Loading vehicle data from NHTSA...
NHTSA recalls, safety ratings, and consumer complaints for the 1991 Ford F53.
NHTSA has not published 5-star crash-test ratings for the 1991 Ford F53. New vehicles are often added to the NCAP rating program after initial release; check nhtsa.gov/ratings for the latest status.
Component: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
BRAKE LINES IN THE ENGINE COMPARTMENT ARE ROUTED TOO NEAR THE LEFT EXHAUST MANIFOLD, CAUSING THE BRAKE FLUID TO OVERHEAT.
Consequence: BRAKE FLUID LOSES VISCOSITY WHEN IT OVERHEATS, CAUSINGLOSS OF BRAKES OR INCREASED VEHICLE STOPPING DISTANCE WHICH MAY RESULT IN ANACCIDENT.
Remedy: FORD WILL INSTALL A HEAT SHIELD AND BRAKE LINE INSULATION ON ENGINE COMPARTMENT BRAKE LINES.
TL* THE CONTACT OWNS A 1991 FORD WINNEBAGO F-53 CHASSIS. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 40 MPH ATTEMPTING TO ENGAGED THE BRAKES, THE VEHICLE DELAYED TO STOP AND ALMOST RESULTED IN A CRASH. THE VEHICLE WAS TAKEN TO A DEALER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 60,542.
I HAVE A SEVERE BREAK FADING PROBLEM. I HAPPENS AFTER YOU HAVE DESCENDED A STEEP DOWNGRADE AND STOP. AT THAT POINT THE BREAK PEDAL GOES COMPLETELY TO THE FLOOR. AFTER A RESTING PERIOD THE PEDAL COMES BACK AGAIN. FORD HAS TOLD ME THE ONLY WAY TO CORRECT THE PROBLEM WITH MY 1991 M53, 50,000 MILES, IS TO DO A $2,500.00 TO $3,000.00 OVERHAUL OF THE BREAK SYSTEM USING PHONELIC PARTS. I FEEL IF AN EXTENSIVE OVERHAUL IS REQUIRED AT THIS POINT, IT WAS A SYSTEM DESIGNED TO FAIL. A SYSTEM DEFECT. THIS PROBLEM COULD HAVE COST THE LIFE OF MY WIFE AND TWO OF MY GRANDCHILDREN AND MYSELF. I HAVE BEEN RESTRICTED TO DRIVING ON FLATLAND EVER SINCE THIS INSTANCE ABOUT 2 YEARS AGO. I HAVE ATTEMPTED TO GET AN ANSWER OR A CORRECTION BUT NO ONE SEEMS TO HAVE ONE EXCEPT $2,500- $3,000. I FEEL FORD HAS A RESPONSIBILITY HERE AND SHOULD PAY ALL OR A SUBSTANTIAL PART OF THE CORRECTION OF THEIR DESIGN ERROR. *NLM
The 1991 Ford F53 has 1 NHTSA recall and 2 consumer complaints on file. For the most detailed information about a specific vehicle, decode its VIN using our free decoder above.
Enter a specific VIN to get the full report — specs, recalls, safety ratings, complaints, investigations, and technical service bulletins.