2022 Kia K5 Problems & Complaints

A fuel system-related safety recall (SC356) remains incomplete on the vehicle. The vehicle was taken to an authorized Kia dealership in Jersey City, NJ, where I was informed that the recall repair had been completed. I paid for towing to the dealership for this repair. However, after picking up the vehicle, it immediately began exhibiting worsening symptoms, including engine shaking, rough operation while driving and idling, and prior stalling incidents. A check engine light also appeared after the visit. Upon further verification, the recall still shows as incomplete. This indicates that the recall repair was either not performed or not completed correctly. The issue appears to involve the fuel system, as the symptoms worsened after refueling and include unstable engine performance consistent with improper fuel delivery or air entering the system. This condition creates a safety risk due to potential engine stalling while driving, as well as the known recall risk involving fuel tank deformation and possible fire hazard. The problem has not been properly resolved by the dealership, and the vehicle is currently unsafe for normal use. The failed recall repair is available for inspection.

The vehicle experienced an overheating condition involving the fuel system, which aligns with an active recall stating that a damaged check valve can allow air into the fuel tank, causing it to expand and come into contact with hot exhaust components, potentially melting the fuel tank. While operating the vehicle, this created a serious safety concern due to the risk of fuel tank damage, fuel leakage, and potential fire. This was not a minor issue, as it directly involved a component that could lead to a fire hazard. The vehicle was later evaluated and deemed unrepairable due to the severity of the issue. Because of this, the vehicle is not currently being used due to safety concerns. Despite the known safety risk and recall-related defect, the situation has not been properly resolved. The handling of this issue raises concerns given the potential for fuel system failure and fire risk associated with this defect. This complaint is being submitted due to the safety risk involving the fuel system and the potential for fire while operating the vehicle.

I bought a 2022 KIA K5 gt-line new and the horn stopped working less than a year later at 64,000 miles Gary Rome KIA assessed the repair and said KIA would not cover. I paid $169.00. In January 2026 my horn stopped working again. Ron Bouchard KIA assessed and said KIA would not cover repairs, I paid $819.98 myself. I have contacted KIA myself and with the assistance of the Ma Atty Gen'l office. I and the Atty Gen'l advocate have not received a reply from KIA. my out of pocket cost so far is $877.38 not including down time and inconvenience. KIA reportedly quietly acknowledged the horn issue in the K5 and extended warranty to cover repairs but did not or will not reimburse me my cost. I have uploaded bills and KIA horn defect acknowledgment article

My 2022 Kia K5 GT-Line has had a recurring check engine light fault (P0471 — exhaust pressure sensor circuit) since approximately 9,874 miles in September 2022. The vehicle has been brought to the servicing Kia dealer a minimum of five times for this same fault across nearly 65,000 miles. It has never been permanently resolved. Most critically: dealer repair records from May 2025 (56,501 miles) confirm a technician identified fault code P047100, noted it as a history code, cleared it, test drove the vehicle, and returned it without performing any repair and without informing me. Ten months later, the same dealer presented this identical fault as a $1,121.07 customer-pay repair on a vehicle under active 10-year/100,000-mile powertrain warranty. The repair was only approved after I contacted Kia Consumer Affairs directly — the dealer had not contacted them despite claiming otherwise. The February 2026 repair failed within 15 minutes of pickup. I made five documented phone calls to the dealer over 33 days reporting the failure. No action was taken. The April 2026 repair — sensor and hose replacement — failed within one hour of pickup on April 1, 2026. Of additional concern: Recall SC288/SC288A (Fuel Tank Inspection and ECM Re-Update) was performed on this vehicle twice — July 2024 and August 2025. The ECM governs the exhaust pressure sensor circuit. The P0471 fault first appeared in dealer records between these two recall dates and has persisted through both completions. CARFAX confirms the April 2026 repair involved the engine/powertrain computer module. I am requesting NHTSA investigate whether SC288/SC288A is connected to recurring P0471 faults in 2022 Kia K5 vehicles. Kia Consumer Affairs Case escalated April 2, 2026.

STATEMENT OF FACTS: I presented my Kia K5 for two safety recalls (SC356 and SC263) with an active Check Engine Light for code P047100 (Exhaust Pressure Sensor). I informed the service advisor, Aliyah, that this code is a symptomatic secondary fault of the pressure irregularities addressed in Recall SC356, which explicitly lists an "Illuminated Check Engine Light" (MIL) as a primary warning sign. The dealership dismissed my technical assessment—which was backed by advanced AI data analysis. After the software update was performed, the advisor claimed the code remained "active," thereby "proving" it was unrelated to the recall. Based on this, I was charged a $248 diagnostic fee and told I needed a $534.02 out-of-pocket hardware repair for a "physically failing" differential pressure sensor that was allegedly reading 2 HPA against a spec of 23.09 HPA. EVIDENCE OF ERROR: Upon taking delivery of the vehicle, the Check Engine Light was completely extinguished. If the light were truly "still active" after the update, as I was told to justify the fee, the fault would have been present at pickup. Since then, I have driven over 120 miles (including multiple cold-start drive cycles between [XXX] and my place of work) with a 100% clear dashboard. My XXX App confirms the XXX fault is resolved, while the recalls remain "Open" administratively. REGULATORY VIOLATION: Under 49 U.S.C. Chapter 301, a manufacturer must remedy a safety defect without charge. A software "Logic Update" cannot physically repair a broken pressure sensor. The fact that the fault disappeared immediately following the update proves the sensor was functional and the fault was caused by the recall defect. By misdiagnosing a recall symptom as a non-covered hardware failure, the dealer effectively charged me for a federal safety repair. I request an investigation into these "diagnostic gatekeeping" practices and a full refund of the $248.00 fee. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2022 Kia K5. The contact received notification of NHTSA Campaign Number: 25V794000 (Fuel System, Gasoline); however, while taking the vehicle to the dealer, it was determined by the dealer that the vehicle could not be repaired. The contact was not given any reason why the vehicle could not be repaired and was offered a buy-back option instead. The contact stated that the rear passenger seats were extremely hot. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was approximately 90,000.

The infotainment system in my 2022 Kia K5 began failing on or around early December, 2025, at approximately 44,000 miles and has continued to worsen. The vehicle is currently at approximately 47,000 miles. The screen displays the Kia startup screen repeatedly and does not fully load, flashing, becoming unresponsive, and ultimately causing distraction while driving. Audio may still function, but key features such as Bluetooth, Apple CarPlay, and auxiliary input do not work. The backup camera will either not function at all or will flash intermittently while reversing. This failure affects safe operation of the vehicle because it limits access to vehicle controls and creates distraction while driving due to the malfunctioning display. It also impacts visibility and usability of integrated systems that are expected to function reliably. The problem has been reproduced consistently and was evaluated by a Kia dealership. The dealership was unable to determine a clear cause for the failure but recommended full replacement of the infotainment system at a cost of approximately $6,700. There were no clear warning messages prior to failure. The issue has persisted despite attempts to reset the system and power cycle the vehicle. This appears to be a premature failure of a critical electronic system that should not occur at this mileage.

EPB light with multiple other dash lights come on. It affects my breaking, shifting and acceleration. I was attempting to get on the freeway the first time it happened and my car would not accelerate. I had to drive off to the side to prevent getting hit. It happens intermittently at no given time. I just got it back from the dealership and am still having the issue.

The car was in an accident with the previous owner I bout the car and the carfax showed rear end collision I told the car worked perfectly. After purchase the car brakes have built up 2 times in 5 months the car stalled it has rpm issues lagging and hesitation as well as the safety front end collision has malfunctioned and it locked my brakes up I did all the steps to try to fix it and I ended up having to disconnect the battery. I sent it to the dealer and they said it was fine I now see the carfax as showing front end collision was reported and has been in the shop multiple times for the hesitation and stalling issue which now that my blue certificated warranty is out they found the issue (pcv valve etc) I’ve asked for a remedy with the dealer and they won’t budge this car is a safety liability.

My 2022 Kia k5 has gone into limp mode multiple times now while I am driving in addition to when it starts up. Check engine light, AUTOHOLD, EPB, traction control, etc. all aluminate on my dashboard. Car drives very rough and doesn’t want to accelerate or shift. Huge safety issue. Dealership said it was the throttle body assembly. Paid to have it replaced and the issues still persists. I have read multiple other comments with the same issue and dealerships have no idea what the issue is or how to correctly diagnose. Error codes were P00BD00, C136081, and C174181.

The driver's seat heater automatically deactivates after 30 seconds. The heating element remains active for only 20 seconds, and unfortunately, the console with the wireless phone charging station is not functioning.

I am submitting this complaint regarding a confirmed safety recall on my 2022 Kia K5 LX that has not been repaired and currently has no available remedy, despite being acknowledged by Kia. This unresolved recall places me, my passengers, and other motorists at ongoing risk. I rely on this vehicle for daily transportation, and continuing to operate it under these conditions creates a constant safety concern that is beyond my control. I have been informed that the recall exists, yet there has been no corrective action, repair timeline, or interim safety solution provided. Leaving consumers in possession of a known defective vehicle without a remedy is unacceptable, especially when the issue involves safety-related components. I am requesting that the NHTSA: •Review Kia’s handling of this recall •Require timely corrective action or an interim safety solution •Ensure accountability so affected drivers are not left operating unsafe vehicles indefinitely I am deeply concerned about the lack of urgency and transparency surrounding this issue. A confirmed safety recall without a remedy is not a minor inconvenience; it is a serious hazard. Thank you for your attention to this matter. I am available to provide additional documentation if needed.

The ac and or heat goes out and I have to press the fuse under the hood and it comes back on other Kia k5 owners have had the same problem was told to report here for recall so fuse box doesn’t get burned out.

The drive train car would not go then my accelerator will rev up and down and not go over 10 miles a hour then all these service lights come on and car go in like limp mode and not drive in middle of intersection no one inspected the car i tuned it off and let it sit for 24 hours and started it and it was normally except the acceleration goes up and down when it wants to there were a lot of warning lights

UNKNOWN. Engine misfires. Piston rings

My son owned the 2022 Kia s-K5 and lost his life in the same car ...him and my nephew died in this car last [XXX] one month after his [XXX] birthday...he was driving the car hit maybe black ice or the car lock up and went sideways on the payment for .3 of a mile and couldn't pick straits or gain control of the car and then hit a ditch n tree and satellites 2 total with the front of the car rolled the car over into a canal with water in drown and died ..the front air bags never deployed the side ones did but it took a lot of damage on the front were it showed them air bags was defaults and did not perform as a safe device as they are designed for ...then the seat belts were locked and that's cause them to not be able to get out of the car they was trapped in the car so this Kia safety equipment didn't do or perform the job it was intended for so them factors could of very well contribute to them 2 boys deaths so I'm putting an the Kia manufacturer as the responsible ones for building or producing such a bad none safe vehicle that has killed my son and my nephew....I feel that the Kia manufacturer should pay for there negligence and be punished for selling them to the public...it's not fair I'll never see my son again INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My vehicle is subject to an unrepaired safety recall involving the fuel system. According to the manufacturer’s recall notice, a damaged check valve may allow air to enter the fuel tank, causing the tank to expand and contact hot exhaust components. This can melt the fuel tank, cause fuel leakage, and increase the risk of a vehicle fire. This vehicle has experienced multiple fuel-system-related recalls, and this recall is currently listed as incomplete with no remedy available. The manufacturer has not provided a repair timeline, and owner notification and repair availability are delayed. I am concerned for my safety and the safety of my passengers because I am required to continue driving a vehicle that the manufacturer acknowledges poses a fire risk and cannot currently be repaired.

The contact owns a 2022 Kia K5. The contact received notification of NHTSA Campaign Number: 25V794000 (FUEL SYSTEM, GASOLINE); however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact experienced the failure, causing the check engine warning light to remain illuminated, and the vehicle hesitated while accelerating. The vehicle was taken to the local mechanic, who diagnosed the vehicle and determined that the check valve was faulty and needed to be replaced. The vehicle was not repaired. Additionally, the contact stated that while the AC was activated, one vent was blowing hot air while the other vent was blowing cold air. No further information was available. The failure mileage was 103,000.

When engine is Idling the cabin immediately starts to smell completely like gasoline. This happens whether the A/C system is on or not. It’s so strong sometimes that I have to put my window down to release the fumes.

My 2022 Kia K5 EX has a serious fuel-system safety defect involving fuel tank expansion, which caused rear seat pan deformation and rear seat strap deformation. Kia America’s engineering review confirmed this in their findings. The fuel tank expansion caused the rear seat to lift/warp from underneath, creating a risk of fuel leakage, fire, and structural failure in a crash. This is a significant safety concern for occupants and the public. Kia America acknowledged this safety defect in a letter dated October 15, 2025 and stated it is “consistent with the fuel tank expansion condition.” They offered to repurchase the vehicle due to this safety issue. (Letter attached.) Because of this defect, my vehicle has been out of service for 78 days and is not safe to drive. I use this vehicle as my primary source of income for full-time rideshare work, which has caused severe loss of income. Due to the extended loss of use and financial hardship, I am now at risk of repossession, even though the vehicle is unsafe because of a manufacturer-confirmed defect. Despite Kia acknowledging the defect, no recall has been issued, which raises concern that other drivers may still be using potentially unsafe vehicles. I am requesting NHTSA to investigate this defect for potential recall action.

The contact owns a 2022 Kia K5. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the Purge Control Solenoid Valve (PCSV), resulting in damage and fuel tank expansion. The vehicle was not repaired. After investigating the failure, the contact related the failure to Service Campaign: SC288. The manufacturer was notified of the failure, a case was opened, and the contact was offered a buyback, but refused the buyback. The failure mileage was 81,000.

While driving my 2022 Kia K5 LXS, the vehicle began shaking violently and lost acceleration. The check-engine light came on, showing code P0301 (cylinder 1 misfire). The issue caused unsafe driving conditions, especially with my child in the car. Kia Roseville incorrectly documented the repair, while Kia Folsom later confirmed the issue was engine-related. The vehicle has also been subject to fuel tank expansion concerns under recalls SC288 and SC288A, which can create additional fire risk and pressure issues. Despite repairs, I still experience safety fears and severe loss of vehicle value due to these recurring defects and poor documentation. Kia America has not provided a resolution.

I noticed my car jerking from a stopped position a few months back it wasn’t consistent but it happened I figured it was just a powerful motor however last on October 7th I was driving down the street to go to the dealership and my car lost power I had to pull over my son was panicking he’s just little and I sat there and luckily it started after a few minutes and I went to the dealership and they blew me off saying it has electrical issues. WELL I went to Oreillys and they tested my battery it was good but only getting 10 % charge to it which he said was odd so he said to try and drive it some and come back he wlll see where it’s at. I did that and he said oh wow you’re back up to 100%! Well that was the 7th now last night I’m driving around Tallmadge ave and BOOM everything lit up I lost power steering my lights shut off completely and it was close to midnight! It was insane I am luckily a very good driver because I almost went right off the road!

While driving on the highway under normal weather conditions and at the speed limit at approx 50 MPH a loud explosion like a gun shot was heard through the car. The sound of broken glass and wind could be heard; however, there was no collision or object that struck the vehicle in any way. Glass began dropping through the sun shade area and upon pulling over and further inspection the sunroof appears to have exploded outward as all the glass was bent in an upward direction. The vehicle is currently awaiting assessment at the dealership. There was no warning of any kind. It was just a spontaneous explosion. It is my understanding that this has been a problem in some vehicles and many different manufacturers and other companies have recalled their cars however Kia has not.

the fuel tank on my car expanded a few hours after inspection was taken place. The dealership stated my car was completely unsafe to drive and would not let me leave with it. My daughter was in the backseat when it happened, but she is safe and so am i

The contact owns a 2022 Kia K5. While the contact's son was driving at an undisclosed speed, the rear seat started to rise independently. There were no warning lights illuminated. The contact's husband was sitting on the rear seat. In addition, the contact stated that the failure had occurred after the vehicle was refueled. The vehicle was taken to the dealer where it was diagnosed with an expanded fuel tank. The contact was informed that the fuel tank needed to be replaced. The vehicle was repaired. The contact stated that the repair had taken three weeks. The vehicle was returned to the contact. The contact stated that two weeks later, the manufacturer began sending emails to the contact, which stated that the vehicle was under recall. The contact was advised to park and not drive the vehicle. The vehicle was towed to the dealer. The vehicle remained at the dealer for two additional months. The manufacturer informed the contact that the vehicle was non-repairable. The contact had not received an offer for a replacement vehicle and the contact was still required to continue monthly payments. In addition, the contact was concerned because her husband had been driving an unsafe vehicle for two weeks after the repair was performed by the dealer. The failure mileage was approximately 79,000.

I was driving my car and heard a loud pop, I was on the interstate and thought maybe my tire was going flat but nothing alerted me on my dash. I heard loud wind noises but everything seemed fine until my car started basically hopping forward and it became hard to accelerate. I had to push the gas harder than normal to maintain average highway speeds. I was also feeling super lightheaded while driving and kept rolling my window down as if I couldn’t get a full breath of air. I would roll it back up after 5 minutes or so and would have to roll it right back down. I was driving a long distance and wasn’t able to immediately stop but I was informed of the gasoline fumes when I family member helped get my bags out of my car. It was the scariest thing

I took my car because of fuel recall, due to multiple vehicles having their gas tank expanding or exploding. Even after they completed the recall on my vehicle I still had my gas tank expand. I took my vehicle to the Kia Frisco dealership and they took my vehicle advising they had to buy it back from me. Once they had the vehicle after close to a month they stated that my vehicle was repairable even after stating that several of these models had gas tanks expanding and exploding. I do not feel safe getting into this vehicle after the repair and I want to report it.

Gas tank expanding causing gas to drip from than tank onto the floor potentially causing a fire hazard.

Paint chipping on driver’s side door

Kia dealership has confirmed that the components of the vehicle's multi-fuse (located under the hood) for the AC/HVAC system have started to burn and are melting part of the fuse panel due to excessive current draw and excessive heat. Due to this, the vehicle's HVAC (both heat and a/c) does not function. A vehicle's HVAC functions help to: 1) Defrost/defog vehicle's windows during rainy and humid days, 2) maintains a vehicle's air quality, 3) cools the vehicle's interior on hot and humid days, 4) assists in preventing mold and bacteria growth via dehumidification, 5) assists in keeping the cabin cool and dry to prevent driver fatigue and promote driver focus. Other than the inoperability of the HVAC system, no other signs or symptoms were present prior to the issue. I initially though this issue would be covered under Kia's HVAC Blower technical bulletin/warranty (WTY037) however the dealership has advised that the WTY037 only applies if the fuse is blown, not melted. This slight difference in melting vs. blowing should be an issue as the effect of the issue is the same, but components melting seems to be slightly more serious, but is not covered. Also, melting components, to me, could lead to fire hazards.

The contact owns a 2022 Kia K5. The contact stated that while driving at 43 MPH, the vehicle made an abnormally loud booming sound. The contact's daughter, who was occupying a rear seat, screamed out because the rear seats had suddenly risen. The contact pulled over to the side of the road and inspected the vehicle. The check engine and the low fuel warning lights were illuminated. The contact's wife met the contact and picked up the children. The contact stated that upon resuming driving, the vehicle was jerking violently, and the fuel gauge level lowered significantly. The vehicle was taken to an independent mechanic, where it was diagnosed with an EVAP system failure. The vehicle was driven to the residence. The vehicle was then towed to the dealer, where it was diagnosed, and determined that the fuel tank had expanded. The vehicle was not repaired. The manufacturer was notified of the failure and offered to repurchase the vehicle. The failure mileage was approximately 85,000.

All my lights on my dash keep lighting up for no reason. When I bought my car it did it and premier Kia said they fixed it but it keeps happening. We pay too much money for cars to act like this.

Thoratal body and engine light and engine rebbing up on its own.

Car stalls out without warning. The electronics (radio, dash, lights, etc...) all are still functional, the engine light comes on while the car is still "on" with the engine stalled out. I pulled over, put the car in park, turned it off, and then restarted the car without issue. After restarting the car, the check engine light is not longer on. This first occurred once about a year or two after i bought the car while on the freeway (2023). The second time I was on a dirt road outside of town (March 2025). The third time I was accelerating through an intersection while taking a left turn, after being stopped at the green light waiting for a time to turn (August 2025). My car stalled out in the middle of the intersection, but I was lucky enough to have gained enough momentum to roll out of the way of oncoming vehicles. The most recent time this occurred, the car had trouble turning over, but was able to after a few tries. I took it into my kia dealership and they told me to replace the battery as it was testing "low". I bought a battery from autozone and replaced it as instructed. However I have never had any issues otherwise and the battery test autozone performed on my old battery said the old battery was still "good". This was recent and the problem is rare so i have not confirmed if this is a fix, however it is a dangerous fault that does not seem to be resolved.

Engine failed for literally no reason and started smoking and Lia won’t stand by warranty either

For really no reason at all truck locked and would not reopen while simultaneously the seats acces to trunk would not work not even emergency safety release would open either

Fuel consumption jumped then car began jerking shortly after engine failure

Gas tank expanded and warped the back seat causing my child’s car seat to not be seated properly. Walking near the car you can smell gasoline very strongly. The check engine light came on briefly and then went away. My car is at the dealership currently as they decide what to do about the issue.

The contact owns a 2022 Kia K5. The contact stated that while driving at various speeds, the A/C failed to blow cold air as intended. Upon further inspection, the contact became aware that the fuse box had started melting. The contact stated that the fuse was shaken as a temporary repair. The vehicle was taken to a local dealer, where the failure was related to TSB: CS2301; however, the VIN was not included. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 91,000.

Blower motor failure, available for inspection upon request. The failure occurred while driving in muggy conditions, resulting in rapid fogging of the windshield and front side windows. With no functioning airflow, the vehicle’s defrost/defog system was inoperable, and visibility through the windshield became significantly impaired. This required me to reduce speed and open windows in inclement weather to maintain a minimal view of the road, creating additional distraction and exposure to hazardous conditions. The blower motor produces no airflow at any fan speed setting. Failure was confirmed during inspection. No warning lights, messages, or other indicators appeared before, during, or after the failure. This is not an isolated incident. A brief search reveals numerous reports from Kia K5 owners describing the same sudden blower motor failure, indicating a likely systemic defect in the HVAC system design. Kia has not issued a recall, technical service bulletin, or other remedy despite repeated reports from vehicle owners. Kia’s continued inaction in the face of widespread, well-documented blower motor failures represents a disregard for both driver safety and basic manufacturing responsibility. Numerous Kia K5 owners have already been victimized by this defect, and doubtlessly many more will be as long as these vehicles remain on the road unrepaired. The loss of climate control directly compromises a driver’s ability to maintain a clear windshield, safely see the road, and operate the vehicle in adverse weather. These are not “comfort” issues, they are safety-critical failures. By ignoring the mounting evidence and leaving affected vehicles on the road without a remedy, Kia is willfully allowing a known hazard to persist, exposing thousands of drivers and passengers to unnecessary and avoidable risk.

Side Curtain and Seat Side Airbags. Unavailable for inspection as Avis Rental Company cleaned the vehicle, removed airbags, and sold at auction as salvage. Side curtain airbags trapped me in the vehicle, and shrapnel from seat side airbag impaled/injured my arm. Combination of Side Curtain and Seat Side airbags, and seat belt, resulted in catastrophic shoulder injuries. Additionally, the gases and powder substance from the airbag deployment caused a severe asthma attack. I was told that the entire interior was covered in a powder substance. Note: It appears that Avis Rental Company rented this vehicle out in violation of Federal Law (FIXING AMERICA'S SURFACE TRANSPORTATION ACT - Public Law 114-94 114th Congress - SEC. 24109. <<NOTE: Raechel and Jacqueline Houck Safe Rental Car Act of 2015.>> RENTAL CAR SAFETY.) as the recall is still showing as unresolved. I had also contact Kia Corporate and Kia Maui to inquire as to whether they had record of the recall being resolved and neither did.

July 5th we were driving heard a loud boom and the car slowed down we pulled over. Then we seen that the seat was lifted up and smelled gas. We had an appointment for Monday July 7 for this recall and wasn’t able to drop off the next on Tuesday July 8. As called that Monday made the dealer aware. Now they been having the car and we are just waiting on the next process. There’s not sure what saying Kia will contact us. I am reaching out to get some type of results. We can’t get a rental car and next week it will be 30 days on the 8th of August. We are looking to resolve this matter with Kia.

My fuel tank has expanded. It has deformed the body beneath the rear seat.

Brake pump failure caused the exhaust camshaft to break on the engine rendering the car inoperable. Engine replacement will cost over 8000 quoted by dealership. Car has check engine lights on the dash. We were advised by the mechanic at the dealership, they have had problems with the k5s with this issue.

While driving the car started to have the sensors for the adaptive cruise control, automatic emergency breaking, blind spot warning, forward collision warning, and rear cross traffic warning all came on. The rpm starting going crazy the car was shaking and struggling to start, the car was shifting weird causing the acceleration to be poor. This all happened while driving if we were on a busy road we would’ve gotten hit the car randomly started breaking and slowing down, this is dangerously and could cause serious injury and damages to the vehicle and others around it. This is a problem a lot of people have been complaining about and need to be fixed it’s not okay or safe to be driving a car with these issues especially when there is no warning it just breaks and shuts down no matter where you are or how fast you may be going.

A silver piller price of trim flew off on the highway in the rear. A lot of Kia k5 owners have experienced this and it could fly off and hit someone on the highway. Transmission is super jerky and can sometimes lose power I’ve also known a lot of people that have similar issues with the kind of transmission in the k5 GT 2022

I have replaced the Engine Splash on my Kia K5 twice and need to get it replaced again. This item is poorly made and it was replaced the two times from Kia at over $500. This seems to be a problem with many of the 2022 Kia K5's. It's almost like it disintegrates when it rains. This is a very expensive repair here are the dates of repairs 02/2023, 04/2024 and the date of the incident that is still needing to be repaired 03/2025.

While driving home recently with my young stepson securely seated in his car seat and my fiancé in the passenger seat, we suddenly heard a terrifying loud bang. Immediately following the explosion, my stepson cried out in pain. At the time, the windows were up and the air conditioning was off, yet we all felt an intense gust of wind inside the vehicle. When I turned around, I saw that my stepson’s seat had been lifted unusually high. We later discovered that either the fuel tank or the fuel pump had exploded.I was shocked and terrified. I had no prior knowledge of any fuel system issues or recalls on this vehicle. After contacting my local Kia dealership, a representative informed me, “Yep, your car has the recall, and it sounds like it swelled up.” Even more troubling is that I never received any recall notifications regarding these issues. The only recall notices I’ve ever received by mail were years ago for a completely different vehicle — my previous Kia Soul, which is no longer in use, as well as the recall for the side curtain airbag.I took it upon myself to do a VIN check and learned that this recall was issued on July 9, 2021, yet I purchased the car from Bev Smith Kia of Fort Pierce on December 30, 2022 — long after the recall had been published. I’m struggling to understand how this vehicle was sold without the required recall repairs being completed or disclosed.I am currently trying to work with Kia to resolve the issue, but I felt it was important to share this with your team so others can be made aware of the potential danger. Had this explosion happened at higher speed or on the highway, the consequences could have been catastrophic.

My 2022 Kia K5 panoramic sunroof spontaneously exploded while the car was parked. There was no impact, no debris, and no warning signs — just a loud explosion and shattered glass everywhere. I previously had a cracked windshield but was unable to afford repairs, as I am unemployed. Now the sunroof has blown out completely, and I believe this could be part of a structural or manufacturing defect. Kia will tow the vehicle to the dealership (Fred Anderson Kia of Raleigh) 06/05 between 8am-10am and I am requesting support under goodwill repair. This was a serious safety hazard and could have injured me, my toddler or others. I’ve since found other reports of Kia sunroofs exploding and believe this needs to be investigated further.

The contact owns a 2022 Kia K5. The contact stated that while attempting to accelerate from a complete stop at the red traffic light, the vehicle failed to respond upon depressing the accelerator pedal. The contact stated that upon shifting to park(P) and restarting the vehicle, the vehicle operated as needed. The vehicle was towed to the local dealer, but was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was 38,000.

Driving this morning 5/7/2025 at 9:09am and smoke started emitting from the center consol accompanied by a burning smell. My husband noticed the smoke coming from the car charging area, it made a popping/poof sound accompanied with even more smoke. We immediately pulled the charger out of the charger port. My car charger was melted and slightly burned.

While accelerating in response to a green light I made a right hand turn and as I accelerated up to the speed limit of 55 mph I heard and felt a very loud “bang or pop”. I proceeded to pull the car over anticipating a tire blow out or something damaging the rear end of my car and upon a full visual inspection of all tires, undercarriage, under the hood and in the truck and main cabin of the car I was unable to locate and issues and there were zero codes or lights. After careful assessment I proceeded to get myself and child home but on the way the car started stumbling and there was a strong Oder of gas. A check engine Illuminated giving us an error code referencing our solenoid that works in pair with our fuel system. After checking the car and going inside for about two hours, my husband came to me and asked what happened to the backseat as the entire thing had been pulled up and underneath it was a very pressurized and round fuel system. I proceeded to call the car dealership service department and told them the codes and everything I was showing and what was happening and asked when I could get the car to them, and if it was safe to ride, they said if it’s still ran to go smoothly to the dealership which was a 10 minute drive. As directed by the dealership I brought the car for service and I also located a voluntary emissions report that Kia issued in April of 2024 along with a copy of letters said to be sent to each owner of my make and model. I never received these letters and update not completed. Kia failed to effectively notify all owners of this potential issue with an over pressurized fuel system, putting myself and my children in great risk. Kia America stated they needed to study my car. A recall still has not been issued, although there are several complaints of the same thing in their cars and now I’m forced into a very unfair buyback and I am being penalized due to Kia failing to alert All parties. There is still no recall.

The vehicle has experienced repeated transmission-related issues, including erratic shifting, delayed response, slippage, and sudden loss of power while driving. These symptoms significantly impact drivability and pose a safety risk, especially when accelerating or merging in traffic. The issue was previously addressed by the dealership under a recall repair. However, the same transmission behavior has returned approximately 3–4 months after the repair. The dealership performed repairs multiple times before, and the symptoms have now recurred. The problem has been confirmed by the authorized dealership and is scheduled for another inspection. There have been warning symptoms such as hesitation during gear shifts and intermittent power dips while in motion, which began reappearing recently. The component remains available for inspection. Given the repeat nature of the issue following an official recall, I believe this may be part of a broader unresolved defect in the vehicle’s transmission system. The issue initially reappeared briefly after the recall repair, then subsided. However, it returned more consistently and noticeably after a couple of months, and is now ongoing.

UNKNOWN. When the vehicle is turned on and parked with the vent opened letting outside air circulate into the cabin. there is a foul smell like coolant or engine fume that come with the air flow. I did change my air filter multiple times but the suffocating smell does not stop. it gives headaches. there are reddit threads on this issue with Kias. please take a look into it. thank you

I was driving on [XXX] and I heard a really loud sound like a Gun Shot in my Car I couldn't just pull over I had to get off at the next exit when I did I checked myself and then I checked my Windows then I opened my back door on the passenger side and saw that behind the seat had swollen up. I drove to work and call KIA where I purchased the car and told them what happened my husband carried the car to them and to make a long story short. After Months of back & forth it was determined that the GAS TANK had EXPANDED!!! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

This has happened on 2 occasions, 1 while starting the car 1 while driving. Both times the cars volume went to max with either radio or Bluetooth on and produced a static noise with it. The volume knob did not adjust the piercing noise unless set to 0 or mute. This was remedied by pulling the amp fuze and reseting the radio. I had no lights or warnings pop up, and have yet to have this inspected by a dealership. This instant volume switch to max output with static while driving almost caused an accident as I was distracted trying to turn down my radio as quickly as possible with pain in my ears on the interstate. While stationary even after turning down the radio I still have lingering pain from how loud it was. From what I can tell this is something with the radio unit or amp within the car.

- Power Steering Motor Failed in under 50,000 miles - Failure of steering motor can make it hard to steer, steering wheel slightly shakes too - Turning the wheel you hear a high pitched rattling / squeak noise - Inspected and reproduced by Dealership / Manufacturer and determined it was the motor

Brake Rotors from factory warp very early, noticable in under 30k miles. Warped rotors makes braking harsh, makes the brakes not work as well ans steering wheel jolt when braking making it dangerous. Was diagnosed by myself and other K5 drivers who took their cars to dealerships and mechanics. No warning lamps or anything, just very rough braking. Happened to me around 24,000 miles

These warnings light up at the same time the dash for Electronic stability system, electronic parking brake, forward collision system, Auto hold and engine light, saying "check forward collision system, check blind spot detection, check smart cruise control system", and the vehicle goes into a sort of limp mode, not allowing it to accelerate past about 40 mph easily. In my research, I've have found approximately 50 other Kia k5 owners who have had this exact same issue. Half of the time, once taken to the dealership for diagnosis, it is weeks without anyone figuring out what the issue might be. Several instances where a part has been replaced which did not fix the issue at all, like an airbag module, or steering column. Several instances of the ecu and hecu being replaced, and several more of the entire engine/chassis wire harness being replaced. As for my case, now at the dealership for 2nd time because they could not reproduce warning lights while test driving vehicle. They have determined mine requires a full chassis wire harness replacement, with an estimated cost of $5k-$7k, which includes the $2800 harness. I initially thought mine was an isolated incident, and was shocked to find as many owners as I have that have experienced the same issue, some with mileage as low 25 miles, and causing sudden braking or issue with steering the vehicle. Being that it involves all the major safety systems of the vehicle, I am also surprised there has not been any sort of recall, considering these issues span all the way back to 2021. Just my two cents. Currently waiting on a tech to come out and determine if this is covered under extended warranty bought at dealership at time of purchase, as I am over the 60k mile factory warranty period. Have had this vehicle for 3+ years, and this just now started happening about a month and a half ago. Some have had this issue just weeks after leaving the lot with their brand new car, and a few of those returned the vehicle for a refund.

Turn signal, the turn signal just goes out and does not work. This is a know issue with kia. I have almost bin hit several times do to this. I have 2 exact cars and they have both the same issue. You cannot just have the bulb replaced, the whole headlight asembly has to be replaced, the front bumper has to be removed to replace the headlight asembly, very costly, this is not so much the cost but more of a safety concern.

I had 130 miles until I needed to fuel up. Out of nowhere, my gas light comes on with the miles now blanked out. I thought it was odd, but stopped at the next gas station to fuel up. It would not let me put more than .22 cents into the tank without gas exploding out the side. Again, cranked up the car & it states it still needs gas. Tried another gas station & got the same result. Ended up at the nearest Kia & they stated it was the fuel tank expansion recall. They told me they ordered the parts and it should be fixed a little after Christmas. A week later and they are stating they do not know how to fix the vehicle and have no options for rentals/loaners. They said Kia would have to contact them before they can work on the vehicle. I have not received a call but did call the 1-800 number I was given and they basically said that they don’t know what they are going to do and someone will reach out to me. This is so scary as a consumer that Kia is allowed to place vehicles on the road that are considered very dangerous. A process needs to be in place fairly quickly or I am afraid there will be a lot of people in my situation. Not only was this scary, I was alone & this could have put me in danger on the road. I will never buy a Kia again & hate the service I have received as I have been left in the dark from the beginning.

2022 Kia K5 GT Line steering wheel is getting stuck when driving over 20mph. It is hard to keep the wheel in a straight line when driving. The steering wheel becomes sticky and will veer to another lane. You have to apply pressure to bring the car back to center which is a safety hazard because when the wheel loosen up you unknowingly be in another lane. While driving, my wheel became extremely stiff and I close to hitting a vehicle in another lane because I had no control of the wheel. Kia dealerships are refusing to service my K5 without giving any reason. It is a scary situation when you can not control the car due to this stuck steering even when all assisted driving and lane assist features are turned off. This issue began in September and I have not been able to remediate the problem. Kia dealerships are not helping. I have taken my car to independent mechanics and they are not able to determine the cause of this issue. When driving at higher speeds like 60mph and over you have to continually add pressure to keep the car in a straight line. I have had front and rear end alignments and full inspections but have no found a solution to this problem.

The contact owns a 2022 Kia K5. The contact stated that while his wife was driving stopped at a stop sign, another vehicle traveling at approximately 30 MPH collided with the driver's side door. The air bags did not deployed, resulting in the contacts wife wife sustaining injuries he attributed to the failure. No warning lights were illuminated. The vehicle was towed to a body repair shop but later deemed a total loss by contacts insurance provider. A police report was filed and injuries were reported. The contact and his wife transported themselves to an area hospital for treatment. Both the contact and his wife were treated for varying levels of pain to their neck and back. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 23V149000 (Air Bgas), but the VIN was not included. The manufacturer was notified of the failure, and a case was opened; the contact was informed that the manufacturer had requested his insurance provider hold the vehicle at the body repair shop pending a review of the incident recorder. The failure mileage was 62,000.

IN OCT 2023 I STARTED HAVING ISSUES WITH MY FUEL TANK. I WAS DRIVING AND NOTICED MY FUEL GAGE WAS ON EMPTY BUT MY FUEL MILEAGE STATED THAT I HAD 100 MILES LEFT. I WENT TO THE GAS STATION TO FUEL UP AND I WASN'T ABLE TO PUMP ANY FUEL. I PROCEEDED TO DRIVE AND HEARD A LOUD BOOM AND A HISSING NOISE. I PULLED OVER TO ASSESS MY VEHICLE AND DIDN'T NOTICE ANYTHING WRONG. I TOOK MY CAR TO THE DEALERSHIP ON 10/26/2023. IN MAY OF 2024 I WAS ON MY WAY TO PICK UP MY DAUGHTER AND GRANDSON AND STARTED NOTICING MY FUEL GAGE WAS HAVING AN ISSUE AGAIN. ON MY WAY TO THE GAS STATION I HEARD A LOUD BOOM. I COULDN'T PUMP FUEL AGAIN. I PROCEEDED TO PICK UP MY DAUGHTER AND GRANDSON. AS THEY GOT IN THE BACKSEAT SHE ASKED ME WHY WAS THE SEAT LIFTED. I INSPECTED MY REAR SEAT AND NOTICED A 3-4 INCH GAP FROM THE SEAT AND THE BASE OF THE SEAT, ALSO IT HAD A LARGE LUMP. I TOOK MY VEHICLE TO THE DEALERSHIP THE FOLLOWING DAY ON MAY 24, 2024.VEHICLE IS AVAILABLE FOR INSPECTION. IT'S CURRENTLY AT THE KIA DEALERSHIP IN DOWNTOWN LOS ANGELES. AS AN UBER DRIVER MY LIFE AND THE LIVES OF MY PASSENGERS AS WELL AS FAMILY MEMBERS HAS BEEN PUT IN DANGER. UNKNOWN. MY VEHICLE HAS BEEN INSPECTED FOR THIS ISSUE ON 10/26/2023, 05/24/2024, AND 09/24/2024. THE VEHICLE IS CURRENTLY AT THE DEALERSHIP. THE EARLY PART OF JULY I TOOK A TRIP TO SEE MY MOM IN ARIZONA APPROX. 280 MILES AWAY FROM MY RESIDENCE. AS I WAS DRIVING BACK HOME ON [XXX] I NOTICED WHAT I THOUGHT WAS SMOKE COMING FROM THE DRIVER SIDE OF MY VEHICLE. I PULLED OVER AND GAS WAS HISSING AND SPILLING OUT OF THE FUEL TANK. I THOUGHT SOMETHING WAS WRONG WITH THE FUEL CAP SO I WENT TO PURCHASE A NEW FUEL CAP. I TRIED TO PUMP MORE GAS BUT I WASN'T ABLE TOO. I REPLACED THE FUEL CAP AND RETURNED TO MY MOTHERS HOME BECAUSE AFTER I REPLACED THE CAP THE FUEL WAS STILL COMING OUT OF THE GAS TANK. I HAD TO PAY $1,000.00 TO HAVE MY CAR TOWED BACK TO CALIFORNIA. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

2022 car with 80000 miles on it has a break booster vaccum pump failure

My 2022 Kia K5 GT-Line was involved in a hit and run accident while my vehicle was unattended and legally parked on the street. The repairs for this vehicle were $11,500+ The entirety of the left side of the car was mauled. Very key integral parts were involved and I have had alignment issues, A/C and heating issues, electrical problems including safety features (lane change, etc) and heavy suspension damage. It took almost 5 months to fix everything on my car insurance company/shop; mostly using aftermarket parts to save money. Loved the “State of condition must be repaired to a pre-accident condition” yet the insurance gets away with using after market parts! As of, 08/29/2024, my vehicle is currently at the Kia dealership for o2 sensor recall, as well as my melted blower motor, melted a/c wiring harness kit, foul stench coming from A/C vents when recirculating switched into fresh air mode. The smell is foul and causing upper respiratory issues for me. The seat has become toxic smelling from mildew/rust. I’ve been trying to address all of the above issues. The shop believes once they fix the A/C blower motor/wiring harness they can try to diagnose the fumes coming from the vents. Most of the repairs are on back order and without a date (2weeks-2months+) I am without a vehicle for my job and my insurance doesn’t cover rental reimbursement.

A couple of days before taking my vehicle to get serviced, I started noticing some concerning factors about an issue going on with the vehicles fuel system. When putting fuel in my car, the gas odometer wouldn't match with what the car was marking the gas miles to be. It would fluctuate throughout the day, in the morning it would mark 174 miles of fuel and in the afternoon it would somehow say I had 215 miles of fuel when I never added more fuel to my call. Also when I opened the gas tank I saw white smoke come out from the tank. My back seat also popped out of the clips that kept it in place. It was very apparent while doing research online of the issues I was going through, that other have similar issues, all leading to the fuel tank expanding. The service center at my local Kia claimed their not 1 but 2 recalls on the vehicles and unfortunately the sensor in the fuel tank needed an update, but because my gas tank expanded while they checked it out, they said they couldn't simply update the sensor as my whole fuel system had to be redone. I have tried to reach out to Kia since I do not have a vehicle to commute to work and it is essential I get the issue resolved with my car. I don't know how long this process will take either since no one provides clear time frames or how the process will go. I am pretty much out of a car for over 6 days and still don't know if it can be repaired or what can be done with my vehicle in the condition it is in.

Fuse melted into the fuse box causing electrical problems which caused blower motor issues which leads to no ac

I have a 2022 Kia K5 GT-Line. My problem started with what I thought was a AC problem. My car was still in warranty. (Under 60,000 miles). They change the blower motor. After it was fixed the next day my AC went out again. I have taken my car in 4 times about the same problem. Just for them to tell me it’s a fuse problem where the fuse box is overheating and the whole fuse box is melting and needs to be repaired which I was told is almost $2000 to be repaired and it is not covered under the warranty. I know of 5 other people that’s having the same problem. I wouldn’t expect this to happen to an 2 year old car.

The contact’s daughter owns a 2022 Kia K5. The contact stated that while the daughter was driving at 65 mph, the steering wheel became difficult to turn. The driver lost control of the vehicle and crashed into a ravine. No warning lights illuminated. The driver sustained arm injuries due to the air bag deployment. No medical attention was received as of yet. A police report was filed. The vehicle was towed to an independent mechanic but was not diagnosed or repaired. The dealer was not contacted. The manufacturer was made aware of the failure and a case was opened. The failure mileage was approximately 35,000.

TRYING TO PASS A TRUCK THAT WAS TRAVELING SLOWLY, I ACCELLERATED AND LOST POWER. I TRIED AGAIN AND SAME THING. THIS IS INDEED A TRAFIC HAZARD. I NOTICED THAT THE RPM RAISED, BUT THE VEHICLE LOST POWER.

On June 12, 2024, the driver heard a loud pop/thump coming from the rear of the vehicle. The driver looked back to inspect the vehicle and noticed that the back seats had lifted his child and car seat up from the proper seating position. Upon further inspection, the driver had noticed a large bulge under the rear seats that was releasing a lot of heat and the smell of gas was throughout the cabin of the vehicle. On the way home at the time of the event the driver stopped to get the gas and when opening the gas cap noticed a violent pressure release, similar to opening a shaken-up soda. The driver quickly got to a safe location as the heat in the passenger cabin started to rise. The driver immediately notified the Kia Service Dept. and the vehicle was towed to the Kia service department on June 13, 2024. On June 18, 2024, the driver was told that the current issue was due to a gas tank expansion issue and that the gas tank expanded causing the metal frame to bend, and that the vehicle may not be repairable since the metal frame had been bent. The service department stating the vehicle is no longer safe to drive and that the issue would be escalated to their consumer affairs team. It is July 29, 2024, and there has been no word of Kia or any representative thereof that has reached out to remedy this issue. The dealer has denied a temporary replacement vehicle and/or rental car replacement for the time being. Where the driver and child were at extreme risk of a potential fatality or extreme injury, It would be expected that the matter be handled a little more expeditiously. Hoping to get this matter resolved!

The contact owns a 2022 Kia K5. The contact stated that while his wife was driving approximately 35 MPH, the A/C unit occasionally shut off, and failed to return to normal operation several minutes later. No warning light was illuminated. The vehicle was driven to the local dealer to be diagnosed. The contact was informed that the fuse was burned and could cause an electrical fire. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 24,000.

The contact owns a 2022 Kia K5. The contact stated while driving at an undisclosed speed, the power train warning light illuminated. The vehicle was taken to a dealer; however, the vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 31,000.

A/C has gone completely out on vehicle. Fuse has melted into fuse box and destroyed the electrical harness causing the blower motor and resistor to malfunction. Second time this incident has occurred and is a know problem to my local KIA dealership.

The contact owns a 2022 Kia K5. The contact stated while driving at various speeds and depressing the accelerator pedal, the vehicle shuddered and hesitated to respond. The check engine warning light was illuminated. The vehicle was taken to the dealer several times, where the dealer related the failure to the fuel cap. The dealer loosened the fuel cap; however, the failure persisted. The vehicle was taken back to the dealer, where it was diagnosed with fuel tank expansion. The vehicle was not repaired. The dealer offered to repurchase the vehicle. The manufacturer was notified of the failure and a case was opened. The failure mileage was approximately 47,940.

Backseat made loud noise and the backseat popped up car started to cut off and stumble as there was no gas in the gas tank leaving me stranded on the side of the road out of state were i donr stay in the way back home to ga

I was driving home yesterday and experienced a loud pop in the back of the car and found the backseat had lifted because the gas tank had expanded I am at the dealership right now Hoping that they will give me a loaner And I would like to trade the car in because I don’t trust the car anymore There are other reports of this similar issue I found online The reports say that there is a PVC pressure release valve that is getting stuck and causing the gas tanks to explode I am currently at the dealership and it is going to be inspected It is the first time this dealership has had this issue reported But there are six other incidents reported in other states like Texas, Louisiana, Florida, and North Carolina

Instrumental Cluster has went completely out. The only light that’s on is the seatbelt light on my 2022 Kia K5. That’s is strange for a brand new car unless there could be a recall which is for the late 2022 / 2023 model cars. I contacted every Kia dealership near me and would not tell me what the issue could be that I needed to bring it in. The amount just to do a diagnostic was not in my budget but finding out later that there are recalls for this exact reason, does not sit well with me. I contacted a service manager in Sherwood AR where I lurched my vehicle to see if its cover under warranty and he has not called back. It’s not customer service satisfying that neither techs were even willing to tell me why it just magically stopped working on a brand new car. I put my life at risk driving my kids and myself to work, I couldn’t see how fast I was going, don’t know how much gas I have in my car, signal light comes on but no sound… NOTHING. Something has to be done and seeing that other Kia’s has had this same issue does not sit well with me and a Kia owner.

I was experiencing problems with my air conditioning not staying on and the blower would not come on at all. It would come on sometimes but it stop cooling and sometimes it wouldn’t come on. I reported the problem in November 2023 and was told that the something in the wiring harness had burnt out and the wiring harness had to be replaced. Their earliest available service appointment was in February 5, 2024. I asked if it was safe to continue driving, and I was told yes it is drivable and wouldn’t be a hazard. It’s been over a month and I can never get the status of my vehicle from the service department. I contact the Kia corporate office and they gave them a service completion date and my vehicle has not been repaired. After a second attempt with the corporate office, the corporate office call wasn’t answered so a message was left. This vehicle has 34K miles and should not be in need of such a repair for a 2022 Kia K5. It’s March 11, 2024 and I’m without my vehicle and haven’t been provided with a loaner after several requests. I have learned my lesson and hoping this matter will be resolved.

I was involved in an accident where my lane departure warning did not work! I was hit twice, causing significant body damage over19,000 in which my air bags did not deploy!

The contact owns a 2022 Kia K5. The contact statement while driving at approximately 45 MPH, there was a sound of air inside the cabin of the vehicle and the fuel gauge erroneously reduced to empty. The vehicle was later driven to the local dealer who diagnosed that the fuel tank was defective and had expanded and needed to be replaced. The contact was informed that the fuel tank expansion had also caused damage to the rear seat support metal. The exact cause of the failure was not yet determined. The manufacturer was notified of the failure. The failure mileage was 72,000.2

On August 23rd my car slowed down while on the highway and completely came to a stop and wouldn’t drive while pressing the gas. At this time the forward safety system, EPB, Auto Hold, caution and traction control lights were on. I had to get the car towed to the dealership. September 1 Kia called said nothing was wrong with the car I could pick it up that same day I got charged for a diagnostic fee and also asked for the inspection to be done. Picked up the car on 9/2. After driving the car 2 days all the lights came up including the check engine light, at this moment the car completely stopped and turned off while in the middle of incoming traffic when turning at a light. Quickly turned blinker lights on and turned the car on and was able to drive it at this time only the check engine light was on called my husband because I was shaken by the fact that I could of been seriously injured if traffic would of been heavier at that time. He called Kia told them about the situation and they said to take the car in. As of right now 10/3 Kia is still not aware of what is going on with the vehicle and have stated that they have checked several things and still have not found the issue. The next thing they will be checking is the fuel system. To this moment I am thankful that nothing worse happened when the car completely came to a stop in the middle of incoming traffic, while the car was just inspected 2 days before.

The saga continues with this particular vehicle, which Goose Creek Mitsubishi failed to disclose had experienced prior accidents, major parts damages, repairs, & replacements. So much so, the frame & body works of the entire vehicle have been quite compromised. The most recent sign of their attempted repairs & replacements, due to undisclosed front & side impact damages, is the entire front bumper, which became fully detached, while in transit. On the way, to & from my wife's surgery, we passed through some uneven pavement sections, along a construction zone, between Barnwell, SC & Aiken, SC, on August 11. As we reached my son's school & entered the parking lot, I began to hear sounds from the front end of the vehicle. By the time we pulled into a parking spot, all but one corner of the bumper had become detached & was lying on the ground. I didn't have the resources, on hand, to properly address the collapsed bumper. Thankfully, my own father came to our rescue. We used bungee cords, straps, & zip ties, in order to secure the front bumper in place. Due to the bumper being offset & the cords/strap crossing over the top edges of the bumper assembly & engine frame, I've been unable to fully secure the hood. The vehicle has been rendered unsafe for highway driving. My mechanic & I have addressed that very bumper, through previous communications, directly to the dealership, through a prior BBB complaint process, & a currently open, SC Consumer Affairs complaint. It's obviously a replacement bumper, attached to a compromised frame. We have shared photos, which revealed breakage & separation, beneath the hood lid, at the very top edges, where the front bumper attachments meet up with the engine frame.There's visible breakage, along the seam of that top edge & at the adjacent passenger side corner. The vehicle was sold to me, in disrepair, & has quickly fallen into further disrepair. Therefore, I've been forced to park the car & wait for proper resolution. Thank You

The Integrated Thermal Management System (ITMS) failed/ malfunctioned. Available for inspection. My car completely lost power on the interstate and it was 70 mph speed limit, I had a semi behind me. I’m taking to the dealer when I’m off in 3 to 4 weeks. Problem has been reported by other owners, as well as Hyundai Sonata N-Lines. Also video evidence. Not been inspected yet, but that’s the problem. No warning lights. Could see the temp gauge moving up when I accelerated. Problem happened when it was cold outside, popped the hood and engine wasn’t overheated at all, ITMS failed.

The contact leased a 2022 Kia K5 equipped with Pirelli Tires, Tire Line: P Zero AS, Tire Size: 235/45/R18. The contact stated that the passenger’s side front tire had a bubble. The vehicle was taken to an independent mechanic where the tire was replaced. The vehicle was taken to the local dealer where it was diagnosed that the driver’s side rear and passenger’s side rear tire thread depth was low. The two tires were replaced. The manufacturer was contacted by email and provided reimbursements for the tires. Additional assistance was provided. The failure mileage was approximately 20,000.

The back rotors (part #:58411L0000) needed to be replaced due to warping which caused the vehicle to rapidly shake at high speeds and when slowing down. I tried contacting the dealership in regards to getting my old rotors or a manufacturer name and number and they were unable to fulfill that request. If my rear brakes failed at any point in time then that is putting myself, any passengers in my car, and others around me at danger. Stopping is a huge safety component of any vehicle. Yes, my problem was confirmed by the dealership I got my car from, which in turn they tried to blame me for the problem. It was only inspected by the dealership I got my car from. The only indication/warning I got was when I started to brake or drive on the highway, I knew that there was an issue since I do not think it is right for a brand new <20,000 mile vehicle should be shaking the way mine was before repair. I got my vehicle serviced and repaired on 05/27/23 and noticed the issue a week prior. Called and scheduled an appointment immediately.

Within 2 months of buying the car, it has stalled in traffic twice with engine revving. During the first time, it was unnoticeable until my car did not react when pushing the gas pedal. The car stayed at a stop until I restarted it twice. Kia dealership was informed, however, they could not find an issue or code. Recently, the second time was different and more scary. It stalled once again and as soon as I noticed, my car would not accelerate and started rolling and revving with high rpms. I immediately put my hazards on in the middle of a 5 lane road in heavy traffic and was able to let the car roll into a parking lot. I left the car there, turned off, for 30 minutes before restarting it to have someone follow me back home. During this scary trip, the car shook violently and my foot was to the floor on the gas pedal and the car still would not accelerate unless on a slope. A five minute drive turned into a 25 minute trip while backing up traffic. (So, very high rpm’s, slow to almost no acceleration, shaking and revving, NO engine light or warning lights triggered). Engine continued loud revving and moving idle in park that evening. Since then, car has been in mechanic once again with no solutions, codes, or lights to help the dealership figure out the issue because they say “it’s driving perfectly now”. They are the only ones to inspect the vehicle each time.

I have had to replace the front rotors twice now. Once at 20k and again at 30k. The tires had plenty of tread life but started to separate in the center of the tire at 20k miles. No inspection by a dealer. Called Kia as well as Kia customer care and was advised nothing was covered under the warranty. No lights came on but the shaking for the brakes as well as a tire vibration was made apparent

The female buckle component located on the seat directly behind the driver has failed. This has put anyone sitting in the car at a much higher risk of serious injury in the event of a car accident. This problem has been confirmed by the dealer and as of now, no solution is available.

While you're driving you hear weird squealing sounds and when you slow down the transmission tends to rattle. 2: After you start the car, there is a very loud sound like track and the car tends to move back and forth.

I had a single vehicle collision and ran into a ditch, none of my airbags deployed and I had a sternal fracture from hitting my chest so hard on the steering wheel. My vehicle was totaled as well.

On December 28th 2022 between the 6:30 am to 8:00 my car was parked and caught on fire. I have filed a complaint with Kia and since then I have gotten the run around about them looking into the vehicle and seeing what cause the issue. My car was still under the manufacture warranty

The transmission is experiencing a loss of power and getting heavy/stuck at about 20-30 mph before It begins to accelerate somewhat faster. The car is also not accelerating properly. Engine light came on as this began. Oil changes on vehicle are up to date as well

I was traveling normally, exiting a highway ramp when my car acceleration system malfunctioned. It seemed as if it was a power train issue or engine issue. I was not able to accelerate or slow down properly due to this malfunction and it caused me to crash. My car was totaled.

On 11/29/2022 my car wouldn't start, just click and continued to try and start then the check ESC warning came on. I had to get it jump started from KIA Roadside assistance and drove vehicle to local KIA Dealership where they tested the battery and said it was a bad battery. They replaced the battery. My car was purchased Dec 23rd 2021, battery was not even a year old . Fast forward 27 days, on Dec 26th, 2022, I was originally scheduled for the 8000 mile maintenance with Jake Sweeney KIA at 10am, went to start vehicle and wouldn't start again. It done the same as before on 11/29. Just click several times and then the check ESC warning came one(I have video of the entire process). after the Check ESC went off the entire cars electrical system went out and I couldn't even get jumper cables out of trunk of car. I contacted roadside assistance again, but they said it would be 3 to 4 hours before they could come, so I bought cables from store. Once started drove it to Jake Sweeney KIA they change oil and rotated tire and did diagnostic check and everything came back fine, but here is my issue I knew it would because once you jump the car there are no codes or issue after that. Left the dealership and will wait to see if it does it for a third time. I feel they should replce vehicle because this is a safety issue if happens outside the home not mention incovenice with everyday life (work etc).

Randomly, the cars engine rev is really low, it’ll go up down up down over and over and over and then shut off, sometimes while in motion. Other times, when you’re finished driving and you shift into park the engine will shut off the moment you hit park. My safety is at risk due to the fact that when I was in motion and it did that it could’ve caused an accident. The dealer claims they are unable to re-create the issue, even though I am video recording proof. Many warning messages appear on my dashboard when this happens, but they all go away. Once you turn the car fully off and back on.

While driving at 40 mph a vehicle failed to stop at a stop sign and pulled out into my lane causing me to struck the front driver’s side of the vehicle. The airbags deployed in the truck that failed to stop but the airbags in my car failed to deploy resulting in several injuries to my head, neck, back, shoulders, abdomen and fractured spine. Police and EMT were called and arrived on scene. I was then transported to the ER via personal vehicle. I have since followed up with my primary care physician along with more tests, lab work and more imaging.

While breaking the steering wheel cut hard right, went to brake even more and the steering locked up and was unable to move properly. What component or system failed or malfunctioned, and is it available for inspection upon request? Steering How was your safety or the safety of others put at risk? It sent me into a guard rail, sprained my wrist due to the air bag Has the problem been reproduced or confirmed by a dealer or independent service center? N/a Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Insurance Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No warning lights. Car was repaired previously and made multiple complaints about the tightness of the steering to the repair shop and the dealership

Client called about his car. After a exhausting analysis, we noticed that the ADA system released the brakes, causing an incident. The forward collision warning did not get activated. The car should stop automatically if it detects a possible crash or when the car it’s getting out of the road and it never happened. The main problem was the airbag placed above the pedals. It’s too big and when gets deployed, can cause a fracture, mainly on the right leg of the driver.

On 11/24/22 my car would not start, and I kept getting a message to check ESC- electronic stability control. I pressed the ESC button on my dashboard but nothing changed. Eventually a relative jumped off the car, bypassing the warning, so I could drive home. The car started correctly the next day and for several days after. Then, on 11/28/22, I got the same warning, then the car would not start. This continued through 11/29/22 at which point I had the vehicle towed to the nearest dealership. It's still there and I have not heard if this has been resolved. At one point the car also said no key detected, although the key was in my hand. Remote start would not work as well. The car has 5800 miles on it. I'm concerned that this could happen while driving the car.

Glass between windshield and sunroof spontaneously shattered while parked in private driveway. There was no impact, the car had not been driven for two days, it was just parked and the glass busted. It is unknown if water will cause a problem with leaking into the cabin of the vehicle.

Dead spot in headlights. Manufacturer intentionally created a dead spot just left of center so as to decrease any chance of headlights shining into oncoming traffic. The dead spot looks like an inverted triangle . These are an LED projector light which already have a very sharp cut off and should not require any further manipulation of spread or throw. The problem becomes severe when going around a left curve or bend as the headlights no longer illuminate the roadway in a safe manner as the very noticeable dead spot is now in the drivers lane.

While driving this vehicle on local streets, I have noticed that when I am on terrain such as an incline going up, with a curve at the ridge, the vehicle's steering becomes hard to control. It stops as suddenly as it starts (going up and around on this certain local incline. I have not reported this to the Dealer yet. The vehicle has not been inspected since I purchased it. No warning lamps, messages etc. occurred prior to it's happening.

My coworker and myself we on the highway, we heard a loud boom and the door swung open. I called the dealership Freddy Kia on the gulf frwy. They said they could not do anything about it, I have to call the service department. I called told the girl what happened she put me on hold after 1hr I hung up. I called again she put me on hold again. I didn’t call back. I need this checked out what can I do? What if I had my grand child in the back and that door did the same. I have not even made a first payment on this vehicle. Can I return the vehicle I do not feel safe in it.

2022 KIA K5 REMOTE CONTROL/ENTRY/START KEY FOB BATTERIES CONTINUALLY DYING EVERY 2-3 WEEKS. ONCE KEY IS DEAD, THE DRIVER IS LOCKED OUT OF VEHICLE AND CANNOT START IT. DRIVER IS GETTING STUCK ON THE SIDE OF THE ROAD CONSTANTLY, POSING A SEVERE SAFETY HAZARD. IF VEHICLE STALLS, DRIVER CANNOT RESTART THE VEHICLE SINCE KEYT FOB IS DEAD. VEHICLE COULD THEN BE STUCK ON AN ACTIVE ROADWAY WITHOUT THE ABILITY TO RESTART THE VEHICLE. KIA CANNOT FIX THE ISSUE AND HAS REFUSED TO REPLACE THE FAILING VEHICLES.

The contact owns a 2022 Kia K5. The contact stated that while driving at 70 MPH with the driver-assist feature, activated, there was another vehicle driving slower at approximately 50 MPH was in front however the vehicle's feature did not automatically decrease in speed causing the contact to rear the vehicle. The air bags did not deploy. The contact had his daughter and her husband at the time of the incident where both sustained a concussion, fractured nose, and arm injuries. Both passengers were taken to the hospital. A police report was filed. The contact was unaware of the passengers in the other vehicle sustained any injuries. The vehicle was towed to an impound lot due to it not being drivable. The dealer and the manufacturer were not notified of the failure. The failure mileage was 5,000.

Vehicle will brake suddenly and without notice while using the adaptive cruise control option. The system believes there is a vehicle in front of the car when none is present. This is usually attributed to a vehicle exiting or when somebody passes and does not leave enough room between vehicles. The car will slow considerably (from 75 to 50) when this occurs and trailing vehicles will have to suddenly brake as well to avoid an accident. Discussions with the dealership have not provided any useful information. The vehicle manual illustrates how to disable ACC however nothing works.

I bought a 2022 Kia K5 on 06/18/2021. On 12/31/2021, the check engine light came on, it shows code P088000 in the Kia Access app. Transmission control system issue. It started to jerk slightly when shifting into reverse. The engine is working twice as hard as it should when trying to pick up speed, using gas at double the normal rate. It will not downshift unless I actually release the gas pedal so it runs at high rpm's at all times. Driving at 55-60mph, the rpm's are at 3-3.5K and it will not downshift at all. (Unless the gas pedal is released). I have called for a service appointment, and my dealership (Joe Myers Kia/Imports) in Houston,TX. And there is a 2 week service wait. I was told there was nothing they could do, they do not have loaner cars any longer. I have to wait to get the code diagnosed.

The contact owns a 2022 Kia K5. The contact stated that while driving 60 mph, she struck two deers that jumped into the roadway. No safety object detection was activated during the failure. The vehicle went to the left and right and stalled. The driver-side door was jammed. The air bags failed to deploy. There were no warning lights illuminated. There were no reported injuries. A police report was filed. The vehicle was towed to an independent lot. The contact called the local dealer but the vehicle was not diagnosed or repaired. The manufacture was not contacted. The approximate failure mileage was 2,000. The VIN was not available.

The contact owns a 2022 Kia K5. The contact stated that while operating the vehicle at night with the headlights on, the low-beam headlights projected a dark triangular non-illuminated section inside the light field causing a visibility hazard to the driver. The vehicle was taken to the local dealer who indicated that no problem was found and stated that the headlights operated as designed. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 100.

A few days ago I picked up my new 2022 Kia K5 GT-Line AWD Sedan. The car has LED projector headlights. On the drivers side headlight it casts a "V" shaped void onto the opposite side of the road, presumably to prevent the bright light from hitting oncoming drivers. However, when going around a left curve this void is directly in front of the car in my lane preventing me from seeing what is in front of me. I do not believe there is a way to adjust this since most likely you would have to remove the headlight, disassemble it, and then take the projectors out and disassemble them. Giving you access to the cutoff plate which I can only assume has a raised v to block that section. The plate would look similar to ∆. I understand the reasoning the engineers had for installing that plate within the projector bulb to prevent blinding other drivers, but at the expense of K5 owners own safety when going around left curves, especially in unfamiliar areas.

The contact owns a 2022 Kia K5. The contact stated that with the key inserted in the ignition and turned to the ON position, the locks failed to automatically lock as designed. The failure only occurs while the vehicle was turned on. The vehicle was securely locked using this method a few days ago, whether the vehicle was tuned ON or OFF. The contact stated that the vehicle was only automatically securely locked when the vehicle was turned off. The contact stated they had a similar failure with the Kia that was traded for the current vehicle. The contact stated that the vehicle had also displayed an odometer reading of 7,400 miles however, the following day the mileage was 200. The dealer was contacted however, there was no reply. The vehicle was not taken to be diagnosed. The manufacturer was made aware of the failure. The failure mileage was unknown. THE CONSUMER STATED THE VEHICLE HAD TIRE ISSUES THAT OCCURED AFTER AN ACCIDENT AND HAVING THE TIRES REPLACED. THE STEERING WHEEL WEEL HAS DEVELOPED A LARGE OPENING. ALSO, THE VEHICLE WOULD START INDEPENDENTLY.