERAL RECALL 94C59 FOR THE ELECTRICAL CENTER BATTERY STUD. THE VIN NUMBER WAS WITHIN THE RECALL, BUT MANUFACTURER REFUSED TO HONOR THE RECALL, INDICATING THAT THIS VEHICLE WAS NOT A POLICE CAR, TAXI , OR A SPECIAL SERVICE WAGON.*AK

PROBLEMS WITH FIRESTONE TIRE EQUIPMENT ON VEHICLE.*MR THE CONSUMER HAD NEW FIRESTONE TIRE INSTALLED ON THE VEHICLE. WHILE DRIVING THE CONSUMER HEARD A THUMPING NOISE AND RETURNED THE VEHICLE TO THE DEALER. THE VEHICLE WAS TAKEN TO THE DEALER FIVE TIMES AND EACH TIME THE DEALER INDICATED THAT THE NOISE WAS DUE TO A MECHANICAL PROBLEM. THE CONSUMER FINALLY TOOK THE VEHICLE TO TWO OTHER TIRE COMPANIES. BOTH COMPANIES CONCLUDED THAT THE THUMPING NOISE WAS COMING FROM THE TIRES. THE TIRES WERE REPLACED AND THE THUMPING SOUND WAS GONE. THE CONSUMER REQUEST REIMBURSEMENT FOR ALL FOUR TIRES AND THE MONEY TO HAVE THE TIRES CHECKED. *NM

MY WIFE'S 1994 CAPRICE HAS HAD INTERMITTENT NON WORKING POWER STEERING SINCE WE BOUGHT THE CAR NEW. IT IS A TOTAL LOST OF STEERING AS IF THE BELT HAD BROKEN OR THE MOTOR WAS TURNED OFF. AFTER SEVERAL LENGTHY SERVICE TRIPS TO THE DEALER, WHO ACTED LIKE WE WERE CRAZY, NOTHING WAS EVER DONE TO THE CAR. RECENTLY (2 MONTHS AGO) MY WIFE STARTED SAYING THAT NOW THE CAR WOULD NOT TURN LEFT AT HIGHER SPEEDS AND SHE HAS ACTUALLY HAD TO GO STRAIGHT THROUGH AN INTERSECTION BECAUSE SHE COULDN'T TURN LEFT. IT ALSO WAS FAILING QUITE OFTEN WHILE TURNING AT VERY LOW OR NO SPEED. THE POWER STEERING PUMP WAS REPLACED. (REMAN FROM AC DELCO). I ALSO NOTICED THAT THE FLUID WAS BROWN AND THICK. ALSO REPLACED PRESSURE HOSE, RETURN HOSE, STEERING BOX (REMAN FROM AUTOZONE) AND THE POWER STEERING PRESSURE IDLE CONTROL SWITCH AT THE SAME TIME. THE RESERVOIR WAS FLUSHED OF ALL THE BROWN FLUID. THE REMAN STEERING BOX WAS ALREADY PRIMED WITH NEW FLUID. AFTER MY WIFE DROVE THE CAR ABOUT A WEEK, SHE CALLED TO INFORM ME THAT THE CAR WAS STILL DOING THE SAME THING!! . HERE IS MY OPINION HAS TO WHAT IS HAPPENING. THIS IS THE FIRST YEAR THAT THE 4.3L V-8 MOTOR WAS USED. THE POWER STEERING PUMP IS NOT TURNING FAST ENOUGH AT IDLE SPEED. WHEN MY WIFE TAKES HER FOOT OFF THE GAS TO MAKE THE LEFT TURN (ITS SORT OF A HALF U TURN THE WAY THE ROAD IS LAID OUT) WHILE AT THE SAME TIME TURNING THE WHEEL, THE ENGINE IS AT IDLE SPEED AT THAT POINT. THE PROBLEM IS THE SAME AS WHEN MANEUVERING IN A PARKING LOT OR DRIVEWAY WHERE THE PROBLEM SHOWS UP MORE OFTEN AND THE ENGINE IS AT IDLE SPEED ALSO. THIS HAS HAPPENED NUMEROUS TIMES OVER THE PAST SEVERAL YEARS AND I CANNOT GET GM INTERESTED IN SOLVING THE PROBLEM. PLEASE ANSWER THIS. MY WIFE ALMOST HAD A SERIOUS ACCIDENT THIS MORNING AND THE PROBLEM NEEDS TO BE CORRECTED BEFORE SOMEONE GETS HURT. DO YOU HAVE ANY SUGGESTIONS OR IDEAS ON WHAT THE PROBLEM MIGHT BE? PLEASE HELP. RONNIE BELITZ. *JB

WHEN STEERING IS TILTED IN A CERTAIN DIRECTION A FUSE WOULD BLOW OUT. *AK THE FUSE THAT BLOWS IS FOR THE WINDSHIELD WIPERS. CONSUMER THINKS IT A PINCHED WIRE IN THE STEERING COLUMN WHEN THE WHEEL IS TITLED AND THE WIPERS ARE TURNED ON. A LIGHT MOVEMENT OF THE TILTED WHEEL WILL BLOW THE FUSE. CONSUMER FEELS THIS IS UNSAFE. *PH *NLM

DIGITAL SPEEDOMETER WAS 35 MPH OFF WHICH RESULTED IN A REAR END COLLISION BECAUSE VEHICLE WAS GOING FASTER THAN THE SPEEDOMETER INDICATED. DIGITAL GAS GAUGE ALSO FAILED TO FUNCTION WHICH RESULTED IN VEHICLE RUNNING OUT OF GAS WHILE DRIVING ALTHOUGH THE GAUGE READ HALF OF TANK. THE CAUSE OF BOTH FAILURES WAS UNDETERMINED.*AK

THE VEHICLE DIED AT 65 MPH,AND WOULD NOT RESTART. HAD TO BE TOWED. *AK

FUEL PUMP FAILURE. WIRE CONNECTED TO FUEL PUMP MELTED BARE. WIRE CONNECTOR MELTED ONTO FUEL PUMP. WIRE HARNESS MELTED. *JB