2014 Heartland BIG Country

Component: EQUIPMENT:OTHER:LABELS

Heartland Recreational Vehicles, LLC (Heartland) is recalling certain trailers of various models and model years. Click on "All Products Associated With This Recall" for a complete list. The tire certification labels applied to the vehicles may contain inaccurate tire sizing and/or inflation information. As such, these vehicles fail to comply with the requirements of 49 CFR Part 567, "Certification."

Consequence: An owner or operator could rely on the inaccurate information in inflating the tires which could cause under or over inflation which, in turn, could lead to a tire failure or crash.

Remedy: Heartland will notify owners, and dealers will send a replacement label with the correct information, free of charge. The recall began on September 29, 2015. Owners may contact Heartland customer service at 1-574-266-3988.

Full recall detail →

Component: EQUIPMENT

Heartland Recreational Vehicles is recalling certain model year 2013-2014 Big Country, Bighorn, Elk Ridge, Elk Ridge Express, Landmark, Prowler, Sundance, Sundance XLT, and Silverado fith wheel and travel trailers manufactured February 13, 2013, through April 16, 2013. If the awning installation sequence was not completely followed, the awning motor may unknowingly become damaged.

Consequence: If motor damage has occurred, it is possible that the awning can unfurl unexpectedly, either while the trailer is at rest or while in transit, increasing the risk of personal injury or a vehicle crash.

Remedy: Heartland will notify owners and Dometic staff will replace the affected motors with a design that is not subject to an out-of-sequence installation error. The recall began on May 20, 2013. A notification schedule has not yet been provided. Owners may contact Heartland Recreational Trailers at 1-888-262-5992 or Dometic at 1-888-447-0003 for more information. Owners are being instructed not to drive their vehicle until repairs can be performed. Heartland's recall campaign number is 99-01-11.

WE PURCHASED A 2014 BRAND NEW HEARTLAND BIG COUNTRY FIFTH WHEEL IN NOVEMBER 2014. WE TOOK IT ON OUR FIRST LONG TRIP BEGINNING JUNE 2015. WITH LESS THAN 3500 MILES ON THE POWER KING TRAILER TIRES WE HAD A BLOW OUT ON THE DRIVER'S SIDE FRONT TIRE TRAVELING AT LESS THAN 60 MILES AN HOUR. THE TIRE SHREDDED AND IN THE PROCESS RIPPED THE BUMPER FROM THE CAMPER, ALONG WITH TV LINES RESULTING IN OVER $4000.00 IN DAMAGE. WE HAD THE TIRE REPLACED AT A TIRE STORE AND CONTINUED OUR TRIP. APPROXIMATELY 3000 MILES LATER THE 2ND TIRE BLEW (ON THE SAME SIDE AS THE FIRST BUT THE REAR TIRE BLEW THIS TIME) ONCE AGAIN WE HAD THE TIRE REPLACED, AND FOCUSSED ON GETTING HOME AT THAT POINT. THE TRAILER WAS REPAIRED UPON OUR RETURN AND WE ALSO PURCHASED A TIRE MONITOR. LAST WEEK WE LOADED THE CAMPER AND HEADED OUT FOR A WEEK IN THE CAROLINAS. WITHIN 75 MILES THE FRONT TRAILER PASSENGER TIRE BLEW. THIS TIME THE BRAKE LINES ON THE PASSENGER SIDE OF THE CAMPER WERE RIPPED OFF FROM PIECES OF THE SHREDDED TIRE. FORTUNATELY A STATE FARM ROAD RANGER ASSISTED US, CHANGED THE TIRE, AND TOLD US THE OTHER TIRE LOOKED UNUSUALLY SHAPED AND RECOMMENDED WE EXIT ASAP TO CHECK IT. A FLORIDA STATE TROOPER OBSERVED THE SAME PROBLEM. WE WERE ABLE TO FIND A TIRE STORE, SELLING THE SAME POWER KING TIRES. THEY HAD NO OTHER, SO WE PUT TWO MORE ON THE PASSENGER SIDE, TURNED AROUND, DROVE THE CAMPER BACK TO CAMPING WORLD AND HAVE JUST SPENT $2000.00 PUTTING NEW GOODYEAR TIRES ON THE ENTIRE CAMPER. WE WERE TOLD WE SHOULD BE THANKFUL NO ONE WAS HURT, AS THE POWER KING TOW MASTER TIRES PUT ON THESE NEW RIGS ARE NOT SAFE, AND SHOULD BE REPLACED AS SOON AS POSSIBLE. WE WERE NOT INFORMED AT ALL REGARDING THIS BY HEARTLAND OR CAMPING WORLD. HOPEFULLY SOMEONE WILL DO SOMETHING ABOUT THIS BEFORE THERE ARE MORE SERIOUS ACCIDENTS AND INJURIES. IT'S SHAMEFUL "MADE IN AMERICA" RV DEALERS ARE GETTING AWAY WITH THIS.