2020 Kia Sorento

Oil is leaking from my car. The dealership said I would need to replace the engine. The car is only 6 years old.

Component/System Affected: UNKNOWN – suspected fuel system or related component due to strong gasoline odor. Vehicle is available for inspection upon request. What Happened: There is a strong gasoline odor specifically at the front driver’s side wheel well/tire area. The odor is also noticeable under the hood. The smell is present while the vehicle is parked (I had to move it out of the garage) and after driving. No visible fuel leaks or puddles have been observed under the vehicle. Safety Risk: Gasoline fumes create a potential fire hazard and pose a risk of accident. The odor is now also noticeable inside the vehicle, which increases concern for occupant safety. Confirmation by Service Centers: The problem has been reproduced and confirmed by independent service centers. Two separate auto mechanic shops inspected the vehicle and both confirmed smelling gasoline, but neither could identify the source of the odor or any mechanical defect. Inspections by Others: The vehicle has been inspected by two independent mechanics only. It has not yet been inspected by the manufacturer, police, or insurance representatives. Warning Lamps or Symptoms: No warning lights or dashboard messages have appeared. The only symptom is a persistent gasoline odor. Timeline: The odor was first noticed on 02/19/2026 and has continued since that date. Vehicle Information: 2020 Kia Sorento VIN: [XXX] Mileage: approximately 87,438 miles Used for local commuting to work and school. Vehicle is garage-kept and receives regular maintenance at certified auto mechanic shops. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The engine is burning oil despite all maintenance being up to date and having fewer than 80k miles. Kia of Duluth Service Center checked the oil and said levels were good on 12/31/25. Fewer than 30 miles were driven and it was brought back to the dealership service center on 1/2/26 and diagnosed with total engine loss due to oil starvation. The extended warranty company (JM&A) are denying coverage because the engine failure is due to lack of oil. They have inspected the vehicle. No warning lights ever came on and this is the second time that this issue has been addressed by Kia of Duluth. The engine could have easily overheated and caught on fire or lost power on the road.

To the Office of Defects Investigation, I am submitting this formal complaint regarding NHTSA Recall 22V703000 (Kia Recall SC249) involving my 2020 Kia Sorento (VIN: [XXX] ). This recall identifies a fire risk due to a potential electrical short in the tow hitch harness module. The recall notice specifically warns that a vehicle fire may occur while parked or driving. After receiving the recall notification, we made multiple attempts to schedule the required repair with Pompano Kia, the authorized dealership in our area. Despite repeated efforts, we were not provided with a confirmed repair appointment, and the recall remained incomplete. On [1-19-2026], before the recall remedy was performed, the vehicle caught fire while being driven on a highway in Florida. The vehicle became fully engulfed and was declared a total loss. Law enforcement and/or fire services responded. The incident appears consistent with the fire risk described in the recall. Following the incident, we visited the dealership to report the fire and the unresolved recall. We were told the matter would be reviewed and that we would receive a follow-up call. No follow-up was received. Attempts to contact the dealership through publicly listed email addresses resulted in delivery failure notices. According to NHTSA records, this recall affects tens of thousands of vehicles nationwide. We are concerned about: • Timeliness and availability of recall repairs • Dealership accessibility and communication • Risk to consumers when recall remedies are not completed before failure occurs We also attempted to consult several attorneys regarding this incident. We were advised that due to the volume of recall-related fire cases involving this manufacturer, representation may not be feasible unless severe bodily injury is involved. This further raises concern about the scale and seriousness of the issue. We respectfully request that NHTSA review: • Whether recall 22V703000 is being remedied INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I bought a Kia 2020 from Long Lewis 3 days after i got it the check engine light come on, I called and told them, then around the 5th day black smut started covering the back of the suv, and i was smelling a burnt oi; and antifreeze smell, took it to a shop and they pulled the codes and one code was P045600 and another was P074100 then airbag codes, not even a month it started jerking they told me to bring it in so i did, he said they cleared the codes and was gonna fixed the evap, i asked about the torch converter and he said that must've been a code from the history but it wasn't, it did have a history of the code though, and i asked about the black smut on back of the vehicle he said nothing they can do about that and said fixing the evap may fix it, but sometimes it smells like it's on fire, and jerks

Check engine light came on indicating a problem with cylinder 4(P0304). Replaced all spark plugs and coil pack to no avail. Car still struggles to accelerate even though light has went out. Especially noticeable at higher speeds.

Oil consumption, causing 8 spark plugs and dangerous driving. Refusing to cover under warranty.

My engine light is on. Codes show cylinder 4 misfire. Code P0304. My vehicle slows down while driving. It takes time to excelerate to a reasonable speed. My vehicle is becoming harder to start each time. I purchased a new battery and replaced spark plugs to no avail. I’ve been told from several mechanics that my engine is bad and needs to be replaced. Kia has refused to replace my engine or help in any way and I feel this is something caused by the manufacture. Others have had the same issue. The vehicle is burning oil and I have practically had to stop driving the vehicle. It is my only means of transportation. I have 113,000+ miles.

The engine check light is on and the car is using more oil than it should. I had the oil changed and had to add quarts before 2000 miles. I called Kia and was told my VIN is not part of the recall. I got an inspection and Cylinder 2 is misfiring and has low pressure so the entire engine needs a replacement.

The engine began leaking and burning oil, and general engine issues.

I was driving 2 minutes away from my house and all of the sudden every warning light on the dashboard came on, billowing smoke started coming through the vents. I immediately pulled in a random driveway, as I was turning I. I heard a loud pop. I shut the car off immediately, jumped out. As I looked at the front of my car, flames were coming from the bottom front. I ran up to the house, the man of the house came out with a fire extinguisher. He put out the flames underneath, asked me to pop the hood, I did so and he put out the flames underneath the hood. As I was waiting for a tow truck, I seen a shiny object at the bottom of the vehicle, I pulled it out. It was a wrist pin from the engine. I also noticed a ton of fluids poured out in the man’s driveway. I had the vehicle towed home and contacted Kia and my insurance company. My case was escalated to Kia corporate and Elizabeth Barooni contacted me. She promised to tow my vehicle to the dealership of my choice, get me a rental car, pay any out of cost expenses and repair the vehicle. The vehicle only had 75,000 miles on it. After all her promises, she never contacted me again. I have tried to contact her and a Kia number called me, I answered they hung up on me. I called the number back and it was James Hope, an employee who works at Kia America Corporation. They have not returned my call since around Christmas. I also contacted GEICO, my insurance company, they sent out a adjuster, they denied my claim. They stated that all of this was caused by mechanical failure, they put on the claim that Kia is known for these issues and they will not cover it. I still remain without a vehicle and Kia Corporate has completely ignored me after making promises to help.

Around 100,000 miles I noticed that my engine was going through a lot of oil. Every time I would get an oil change, I would ask why and they stated that these Kia engines after hitting 100,000 start to burn oil fast and about every 1,000 miles you have to add a quart of oil and go from your normal every 5,000 mile oil change to every 3,000 mile oil change. Some times the oil light would blink but some times it wouldn't. I had a mechanic double check this and he confirmed and said nothing you can do they are just like and he sees it all the time. I kept up with my oil changes every 3,000 miles and every week and a half checking the oil. Around 134,000 miles or so on 11/28/25 at 4:30am I was driving and all of a sudden my car was driving weird and shaking. Soon the engine light came on. The oil light this entire time never came on. I pulled into a Target parking lot an noticed there was no oil in the car and it went through 5qts in a week and a half. I added 4 qts oil to the car and waited for the mechanic shop 1/2 a mile to open up at 7am. The inspected the car and said a cylinder was blown and to drive slow and get it home and just park it and a new engine is needed. I called my mechanic and he came by the house and he looked and it to see if he could fix it and no luck but said that Kia did have recalls on their engines and to fight it. I called Kia and they didn't deny recalls on some cars but not mine. They advised me to do a claim to get help to get the engine on a recall. The car has not been driven since then and remains in the garage and is in perfect well kept condition otherwise.