Loading vehicle data from NHTSA...
NHTSA recalls, safety ratings, and consumer complaints for the 2002 Mercury Mountaineer.
| Overall Rating | Not Rated |
| Frontal Crash | Not Rated |
| Side Crash | Not Rated |
| Rollover |
Component: VISIBILITY:GLASS, SIDE/REAR
CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 205, "GLAZING MATERIALS."
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT(S) MAY BE SERIOUSLY INJURED BY SHATTERED GLASS.
Remedy: SAFELITE WILL NOTIFY ITS RETAIL CUSTOMERS AND REPLACE THE GLASS FREE OF CHARGE. RETAIL CUSTOMERS CAN CONTACT SAFELITE TOLL FREE AT 1-888-843-2906. SAFELITE WILL NOTIFY ITS WHOLESALE CUSTOMERS AND REIMBURSE WHOLESALE CUSTOMERS FOR CURRENT INVENTORY AND AT A SPECIFIED RATE FOR REPLACING THEIR CUSTOMER'S GLASS. WHOLESALE CUSTOMERS CAN CONTACT SAFELITE'S WHOLESALE DIVISION, SERVICE AUTOGLASS TOLL FREE AT 1-888-246-6298. THE RECALL BEGAN ON JANUARY 15, 2008.
Component: VEHICLE SPEED CONTROL
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
Remedy: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Aftermarket rack and pinion system re-manufactured by Detroit Axel began leaking fluid and caused a loss of power steering within 3 months of purchase. A second unit was installed and after about a year had the exact same failure as the first unit. Also resulting in the loss of power steering. It is my contention that Detroit Axel is not capable of re-manufacturing to a satisfactory safety standard. I believe they should be investigated and perhaps subject to a product recall. I pray nobody has yet been killed by their ineptitude!
Body : to much rust, corrosion, on rear of truck other failure or detachment of exterior body like rear gate frame components, and other structural components that may present a safety hazard. Electrical : electrical systems and items such asa wiring and cable on or inside the door, ignition switch cover detach ,instrument panel and gauges blinking that causes motors and actuators that power mechanical devices like (windows, sunroofs, seats, etc.) Generate some kind of electrical problem that may present a safety hazard. Power train :transmissions, transfer cases fluid hard to check ,electronic control units and shift lever inacurated, drive axles, hubs, shafts, differentials, CV joints star vibration that may present a safety hazard.
Heard a pop noise under hood. Engine shut off battery light came on. Went to open hood and there was a fire.
The 2002 Mercury Mountaineer has 4 NHTSA recalls and 390 consumer complaints on file. It received an overall safety rating of Not Rated out of 5 stars in NHTSA crash testing. The high number of complaints suggests potential reliability concerns — review the complaint details above before purchasing. For the most detailed information about a specific vehicle, decode its VIN using our free decoder above.
Enter a specific VIN to get the full report — specs, recalls, safety ratings, complaints, investigations, and technical service bulletins.
Component: VISIBILITY:GLASS, SIDE/REAR
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 2002 FORD EXPLORER AND MERCURY MONTAINEER SPORT UTILITY VEHICLES. THE BRACKETS CONNECTING THE LEFT CYLINDERS TO EACH SIDE OF THE LIFTGATE GLASS COULD ROTATE OUT OF POSITION IF EITHER THE URETHANE BOND OR TORQUE ARE NOT SUFFICIENT.
Consequence: ROTATION OF THE BRACKETS COULD POTENTIALLY CAUSE THE LIFT CYLINDERS TO DETACH FROM THE GLASS OR, IN SOME CASES, COULD POTENTIALLY CAUSE THE LIFTGATE GLASS TO BREAK. EITHER CONDITION IS MOST LIKELY TO OCCUR WHEN THE GLASS IS BEING CLOSED.
Remedy: FORD DEALERS WILL INSPECT THE VEHICLES FOR THE POSITION OF BOTH THE LEFT AND RIGHT LIFTGATGE GLASS LIFT CYLINDER BRACKETS. IF THE BRACKETS ARE IN THE PROPER POSITION, THE BRACKET RETAINERS WILL BE TIGHTENED TO A HIGHER TORQUE. IN CASES WHERE THE BRACKET IS NOT PROPERLY POSITION, THE BRACKET MUST BE RE-ALIGNED.
Component: TIRES:SIDEWALL
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE RIGHT SIDE TIRES MAY HAVE HORIZONTAL CUTS ON THE EDGE OF THE TREAD THAT COULD HAVE OCCURRED DURING VEHICLE ASSEMBLY.
Consequence: OVER TIME, THE TIRE COULD FAIL, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE TIRES AND, IF ANY SLICES ARE FOUND, THE CUT TIRES WILL BE REPLACED. OWNER NOTIFICATION BEGAN JUNE 7, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
TL* THE CONTACT OWNS A 2002 MERCURY MOUNTAINEER. THE CONTACT STATED THAT THE REAR LIFT GATE FAILED TO LATCH SECURELY ON SEVERAL OCCASIONS. THE CONTACT STATED THAT THE FAILURE WAS INTERMITTENT. THE CONTACT STATED ON ONE OCCASION WHILE DRIVING THE VEHICLE, THE LIFT GATE AJAR WARNING LIGHT ILLUMINATED. THE CONTACT'S SON WENT TO CLOSE THE LIFT GATE AND GLASS SHATTERED. THE CONTACT HIRED A GLASS REPAIRMEN TO FIX THE WINDOW FOR $250.00. THE DEALER NOR THE MANUFACTURER HAD BEEN NOTIFIED OF THE FAILURE. UPON INVESTIGATION, THE CONTACT ASSOCIATED NHTSA CAMPAIGN NUMBER: 01I010000 (VISIBILITY) WITH THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.
TL* THE CONTACT OWNED A 2002 MERCURY MOUNTAINEER. WHILE DRIVING, THE VEHICLE SLID ON ICE. THE CONTACT LOST CONTROL OF THE VEHICLE AND CRASHED INTO A DITCH. THE AIR BAGS FAILED TO DEPLOY. THE CONTACT SUSTAINED HEAD, CHEST, LOWER AND UPPER BACK, ABDOMINAL, AND NECK INJURIES THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT TAKEN TO A DEALER OR AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 250,000.
MY POWER WILL STAY ON FOR LONG PERIODS OF TIME ALSO I'M HAVING AN ACCELERATION PROBLEM WHEN I DRIVE I HAVE TO WAIT FOR IT TO GO TO ABOUT 25 MI TILL 26 FOR IT TO PICK UP ANY SPEED IT TAKES A VERY LONG TIME FOR IT TO PICK UP ANY SPEED IN THE 1ST PLACE.
I PURCHASED A VEHICLE ON MARCH 11, 2017 FROM A DEALERSHIP NAMED REDEFINED AUTO SALES IN SKOKIE, IL. SINCE I HAVE PURCHASED THIS VEHICLE, I HAVE SPENT OVER $1,500 IN COSTS FOR REPAIRS TO THIS VEHICLE, BEGINNING WITH I HAD TO GET AN OIL CHANGE ON THE SAME DAY THAT I PURCHASED THE VEHICLE BECAUSE THE CHANGE OIL REQUIRED LIGHT CAME ON AS SOON AS I EXITED THE EXPRESSWAY IN ROUTE FROM THE DEALERSHIP. ALSO, AS I WAS EN ROUTE FROM THE DEALERSHIP, ON THE EXPRESSWAY A MOTORIST TRIED TO CUT ME OFF AND THAT IS WHEN I FOUND OUT THAT THE HORN WAS NOT WORKING. THINGS HAVE JUST WENT DOWNHILL FROM THERE.
I PURCHASED A USED VEHICLE FROM REDEFINED AUTO SALES LOCATED IN SKOKIE, IL ON 3/11/17. SINCE THEN I HAVE SPENT OVER $1500.00 IN COST FOR REPAIRS ON THIS VEHICLE, BEGINNING WITH I HAD TO GET THE OIL CHANGED THE SAME DAY THAT I BOUGHT THE VEHICLE BECAUSE THE CHANGE OIL REQUIRED LIGHT CAME ON AS SOON AS I EXITED THE EXPRESSWAY, I ALMOST GOT INTO A SERIOUS ACCIDENT ON THE EXPRESSWAY IN ROUTE FROM THE CAR DEALERSHIP BECAUSE A MOTORIST TRIED TO CUT ME OFF AND THAT IS WHEN I DISCOVERED THAT THE HORN WAS NOT WORKING. THE NEXT DAY THE POWER DOOR LOCKS STOPPED WORKING AND THINGS JUST HAS WENT DOWN HILL SINCE THEN, THE VEHICLE IS IN THE SHOP RIGHT NOW AS I'M TYPING THIS, I HAVE NOT DRIVEN THE VEHICLE ANYWHERE OTHER THAN BACK AND FORTH TO REPAIR SHOPS. I FILED A COMPLAINT WITH THE BBB BUT NOTHING WAS DONE ABOUT THE COMPLAINT BECAUSE THE BUSINESS RESPONDED SAYING THE VEHICLE WAS USED AND I REJECTED THE RESPONSE AND THEN RECEIVED AN EMAIL FROM THE BBB SAYING THAT THE CASE WAS CLOSED. THIS VEHICLE WAS A LEMON WITH A LOT OF ISSUES AND NONE OF THOSE ISSUES WERE DISCLOSED TO ME WHEN I PURCHASED THE VEHICLE.
WHILE DRIVING ON A STRAIGHT ROAD GOING 20-25 MPH, MY DRIVER AND PASSENGER SIDE/CURTAIN AIRBAGS DEPLOYED FOR NO REASON. I PULLED OVER AND CALLED MY INSURANCE COMPANY STILL CONFUSED AS TO WHY THIS HAPPENED. THEY INFORMED ME TO CALL FORD AND REPORT IT AND CUT THE AIRBAG ENOUGH TO SEE. WITH NO LUCK ON GETTING HELP FROM FORD OR MY INSURANCE COMPANY, I'M NOW DEALING WITH FAILING INSPECTION DUE TO MY AIRBAG LIGHT. I FEEL THIS IS A MANUFACTURER PROBLEM AS I HAVEN'T MADE ANY MODIFICATIONS TO THE VEHICLE.
WHEN GOING 25-30 MPH VEHICLE WILL NOT SHIFT.IT ACTUALLY KICKED THE VEHICLE BACK. OD LIGHT STARTED TO FLASH THEN SERVICE ENGINE SOON LIGHT CAME ON.BEEN DOING THIS SINCE. WENT TO GO GET MOUNTAINEER READ AND OF COARSE..THE TRANSMISSION..SOMETHING NEEDS TO BE DONE OTHERWISE THIS MIGHT EVENTUALLY LEAD TO A LAWSUIT AFTER READING ALL OF THE COMPLAINTS ON THE EXACT SAME THING.
I WAS DRIVING ON THE HIGHWAY & STOPPED AT ONE OF THE SERVICE STATIONS ALONG THE HIGHWAY. WHEN I RETURNED TO THE VEHICLE I PUT MY CHILDREN IN THE CAR, TURNED IT ON, PUT THE CAR IN DRIVE HIT THE GAS & THE VEHICLE DID NOT MOVE. I TRIED PUTTING IT IN REVERSE & NOTHING HAPPENED. THE CAR WOULD REV UP BUT WOULD NOT MOVE. IT FELT LIKE I HAD THE CAR ON NEUTRAL. TRIED SEVERAL TIMES & NOTHING HAPPENED. I THEN TRIED TO PUT THE CAR ON D3 & THAT IS WHEN IT MOVED SLIGHTLY. PARK & DRIVE DO NOT WORK!! VERY DANGEROUS HAD THIS HAPPENED WHILE I WAS STILL DRIVING ON THE HIGHWAY, WHICH IS WHAT WOULD HAVE PROBABLY HAPPENED. I WAS ONLY OUT OF MY CAR FOR 10 MINUTES.
STARTED VEHICLE TO GO TO WORK LIKE EVERY DAY TRIED TO SHIFT INTO R SHIFTER BROKE OF IN MY HAND. NEEDS TO BE RECALLED. I AM GLAD IT HAPPENED IN DRIVE WAY. I LIVE ON HIGHWAY AND IT COULD HAVE BROKE AFTER I WAS IN HIGHWAY SHIFTING INTO D.
TL* THE CONTACT OWNS A 2002 MERCURY MOUNTAINEER EQUIPPED WITH BF GOODRICH TIRES 105S RUGGED TRAIL T/A TIRES, SIZE: P245/65R17. THE CONTACT NOTICED EXCESSIVE CRACKING AROUND THE TREAD FOR ALL FOUR TIRES. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS CONFIRMED THAT THE TIRES NEEDED TO BE REPLACED. THE TIRES WERE NOT REPLACED. THE TIRES WERE NOT ORIGINAL EQUIPMENT. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE TIRE FAILURE MILEAGE WAS 10,000 AND THE VEHICLE FAILURE MILEAGE WAS 90,000.
DRIVING AT NORMAL SPEED OF APPROXIMATELY 40 MPH ON A CITY STREET, THE SPARK PLUG AND COIL SHOT OUT FROM THE #2 CYLINDER. A LARGE PERCUSSION BANGING SOUND EMITTED FROM UNDER THE HOOD WHICH WAS THE DETECTABLE EVIDENCE SOMETHING HAD JUST GONE DESPERATELY WRONG WITH THE ENGINE.
WHILE DRIVING TO WORK ONE MORNING ALL I HERE WAS DING DING DING OD/OFF STARTED FLASHING . SEC LATER CHECK TRANSMISSION LIGHT CAME ON NOW WHEN I DRIVE PUTTING FOOT ON THE PADDLE TO GO IT WILL IDLE UP I RELEASE AND IT WILL SHIFT N GO. AAMCO SAYING THAT I NEED A REBUILT TRANNY THAT'S BS WITH ALL WHAT I HAVE BEEN READING IT'S JUST A RIP OFF I DON'T HAVE $3500 TO GET THIS FIX. NOW SEEING NOT ONCE NOT TWICE SO MANY COMPLAINTS I READ THAT PEOPLE PAID FOR 2 OR MORE TRANNY FOR THE VEHICLE'S AND NOTHING IS BEEN DONE ABOUT IT. AND THE FORD DEALS KNOWS ABOUT IT..... DO A HUMAN BEING HAS TO LOSE THEIR LIFE BEFORE FORD DEALER'S CAN OWN UP TO THERE RESPONSIBILITY? IF THEY WAS IN OUR SHOES THEY WOULD WANT THE SAME THING VICE VERSE THEY SAY U REAP WHAT YOU SOW. PLEASE PLEASE PLEASE HELP UP JUST FIX OUR TRANSMISSION THAT'S ALL.. ANOTHER THING ABS LIGHT STAYS ON CHECK ENGINE LIGHT STAYS ON THE SEAT BELT LIGHT STAYS ON ALL MY WINDOWS DOESN'T LET DOWN NOW WTF? *TR
Showing 15 of 390 complaints