Loading vehicle data from NHTSA...
NHTSA recalls, safety ratings, and consumer complaints for the 2002 Pontiac Grand Prix.
| Trim | City | Hwy | Combined | Annual fuel $ |
|---|---|---|---|---|
| 3.8L 6 cyl Automatic 4-spd | 16 | 25 | 19 | $3,650 |
| 3.1L 6 cyl Automatic 4-spd | 18 | 26 | 21 | $2,850 |
| 3.8L 6 cyl Automatic 4-spd | 17 | 27 | 20 | $3,000 |
| Overall Rating | Not Rated |
| Frontal Crash | Not Rated |
| Side Crash | Not Rated |
| Rollover | Not Rated |
Component: ENGINE AND ENGINE COOLING:ENGINE
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Component: ENGINE AND ENGINE COOLING
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
The contact owns a 2002 Pontiac Grand Prix. The contact received notification of NHTSA Campaign Number: 15V701000 (Engine and Engine Cooling). The vehicle was taken to the dealer, where the contact was informed that the vehicle could not be serviced because it was an older vehicle, and the dealer informed the contact that the recall part had been discontinued. The contact was referred to the manufacturer for assistance. The vehicle was then taken to Christian Brothers Automotive, where it was serviced, and the contact was informed that engine oil was leaking onto the exhaust manifold. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 38,500.
On May 27th 2023 just three days ago I went to start my car but it would not start, I tried two times then I smelled gas so I let it sit over night then the next day my friend went out to start it for me and it made a loud bang and the intake manifold exploded causing a fire and debris went everywhere, my is lucky he got away from the when he did or he would have been injured maybe even killed from the flames. I did not take any photos or report to anyone, a neighbor heard the load bang and came out to see if anyone was ok. There were no warning signals that appeared to my knowledge. There were 200,000 miles on the vehicle at time of the incident.
I had just drove about 30 miles home and when I arrived my engine was was smoking a little more than was usual because of oil burn off. So I popped the hood and a fire started in the back of the engine where I was having problems previously with the power steering pump. Obviously when I opened the hood it helped the fire and it grew. Took 30 minutes to put out. Car is now out of commission and I don't know what to do.
The 2002 Pontiac Grand Prix has 7 NHTSA recalls and 339 consumer complaints on file. It received an overall safety rating of Not Rated out of 5 stars in NHTSA crash testing. The high number of complaints suggests potential reliability concerns — review the complaint details above before purchasing. For the most detailed information about a specific vehicle, decode its VIN using our free decoder above.
Enter a specific VIN to get the full report — specs, recalls, safety ratings, complaints, investigations, and technical service bulletins.
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Component: STEERING
DORMAN IS RECALLING 979 STEERING KNUCKLES, DORMAN P/NOS. 697-902 AND 697-903, SOLD UNDER DORMAN'S "OE SOLUTIONS<SUP>TM</SUP>" BRAND NAME, AND NAPA P/NOS. 7-8502 AND 7-8503 WHICH WERE SOLD FOR REPLACEMENT USE ON THE VARIOUS VEHICLES LISTED ABOVE. A POTENTIAL MATERIAL OR DESIGN DEFECT COULD RESULT IN THE STEERING KNUCKLE BREAKING IN THE HUB AREA.
Consequence: A BROKEN STEERING KNUCKLE COULD RESULT IN LOSS OF STEERING CONTROL AND A POSSIBLE CRASH WITHOUT WARNING.
Remedy: DORMAN WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE STEERING KNUCKLES FREE OF CHARGE AND REIMBURSE THE REPAIR FACILITY OR OWNER FOR LABOR. THE RECALL BEGAN ON FEBRUARY 23, 2009. OWNERS MAY CONTACT DORMAN'S TOLL-FREE HOTLINE AT 1-800-523-2492 AND PRESS 5.
Component: EXTERIOR LIGHTING:HEADLIGHTS
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Remedy: DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Component: ENGINE AND ENGINE COOLING
GM IS RECALLING 207,542 MY 1997-2003 BUICK REGAL AND PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L SUPERCHARGED V-6 ENGINE. THESE VEHICLES HAVE HIGHER FRONT ROCKER COVER GASKET TEMPERATURES, CREATING THE POTENTIAL FOR EARLIER DEGRADATION OF THE FRONT ROCKER COVER GASKET AND EVENTUAL OIL SEEPAGE.
Consequence: CERTAIN UNDERHOOD FIRES MAY BE CAUSED BY DROPS OF ENGINE OIL, FROM SEEPAGE OR SPILLAGE, BEING DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING. IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND, IN SOME INSTANCES, THE FIRE MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, ALONG WITH THE 1-3-5 SPARK PLUG WIRE RETAINERS, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. , FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. UNTIL THE REMEDY IS COMPLETED, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS (1) THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CAR PORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE. THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL. OWNERS MAY CONTACT BUICK AT 1-866-608-8080 OR PONTIAC AT 1-800-620-7668, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Component: EXTERIOR LIGHTING
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Remedy: SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Component: FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Consequence: FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Remedy: DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
I was driving a red 2002 Pontiac. While sitting at a stop sign and the driver of a 2012 Ford Fiesta was going 55-60 MPH and ran in the back of my vehicle.
The night of the incident I was driving to my brother's house when I pulled over lifted the hood it burst into flames
TL* THE CONTACT OWNS A 2002 PONTIAC GRAD PRIX. THE CONTACT STATED THAT AFTER THE VEHICLE WAS SERVICED BY AN INDEPENDENT MECHANIC FOR A TUNE-UP, OIL CHANGE AND NO FAILURE CODES FOUND. THE CONTACT STATED AFTER RETRIEVING THE VEHICLE FROM THE MECHANIC, SHE WAS DRIVING APPROXIMATELY 45 MPH WHEN SMOKE WAS SEEN COMING THROUGH THE GEAR SHIFT ASSEMBLY AND A BURNING ODOR WAS DETECTED IN THE CABIN OF THE VEHICLE. SHE PULLED OVER AND UPON EXITING THE VEHICLE, LOOKED UNDERNEATH THE VEHICLE AND SAW FLAMES. THE CONTACT STATED SHE EXTINGUISHED THE FIRE BY USING WATER AND GATORADE. THE CONTACT STATED THAT THE FIRE WAS IN THE EXHAUST AREA OF THE VEHICLE. THE FIRE DEPARTMENT WAS NOT CONTACTED. THE CONTACT STATED THAT THE INDEPENDENT MECHANIC WAS CONTACTED AND INFORMED HER THAT THE VEHICLE WAS SAFE TO DRIVE HOME HOWEVER, THE VEHICLE HAS BEEN STALLING AFTER THE FIRE. THE VEHICLE STALLS AFTER THE FIRE. THE MANUFACTURER AND DEALER WERE NOT CONTACTED ABOUT THE FAILURE. THE CONTACT STATED THAT SHE WAS UNAWARE THAT THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING). THE APPROXIMATE FAILURE MILEAGE WAS 150,000. *DT
LARGE AMOUNTS OF OIL IS ACCUMULATING ON TOP OF THE ENGINE. DURING HARD BRAKING/TURNING, THIS OIL CAN SPILL OFF THE ENGINE ONTO THE HOT EXHAUST.
BOUGHT THE CAR IN APRIL OF 2017. HAD TO REPLACE RACK AND PINION. A FEW MONTHS DOWN THE ROAD WAS DRIVING CAR AND STEERING WHEEL BECAME LOOSE AND IT TURNED HALFWAY TO THE LEFT TO KEEP CAR STRAIGHT. RACK AND PINION BUSTED. REPLACED RACK AND PINION AGAIN PLUS STRUTS AND THE CAR WILL MAKE POPPING SOUNDS WHEN TURNING STEEERING WHEEL. THE FRONT END OF MY CAR HAS BEEN PRETTY MUCH REPLACED TWICE. SCARY TO DRIVE.
II HAD A NO ENGINE CRANK-NO DASHBOARD LIGHTS, INTERMINTENT START. CWAS PARKED NAD NOT MOVING. THE PROBLEM I CAUSED BY THE THE IGNITION SWITCH AND PASS KEY SYSTEM. GM HAD THIS PROBLEM IN 2004 ON THE COLBOLT. 6DEATHS DUE TO LOSS OF ENGINEPOWER, STEERING AND POWER BRAKES. I WILL NOT DRIVE THIS CAR,TILL IGET IT REPAIRED. I AM THE ORIGIONAL OWNER WITH 40000 MILES USE.
LOWER INTAKE MANIFOLD LEAKING COOLANT INTO ENGINE, SAFETY HAZARD, INEVITABLE EMISSIONS FAILURE. MANY RECALLS REGARDING PONTIAC GRAND PRIX WITH THE ISSUE
IN 04 I HAD MY RACK N PINION REPLACED CAUSE LEFT SIDE BROKE MATAGA OF STOCKTON DID IT THEY ALSO REPLACED POWER STEERING PUMP EVER SINCE THEN I'VE HAD PROBLEMS WITH THE STEERING AND NOW IT'S WORSE I'VE REPLACED THE POWER STEERING PUMP BUT IT STILL STEERS HARD ALSO THE STEERING DOESN'T FEEL RIGHT VERY SENSITIVE AT TIMES LIKES TO WANDER AND I HAVE TO USE THE BUTTON UNDERNEATH THE STEERING COLUMN TO RELEASE MY KEY I REPLACED THE INTERMEDIATE STEERING SHAFT STILL DOESN'T FEEL SAFE I SAW IN 09 YOU HAD A RECALL ON STEERING KNUCKLES I NEVER RECEIVED IT CAN I GET A RECALL ON THAT TO GET REPLACED THANK YOU
AFTER INSTALLING A AFTERMARKET INDIGLO REVERSE GAUGE OVERLAY ABS LIGHT APPEARED ON INSTRUMENT CLUSTER AND NEVER WENT OFF. CAR WAS STATIONARY. CHECKED FUSES, TRIED TO RESET BY TURNING IGNITION TO THE ON POSITION AND PUMPING THE BRAKES THREE TIMES WORKED ONCE THEN CAME BACK ON. THEN TRY DISCONNECTING THE BATTERY FOR 20 MINUTES BUT IT DID NOT WORK. O'REILLY'S AUTO DID HE SCAN COACH WITH POINTING TOWARDS THE ASB SENSOR BRAKES FEEL GOOD AND NORMALLY. I INCLUDED TWO IMAGES ONE WITH THE OLD OVERLAY ON THE INSTRUMENT CLUSTER THE OTHER PICTURE IS WHEN I TOOK THE OLD ONE OFF TO PUT THE NEW ONE ON WHICH IS WHEN THE LIGHT CAME ON
MY CAR WOULDN'T START SO I CALLED AAA. THE MAN TRIED TO START THE CAR BEFORE HE ATTEMPTED TO JUMP IT. WHEN HE TURNED THE KEY, THE CAR EXPLODED AND CAUGHT FIRE. THANK GOODNESS HE HADN'T OPENED THE HOOD BECAUSE I WAS STANDING NEXT TO THE CAR AND COULD HAVE BEEN KILLED FROM THE FLYING DEBRIS. WHEN WE OPENED THE HOOD TO PUT OUT THE FIRE, THE INTAKE MANIFOLD WAS COMPLETELY DESTROYED AND IN PIECES. I ENDED UP HAVING THE CAR TOWED AND THEY REPLACED THE INTAKE MANIFOLD AND THE FUEL RAILS COSTING ME $900. YESTERDAY I WENT TO START THE CAR AND IT ACTED LIKE IT DIDN'T WANT TO START AGAIN BUT FINALLY IT DID BUT I DID HEAR A POP. WHEN I RESEARCHED THE PROBLEM ONLINE, I FOUND AN ARTICLE ABOUT CHEVY IMPALAS EXPLODING BUT FROM READING THE COMMENTS, IT APPEARS THIS IS A PROBLEM WITH ALL GM CARS FROM THAT TIME PERIOD. I'M LINKNG THE ARTICLE SO YOU CAN READ THE REVIEWS AND CAN SEE THAT THIS IS STILL AN ONGOING PROBLEM. THE OPENING COMMENT EXPLAINS THAT THERE WAS A PREVIOUS RECALL ABOUT THIS VERY SAME PROBLEM IN THE LATE 1990'S. THE PROBLEM IS WITH DEFECTIVE FUEL PRESSURE REGULATORS. EVERYTHING DESCRIBED IS EXACTLY WHAT HAPPENED WITH MY CAR ON FEBRUARY 6 OF THIS YEAR. I NOW KNOW I NEED TO HAVE THE REGULATOR REPLACED OR IT MIGHT HAPPEN AGAIN. I'M A SENIOR ON LIMITED INCOME AND I CAN'T AFFORD THIS EXPENSE, ESPECIALLY WHEN IT'S A PROBLEM THAT SHOULD HAVE BEEN FIXED WITH A RECALL. UNFORTUNATELY, I DIDN'T TAKE ANY PHOTOS OF THE INCIDENT BUT I HAVE THE REPAIR BILL AND I'M SURE I COULD GET A STATEMENT FROM THE AAA PERSON WHO WAS ALSO PRESENT WHEN IT HAPPENED. HERE IS THE LINK FOR FURTHER TESTIMONY SHOWING SOMEONE WROTE AS RECENTLY AS FEBRUARY 12 WITH THE SAME ISSUE. HTTPS://RJHILLCONSULTING.WORDPRESS.COM/2014/03/08/CHEVY-IMPALA-NOT-RECALLED-FOR-EXPLODING-INTAKE-MANIFOLD-AND-ENGINE-FIRE/
MY 2002 PONTIAC GRAND PRIX WITH A 3.8 LITER ENGINE CAUGHT FIRE WHILE I WAS OUT OF STATE IN DETROIT DOING TRAINING FOR WORK. I PARKED AT THE HOTEL I WAS STAYING AT AFTER A SHORT TRIP TO DINNER AND BACK I PARK MY CAR AND 15 MIN. LATER I HEARD TWO LOAD POPS (NOISE WAS FRONT TIRES BLEW OUT BECAUSE THE FIRE GOT TO HOT) AND LOOKED OUTSIDE MY HOTEL ROOM AND MY CAR WAS ON FIRE AND A CO-WORKERS CAR PARKED NEXT TO MY CAR CAUGHT ON FIRE THERE WAS HOTEL DAMAGE. PLUS TWO CARS TOTALED AND NO WAY HOME. IT SUCKS! THERE WAS A RECALL ON THE CAR INVOLVING ENGINE FIRES. I TOOK THE CAR TO A GM DEALER AND HAD THE RECALL WORK DONE A YEAR AGO. NICE WORK GM!
HAD A RECALL FOR MY CAR. NO LOW COOLANT LIGHT WAS OFF BEFORE AS INSTRUCTED WENT TO A DEALER TO FIX THE RECALL GATEWAY MOTORS IN BROKEN BOW DID THE RECALL LOW COOLANT LIGHT CAME ON AFTER THE REPAIR WAS DONE SO I CONTACTED SANDHILLS MOTOR TO LET THEM LOOK AT IT. SAID THERMOSTAT WAS BAD HAD IT REPLACED OVER $200 DOLLARS FOR THAT I TOOK IT BACK TO GATEWAY MOTORS IN BROKEN BOW TO SEE WHAT IS WRONG WITH IT QUOTED ME A $500 DOLLAR REPAIR TO AVOID CATASTROPHIC DAMAGE I'M NOT RICH SO IT GOES FROM A FREE RECALL FIX TO ME PAYING OVER $700
Showing 15 of 339 complaints