2022 Ford Maverick Problems & Complaints

There is a Ford Customer Satisfaction Program, 25N09 issued September 2025 which covers half shaft replacement for Mavericks manufactured from 12/01/21 through 11/23/22. The upgraded beefier replacement half shafts were not available until late 2024. The program states that if the half shafts on one side fails that that both half shafts are to be replaced. My 2022 Maverick was manufactured 11/21/2021 (the second month of production), a mere 10 days before the initial date of coverage. The half shaft on one side was replaced on 01/10/25 with the upgraded version of the half shaft under warranty. They did not replace the other side. If the beefier replacement half shafts were not available until late 2024 how am I to believe that my Maverick does not have the same under engineered pieces in the other 68,000 2022 Mavericks?

Per a video posted on LinkedIn on March 20, 2026 by Chris Hackney, a Fountainhead Logistics Class 8 tractor displaying a Texas License plate on the front bumper & equipped with the Kodiak Robotics "Kodiak Driver" autonomous system was pulling three 40' belly dump trailers used to transport frac sand on an unknown public roadway in the West Texas Permian Basin in violation of Texas State law which prohibits triple trailers on public roadways. I can't confirm that the movement of the triple trailers shown in the video actually occurred on a public roadway vs a private lease road in the oil & natural gas fields where Fountainhead Logistics operates. I request NHTSA reach out to Fountainhead Logistics &/or Kodiak Robotics to confirm if such alleged illegal movement was made on a public roadway.

My 2022 Ford Maverick Hybrid experienced a complete electrical system failure at approximately 15,933 miles, resulting in a no-start condition. The failure involved the vehicle’s electrical distribution system. An authorized Ford dealership (Autos Vega Ford) diagnosed that voltage was not reaching the Body Control Module (BCM) due to a fault in the battery cable and wiring system. The repair required replacement of the 12V battery, high-voltage battery cables, and wiring components. The failure was confirmed by the dealership (Autos Vega Ford) and required multiple jump starts, but the vehicle would not consistently restart after being turned off. There were no prior warning indicators before the failure. The issue occurred suddenly without warning. This failure created a safety risk because the vehicle could not be started or operated. If this failure occurred in an unsafe or remote location, it could leave occupants stranded and unable to move the vehicle. Service records are available through the authorized dealership (Autos Vega Ford). This appears to be a premature electrical system failure at low mileage involving critical components such as battery cables and wiring. Similar issues involving electrical systems, battery defects, and wiring faults have been reported in Ford Maverick Hybrid vehicles. The vehicle became inoperable without warning and required towing/assistance to reach a repair facility. A sudden no-start condition in a hybrid vehicle can create hazardous situations if it occurs in traffic, at intersections, or in remote areas where assistance is not immediately available.

My 2022 Ford Maverick (EcoBoost AWD) experienced a sudden transmission failure at approximately 73,000 miles. The dealership diagnosed the issue as coolant contamination entering the transmission due to a failed heat exchanger/transmission cooler. The dealer stated that engine coolant mixed with the transmission fluid, which destroyed the transmission and required replacement of the transmission, replacement of heat exchangers, and flushing of the cooling system. The repair estimate is 11,324.39. Ford acknowledged the issue and provided partial goodwill assistance of 3,079, leaving more than 8,000 out of pocket for the repair. This failure occurred without warning and resulted in complete transmission failure. The dealer indicated that coolant contamination is the cause and referenced Ford service guidance addressing this failure scenario (SSM 53465). I am concerned that a failure of the transmission cooler/heat exchanger can allow coolant to contaminate the transmission and cause catastrophic drivetrain failure at relatively low mileage.

Driver side door limiter welds broke loose. Ford said they had to replace the entire door and it was not covered by warranty. The dealer said that this happened to a bunch of Ford Escapes, but they did not have a recall for the Maverick yet.

What component or system failed or malfunctioned, and is it available for inspection upon request? turning the steering wheel makes clicking sounds from under the dash like a card in a bike tire spokes. How was your safety or the safety of others put at risk? a problem from a steering wheel/column making strange noises in a new/newer vehicle, how is anyone to know if it will lock up or not work properly while driving? this could cause life threatening loss if malfunctioning. Has the problem been reproduced or confirmed by a dealer or independent service center? yes, taking to local ford dealer, they have repeated and confirmed the issue as an issue with the rack and pinion motor resulting in 1100 repair bill. truck has 31k miles, but just couple months over the 3 yr 3k mile factory warranty. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? randall ford dealer in fort smith, arkansas Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? no, none

The contact owns a 2022 Ford Maverick. The contact stated that while driving at an undisclosed speed, the trailer brakes became inoperable. There was no warning light illuminated. The contact was informed by another driver that the trailer brake lights were not illuminated while the vehicle was stopped. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 44,700. The VIN was not available.

When driving at normal speed, my truck completely shut down with no warning. The instrument panel went dark and the engine shut off. I do not believe I was able to steer, though I think the brakes allowed me to slow the vehicle to a stop. I was near an intersection, so I was lucky to not have been hit from the rear or run in to traffic in front of me. The vehicle was unresponsive and would not turn back on. I was stuck blocking 1 lane of traffic for an hour because the vehicle could not be steered or taken out of gear to push it to the side of the road. I inspected the battery connection and nothing seemed out of place or degraded while trying to get the car out of the road. Highway Patrol also looked, but only was able to offer a tow truck as a solution. My truck has been at the dealer service for almost 2 days awaiting inspection at this point so I have no additional information on what caused this dangerous situation. There had been no indication prior, the truck had started and run normally and all scheduled services had been carried out by the dealer up to this point.

I have a 2022 Ford Maverick XL Hybrid and the system that failed is the rear lighting system, specifically the tail lamps, brake lamps, and rear turn signals. This appears to be related to the Body Control Module (BCM) software, which was the subject of Ford Recall 24S27 affecting many 2022–2024 Ford Mavericks. The failure began on my vehicle with the left rear tail lamp assembly (running light, brake light, and turn signal), and within approximately two minutes the right rear tail lamp assembly also stopped functioning. Since that time, the entire rear lighting system has been inoperative while driving. This issue creates an extremely serious safety hazard. While driving, my vehicle has no functioning rear running lights, brake lights, or turn signals. This means other drivers cannot see when I am braking, signaling a turn, or even driving at night. This significantly increases the risk of rear-end collisions or other traffic accidents, especially in low visibility conditions. I was unaware of the issue until visually noticing it when unlocking the vehicle, and there were no dashboard alerts to warn me prior to that either. Loveland Ford in Loveland, Colorado inspected the vehicle and confirmed that the rear lighting system is not functioning. However, instead of addressing the known Recall 24S27 Body Control Module software issue, they stated that LED bulbs were installed where halogen bulbs should be and issued an $816 estimate to replace the bulbs. I have never performed any aftermarket modifications, and the vehicle has only been serviced by Ford dealerships. The vehicle has been inspected by Loveland Ford, an authorized Ford dealership. Ford customer service confirmed that Recall 24S27 exists for this exact issue in many 2022–2024 Ford Mavericks but stated there is no record of my VIN receiving the recall remedy, which could mean the recall was never accomplished. No warning lamps, dashboard messages, or other alerts appeared prior to the failure.

The rear brake lights intermittently do not work, but at the same time the middle third light brake light works fine. also the turn signals work fine. People will rear end me if they don’t see my brake lights. I am a retired, master mechanic, and my son is also a mechanic. We have both looked into this problem and it possibly could be either a module or the turn signal switch. I had no warning of this problem coming on other than someone telling me my rear brake lights stopped working when they were following me. This is a very dangerous situation.

In cold weather -6F The cover over the positive terminal used to jump start the vehicle is impossible to remove. This causes a situation where the vehicle can not be jump started or render assistance to another that needs jump started. The issue stems from the fact that the plastic cover over the positive terminal is unable to bend when it is cold and can not be "unclipped".

This is a complaint of Sheridan Ford in Wilmington DE specifically refusing to complete the recall without my paying out of pocket. Manufacturer Recall Number24S59 NHTSA Recall Number24V684 was left incomplete because they demanded I pay for a "diagnostic" fee on a known safety issue - this dealership is taking advantage of a saftey recall that is required to force customers to pay

Clunking in the front end around 20,000 miles. Brought to multiple dealers and they all said no problem found yet clearly hear clunking both sides front going over bumps or steering back and forth quickly. Finally I just replaced them and noise gone. Second thing is headliner is completely ruined from moisture intrusion and can visibly be seen but dealer states no leaks present yet my headliner is water stained looking like those wet tiles in a school. Third is my transmission. It is very erratic when shifting and sometimes flares when downshifting. Dealers state no problems exist. Operates as designed, yet I have driven other mavericks and they do not have the same issues as myself. I have changed the fluid with genuine ford ulv transmission fluid from dealer at about 50k miles. I change my oil every 3k, changed my differentials and transfer case all with genuine fluid. I am an AAS Automotive Technology graduate and currently ASE certified and have worked in multiple dealerships replacing transmissions, engines, almost anything since I have started. I need to gather my records as I have kept receipts and records as I do all my own maintenance and repairs. I have replaced the downstream oxygen sensor twice. Yesterday morning I got a frozen throttle body and limp mode and if I did not have my scan tool I would have been stranded as it would not let me drive due to the stuck closed codes. All codes since I owned the vehicle with 3 miles on it are stored in my ford app and on my scan tool with vin. I have tried calling ford, email, different dealerships and they deny me or want me to pay out of pocket when I have warranty.

When it rains water gets into the passenger-side footwell and beneath the carpeting during rain events.

After a little over 3 years, my truck has had issues maintaining its 12v battery putting me at risk of being stranded. The battery was replaced once under warranty. Now that I am out of warranty, the replacement battery is now going bad.

The vehicle experiences water intrusion into the passenger-side footwell and under-carpet area during rain events. The suspected failure involves the body sealing system, potentially including the windshield cowl area, firewall seams, HVAC intake/cowl drainage, or related body panel seals. The vehicle and all affected components are fully intact and available for inspection upon request. The carpet has been lifted to document standing water and mold growth but has not been replaced or permanently altered. This defect presents multiple safety risks, including: Visible Black Mold contamination inside the passenger compartment, airbag, and throughout HVAC system, creating a health hazard for occupants. Potential electrical system damage due to repeated water exposure. Possible impact on airbag and restraint system wiring, which is located beneath the passenger-side dash and carpet. Increased risk of window fogging and reduced visibility during wet conditions. The vehicle is currently unsafe to occupy during or after rain due to these conditions. The problem is consistently reproducible whenever the vehicle is exposed to rain. The issue has occurred repeatedly over the course of ownership. A Ford dealership has acknowledged the presence of water intrusion but has not performed a full diagnostic inspection, instead requiring a paid inspection fee, claiming they are "fully booked until further notice" and stating they are “unaware” of similar issues, despite widespread owner reports.

Battery in the passenger compartment is charging at 15.2 volts constantly. Ford dealer claims this is not a problem, but the battery life has been shortened, and the battery model number states it should be charged between 13.8 and 14.2 volts. The battery is located under the rear seat, inside the passenger compartment. From my limited understanding of battery technology, over-charging can produce hydrogen into the passenger compartment. My vehicle is now on the third battery, and has only 73,511 miles.

The contact owns a 2022 Ford Maverick. The contact stated that while her son was driving approximately 60-65 MPH on the Interstate, the passenger’s side front wheel detached. There were no warning lights illuminated. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 40,000.

The contact owns a 2022 Ford Maverick. The contact stated that while attempting to start the vehicle, the vehicle failed to respond. No warning light was illuminated. The vehicle was taken to the dealer where it was diagnosed, and determined that the battery needed to be replaced. The contact stated that the failure had occurred on several occasions. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 19,150.

Door check has failed in the frame. The spot welds have broken in similar fashion to the Ford Customer Satisfaction Program 23B56 on the Escapes. There are popping noises, creaking, alignment issues, and prevents the window from rolling down.

The vehicle begins to vibrate in the front end when accelerating and reaching 80 km/h. It becomes extremely unstable. The dealership was unable to find the cause of the problem.

The rear drive unit (rdu) begin to shutter and lock rear tires at low turning speeds. The vehicle was out of warranty with 85k miles. I paid a Ford dealer to replace the rdu and 2 weeks later the same issue was occurring.

My car shuts off Battery drains, burning smell Rear camera gives out Clicking noises

HVAC evaporator drain is broken/cracked/clogged at firewall forcing water that should drain to outside of vehicle under the passenger side rubber floor mats, making it unknown to driver for months that this is happening and by the fuse box creating mold, mildew, and electrical issues. This is a known issue with ford trucks. Ford refuses to acknowledge and help with repair requiring removal of dashboard and replacement of moldy floor mats which is a health hazard. Dealership wants several thousand for repairs. This is an engineering design problem and must be recalled due to health hazards, electrical damage to full fuse box being under the carpet that's wet and the fact that ford knows this issue exists but won't correct the design flaw.

I am getting a “rear seat belt monitor fault” warning on my dash accompanied by an air bag warning light. It is also not allowing the auto start stop function to work as the vehicle states it cannot verify the driver seat belt is fastened. I have read in online forums that this is not an isolated issue.

Never in all my years of driving have I or anyone i know experienced a vehicle with such a sensitive windshield that cracks with even minimal impact. I've owned this Ford maverick for under 3 years with 3 chip repairs and 2 replacements. This is unfair to consumers as often we are not aware of this issue until it is too late to change undo the purchases on these vehicles and have to drive faulty vehicles. It's surprising that there's no recall already assessed for something that causes customers to have higher insurance premiums, constant damage that affects visibility and causes some to drive with these defects to avoid extra costs and wasted money. I am hopeful you can assist us consumers in having Ford rectifying these issues at no cost to us as their choice to use defective windshield glass has cost all of us. This issue is widely known by owners and discussed on social media forums in abundance. Dealers are aware of this issue and offer nothing but an attempt to purchase other vehicles. Minimal research on the internet provides an abundance of evidence. I thank you for your time and assistance in advance for this issue.

I was at a stoplight, when the light turned green I went to press the gas and the whole car lost power and died. The car stalled and would not turn over again. The vehicle had power but would not start the engine. All the alerts were flashing on the dash and the car would not go into neutral, so I was stuck in the middle of the roadway. I followed the procedures to activate the manual override and place the car into neutral and the vehicle would still not move. The electrical brake would not allow the vehicle to move. We tried repeatedly to put the car into neutral to move out of an active roadway and would be able to push the vehicle about an inch before the electrical break would kick in again. The vehicle would not start regardless of what was attempted. We even disconnected the battery in hopes of either getting the vehicle into neutral (which did not work either) or restarting whatever was wrong with the electrical system and be able to start the truck. Nothing worked and the vehicle had to be hoisted by pulley onto a flat bed tow truck. Then required to be "shaken" off of the truck when it arrived at the Ford dealership.

The contact owns a 2022 Ford Maverick. The contact stated while the door was closed, the window failed to roll down; however, upon opening the door, the window was able to be rolled up. A dealer was contacted. The vehicle was taken to the dealer where it was determined that door needed to be replaced. The vehicle was not repaired. The contact related the failure to a Customer Satisfaction Program: 23B56 (Inspect front door check-arm reinforcement spot welds); however, the VIN was not included in the CSP. The vehicle was repaired. The manufacturer was notified of the failure, and the contact was informed that there were no recalls on the VIN related to the failure. The failure mileage was 27,000.

Truck smelled funny, pulled over to check it out. Got out truck and noticed it was on fire from engine.

The vehicle vibrates or surges rapidly when accelerating or going up a steep hill. I have been advised that it is due to defective axles which are currently on backorder with no expected ETA.

No warning transmission went out while driving on freeway. Lost all power and vehicle would not engage into gear again.

The transmission is occasionally without any warning disengaging while driving. You must then try to get off the road turn the truck off put the key back to run with engine off, shift it to park, start it again and then you can drive it again until it does it again.

While exiting highway (removing foot from gas) vehicle thumped. The a “ Powertrain Malfunction / Reduced Power” message came up on dash.

The contact owns a 2022 Ford Maverick. The contact stated that while opening the front driver's side door, there was an abnormally loud creaking sound coming from the door. The contact stated that the sound became louder over time. There were fractures around the door frame, causing the sound. As a result of the failure, the contact stated that the front, driver side door window would only roll down at approximately an inch. The vehicle was taken to the dealer to be diagnosed; however, the contact was not informed which part needed to be replaced. The dealer stated that a door panel kit was to be sent to the dealer for the repair. The vehicle was not repaired. The manufacturer was informed of the failure and opened a case. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 72,000.

When in adaptive cruise control the vehicle must of not seen the lines properly and started to steer towards the ditch. Then when trying to steer back onto the road the truck keep trying to steer into the ditch. The truck was fighting the drivers input even though the truck should deactivate the adaptive cruise control when manually taking over. The truck end up in the ditch and ran over a mailbox. The truck was inspected by Ford but they claimed nothing is wrong with it. It says in the manual that adaptive cruise control sometimes doesn't detect lines properly but when taking control the vehicle shouldn't continue to steer into a ditch. The Ford dealership were not able to get the same results because how can they when this problem doesn't happen all the time? The vehicle should not be fighting the driver instead it should of canceled the adaptive cruise control. It's very dangerous and I think needs to be looked into.

Phone calls while connected to CarPlay do not come through car on first call. You have to press speaker on your phone twice to get it to come through. Which can lead to distraction while driving. Switching between CarPlay and radio also causes serious sound difference with one being deafening and extremely startling which can be dangerous while driving. Ford will not look into and brushes it off anytime it is mentioned to the dealership service department.

The contact owns a 2022 Ford Maverick. The contact stated that after driving the vehicle and parking, the vehicle failed to restart. The vehicle was jump-started. There were no warning lights illuminated. The vehicle was taken to the local dealer, where it was diagnosed and determined that the battery needed to be replaced. The vehicle was repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 36,000. The VIN was invalid.

Unknown what the problem part is but the car has a water leak that turned into mold behind the glove box and passenger side carpet. Have been having issues in the car as far as coughing and eyes burning. Had it inspected once and was told there was no water leak but had an accident recently and the shop saw mold and I found it throughout the passenger side of the car.

CV joints failing. 61k miles and getting a shaking front end wheel driving. A failure could cause an accident or other safety odor for the drivers and others. I’ve seen many reports of the same failures but no recalls yet. Ford should take care of this issue.

Door check spot welds broke. Door has unsafe operation. Will not hold open, and swings wildly. No inspection yet. Ford Dealer aware of problem. 2 month out of warranty.

Water intrusion on front passenger side of vehicle causing mold. Vehicle still has original windshield and all original carpet and interior. Ford Service department unable to do “leak detection at facility” but referenced several online sources believing it is a defective cowl or a/c part that is not sealed. Service department dried vehicle out for 3-4 days and water intrusion is still happening and mold came back.

At 70,000 (stock truck) truck began shaking under load/ acceleration. Both front CV axles have failed.

2022 Ford Maverick had water build up under the front passenger seat floor. I'm at 3.5 years of ownership and the dealer is telling me it will cost $1100 to fix because of an improperly installed windshield and cowl issue which ruined the internal filter and air circulation motor. Now i have to pay out of pocket because of a crappy manufacturer defect. I have seen in Maverick forums that this is a common issue and yet we are the ones having to fork out the cash.

The contact owns a 2022 Ford Maverick. The contact received notifications of NHTSA Campaign Numbers: 24V684000 (Back Over Prevention) and 25V019000 (Electrical System); however, the parts to do the recall repairs were not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available for NHTSA Campaign Number: 25V019000 (Electrical System); and Parts distribution disconnect for NHTSA Campaign Number: 24V684000 (Back Over Prevention).

At 61,000 miles on the odometer and the Cv shafts have to be replaced. Ford has no supply on hand and is on a global back order until the end of April. Part adviser said that this is a consistent issue with mavericks.

The contact owns a 2022 Ford Maverick. The contact stated while her husband was driving at approximately 35 MPH approaching a light with the Auto STOP/START feature engaged, the vehicle shut off. There were no warning lights illuminated. The contact replaced the battery. The contact received notification of NHTSA Campaign Number: 25V019000 (Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The vehicle was taken to the local dealer; where it was determined that the battery was not acknowledging the software. The vehicle was repaired, but the failure recurred. The dealer indicated that there was a loosened bearing and missing screws. The contact stated that the vehicle failed to start 60 percent of the time. While the contact was driving at 35 MPH, the vehicle stalled approaching a stop. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 36,000. VIN tool confirms parts not available.

My truck's CV axles broke around 20,000 miles. Replacement parts weren't available. This was a safety issue because I expected a new truck with low mileage to be reliable. If I wasn't technically inclined, I might not have understood the danger. The dealership replaced them under warranty, but they didn't inspect the broken parts. The truck shook badly when accelerating, which was the warning sign.

CV axles failed at around 28k. Replacement parts not available nationwide. Ford has recognized an engineering flaw in the axles, but have not issued a recall. I was informed it was dafe to drive while waiting for new cv axles.

Vehicle CV Axels going bad repeatedly. Replaced them 3 times. Luckily we've discovered the CV axel failures in low speeds. If it fails at the wrong time like during a turn on the highway, it could cause a serious accident. Plus the cost and inconvenience of repeated repairs continue to be an issue on such a new truck. Most owners report the same issue happening on Maverick forums. It seems lie this program is too common to be ignored. When we contact Ford dealerships parts are never available (back ordered) and it takes weeks to get this replaced adding more complexity to this situation. Formally requesting this issue to be reviewed at the NHTSA level.

At a intersection turning lane as I got a green arrow, ( as I pushed down on accelerator)a loud pop sounded and all vehicle operations stopped immediately. The battery had popped in the top front side, with battery liquid all over battery. No hazard lights, no putting into gear, only driver door operational at a very busy intersection. Flagging traffic and trying to call for new battery, very tough. Plant city Florida police arrived 20 minutes later. They waited with me until 40 minutes a battery arrived. I cleaned up acid with towel I had in front and tech changed battery. [THIS INCIDENT [XXX]- intersection [XXX] ] I can't express th [XXX] ot changing every battery thats compromised is beyond crazy. I paid $385 for the battery and spent $10 thousand of my life in that intersection. Fords are a lifetime of Dad's/my Family vehicle purchase history and I wish I had some of Ford Brass in the intersection with me. If they think they have a problem, I can guarantee it. Bartow Ford can't do anything because ( its Ford problem/remedy. I was discouraged they didn't say bring it in, but my buying any future product may be my remedy. Their were no warning lights, no smells from engine, no signs of any whisps of smoke coming up from hood. All I can finish with is when it happens, your out of business completely, where ever your at. The tech took the battery and I didn't take a picture because getting out of traffic was No.1. You can't sit inside and read your manual, with no emergency hazards at a busy intersection. You won't get this adrenaline rush/anxiety on a Universal thrill ride. You have a good chance of being hit by one or more vehicles on the inside or outside. Thank you INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Cv axles bad went out at 29000 miles could break and your truck could roll

The contact owned a 2022 Ford Maverick. The contact stated that while her grandson was driving at various speeds, the steering wheel locked and the vehicle lost power steering and functionality. The vehicle flipped over several times. An unknown warning light illuminated. It was unknown if the air bags were deployed. A police report was filed. The contact’s grandson was taken to the hospital via ambulance due to sustaining injuries to the back and neck. The vehicle was towed to a local towing yard. The insurance company was contacted and deemed the vehicle a total loss. The insurance company towed the vehicle to an unknown location. The manufacturer was not notified of the failure. The failure mileage was approximately 27,000. 

The contact owns a 2022 Ford Maverick. The contact received notifications of NHTSA Campaign Numbers: 24V684000 (BACK OVER PREVENTION) and 25V019000 (ELECTRICAL SYSTEM); however, the parts to do the recall repairs were not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2022 Ford Maverick. The contact received notifications of NHTSA Campaign Numbers: 24V684000 (Back Over Prevention) and 25V019000 (Electrical System); however, the parts to do the recall repair were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

while i was driving the truck lost power and i could not turn on my 4 way flashers when i was on the side of the road. when i called ford and asked if i would replace the battery if i would get compensation they told me no even though there is a recall

The contact’s father owns a 2022 Ford Maverick. The contact stated that while attempting to start the vehicle, the vehicle failed to start. The contact stated that the electrical components in the vehicle were on; however, the engine was off. There was no warning light illuminated. The vehicle was towed to a local dealer where the vehicle was diagnosed, and the contact was informed that no cause for the failure was found. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 24,104.

The contact owns a 2022 Ford Maverick. The contact received notification of NHTSA Campaign Number: 25V019000 (ELECTRICAL SYSTEM); however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2022 Ford Maverick. The contact stated while driving approximately 65 MPH, the vehicle lost motive power. The vehicle failed to accelerate as designed. The powertrain message was displayed. Additionally, the WRENCH symbol was displayed. The vehicle was taken to the local dealer, but the dealer was unable to duplicate the failure. The vehicle was not diagnosed or repaired. The Ford Pass App alerted the contact of the failure. The vehicle was taken to another local dealer, Loudon Motors Ford LLC (3476 Union Ave SE, Minerva, OH 44657); where it was diagnosed that the throttle assembly had caused the failure. The vehicle was repaired, but the failure recurred. The manufacturer was contacted and referred the contact to the local dealer for assistance. The failure mileage was approximately 20,000.

The contact owns a 2022 Ford Maverick. The contact stated that while attempting to park the vehicle, the rearview camera became inoperable. The contact stated that the image displayed on the screen was frozen. The contact received notifications of NHTSA Campaign Numbers: 24V684000 (Back Over Prevention) and 25V019000 (Electrical System); however, the parts to do the recall repairs were unavailable. The dealer was contacted. The vehicle was not diagnosed or repaired. The dealer informed the contact that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The approximate failure mileage was 52, 000. VIN tool confirms parts not available.

This is possibly more information regarding the known back-up camera recall NHTSA 24V684. After backing out of a parking space 1/26/2025, the camera froze (not the first time) and this time a message appeared in the upper left corner that read: "Indexing Nexus". I have also had on other occasions times where the Infotainment system itself would freeze with no warning and when the back up camera was not in use. I suspect the recall addressing the camera issue is only part of this and that the system itself has issues not related to the camera. Pressing and holding the POWER and Fast Forward buttons forcing a system restart restored usability.

The radio head unit often is unresponsive. Needs to be reset multiple times a week. Volume will either not work or no sound at all. Screen freezes and pops. Music cuts out. Skip button from steering wheel does not work sometimes. All operations on the touch screen are slow and laggy. Has had this problem since owning the vehicle.

The vehicle constantly goes into deep sleep mode and will not start. Battery was tested good at the dealer but would die after 2 hours of sitting. Battery was replaced with an AGM and still has the same issues. Dealer cant find an issue. Happened again today and left me stranded.

The contact owns a 2022 Ford Maverick. The contact stated that while driving on the highway at 70 MPH, the transmission unexpectedly shifted out of drive. The contact pulled over; however, the transmission failed to shift to park(P). The contact activated the parking brake and disconnected the battery to park the vehicle. The vehicle was restarted; however, the transmission failed to shift into park. The contact stated that while driving at an undisclosed speed, the transmission jumped out of gear, and the contact pulled over and had the vehicle towed to a local dealer to be diagnosed. The contact was informed that the transmission was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure milage was 126,000.

The contact owns a 2022 Ford Maverick. The contact stated upon opening the front driver's side door, the door made an abnormal cracking and popping sound. The vehicle was taken to the dealer, where it was determined that the door hinge or the entire door might need to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The manufacturer referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 57,000.

This car shifts to drive to neutral without any intervention on the freeway.

My husband was driving on a highway going 55 mph when the engine light came on and then the car completely shut off and died and would not start. It left him stranded on the highway with no shoulder at -35F. Ford now tells me they cant even look at the vehicle to see what is wrong until April 2025.

Front CV axles. Front end shakes really bad at 30-50 mph. Dealer changed front passenger side CV axle but it still shakes really bad. I'll be bringing it back to the dealership, but warranty expires soon they need to have a recall and a better replacement part for this fix. I am not the only one with this problem.

Was not able to put the car in reverse. Had to be pulled out of driveway by another truck. When driving forward the engine was very loud RPMs were in the beginning of the red zone. Took car straight to dealer. Told the transmission fluid sensor was broken.

The service engine light turned on. Observed the outside temperature displayed was incorrect at 189 degrees in the winter. The heat stopped working and front window defroster stopped working.

My CV Axles were in desperate need of replacement at 30,000 miles, with no after market modifications done to the vehicle, Discovered while modifying the vehicle. My truck was described as "condemned" by my mechanic, and this is a KNOWN ISSUE FOR MOST FORD MAVERICK OWNERS.

The contact owns a 2022 Ford Maverick. The contact received notification of NHTSA Campaign Number: 24V684000 (BACK OVER PREVENTION); however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced the failure. VIN tool confirms parts not available.

The contact owns a 2022 Ford Maverick. The contact stated that while stopped at an intersection, the vehicle stalled. The contact stated that the hazard light was inoperable. There was no warning lights illuminated. The vehicle was towed to the local dealer who was unable to duplicate the failure. The vehicle was not diagnosed or repaired. The vehicle was restarted and operated as needed. The manufacturer was contacted and opened a case. The contact was referred to the NHTSA Hotline to report the failure. The approximate failure mileage was 50,000. The VIN was not available.

CV axles make a very concerning, loud noise when driving. Any small bump on the road and it sounds like the front of my truck is going to fall off. When turning, there are loud knocking and clicking sounds coming from the front end, mainly passenger side. Electrical: My radio and head unit restarts randomly, both while driving and when the vehicle is turned off with keys removed from ignition. When it restarts, I hear a popping noise from the speakers, and the screen blacks out.

The component that failed on this vehicle was the restraint control module (RCM). It was replaced by the dealer and is not available for inspection. The safety of the driver I believe was at risk due to the vehicle occupant sensor not showing an occupant and only showing a question mark on the dash display. This was also causing an airbag and seat belt indicator light. The problem has been reproduced by a dealer. The problem first showed a rear seat occupant issue and then started showing for the left front seat. Showing an air bag and seat belt indicator.

CV AXLE SHUDDER

Vehicle shut off spontaneously with out steering control or ability to turn on hazard lights. Upon shut off vehicle dash and all internal lights flickered on off for hours no power with key ignition would not function

The contact owns a 2022 Ford Maverick. The contact received notification of NHTSA Campaign Number: 24V684000 (Back Over Prevention); however, the part to do the recall repair was not yet available. The contact stated while reversing, the rearview camera image was frozen. The contact stated that the rearview camera image remained displayed and frozen upon shifting into drive(D). The contact stated that upon turning off and restarting the vehicle, the image was no longer displayed. The local dealer was contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 33,400. VIN tool confirms parts not available.

This morning before my drive to work, a service vehicle soon message popped up on the screen. During my drive to work the vehicle began to respond sluggishly and lose power and acceleration on the highway. My safety and the safety of others was put at risk and the vehicle was unable to maintain highway speeds. I was able to make it to work driving at reduced speeds, and after parking the vehicle received a message on my Ford App of a Powertrain Malfunction / Reduced Power alert. My vehicle was serviced by Ford on 06/20/2024 for a recall related to the Powertrain Control Module (PCM).

Premature failure of both front CV axles. The vehicle had an extremely unsafe vibration in the front end during acceleration. Dealer has replaced both axles under warranty. This is a known failure and many of these vehicles are experiencing premature failure. Warranty will cover but failures are continuing to happen. Many owners have replaced the axles multiple times, prior to getting to even 65k miles.

I was involved in an accident. During the accident none of the airbags deployed. The impact was so hard that it lifted the truck up off the ground and spinned us around 90 degrees. This resulted in the individuals seated on the passenger side of the truck to be thrown into the door fairly hard, with one passenger hitting her head on the window even with the seatbelt on. The point of impact was the drivers side back tire and bumper area.

My license plate light has stopped working. It was replaced and still isn’t working. This reduces visibility and increases risk of a crash. This is in addition to the legal requirement to have an operating license plate light.

The contact owns a 2022 Ford Maverick. The contact received notification of NHTSA Campaign Number: 24V684000 (Back Over Prevention); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2022 Ford Maverick. The contact received notification of NHTSA Campaign Number: 24V293000 (Exterior Lighting, Electrical System), and the software update was completed. After receiving the update, the contact stated that the instrument panel failed to display the starting messages and displayed the vehicles in many different systems. The vehicle was taken to the dealer who had completed the software update a second time. After receiving the software update the second time, the instrument panel began functioning as intended and properly displaying the necessary information. The contact stated that the radio and display screen started malfunctioning. The vehicle was returned to the dealer who was not able to determine the cause of the failure and was only able to complete the remedy the manufacturer had authorized. The vehicle had not been repaired. The manufacturer was not made aware of the failure. The failure mileage was 38,000.

The whole car shut down while i was driving. I lost all power to the car and couldnt get it started again.

Both front cv axles failed at 55,000 miles causing shake while accelerating

Front CV axles causing Intense vibration through out front suspension/drivetrain

I ordered my truck with all terain tires, they installed Falken wildpeak A/T AT3W 235 65R 17 tires.When me vehicle sits for a while (especially when its cold out) .I get a vibration for the first few miles down the road then it goes away. I have taken it to the dealer they are blameing the issue on the Falken tires,they said these tires develop a flat spot after sitting for a while. So they didnt think it was going to hurt my vehicle so they where not going to replace them.Seeing how I paid extra for all terrain tires and they installed these tires I don't think that was the correct action on there part.

The rear brakes and rotors have prematurely worn out at only 28k miles, while the front brakes are like new. There is no way for me or any local repair shop to put it into brake service mode. The official Ford procedure does not work. NHTSA issued SSM 51217 acknowledging the issue, but the only solution is only to take it to a Ford dealer to do a simple procedure such as changing rear brake pads. This solution is unacceptable and causes an undue burden upon the customer in time and money for a known manufacturing defect. My closest dealer is 1 hour away. It can not pass my state safety inspection without this being done. Ford should be issuing a recall to address this defect, not simply driving people to the dealer network for basic safety maintenance.

In October 2023, we took our 2022 Ford Maverick to a local Ford dealership for a front airbag recall. However, after we picked up our Maverick and we got home we noticed a deep scratch across the top of the dash and the tool from the technician in the console. We contacted the dealership about this scratch. Our Maverick was taken to the dealership in January 2024 for this repair. Upon the completion of installing the dash, the technician scratched the outside of the driver’s side front door causing yet another delay. The Maverick was then taken to their body shop (on premises) to repair the scratch and repaint the door. Within a week of having our Maverick back, we started smelling a very foul odor in the truck. This smell made my throat and nose burn and was nauseating while riding in the truck even with the windows down. We went back to the dealership to meet with the owner about this odor. They removed the seats, carpet, and dash to locate the problem. They discovered a place at the bottom of the windshield that had not been sealed from the manufacturing production department. They discovered black mold in the insulation behind the dash near the firewall and under the carpet. They have discussed this with Ford Motor Company on how to handle this problem. Currently our Maverick is still on the lot at the local dealership, since the first week of April 2024. We have reservations about the mold/mildew odor as a health/breathing issue to continue driving this vehicle. Ford Motor Company has been attempting to come to some agreement of handling this situation but not addressing the odor in the vehicle. After some online research of the 2022/23 Ford Mavericks this seems to be a bigger issue across the nation. There are not any recalls to correct this problem for water intrusion into the vehicle.

I’ve been noticing a frequent issue with my trailer not having the left blinker work per notification it gives. So I gave been checking the information screen for trailer lighting any time that I’m pulling a trailer just to make sure all of my lights are working. Today, the truck told me all lights were on and working with the trailer. Meanwhile, after getting pulled over and explaining the info the truck is giving and then unplugging and replugging the trailer from the truck to prove that the lights do in fact work I was finally dismissed from the traffic stop. So the truck was telling me that all lights are on and working on the trailer… meanwhile there wasn’t a single light on!!! The issue with the left turn signal light not blinking on a trailer is relative to the truck as well since it only does it on the truck and with a multitude of different trailers/magnetic trailer lights.

The contact owns a 2022 Ford Maverick. The contact stated while driving 35 MPH, the accelerator pedal was depressed; however, the vehicle failed to accelerate as needed. The contact stated that the message “Engine Power Reduced” was displayed. Additionally, the contact stated that the “BRAKE” warning light illuminated; however, due to the failure the computer system generated the failure code in error. The vehicle was taken to the dealer where it was diagnosed as a fractured well in the braking system. The contact was informed that the braking system needed to be replaced. The vehicle was not repaired. The contact was informed that the parts needed to be ordered to perform the repair. The manufacturer was made aware of the failure. The failure mileage was approximately 56,000. The VIN was unavailable.

In early April 2023 I opened my driver’s side door and the inside of my 2022 Ford Maverick was wet from the headliner down to the carpets. There WAS condensation throughout the interior of the vehicle even though the Repair Order stated there was none. The inside of the vehicle was damp. All windows were closed tightly. The headliner, back seat, front seat, carpets, and all the interior was damp. I had a book on my back seat that was damp and the pages were curled. There was MOLD underneath the floor mats. I contacted a MOLD specialist who stated that it is impossible to effectively rid a vehicle of MOLD. He stated that MOLD spores are in every crevice of the truck and it WILL return. On April 6, 2023 I took the truck to The Ford Store where I purchased it. There was 1294 miles on the odometer. They could not find the leak. My vehicle was there for several weeks and the interior was completely torn down from the headliner to the carpets. The Service Department finally said that they located the leak area and repaired it. The dealer guaranteed in writing that the MOLD was gone. On June 23, 2024 (today) I was getting ready to take the truck back to The Ford Store for tomorrow’s appointment. They will be addressing the three recalls. I just noticed MOLD under the mats again. The MOLD is on the floor board and is crawling up the footwells under the rubber mats. There is also MOLD on some of the plastic material close to the floor boards. My health and the health of all passengers who have ridden in my vehicle for the last 14 months have been and continue to be at risk. I have been contacted by other Ford Maverick owners who have experienced the same issue. The Ford Maverick Truck Club has many posts about leaks and subsequent MOLD issues.

On Thursday (June 13, 2024) my truck displayed a fault that states Rear Belt Monitor Fault Service Required, at the same time my air bag light came on. I proceeded to work and found a lot of people have had this issue with their Ford Mavericks but have all said it is actually their drivers seatbelt with the issue. My husband thought he would test it to see and while driving he took his seatbelt off, the airbag light and fault went away but also even driving at highway speeds it never told us the seatbelt was off. When he plugged the seatbelt back in my truck indicated that seatbelt 3 was actually plugged in and the fault and airbag light came back on.

I was driving on the freeway driving eastbound on 152 and I switch to the fast lane to pass a vehicle and the throttle stopped working, the truck lost speed and the truck turned off, a message popped on the screen saying that I needed to put it in park. I put it in park put the hazards on and attempt to restart it and it would crank but wouldn’t start. I did this until the allowed amount of times reached its limit. I attempted to put the gear in neutral but the knob was stuck. The truck was at a slight angle as I was going uphill and couldn’t get it to move. I find the release lever to make it neutral and it didn’t work but now that lever got stuck all this is going on while the traffic is at is heaviest. The truck stalled until 2 hrs later when a tow truck came to pick it up. I got dropped off at a safe location and the truck turned on and would shift into gear but it sounded bad. Info screen says something about not being able to park and the key is stuck on the truck still.

My vehicle sits at about 26k miles currently. I experienced extreme shaking coming from under the vehicle under acceleration. The issue happened while going up a hill with my whole family. I had to pull over to inspect the issue as it felt like a wheel was coming off. Upon visual inspection both CV Joints were leaking grease all over the undercarriage of my vehicle. A screeching grinding and clunking noise was heard as I continued to drive. This noise went away shortly after, however the shaking upon acceleration continued. It's important to note that I do not take my vehicle off road and is mostly driven on paved roads to and from work and has never been overloaded in anyway. After I took the vehicle to the Dealership, they confirmed that both half shafts were failing and were disintegrating. The passenger side bad enough that it had expelled most of the grease. Continued use would have led to complete failure and could've resulted in an accident. On a vehicle with under 26k miles.

driving down I 90 at 65 mph, powertrain/ power malfunction light came on and power was reduced to 20 mph. Very dangerous . This happened at least 4 times until I was able to return home. shut truck off and would go until the warning light came back on. contacting dealer tomorrow

The contact owns a 2022 Ford Maverick. The contact stated that for two years from the end of November to April, he observed a burning odor in the cabin of the vehicle, that caused him to have a headaches and stomach aches. The vehicle was taken to a dealer on multiple occasions where the failure was not able to be replicated. The vehicle was then taken to a different dealer where it was diagnosed that the blower motor resistor needed to be replaced. The vehicle was repaired but the failure persisted. The contact believed that the failure was associated with NHTSA Campaign Number: 23V380000 (Engine). The manufacturer was notified of the failure and a complaint was filed. The failure mileage was 3,975.

See attached document for complaint

My truck started collecting water in the front passenger side floor. Took it to the dealer and they couldn’t find the leak at first. Then they claim it was coming from the window seal on the back passenger window. I refused to have it repaired for 950$. 600 dollars in now with leaky rear window. This has already started a mold issue under the carpet. This needs to be addressed by the manufacturer.

What component or system failed or malfunctioned? It’s not exactly failed or malfunctioned as much as it is just a flawed design. However, the problem is that the drivers seatbelt keeps getting wrapped up in the lever to recline the seat. This results in the handle getting pulled off of the seat constantly, the seat unexpectedly reclining when the driver pulls on the seatbelt too hard, or the seatbelt simply getting bunched up in the handle causing it to just become stuck and non functional. Is it available for inspection upon request? It is available for inspection anytime. How was your safety or the safety of others put at risk? When the drivers seat suddenly reclines or the seatbelt fails to engage due to being caught up in another component of the vehicle that’s a problem. Has the problem been reproduced or confirmed by a dealer or independent service center? No although I can duplicate that issue. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No.

Manufacturing defect on the cowl deflector seal causes water to leak into the cabin and pool up on the floor of the passenger side front seat. Significant amount of water. This will result in damage to the carpets, mold issues (health and safety concern) along with possible damage to the electronics that is passes through right under and behind the glove box. Also passes through the cabin air filter box. Many Maverick owners have reported this problem in various internet forums, and yet there has not been a recall. I had to pay the local dealer to reseal this area with silicone due to a faulty design. Ford would not cover the expense. The dealer wanted $900 to dry the carpet.

The contact owns a 2022 Ford Maverick. The contact stated that the vehicle would not properly accelerate from a stationary position and the check engine warning light remained illuminated. The vehicle was taken to the local dealer who diagnosed that the EVP Emissions Control System and the purge valve were faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure. The failure mileage was 43,000.

Had front half shafts replaced under warranty at 12k miles. Currently at 22k miles and experiencing the same vibration/shudder at about 50mph. Vehicle is available for inspection upon request. Failure of a half shaft could leave the vehicle stranded or could cause loss of control. Problem was already confirmed by dealership and half shafts were replaced. Problem is presenting itself again 10k miles later. Problem is well known with other owners. No warning lamps.

I bought a 2022 Maverick on 12 JAN 2022. The car broke down on the highway six months after (23 JUL 2022). Ford service department claimed it was a fuel injector issue and by replacing the part, the truck should be as good as new. Fast forward to Sat 30 DEC 2023 and the truck breaks down on the highway again with the engine light flashing. Ford service department informed me that the engine has to be replaced because several parts are broken/shattered and they do not know how. I am inclined to believe that the issue was never fixed to begin with and Ford put my safety and the lives of the people I care about at risk. I was sold a lemon with major engine issues and I am terrified of driving the truck again. All the service reports are currently at the dealership; I can acquire copies when needed.

Engine shut down at speed. Power totally went off. No power steering. Service engine light came on. I was able to restart vehicle but it kept shutting off. Vehicle starts with engine warning light but cannot be derived without shutting down. this has happened twice. Once with about 200 miles and the second time with 3,500 miles

I was driving back home from errands and during a stop, the entire car suddenly powered off and became unresponsive. I couldn’t even flash my hazards and was stuck in the middle of a busy intersection. Also couldn’t put it in neutral since the gear shifter is electronically powered. Some bystanders tried to jump my car, but it took 6 solid tries before they could restore power. I drove it another 1000 ft, trying to head to a service center and this time it completely powered off while in motion. I had to fight with the steering wheel to pull it to the shoulder as the power steering went out and the car started making clicking noises. The entire car was completely dead, once again. A tow truck diagnosed the battery as still healthy and suspects a deeper electrical fault with the car. It has been towed to the dealer for service under warranty, but I am reading that I am not the only one with this issue. A lot of folks are getting battery swaps and having the issue recur later. Could this be a wiring harness fault, or a much more pervasive electrical issue? The entire episode was terrifying, and I could have gotten into a major accident if this was on a busier road.

This vehicle was purchased in 2021 with a 3 year 36k mile warranty. At 39k miles the truck has started to shut off randomly while driving. It has put us in very dangerous situations and it happens multiple times every day. The vehicle will be driving down the road and suddenly shut off. It will not switch to neutral so cannot be pulled off the road. It will not turn on for at least 20 minutes so we get stuck in the middle of the road. Sometimes it will turn back on but other times it has to be jumped. Ford is telling us that any repairs will not be covered because this brand new car is out of warranty.

The passenger side footwell is accumulating water. Windows are closed, no significant rainfall. Perhaps associated with the AC. Mold spores have formed on the carpet causing a health hazard. I am too worried to pull up the carpet to see what it is like underneath. After drying it several times, it continues to form puddles, again with no rain.

Multiple instances of Auto Hold function sucking brake to floor and haulting vehicle at low speeds causing danger of a rear collision. Recommend adding a 1 second delay to current system before engaging auto hold function.

I pulled my 2022 Maverick into my parking spot at work and everything went dead. I had to use my key to open my tailgate. The tow service jumped the battery and it started, however, when they went to take it off the tow truck at the Ford dealership, it had to be jump started again. I was told the battery was bad and they changed it. The vehicle worked fine for three days and on the morning of the fourth day I had difficulty starting the vehicle. The first three times I turned the key all I heard was clicking and it started on the fourth try. I then drove it straight to the dealership where it has been for the past 8 days.

The contact owns a 2022 Ford Maverick. The contact stated that after she parked the vehicle, her daughter unlatched the rear passenger's seat belt; however, the shoulder strap that she had placed behind her was twisted and inadvertently retracted. The seat belt then seized while tightly wrapped around the contact's daughter's waist, causing her breathing difficulty. The contact had to cut the rear passenger's seat belt with a scissor to release her daughter. The contact's daughter sustained bruising on her stomach and waist; however, medical attention was not received. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was 34,115.

I have a 2022 Ford Maverick, 2.0 ecoboost engine, awd. I have been having brake problems since the beginning. The problem is the front brakes do not back out enough to leave a proper air gap between the brake pad and rotor when deactivating the service mode. Therefore the pads keep riding on the rotors causing glazing and grabby brakes when coming to a stop behind a vehicle. Turning off the active breaking did help with the grabby brakes when stopping behind a vehicle, but did not resolve the glazing issue. I took the truck into two dealerships and the techs. could not find a solution. the front calipers, front brake hoses and the brake master cylinder have been replaced with no success. Maybe the solution is to adjust the air gap settings somewhere in the software.

The Ford Maverick rear view camera is dangerously laggy - it will freeze several times during backing. It also washes out in bright sun. I consider this a dangerous feature that should be addressed.

The contact owns a 2022 Ford Maverick. The contact received notification of NHTSA Campaign Number: NHTSA Campaign Number: 22V594000 (Air Bags) and 22V730000 (Exterior Lighting, Service Brakes, Hydraulic) however, the parts to do the recall repairs were not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

The truck is leaking rain water into the cabin driver's side floor. Technicians have not been able to find the leak and the carpet is moldy and smells. The truck has been in the shop two times now and Ford has not offered to replace the moldy carpet under warranty.

Wind’s go through the door around 70 mph and feels like the windows are open and the front door click to open twice in each door and the computers right away, shows the next door open.

The contact owns a 2022 Ford Maverick. The contact received notification of NHTSA Campaign Number: 22V594000 (Air Bags) however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect. The consumer stated because the vehicle was not purchased at the dealer parts were not available.

The contact owns a 2022 Ford Maverick. The contact stated that while driving at 75 MPH, another vehicle side-swiped the contact's vehicle on the passenger's front side; however, the side curtain air bag failed to deploy. There were no injuries. A police report was filed. The vehicle was towed to an auto repair center. The contact related the failure to NHTSA Campaign Number - 22V594000 (Air Bags). The dealer was made aware of the failure; however, the parts to repair the recall are not yet available. The manufacturer was not made aware of the failure. The failure mileage was approximately 8,000.

when starting out driving or cornering at low speeds the horn would randomly honk steadsily and eventually time out.

I was hit by another car in between the passenger side front door and the passenger side back door. I was hit with enough force to push me off the road. There was no side airbag deployment.

(there is a brake system malfunction. When braking sometimes the brakes would skip and I could feel the brakes not grabbing the rotors the way they should. the problem has not been reproduced or confirmed by a dealer because the dealership could not figure out what was causing the problem with the brakes. the dealership inspected the brakes. there was no warning lamps or messages of the brake problem.) I first started to hear a intermittent rubbing noise when braking and driving slow a couple months after I purchased the vehicle. I took it the vehicle into the dealership and they could not figure out what was wrong. I was told perhaps i was to aggressive on the brakes. the problem continued so i went to another dealership and they looked at the brakes and could not figure out what was causing the noise. the rotors looked glossy (glazed) So I decided to replace the rotors and brakes at my cost because I was told the truck was out of warranty. one week after the repairs were made, I started to hear the rubbing noise again. I was furious! I couldnt believe this was happening on a brand new vehicle, especially on a ford. So I continued to drive until the rotors got so bad that the steering wheel was shaking when I braked.the rotors were warped. So I decided to take matters into my own hands and replace the brake pads and rotors using the ford manual for the 2022 maverick. This time I decided to only drive eco mode on the highway and normal mode in the city. I also turn off the active braking every time I got in the truck. I was also very careful not to be aggressive on the brakes and not to ride them when slowing down. I kept a close watch on the rotors. after two weeks of driving the rubbing noise started again and the rotors are glazed again. I do not know if its a mechanical issue with the brake calipers/master cylinder or a computer/software issue. I cannot afford to be replacing brakes and rotors every two weeks. I am greatly disappointed in ford motor company .

I was working on my vehicle, when I close the hood. Upon closing, I heard something, I go to open, and the hood latch is stuck closed, not sure if that's a safety concern, but it was for me, as I could not access any important components of my vehicle, took it to the dealer, but still something of concern on a new vehicle.

I know there are issues with the Hybrid versions, but this one is not a hybrid. I have had the battery die 4 separate times resulting in me being stranded due to no fault of my own. This Ford Maverick was purchased through the Military Auto Sales at Ramstein AB Germany. It is US-spec and owned/operated by a US Military member stationed overseas. The first time it happened at the Frankfurt airport after owning it for a week and driving it from the Port of Bremerhaven (port of entry). Once I got it jumped and back to Ramstein I did not have an issue for 3 weeks. It died after sitting for three days over New Years. I jumped it and drove it around for over an hour to charge the battery. I then left it for a few days to see if it occurred again. One week later it died. I then jumped it and drove it around again to charge the battery. At this point I suspected the Ford Pass Connect, bluetooth or wifi to be the cause so I turned all of those off. After going on a work trip for a week I came back to discover it was dead again. Something is wrong with teh battery or electrical system. It should automatically go to a deep sleep mode if lower voltage is detected. I don't know what is running (it is not something the driver selected) but it is killing the battery. The last time my Duracell jump pack registered an error and could not jump it. This is a serious defect that can leave people stranded without warning.

The main fuel line feeding the fuel pump ruptured without warning, causing gas to spray across the engine compartment. The hot engine caused the gas to start cooking off, resulting in a fire in the engine compartment. The fuel line rupture has been confirmed by my Ford dealership.

The 2022 Ford Maverick has a design flaw the harms the environment and places driver and passengers at risk. Specifically the vehicle does not have a metal skid plate which places the Evap System at risk for damage. If the system is damaged the vehicle is still driveable, but doing so allows gas vapors into the environment and worse, possibly into the passenger compartment. Looking under the vehicle, one finds some sort of fabric or mesh material which is definately not robust enough to protect the evap system components from damage. Driving on paved roads....no problem. Using this vehicle as a truck involves driving on farm land, pastures, lightly wooded areas,etc. This is where the damage may occur. There is no warning posted on the vehicle or in the owners manual that warns drivers to avoid these areas. The solution is simple. A recall to replace the fabric or mesh material with a metal skid plate. Most trucks and off-road vehicles have metal skid plates as standard components. Why the 2022 Maverick does not is beyond my understanding.

The side curtain airbags in my 2022 Ford Maverick have been recalled, but the replacement parts will not be available for 5-6 months. This is a Massive safety concern for me as I drive the truck with my 1 and 3-year-old daughters. This is a dangerous situation that I am being told can not be remedied in a timely manner. I can not be expected to cover the added cost of a rental vehicle for close to half of a year and I refuse to put my children and myself in danger by continuing to use this faulty vehicle.

The contact owns a 2022 Ford Maverick. The contact stated that NHTSA Campaign Number: 22V193000 (Electrical System) was repaired at the dealer. The contact was stopped by the police and informed that the brake light on the trailer was illuminated. The vehicle was taken to the dealer for the Ford Tech to reprogram the brake module. The contact was informed to no use the trailer brakes. The manufacturer was contacted and referred the contact to the NHTSA Hotline for assistance. The failure mileage was 9,000.

Transmission Failure. Following a 550 mile road trip over two days. The transmission would fail to engage in Drive and Reverse until the engine was throttled to 4000-4500RPM. Transmission felt like a Manual with failing clutch, would slip until slowly engaging after running at high RPMs for a few seconds. The condition appeared after the first day of the trip, and was intermittent, occurring only during standing starts. Once the vehicle was moving, there was no problem maintaining speed. Over the next two days the condition deteriorated to the point where it was occurring almost every time the vehicle was started and an attempt was made to start from a stand still. It began to become noticeable shifting from 1-2, 2-3, 3-4 as well, where it felt like the transmission was slipping during acceleration. There were no warning lamps or indications from the vehicle that there was a failure. This caused a loss of power and acceleration, which endangers the vehicle occupants in situations where power and acceleration is needed, such as merging, crossing intersections, or making defensive driving maneuvers. This vehicle was towed to a dealer, where the dealer validated the concern, and the transmission was replaced under warranty. Repair notes state that the transmission converter had failed. The transmission was returned to the manufacturer during the service visit. There are multiple instances online of other vehicles with this transmission having the same problem.

Mavericks with Integrated Trailer Brake Controllers are not sending any voltage to the trailer brakes when the brake pedal is pressed. Customers are at risk of not having the anticipated additional braking ability of their trailers and will be putting the entire braking load on the truck alone. A Ford dealership had my vehicle for 2 weeks with no repairs done or guidance on when it would be repaired.

The backup camera has been freezing off and on since buying the truck. When backing up, the camera will lag and then jump to the current picture the camera is showing. Earlier today, while backing up towards my trailer, the camera lagged causing me to run into the trailer. There was no damage to the truck or trailer, but is a safety issue if anyone crosses behind you while in reverse.

Driving down road at 45 mph as usual. Car suddenly shudders and as I pull to a stop car is stuck in neutral. Will not receive gas. Suddenly lurches into first gear, almost making me hit who is in front of me. I pull into center lane and the car is frozen and won't move. I restart the car and it stays stuck in first gear revving high. I limp it home given I'm a few minutes away. Could have caused a serious incident.

EL DIA 21 DE MARZO DEL 2022 LLEGANDO A MI CASA Y PARA SER BIEN ESPECIFICA FRENTE A MI CASA ME ESTABA ACOMODANDO PARA COLOCAR EN RIVERSA MI GUAGUA Y LA MISMA SE ACELERO SOLA Y LOS FRENOS NO LE FUNCIONARON, CAUSANDO QUE ME FUERA POR UN RISCO. LOS AIR BAGS NUNCA LE ABRIERON.

Since the date of purchase (10/29/21) I am unable to change/set FM stations. Apps (ie: iHeart, Spotify) and voice command work intermittently. Apps will not work unless phone is plugged in. 911 assist will not work if not paired and connected to a Bluetooth enabled and compatible cell phone (see pg. 59 2022 Maverick owner’s manual). Unsure if lane keeping assistance is working properly. Vehicle was brought to Sam Galloway Ford on 10/30/21. Per Sam Galloway Ford: “Ford is aware of these problems. It is a ‘hardware’ issue.”