2019 BMW 3 Series

Vehicle shudders under acceleration no warning lights or errors . Changed transfer case oil and same problem continues. No recall from manufacturer for issu

See attached document for complaint.

I am reporting a premature failure of two critical engine components: the Heat Management Module (Coolant Pump/Thermostat assembly) and the Oil Filter Housing. Despite the vehicle's low mileage (40,000 miles), the Heat Management Module began leaking coolant, posing a significant risk of engine overheating and sudden loss of power while driving. Simultaneously, the Oil Filter Housing has developed a leak, allowing oil to seep onto the engine block and potentially onto the serpentine belt. Both failures represent a safety hazard: Coolant Leak: Risk of thermal engine damage and being stranded in traffic due to overheating. Oil Leak: Risk of oil contacting hot exhaust components (fire hazard) or causing the serpentine belt to slip/fail, resulting in a sudden loss of power steering and charging systems. These components appear to have failed due to manufacturing or material defects rather than standard wear and tear for a vehicle of this age and mileage

My 2019 BMW 330i has a recurring cooling system defect, including coolant leaks, heater inoperative, and risk of engine overheating. The defect began while the vehicle was under warranty and was repaired by BMW, but it recurred. BMW later instructed me not to drive the vehicle due to safety concerns, yet declined responsibility and transportation. The vehicle remains unsafe to operate.

The contact owns a 2019 BMW 330i. The contact stated that while driving at 60 MPH on a three-lane highway, traveling in the exit lane, and using the hands-free calling system to speak with his wife, the vehicle crashed into an unknown metal object in the roadway, which tore the undercarriage. The driver-side air bag exploded without warning, resulting in him sustaining a concussion, and the vehicle came to a stop. The emergency call system failed to activate. His wife was able to contact 911, who was delayed in locating the incident site. The fire department, ambulance, and police department were on the scene. The contact was treated at the scene by the ambulance. The contact went to a walk-in clinic the next day, where medical attention was provided. There was no reported fire or police report filed due to the lack of identification of any damage. The vehicle was towed to the local dealer, who determined there was damage to the undercarriage. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The contact had written a letter to send to the manufacturer. The failure mileage was approximately 51,443.

The contact owns a 2019 BMW 330I. The contact recently purchased the vehicle. The contact received notification of NHTSA Campaign Number: 25V636000 (Electrical System); however, the part to do the recall repair was not yet available. The contact stated while driving 60 MPH, the vehicle failed to accelerate as intended while depressing the accelerator pedal. The message "Drivetrain Malfunction" was displayed. The contact stated that on a separate occasion, when the vehicle was started, the vehicle vibrated and jerked abnormally with several unknown warning lights illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The failure became progressively worse, and the vehicle was no longer being driven. The manufacturer was not made aware of the failure. The approximate failure mileage was 54,000.

The contact owned a 2019 BMW 330I. The contact stated that while the vehicle was parked on the driveway, the vehicle caught fire. The contact called the fire department, and the fire was extinguished. The vehicle was towed to an impound lot and was declared a total loss by the contact's insurance provider. The contact stated that recently he had received a recall notice from the manufacturer for NHTSA Campaign Number: 25V636000 (Electrical System). The contact related the fire to the description of the recall of the fire risk when parked. The manufacturer was informed of the failure. The failure mileage was approximately 57,000.

The contact owns a 2019 BMW 330I. The contact stated that upon starting the vehicle, the check engine warning light illuminated intermittently. The contact received notification of NHTSA Campaign Number: 25V636000 (Electrical System); however, the part to do the recall repair was not yet available. The dealer was not contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The approximate failure mileage was 91,000.

My parked vehicle, with the ignition off, caught fire while I was inside the gym. Within10-15 mins of entering the gym, the gym intercom announced that a car matching the description of my vehicle was on fire on the parking lot. When I went outside, firefighters were actively extinguishing the flams and cutting in the hood of the car. The vehicle was ultimately destroyed and considered a total loss. The vehicle has an active recall warning of a potential fire risk, even when the car is parked and turned off. The fire occurred without any action on my part, and I could have been seriously injured or killed. Also, others as well.

The contact owns a 2019 BMW 330I. The contact had received notification of NHTSA Campaign Number: 25V636000 (Electrical System); however, the part to do the recall repair was not yet available. The contact called the local dealer and the manufacturer and was advised that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure.

Seat restraint malfunction that prevents the air bag from working properly. Dealer is aware of this problem but has not been able to correct it.

The issue at hand is the oil filter housings on the B 58 and B 48 motors that BMW manufacturers. These oil filter housings are known to break after four years or 60,000 miles. can range from the engine overheating to oil leaks. The engine overheating can total the motor and the oil leaking can become a fire hazard. I was fortunate enough to be able to replace mine while BMW replaced another common failure point which is the heat management module. However, this is not as big as an issue as the oil filter, housing, because if the oil leaks, it can become again a fire hazard. There are several forum posts online about this issue I would like for NTHA please look at this thank you.

Vehicle is relatively new and kept in great shape. No damage nothing, one day the sensor for passenger airbag malfunction appears indicating that passenger airbag will not deploy in event of a crash. Dealership says it’s not covered under warranty and have to pay to replace out of pocket costing multiple thousands of dollars. Error seems manufacturer defect.