2000 Audi A4

Component: ENGINE AND ENGINE COOLING:ENGINE

The Gates Corporation (Gates) is recalling certain aftermarket Tru-Flow Water Pumps, part number TFW 41127, sold at certain NAPA Auto Parts and/or installed by automotive service technicians after November 1, 2013 (and manufactured August 2013 through October 2013) that have a black-colored pulley/sprocket or do not have 'US9377' stamped on the water pump housing. These service replacement parts were sold for use in model year 1999-2005 Audi A4, 2000-2006 Audi TT, 1998-2005 Volkswagen Beetle, 1999-2006 Golf, 1999-2008 and 2011-2013 Volkswagen Jetta, and 2000-2005 Volkswagen Passat. In the affected water pumps, the pulley or sprocket that turns the timing belt may develop microfractures causing the timing belt to fail.

Consequence: A failure of the timing belt may cause the engine to shut down, potentially increasing the risk of a vehicle crash.

Remedy: Gates will notify owners, and dealers will replace the water pump, free of charge. The recall began during May 2014. Owners may contact The Gates Corporation at 1-303-744-1911.

Full recall detail →

Component: EXTERIOR LIGHTING

CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."

Consequence: LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH

Remedy: AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.

Full recall detail →

Component: EXTERIOR LIGHTING

CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Consequence: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

Remedy: CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.

Full recall detail →

AUDI COMPLAINT AND RECALL REQUEST THE ANTI LOCK BRAKING SYSTEM NO LONGER WORKS LIKE IT SHOULD. WHEN THE VEHICLE IS STARTED I GET A SOLID AMBER ABS WARNING LIGHT ALONG WITH A FLASHING BRAKE LIGHT ACCOMPANIED WITH THREE WARNING TONES. UPON DOING AN INTERNET SEARCH I IMMEDIATELY REALIZED THIS PROBLEM WITH THE BOSCH 5.3 ABS CONTROL MODULE UNIT IS EXTREMELY COMMON ON 1998 TO 2001 AUDI AND VW MODELS. AUDI/VW CREATED A SERVICE BULLETIN TO REPAIR VW'S IN THE SAME DATE RANGE (BULLETIN 0517 NHTSA ID NUMBER: 10016037), BUT IGNORED THE ISSUE WITH AUDI'S. AS PER THE VEHICLE'S OWNER'S MANUAL, IT STATES THAT WHILE THE SYSTEM IS IN THIS STATE, THE REAR BRAKES MAY LOCK UP UNDER BRAKING. THIS IS A SERIOUS PROBLEM THAT WILL NOT ALLOW ME TO BRAKE QUICKLY IN EMERGENCY SITUATIONS. THE COST OF REPLACING THE ABS MODULE FROM THE DEALERSHIP WAS QUOTED AT OVER $1000. A SIMPLE INTERNET SEARCH REVEALS THAT THOUSANDS OF AUDI OWNERS HAVE VOICED COMPLAINTS. THIS IS A BLATANT DISREGARD FOR THEIR CUSTOMER'S SAFETY AND A RECALL SHOULD BE REQUIRED. *TR

2000 AUDI A4. CONSUMER WRITES IN REGARDS TO THE OVD 2 UNIT IN AUDI AND VW VEHICLES *TGW THE CONSUMER STATED THE PROBLEM INVOLVED THE OVD 2 UNIT WHICH COMMUNICATED THE SMOG TEST RESULTS TO THE COMPUTER AND DMV. ALTHOUGH, THE VEHICLE WOULD PASS THE EMISSIONS TEST, THERE WOULD BE A COMMUNICATION ERROR. THE DMV REQUIRED THE COMMUNICATION AND MADE NO EXCEPTION. THE ROOT OF THE PROBLEM STEMMED FROM THE OVD 2 UNIT PLACED INTO THE RADIO. WHEN THE RADIO IS REPLACED WITH A NON AUDI OR VW RADIO THE OVD 2 UNIT IS NO LONGER THERE. THE CONSUMER WAS INFORMED THE PRICE TO REPLACE THE RADIO CONTAINING THE OVD 2 UNIT IS $1000 AND UP.

ON MY 2000 AUDI A4 THE ANTI LOCK BRAKING SYSTEM NO LONGER WORKS. I GET A SOLID AMBER ABS WARNING LIGHT ALONG WITH A FLASHING BRAKE LIGHT ACCOMPANIED WITH THREE WARNING TONES WHEN I START THE CAR. AFTER MUCH RESEARCH, THIS IS A COMMON PROBLEM ON 1998 TO 2001 AUDI AND VW MODELS. I HAVE NOT HEARD OF ANY RECALL, HOWEVER THERE SHOULD BE ONE. THIS IS A SERIOUS PROBLEM THAT WILL NOT ALLOW ME TO BRAKE QUICKLY IN ALL SITUATIONS ESPECIALLY WINTER CONDITIONS AND THE COST TO GET IT REPLACED IS FAR TOO MUCH. *TR

1. WHEN THE ABS IS ACTIVATED DURING SNOW OR ICE CONDITIONS. 2. THE BRAKES "STICK" AND THE ABS IS NOT FULLY DEACTIVATED ONCE YOUR FOOT IS OFF THE BRAKE PEDAL. OFTEN THE REAR DRIVER SIDE BRAKE IS STILL ENGAGED SLIGHTLY DURING DRIVING. WHEN STOPPED YOU CAN SMELL THE RUBBING BRAKES AND YOU CAN TELL THE BRAKE IS RUBBING WHILE DRIVING AS IT SLOWS DOWN THE VEHICLE. IT USUALLY UNSTICKS AFTER SEVERAL MILES OF DRIVING OR LEAVING THE CAR SIT OVERNIGHT NOT RUNNING. 3. I'VE TAKEN THE VEHICLE TO THE DEALER SEVERAL TIMES OVER THE YEARS, BUT THEY TELL ME THAT THERE IS NOTHING WRONG WITH THE BRAKES OR ABS SYSTEM. *TR

I WAS HEADED NORTH BOUND ON THE CALIFORNIA 57 RIGHT BEFORE DIAMOND BAR BLVD. WHEN MY CAR STARTED TO FISH TAIL. I DROVE OVER TO THE SHOULDER LANE AND RIGHT AS I MERGED OVER MY BACK DRIVER SIDE TIRE SNAPPED OFF TAKING HALF MY WHEEL BASE WITH IT LEAVING NO WAY TO PUT A SPARE TIRE ON. *TR

ABS MODULE FAILURE & CENTER CLUSTER FAILURE - 2000 AUDI A4 1.8T, 65,000 MILES. ABS COMES ON ALONG WITH BLINKING BRAKE LIGHTS. KNOWN AUDI ISSUE. HAVING ABS REBUILT BY MODULE MASTERS AS AUDI WANTS $$ AND ANY NEW ABS MODULE THEY WILL INSTALL WILL ALSO FAIL. CENTER CLUSTER ALSO FAILED, ALSO KNOWN AUDI ISSUE. *TR

THE HEAT SHIELDS ABOVE MY CATALYTIC CONVERTERS CAUGHT FIRE AND HAD TO BE REPLACED, AT A LARGE EXPENSE TO ME. UPON RECEIPT OF THE REPLACEMENT PARTS, IT WAS NOTICED THAT THE PARTS HAD BEEN REDESIGNED. I BELIEVE THAT THE MANUFACTURER HAS FOUND A FUNDAMENTAL ISSUE WITH THEIR ORIGINAL DESIGN AND IS QUIETLY REPLACING THEM. THE PROBLEM WITH THIS IS THAT IT TAKES YOUR CAR CATCHING ON FIRE TO KNOW YOU NEED TO REPLACE THEM. *TR

REPLACEMENT HEADLIGHT ASSEMBLY P/N 341-1107L-US MADE BY DEPO FOR 2000 AUDI A4 HAS THE CENTER BULB ROTATED 180 DEGREES FROM THE ORIGINAL. A BULB ENGINEER AT SYLVANIA/OSRAM SAID THE PARTICULAR BULB LIGHT PATTERN IS DEPENDENT UPON ORIENTATION DUE TO THE FILAMENT STRUT AND A REFLECTOR IS DESIGNED TO WORK WITH THE BULB IN A CERTAIN DIRECTION. THE POTENTIAL ISSUES ARE 1) WAS THE REFLECTOR DESIGNED AND TESTED TO WORK WITH THE BULB THAT WAY, AND IF NOT 2) WAS THIS SOMETHING THAT WAS JUST OVERLOOKED OR IGNORED WHEN THE LIGHT WAS COPIED FROM THE ORIGINAL AUDI DESIGN, OR 3) WAS THIS A MANUFACTURING MISTAKE THAT HAPPENED TO A BATCH OF PARTS. A US DISTRIBUTOR THINKS #1 IS THE CASE, BUT HE MADE THE COMMENT WITHOUT SPEAKING TO THE ENGINEERS IN TAIWAN. IF THIS CONDITION IS IMPROPER, THERE ARE MANY LIGHT ASSEMBLIES OUT THERE LIKE THIS AND THEY MAY NOT PASS REGULATORY TESTS. I HAVE A PICTORIAL COMPARISON OF THE DEPO PART ALONGSIDE THE ORIGINAL THAT I CAN EMAIL AS ADDITIONAL INFORMATION. UPDATED 07/23/09 *BF *TR PICTURE RECEIVED. UPDATED 07/27/09

I HAVE A 2000 AUDI A4. THERE WAS A LETTER THAT WAS MAILED TO ME EXPLAINING THE DEFECT WITH THE VEHICLE 2 MONTHS AFTER THE INCIDENT HAPPENED. THE TIMING BELT ON MY VEHICLE BROKE RESULTING IN SEVERE ENGINE DAMAGE. THE MANUFACTURER REFUSES TO PAY FOR THE DAMAGE OR FIX IT. *TR

THE ABS AND BRAKE LIGHT IS FLASHING ON MY DASH BOARD. THE REPAIR SHOP SAYS THAT THE ABS CONTROL MODULE NEEDS TO BE REPLACED. THE COST IS ABOUT $1000! MY CAR HAS ABOUT 120,000 MILES ON IT. *TR

THERE ARE HUNDREDS OF COMPLAINTS ONLINE ABOUT THE ANTI-LOCK BRAKING FAILING IN AUDI'S AND VW'S BUILT BETWEEN 1996 AND 2001. ACCORDING TO MY MECHANIC, THIS IS A VERY COMMON PROBLEM THAT THEY'VE SEEN A LOT OF. SEE MANY OWNERS DISCUSSING THE PROBLEM HERE: HTTP://AUDI-VW-ABS-RECALL.BLOGSPOT.COM/2005/07/AUDI-AND-VW-PLEASE-RECALL-CARS-BETWEEN.HTML THE ABS IS A VERY IMPORTANT PIECE OF SAFETY EQUIPMENT, AND IT SEEMS IRRESPONSIBLE TO ME THAT AUDI HAS FAILED TO RECALL A VERY COMMON AND KNOWN MANUFACTURING DEFECT. *TR