2022 Toyota Tacoma

Transmission blew at 40200 miles under normal driving conditions going approximately 30/35 mph

G

Power steering pump was replaced at 33000 miles 12-7-23. Timing chain seal leak, engine was pulled at 37700 miles 6-19-24. Power steering pump leaking again at 45500 miles 1-3-25. White paint peeling at 45500 miles 1-3-25. Toyota said $1100 for new Power steering pump that is 12500 miles old. They will not cover white paint peeling in 3 areas.

See attached document for complaint.

Transmission is failing, fluid was black and burnt at 35k miles (dealer did not provide a large enough sample to allow for testing the fluid because I didn't specify the amount I needed), and vehicle is not throwing a CEL or MIL so therefore Toyota says that there is no defect. Fluid change did improve the functioning, but it did not correct the problem. Transmission failures are a known problem on numerous Toyota vehicles using an A series transmission. My vehicle has done this and progressively worsened since it had roughly 500 miles on it. Dealership originally refused to document my complaints in their system and Toyota Customer Care's assistance has been minimal at best. My vehicle suffers from numerous of the same complaints that are listed under the 2024 model Tacoma. Before servicing the transmission fluid the vehicle would occasionally have an extremely hard shift around 55mph that would result in the truck spinning tires on the interstate which shouldn't even be possible. I actually managed to capture a short video of the dash as it was doing this once and even sent it to Toyota but they said if they can't replicate it then it doesn't count. I think there needs to be an investigation into Toyota's transmission issues as well as someone should investigate their programming for MIL/CEL activation parameters as their vehicles are alerting the driver's to a problem until there is a complete and total failure which could leave the driver in an unnecessary and dangerous situation that could possibly be avoided if the driver was informed when the "Fail-safe" features activate instead of when they're unable to compensate. I am unable to load the video through this computer; however, I can upload the video from my phone upon request.

The contact owns a 2022 Toyota Tacoma. The contact stated that while driving approximately 35 MPH and driving up a steep incline, there was an engine misfire and the vehicle almost stalled. The contact depressed the accelerator pedal and heard an abnormal sound coming from the engine compartment. The contact stated that it was like a clanging metal-on-metal sound. The contact stated that no warning was illuminated. The contact stated that prior to the failure, the vehicle was idling roughly and hesitated while depressing the accelerator pedal. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle was not diagnosed or repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 26,000.

I have a 2022 white Toyota Tacoma trd4x4. The paint is chipping in the inside fender on the left side. I did some research and looks like there was a recall for this very issue and that Toyota was reimbursing for the repairs. I called Toyota today and they said that I’m vin doesn’t fall in that recall. A vehicle that is less that 3 years old new shouldn’t have the paint chipping. I don’t drive the vehicle much and don’t use it in extreme conditions. They refused to help and stated I’m out of warranty. The recall was for the same issue I am having on all white tacomas on the inner fender and window areas. They didn’t want to help because my white is not the same code. But thought it was funny because it’s the same issue, same color and defective in the same place. On top of that, paint shouldn’t chip in 3 years from new to now when the vehicle has been garage kept and has only 20k miles. I would really appreciate you guys opening an investigation on this please. Thank you!

The contact owns a 2022 Toyota Tacoma. The contact stated that while driving at an undisclosed speed, another vehicle failed to stop at a red light. Consequently, the other vehicle collided with the vehicle on the passenger's side door and front quarter panel, sending the vehicle careening and nearly tipping over before coming to a complete stop. The air bags did not deploy. No warning lights were illuminated. The vehicle was towed to the dealer, who submitted a request to the manufacturer to have an engineer inspect the vehicle. The engineer reviewed the incident recorder and informed the contact that the air bags did not deploy because the occupancy sensor did not detect a passenger. The contact disputed the findings, stating that her son was occupying the passenger seat and had been wearing a seat belt at the time of the collision. A police report was filed, and injuries were reported. The contact was transported to an area hospital by EMT and treated for back pain. She later followed up with her primary care physician and neurosurgeon who located a tear just below where a previous surgery was performed stating that the tear was not present as of her most recent evaluation before the accident. The contact stated that she previously had back surgery to repair and/or remove discs L3, L4, and L5. The manufacturer was notified of the failure, and a case was opened. The contact was later informed by the manufacturer that there was no data from the incident recorder on the date of the collision. The failure mileage was 24,000.

Known issue of paint peeling around the window frame on white vehicles. However, Toyota indicates that this VIN is not affected by this reported issue. They cannot explain why and deny it could be happening based on the VIN number alone.

A txdot road work crew had traffic stopped on the highway. We were last in a row of traffic when a distracted, driver, traveling near full highway speed rear-ended us. The truck automatically connected us to an agent who called 911. The message screen showed 2 warnings which said seatbelt malfunction and airbag malfunction. My husband and I both sustained injuries from the forward force against the seat belts to his abdomen and my shoulder, both of which required surgical repair. The airbags did not deploy. The truck was a total loss. A police report was filed but I do not have a copy.

I started up my Toyota Tacoma early morning on [XXX] and noticed the engine light came on after it warmed up in the cold climate of Northern Arizona. As such, this occurred at 36,303 miles. The fault code stated the following: “A malfunction in the electronic control of the engine, throttle, or automatic transmission has been detected. Contact your Toyota dealer in order to have your vehicle inspected.” Later in the day, I scheduled an appointment for December 14, 2024 at Anderson Toyota. I explained the situation and was disappointed to get an engine light so early, as it didn’t make any sense. Afterwards, at 8:47 PM from getting off work, I intuitively decided to check the engine compartment as the lady with the dealership claimed if rats chewed up the wires it wouldn’t be covered under warranty. Lo and behold, I didn’t find any wires chewed up, but I did find the engine oil filler cap wholly missing! I documented this incident with my camera phone in utter disgust, my initial assessment is Toyota failed to reinstall the oil filler cap. I called the next day, and left a voicemail expressing my disgust and disappointment in their service. Upon arrival, Service Advisor Jennifer advised it is a known issue with the OEM oil filler caps coming off. The dealership claims it wasn’t their tech, but a faulty part. Again, (1) this puts me in danger on the road with open contamination occurring to the point, where my engine light is now activated and (2) Toyota should issue a lifetime replacement warranty for any engine issues for the 22’ model Tacomas as the damage has occurred, regardless of what the dealership claims. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2022 Toyota Tacoma. The contact stated that while driving through an intersection at approximately 25 MPH; another vehicle who ran the red light T-boned the contact's vehicle on the passenger side. The air bags did not deploy upon impact. The contact sustained pain in her back and was treated by her doctor for a torn disk. A police report was filed. The vehicle was initially towed to an independent body shop and was later towed to the dealer where it remained in their possession. The manufacturer was notified of the failure and was given a case number. The vehicle had yet to be repaired. The failure mileage was approximately 24,000.