1996 Buick Roadmaster

THE LOWER CONTROL ARM BALL JOINT BROKE OFF WHEN I STARTED TO DRIVE THE CAR IN A PARKING LOT ON OCTOBER 31, 2006. I HAD TO HAVE A NEW LOWER ARM AND BALL JOINT INSTALLED ON THE CAR SINCE A BOLT HAD SHEARED HOLDING THE BALL JOINT TO THE ARM. BUICK HAD A PREVIOUS RECALL ON THIS, BUT MY CAR WAS SUPPOSEDLY BUILT WITH A LATER SERIAL NUMBER. I HAVE THE BROKEN ASSEMBLY STORED IN MY GARAGE. *JB

UPON LEAVING FOR WORK IN THE MORNING, MY 1996 BUICK ROADMASTER WITH 56,600 MILES WOULD NOT START. I HAD THE CAR TOWED TO A LOCAL AUTO REPAIR GARAGE. WENT TO PICK UP CAR A COUPLE OF DAYS LATER AND THE MECHANIC TOLD ME I WAS LUCKY THERE HAD NOT BEEN A FIRE OR EXPLOSION DUE TO THE SMOLDERING FUEL PUMP AND MELTED WIRING HARNESS INSIDE THE FUEL TANK. HE GAVE ME THE PART. I THOUGHT THAT GENERAL MOTORS WOULD BE INTERESTED IN HEARING ABOUT THIS DEFECT AS I WAS SURE THAT MANY OTHER ROADMASTERS ARE STILL ON THE ROAD. I CALLED THE CUSTOMER RELATIONS DEPT. ON 6/27 AND RELATED THIS SAFETY CONCERN AND ALSO SENT AN E-MAIL TO THEM ON THEIR WEBSITE OFFERING TO SEND PICTURES OF THIS PART. AS OF TODAY, 7/6/06, I HAD NOT HEARD FROM ANYONE SO I CALLED AGAIN. I EMPHASIZED MY CONCERNS AGAIN AND ALSO REQUESTED TO BE COMPENSATED FOR THIS REPAIR AS I FELT THIS WAS NOT A NORMAL WEAR AND TEAR PROBLEM, BUT A DEFECT PROBLEM. I WAS TOLD THAT THE VEHICLE WAS TOO OLD. I TOLD THEM THAT I DID NOT REALIZE THERE WAS A TIME LIMIT ON PEOPLE'S SAFETY AND WELL BEING. I ALSO TOLD THEM THAT I WAS DISAPPOINTED THAT NO ONE AT GM WAS INTERESTED IN SEEING THIS PART OR PICTURES. THEY COULD BE RELYING ON THE FACT THAT THE GAS TANK IS UNDER A VACUUM, BUT IN THIS CASE, THE PUMP WAS ACTUALLY SMOLDERING AND IF I HAD HAPPENED TO STOP AND GET GAS WHILE THIS WAS SMOLDERING AND REMOVED THE GAS CAP AND ADDED THE THIRD ELEMENT, OXYGEN, THERE VERY WELL COULD HAVE BEEN A FIRE OR EXPLOSION. THIS IS AN ORIGINAL GM PART AND I FIND IT HARD TO BELIEVE THAT GM HAS NO INTEREST IN THIS MATTER. THE ORIGINAL MILEAGE SHOULD BE A FACTOR, NOT JUST THE YEAR. CUSTOMER RELATIONS TOLD ME THEY WOULD SEND ME IN WRITING THEIR REFUSAL TO ASSIST ME WITH ANY COMPENSATION FOR THE REPAIR. WHAT BOTHERS ME THE MOST IS THEIR LACK OF CONCERN FOR OTHER PEOPLE'S SAFETY. *JB

DRIVING ON SAN PABLO DAM RD JUST PAST APPIAN WAY AT ABOUT 30-35 MPH THE RIGHT FT TIRE FOLDED UP UNDER THE CAR THE LOWER BALL JOINT FAILED AND SNAPPED IN HALF. *JB

SINCE NEW THIS 1996 BUICK ROADMASTER STATION WAGON HAS HAD 4 TRANSMISSIONS INSTALLED IN IT. THIS PARTICULAR CAR HAS THE FACTORY INSTALLED 5000LB TOW PACKAGE. THIS CAR USES THE GM, 4L60E, 4 SPEED, ELECTRONIC TRANSMISSION. ACCORDING TO THE ORIGINAL OWNER, THE 4L60E TRANSMISSION WENT OUT WHEN IT ONLY HAD ROUGHLY 40,000 MILES ON IT. HE TOLD ME THE 2ND TRANSMISSION WENT OUT 40,000MILES AFTER IT WAS INSTALLED. THE PREVIOUS OWNER TOLD ME HE HAD THE 3RD TRANSMISSION INSTALLED WHEN THE CAR HAD 85,000 MILES ON IT. I BOUGHT THE CAR WITH 119,000 MILES ON THE ODOMETER, AND THE 3RD TRANSMISSION FAILED WHEN THE CAR HAD 142,000 MILES ON IT. THE 4L60E TRANSMISSION IS A VERY POOR TRANSMISSION FOR THE TASK ASSIGNED. THE CAR ALREADY WEIGHS 4500LBS AND IS RATED TO TOW 5000 MORE LBS. MAKING UP ROUGHLY A 10,000LB PLATFORM. THIS TRANSMISSION FAILS IN MANY, MANY VEHICLES IT WAS INSTALLED IN REGARDLESS OF PURPOSE, USE, OR CARE. *NM

VEHICLE IS EXPERIENCING PROBLEMS WITH THE AUTO DOOR LOCKS, AND THE COURTESY LIGHTS. OWNER HAS CONTACTED THE MANUFACTURER WHO SAYS THERE IS NOTHING THEY CAN DO. PROVIDE FURTHER DETAILS. *NM

I ACQUIRED A CAR WITH FOUR NEW TIRES ARIZONIAN R/S,A/S. THE TIRES SAY TRACTION A TEMPERATURE B WEAR 360. UTQG GRADING SAYS TRACTION B TEMPERARURE C WEAR 240. WHY SUCH A VARIANCE? I WOULD NEVER RUN A TIRE WITH YOUR GRADING. I FEEL WEARY UNSAFE. *JB

WHILE BACKING IN VEHICLE STALLED. VEHICLE FAILED TO RESTART AFTER SEVERAL ATTEMPTS. SERVICE TECHNICIAN STATED, WIRING HARNESS NEEDED REPLACEMENT. *AK WIRES INSIDE THE GAS TANK BURNED AND MELTED PLASTIC AT THE FUEL TANK HOOK UP. THIS COULD'VE BLOWN UP AND KILLED SOMEONE. CONSUMER WOULD LIKE A REFUND FOR THE WIRING HARNESS. *PH

FUEL PUMP FAILED & VEHICLE WOULD NOT START, VEHICLE TOWED TO SHOP, MECHANIC FOUND SHORTED FUEL PUMP DUE TO LOOSE WIRING THAT CAUSED ARCING IN TANK FOR SOME TIME. MECHANIC STATED THAT WIRING MAY NOT HAVE BEEN HOOKED UP PROPERLY AT FACTORY. *JB

WHILE TRAVELING ON THE HIGHWAY WITHOUT PRIOR WARNING. THE STEERING WHEEL WILL WANDER OFF TO THE LEFT AND WILL PULL TO THE RIGHT OF THE ROAD. PLEASE FILL IN ADDITIONAL INFORMATION DEALER IS AWARE OF THE PROBLEM. TS

96 BUICK ROADMASTER WAGON DRIVER'S SIDE DOOR CATCHES FIRE AND DESTROYS CAR! INTERNAL DOOR FIRE.

TO START THE ENGINE , AND THE CAR WAS PUSHED INTO ST STALL BY.THE SS TUBE UNDER THE CAR AND THE SS MANIFOLD ON THE MOTOR BLOCK ARE CONNECTED VIE A THIN-WALLED PLASRIC TUBE, WHICH IS HEAT-SHRINKE UNDER THE CAR AND CONNECTED TO THE MANIFOLD BY A FLIMSY PLASTIC CONNECTOR. BOTH CONNECTORS BROKE ( OF COURSE THEY MUST BRAKE EVENTUALLY THRU AGE ETC), AND THE GAS SPILLED ONTO THE HOT MOTOR BLOCK, FORMING A PUDDLE AND VAPORIZING , THUS FORMING AN EXPLOSIVE MIXTURE WAITING TO BE IGNITED FROM THE HOT EXHAUST MAMNIFOLD. *AK REFERENCED IN EA02-030

DUE TO MISALIGNMENT TIRES ARE WEARING.*AK