2006 Ford Expedition Problems & Complaints

the service engine light continues to turn on. the timing belt continues to fail and has already been replaced once. the camshaft on both sides have been replaced. the solenoids have also been replaced and the diagnostics codes still pop up (p0022) (p0021) are just some that i can remember. the engine does not have enough power on the driver side and throws the timing belt off which causes the loud rattle coming from the engine. when reaching the speed of 40-45 mph the truck begins to shake. recently in november 2023, when fueling up with gas , the truck began to shake and not respond. when accelerating, the truck takes off very slowly and the gears dont kick in on time. when the gas light comes on , the truck begins to function well. but as soon as i put gas again. it feels like the truck is going to fall apart. the driver door gets stuck when trying to open from the inside. the back door on the left does not open from the outside. the gear handle can be moved up and down while the truck is not turned on. please help!!

The contact owns a 2006 Ford Expedition. The contact stated that while driving 35 MPH, the contact stated that there were exhaust fumes inside the vehicle. The engine warning light was illuminated. The vehicle was diagnosed by an independent mechanic and confirmed the failure was a defective charcoal canister for the evac system. The vehicle had not been repaired. The manufacturer was made aware of the failure however, the part was not available. The failure mileage was approximately 70,000.

The contact owns a 2006 Ford Expedition. The contact stated that while driving at a low rate of speed, the vehicle would independently accelerate upon depression of the accelerator pedal without warning. During a recent failure, the contact crashed into a fence as part of the fence had become wedged underneath the vehicle. After placing the vehicle into park and exiting the vehicle, the wheels continued to move. The air bags did not deploy upon impact. Despite minor soreness to his neck, no medial attention was required. A police report was not filed. Despite the failure, the contact managed to restart the vehicle and safely to his destination. The fence sustained severe damage as a result of the failure. The dealer nor the manufacturer had yet to be notified of the failure. The vehicle had yet to be diagnosed or repaired. The failure mileage was approximately 220,000.

The contact owns a 2006 Ford Expedition. The contact stated while driving 55 MPH, the vehicle was driving sluggishly. The contact stated that the check engine warning light was illuminated. The vehicle was not drivable. The contact towed the vehicle to an independent mechanic and was informed that the ignition coil, the throttle body sensor (TBS) sensor, and the timing chain needed to be replaced. The vehicle was not repaired. The vehicle was not diagnosed or repaired at the dealer. A dealer was not contacted. The manufacturer had been informed of the failure. The contact stated on another occasion the vehicle failed to start. The vehicle was not drivable. The failure mileage was approximately 130,000.

While driving yesterday i heard a pop. The 4th coil pack literally blew out from its spot. I have now had 3 coil packs blow out at random causing the holes that the bolt straps the coil pack to the spark plug to strip out. I have a transmission leak that will not stop and I've taken it in multiple times for repairs and it still is leaking. Since getting this vehicle i noticed at the electrical issue where everything including my headlights will shut off and then pop back on while I'm driving. My seat belt will not open so i can buckle and I'm now getting frustrated because I've spent a lot of money on this only to realize has had the same issue with previous owners and they for some reason were too embarrassed to report it but I'm not and I'm sick of dumping money into this damb thing!

UPON RECEIVING TUNE UP THE SPARK PLUGS BROKE APART.AFTER GETTING THEM OUT CYL#1 WOULD NOT HOLD SPARK PLUG,CAUSED ME TO SPEND MORE MONEY TO GET PROBLEM FIXED.BUT THE SHOPS WILL NOT GUARANTEE THE WORK THAT IS NEEDED.THEY ALL SAID IT WAS A FACTORY ISSUE.THE TRUCK WAS STATIONARY AS WELL.

TL* THE CONTACT CALLED ON BEHALF OF THE OWNER OF A 2006 FORD EXPEDITION. WHEN THE VEHICLE WAS STARTED, THERE WAS AN ODOR OF ANTIFREEZE IN THE VEHICLE. ADDITIONALLY, THE TEMPERATURE GAUGE AND CYLINDER HEAD TEMPERATURE SWITCH BECAME INOPERABLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE INTAKE MANIFOLD AND CYLINDER HEAD TEMPERATURE SWITCH NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 245,000.

TRAVELING ON OLD ADOBE RD IN PETALUMA, CA AT APPROX. 25-30 MPH, WENT OVER INCLINE AND SAW TRAFFIC WAS STOPPED. PRESSED HARD ON BRAKE PEDAL AND VEHICLE SLOWED BUT DID NOT STOP. RESULTED IN A 3 CAR ACCIDENT

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. WHILE DRIVING APPROXIMATELY 40 MPH, THE FRONT PASSENGER SIDE WINDOW SHATTERED. THERE WERE NO INJURIES. THE CONTACT STATED THAT THE WINDOW WAS NOT STRUCK BY DEBRIS OR A FOREIGN OBJECT. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 178,000.

THE VEHICLE EXPLODED IN OUR DRIVEWAY. IT HAD NOT BEEN DRIVEN OR TURNED ON IN ALMOST 2 WEEKS. IT WAS LOCKED. THIS CAUGHT ONE OTHER CAR ON FIRE AND TO EXPLODED AND ANOTHER TO GET BODY MELT DOWN ON ONE SIDE.

THE CAR WILL SOMETIMES NOT START OR WHEN RUNNING THE ENGINE WILL DIE. IT APPEARS NOT TO GET FUEL

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. WHILE DRIVING APPROXIMATELY 60 MPH, THE VEHICLE'S SPEED DECELERATED TO 20 MPH. THE CONTACT COASTED THE VEHICLE TO THE SIDE OF THE ROAD AND TURNED OFF THE ENGINE. ONCE RESTARTED, THE VEHICLE WAS ABLE TO OPERATE NORMALLY. THE CONTACT STATED THAT THE FAILURE RECURRED AFTER DRIVING 30 MILES DOWN THE ROAD AND THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS NOT TAKEN TO A DEALER OR AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 196,997.

MY 2006 FORD EXPEDITION SHUT OFF WITHOUT ANY WARNINGS IN THE MIDST OF ME DRIVING THE TRUCK EVERYTHING SHUTS DOWN IT'S HARD FOR ME TO STEER MY VEHICLE AND THE BRAKES LOCKS UP THIS WAS SO SCARY DRIVING THE EXPRESSWAY AND TRYING TO MANEUVER A STALLED VEHICLE

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT STATED THAT THE "FAIL SAFE MODE" INDICATOR DISPLAYED. HERTRICH FORD IN MILFORD, DELAWARE WAS MADE AWARE OF THE FAILURE AND REPLACED THE THROTTLE BODY AND THE DRIVER'S SIDE FUEL MODULE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND REFERRED THE CONTACT TO NHTSA. THE FAILURE MILEAGE WAS APPROXIMATELY 160,000.

WHEN THE TEMPERATURE IS BELOW FREEZING OUTSIDE THE DRIVER SIDE DOOR WILL NOT LOCK OR UNLOCK. THE DOOR OPENS WHILE DRIVING. THIS HAS BEEN HAPPENING SINCE THE VEHICLE AS NEWER (AND UNDER WARRANTY) DEALERS AND FACTORY ARE UNWILLING TO REPAIR THIS AS A GOOD WILL.

TAMARA RECALL

WHILE DRIVING CARBON BUILDS UP IN VEHICLE

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. WHILE DRIVING 72 MPH, THE VEHICLE ACCELERATED TO 90 MPH WITHOUT WARNING. THE CONTACT STATED THAT THE BRAKE PEDAL WAS DEPRESSED, BUT FAILED TO SLOW DOWN THE VEHICLE. THE CONTACT WAS ABLE TO GET THE VEHICLE OFF THE HIGHWAY AND INTO A FIELD WHERE THE VEHICLE WAS TURNED OFF AND ALLOWED TO SLOW DOWN. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT WAS INFORMED THAT THE BRAKE PADS AND ROTORS NEEDED TO BE REPLACED. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 192,000. *BF *TT

FORD HAD A RECALL FOR BROKEN SPARK PLUGS & A CLASS ACTION LAWSUIT ON THIS VEHICLE. FORD HAS FAILED TO FULLY COMPENSATE US & TOLD ME HARDLY NO ONE WOULD RECEIVE COMPENSATION. WE REPLACED THE PLUGS WITH FORD APPROVED REVISED PLUGS AT FORD WITH @ 149K MILES ON 11/2015. THE ENGINE CODES OR PROBLEMS WOULD COME UP NOW AND AGAIN & WE HAD IT INTO VARIOUS VENDORS.. 2/ 2017, DRIVING BACK TO WYOMING I CAME UP AN I WAS UNDER LOAD (HAULING A TRAILER) AND THE AUTO ALMOST DID NOT MAKE IT HOME OR UP A GRADE. WE TOOK IT IN TO REPLACE THE COILS. THE VENDOR, MIDWAY MOTORS REPLACED THE COIL & NOTICED THE NEW REVISED FORD APPROVED SPARK PLUG 5 WAS BROKEN, AND PLUG 6 ALSO SHOWED A CODE, (MILEAGE 172627 MILES). THE ENGINE WAS DAMAGED SO WE TRADED THE FORD IN FOR A DODGE. MY POINT FORD HAS NOT FIXED THE ISSUE & IS DECEIVING THE PUBLIC. AND 2ND LAWSUIT CLAIM FORM IS [XXX] . THE VEHICLE WAS KEPT IN LIKE NEW SHAPE PRISTINE. I WAS SAD I HAD TO TRADE IT IN BUT DID NOT FEEL SAFE. I THINK YOU NEED TO KNOW HOW FORD IS PRACTICING AND NOT HANDLING ETHICALLY, LEGALLY, OR PROPERLY; BOTH THE CLASS ACTION LAWSUIT AND ALSO THE (REVISED SPARK PLUGS ARE ALSO FAILING). YES I HAVE DETAILED DOCUMENTS!! ASK ME I CAN EMAIL YOU PDF [XXX] [XXX] . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).'*JB

CORROSION PROBLEMS IN MANY DIFFERENT PARTS OF THE VEHICLE.

THE TRANSMISSIONS OVERDRIVE (84,000 ) STOP WORKING EFFICIENTLY WITHOUT ANY SIGNAL OF PROBLEM. WHEN IN MOTION REACHING 35 MILES/HOUR THE TRANSMISSION STOPS.

AT APPROXIMATELY 45 MILES AN HOUR THERE IS A GRINDING NOISE THAT SOUNDS LIKE THE TRANSMISSION. IF I SPEED UP IT GOES AWAY. AFTER DRIVE FOR AWHILE THE OVERDIVE LIGHT STARTS TO BLINK. IF I TURN OFF THE ENGINE THE LIGHT STOPS BLINKING. THE CAR PERFORMS MUCH BETTER WITH THE OVERDIVE OFF. HAD THE TRANSMISSION REBUILT AND IT DIDN'T SOLVE THE PROBLEM. THE TRANSMISSION SHOP SAYS THE PROBLEM IS NOT IN THE TRANSMISSUON ITSELF. FORD DEALER RECOMMENDED CHANGING THE TROTTLE SENSON, $100 LATER THAT DIDN'T WORK. MECHANICS IN TOWN CAN'T FIGURE IT OUT. IT SOUNDS LIKE 2 GEARS TRYING TO ENGAGE, THUS THE GRINDING NOISE. WHEN I DRIVE WITH THE OVERDRIVE OFF IT HAPPENS AT A HIGHER SPEED. ALWAYS HAPPENS WHEN DRIVI G UP A LONG INCLINE. GOING CRAZY WITH THIS PROBLEM.

TL* THE CONTACT OWNED A 2006 FORD EXPEDITION. WHILE DRIVING APPROXIMATELY 45-50 MPH, THE VEHICLE SUDDENLY HYDROPLANED AND CRASHED INTO A CONCRETE WALL OFF TO THE SIDE OF THE ROAD. THE VEHICLE SPUN AROUND 8-10 TIMES AND CRASHED INTO THE WALL APPROXIMATELY AN ADDITIONAL FIVE TIMES. THE VEHICLE EVENTUALLY WENT BACK ONTO THE ROAD FACING ONCOMING TRAFFIC. THE CONTACT RESTARTED THE VEHICLE TO MOVE TO THE SIDE OF THE ROAD AND THE INJECTORS FOR THE PASSENGER SIDE AIR BAG RELEASED; HOWEVER, THE PASSENGER AND DRIVER SIDE AIR BAGS DID NOT DEPLOY. THE VEHICLE WAS DESTROYED AND TOWED. A POLICE REPORT WAS FILED. THE CHILD IN THE REAR WAS EJECTED FROM THE SAFETY SEAT, THE PASSENGER RECEIVED INJURIES TO THE ARM, BACK, AND NECK AREA, AND THE CONTACT RECEIVED INJURIES TO THE BACK, LEG, PELVIC, WRIST, AND HEAD INJURIES. MEDICAL ATTENTION WAS NEEDED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OPENED CASE NUMBER: CAS12509910. THE APPROXIMATE FAILURE MILEAGE WAS 160,000.

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. WHILE DRIVING OR WHILE THE VEHICLE WAS IDLING, THE CONTACT HEARD A TICKING NOISE COMING FROM THE ENGINE. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER (KEN GRODY FORD AT 6211 BEACH BLVD, BUENA PARK, CA 90621) WHERE IT WAS DIAGNOSED THAT THE VALVE LASH ADJUSTER AND THE TIMING CHAIN TENSIONERS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER INFORMED THE CONTACT TO CALL NHTSA AND DID NOT OFFER ANY FURTHER ASSISTANCE. THE FAILURE MILEAGE WAS 100,464.

WHILE IN TRAFFIC, AT LEAST 100 TIMES IN THE LAST FOUR YEARS (AT VARIABLE SPEEDS FROM 5 TO 65 MPH ON CITY STREETS AND FREEWAYS) MOST RECENTLY TWICE IN THE LAST WEEK, THE RPMS DROP BELOW 500 AND THE VEHICLE DIES AND "ENGINE FAILSAFE MODE" LIGHTS UP ON THE DASH. I HAVE TO EITHER COAST TO PULL OVER OR DEAD STOP IN THE MIDDLE OF THE ROAD. I HAVE TO TURN THE VEHICLE COMPLETELY OFF (EVEN THOUGH IN FAILSAFE MODE ENGINE IS OFF, THE ELECTRONICS ARE STILL ON) AND THEN RESTART AND THEN IT WILL DRIVE JUST FINE UNTIL IT HAPPENS AGAIN. IT HAPPENS ANYWHERE FROM ONCE EVERY 6 MONTHS TO 6 TIMES IN 1 WEEK. IT SEEMS AS THOUGH IF I DRIVE WITH BOTH FEET IN TRAFFIC AND MAINTAIN ABOUT 800-1000 RMPS AT ALL TIMES IT DOESN'T DO THIS, HOWEVER THIS CANNOT BE DONE ALL THE TIME ESPECIALLY WHEN TRYING TO STOP THE LARGE VEHICLE QUICKLY OR TURNING IN AN INTERSECTION. NOTHING HAS BEEN DIAGNOSED BY DEALERSHIP AS NO CODES ARE THROWN. I ALSO OWN A OBD2 READER AND NO CODES HAVE EVER LISTED UNLESS ITS TIME TO CHANGE THE SPARK PLUGS. SEVERAL DIFFERENT MECHANICS, FORUMS AND BRAINSTORMING HAS NOT FIGURED IT OUT. I HAVE REPLACED MOSTLY EVERYTHING WITH EXCEPTION TO A NEW TRANSMISSION AND COMPUTER. MOSTLY EVERYTHING INCLUDING WIRES AND VACUUM LINES AND GASKETS HAVE BEEN REPLACED DUE TO MAINTENANCE OR REPAIRS FROM EVERYTHING ELSE THAT HAS GONE WRONG WITH IT. I HAVE PUT ABOUT $10K INTO NEW PARTS FOR THIS VEHICLE. I BOUGHT IT WITH 60K MILES ON IT AND IT NOW HAS 117K, ITS A DAILY DRIVER WITH 28 MILES OF TRAVEL 5 DAYS A WEEK. ALSO THE ONLY VEHICLE THAT FITS ALL OF THE CHILDREN FOR SOCCER, TRACK AND VOLLEYBALL TRAVELING TOURNAMENTS/GAMES. LUCKILY IT DOESN'T HAPPEN VERY OFTEN WHEN I'M NOT IN TRAFFIC SO THE KIDS AREN'T USUALLY WITH ME BUT IT IS VERY SCARY NOT TO KNOW IF YOU ARE GOING TO STOP OR IF THE PEOPLE BEHIND YOU ARE GOING TO HIT YOU OR NOT.

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THAT WHILE THE DRIVER WAS DRIVING AT AN UNKNOWN SPEED, THE VEHICLE STALLED AS THE FAIL SAFE MODE WARNING MESSAGE ILLUMINATED ACROSS THE INSTRUMENT PANEL. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 194,000.

ENGINE FAIL SAFE MODE ENGAGES AT VARIOUS AND UNPREDICTABLE SPEEDS AND AT ANY GIVEN TIME. IT HAS HAPPENED NUMEROUS TIMES AND SHOWS NO CODE AFTERWARDS. A VERY DANGEROUS ISSUE THAT NEEDS TO BE ADDRESSED BY FORD. I HAVE FOUND THOUSANDS OF COMPLAINTS ABOUT THIS ISSUE BUT I CAN FIND NO INDICATION THAT FORD HAS BEEN WILLING TO ADDRESS THE ISSUE. WHEN ASKED FOR THE DATE THE INCIDENT HAPPENED I AM ENTERING THE DATE OF COMPLAINT BECAUSE THIS HAS HAPPENED MULTIPLE TIMES. NO CODES DOES NOT MEAN THE VEHICLE DOESN'T HAVE ISSUES. FORD NEEDS TO ADDRESS THIS ISSUE....RECALL AND CORRECT THE PROBLEM.

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. WHILE DRIVING AT VARIOUS SPEEDS AND AFTER A LOUD ALARM SOUND, THE VEHICLE STALLED AND THE ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE SPARK PLUGS WERE REPLACED AND THE MECHANIC INFORMED THE CONTACT THAT THE CATALYTIC CONVERTER WAS FAILING. THE FAILURE HAD REOCCURRED ON SEVERAL OCCASIONS. THE FAILURE MILEAGE WAS 80,000.

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. WHILE DRIVING OVER 50 MPH, THE VEHICLE SHOOK VIGOROUSLY AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 135,000.

"TAKATA RECALL" THERE IS A LOUD VIBRATION COMING FROM PASSENGER SIDE OF DASHBOARD. I HAVE TAKEN THE VEHICLE IN TO BE INSPECTED AND WAS TOLD THERE IS A LEAK IN MY AIR BAG AND THAT UPON COLLISION THE AIR BAG MAY NOT DEPLOY.

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. WHILE DRIVING 45 MPH, THE OSC WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION TORQUE CONVERTER FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO A TRANSMISSION SPECIALIST WHERE IT WAS DIAGNOSED THAT SEVERAL COMPONENTS IN THE TRANSMISSION FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 107,000.

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THAT THE ENGINE FAIL SAFE MODE WARNING INDICATOR RANDOMLY FLASHED. THE VEHICLE'S SPEED REDUCED AND STALLED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO A MANUFACTURER'S MASTER MECHANIC FOR FURTHER DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS NOT AVAILABLE.

I HAVE A 2006 FORD EXPEDITION EDDIE BAUER 4X2 AND MY PROBLEM STARTED AFTER I PURCHASED THE VEHICLE IN 2010. IN 2011 I WAS IN TAMPA, FL AFTER GASSING UP I WENT TO PUT THE VEHICLE IN GEAR AND THE GEAR SHIFT LEVER BROKE OFF THE VEHICLE HAD TO BE TOWED TO SARASOTA FORD IN SARASOTA, FL WHERE I LIVE. THAT'S THE FIRST TIME NOW THE SECOND TIME I WAS LEAVING FOR WORK AT 4:30 AM IN NOVEMBER OR DECEMBER OF 2014 I WAS IN MY DRIVEWAY AND WENT TO PUT THE VEHICLE IN GEAR WHEN THE GEAR SHIFT LEVER BROKE OFF. THE THIRD EVENT HAPPENED ON FRIDAY JULY 8, 2016 AT 4: 28 AM IN MY DRIVEWAY I WAS LEAVING FOR WORK AS I WENT TO PUT THE VEHICLE IN GEAR THE GEAR SHIFT LEVER BROKE OFF. I HAVE HAD TO MISS TWO DAYS OF WORK BY USING PTO/PAID TIME OFF WHICH IS MY VACATION TIME DUE TO THE GEAR SHIFT LEVER CONTINUALLY BREAKING OFF. SARASOTA FORD TOLD ME THAT THE SHIFT LEVER HAS BEEN DISCONTINUED SO THEY HAD TO LOCATE A USED PART FOR THE LAST REPAIR. I HAVE FILED TWO COMPLAINTS WITH FORD MOTOR COMPANY TO WHICH THEY WILL NOT DISCLOSE ANY FINDINGS OR OTHER RELATED COMPLAINTS ONLY THAT THERE ARE NO RECALLS. I HAVE HAD SARASOTA FORD CHARGE ME FOR A NEW PART THEN TAKE SOME MONEY OFF AFTER I FOUND OUT IT WAS A USED PART TO WHICH THEY NEVER NOTIFIED OR ASKED ME IF IT WAS OK TO PUT USED PARTS ON MY VEHICLE. THE SALES MANAGER BILL GODFREY LIED TO ME WHEN I ASKED FOR COPIES OF MY PRIOR INVOICES IN REFERENCE TO THIS ONGOING ISSUE. HE STATED THAT THE RECORDS WERE NOT ON SITE WHEN IN FACT THEY WERE AS I BELIEVE ONE OF THE FILE CLERKS ACTUALLY TOLD US THESE RECORDS WHERE ON SITE IN A OFFICE AND SHE SUPPLIED US WITH THE DOCUMENTS.

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THAT THE ENGINE FAIL SAFE MODE WARNING LIGHT FLASHED AND THE VEHICLE DRASTICALLY REDUCED SPEED AND STALLED WITHOUT WARNING. THE CONTACT HAD TO APPLY FORCE TO COAST THE VEHICLE OFF THE ROAD. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE COMPUTER NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 140,000.

MY 2006 FORD EXPEDITION'S "ENGINE FAILSAFE MODE" INITIATED AND ALERTED ME WHILE I WAS OPERATING THE VEHICLE, WHICH RESULTED IN THE VEHICLE SHUTTING DOWN COMPLETELY AND LOSING ALL POWER. MY MAIN ISSUE/CONCERN WITH THIS IS THAT I LOST STEERING AND A SIGNIFICANT AMOUNT OF BRAKING POWER. FORTUNATELY, I WAS ON A SIDE ROAD AND WAS ABLE TO SAFELY PULL OVER OUT OF HARM'S WAY. THE VEHICLE WAS ABLE TO START A COUPLE OF TRIES LATER, AND I WAS ABLE TO GET THE VEHICLE INTO A SERVICE SHOP SAFELY, WHICH WAS OVER AN HOUR AWAY. I CANNOT HELP BUT BE GRATEFUL FOR GETTING HOME SAFELY, BUT AM VERY CONCERNED ABOUT THESE VEHICLES EXPERIENCING SUCH ISSUES AS THEY TRAVERSE MAJOR THOROUGHFARES, ESPECIALLY ON A HIGHWAY TRAVELING AROUND 70MPH. THIS POTENTIALLY POSED VERY IMPACTFUL CONSEQUENCES AND PUTS MYSELF, FRIENDS/FAMILY TRAVELING WITH ME, AND OTHER MOTORISTS.

WHILE DRIVING ON A HIGHWAY AT 60 MPH AND ON A CITY STREET AT 40 MPH THE VEHICLE WITHOUT ANY WARNING SHUTS OFF AND GOES INTO ENGINE FAIL SAFE MODE, THE VEHICLE STILL HAS BRAKING AND STEERING AND AFTER TURNING IGNITION KEY TO OFF THEN ON IT RESTARTS AND DRIVES FINE. THIS VEHICLE HAS 120,000 MILES ON IT .

WHILE DRIVING AT 45 MPH ON 2 LANE ROAD THE TRUCK ACTED AS IF IT HAD RUN OUT OF GAS. I SHIFTED INTO NEUTRAL AND COASTED TO A PARKING LOT AT A STORE ON THE OTHER SIDE OF THE ROAD. THANKFULLY THERE WAS NOT OPPOSING TRAFFIC OR I WOULD HAVE STOPPED IN MY LANE AND BLOCKED TRAFFIC.

PAINT BUBBLING/BLISTERING UP ON BACK LIFT GATE.

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. WHILE DRIVING 50 MPH, THE ENGINE LIGHT ILLUMINATED, THE VEHICLE LOST POWER, JERKED, AND STALLED. THE CONTACT HAD TO RESTART THE VEHICLE TO RESUME NORMAL OPERATION. IN ADDITION, WHILE DRIVING AT 50 MPH, THE VEHICLE REPEATEDLY SLOW DOWN AND ACCELERATE. THE FAILURE RECURRED A FEW TIMES. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE SPARK PLUGS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 158,307.

HAVE HAD AN A/C PROBLEMS OF THE COMPRESSOR GOING OUT 2007, 2009, 2011, 2013 AND 2016. A/C MAKES A NOISE IN THE BACK END ON PASSENGER SIDE. THEN IT BLOWS WARM AIR. ONLY TWICE DID IT LEAK CONDENSATION ON THE FLOOR BOARDS. HAVE ONLY HAD 2 OF THE COMPRESSOR REPAIRS UNDER WARRANTY AND THE REST HAVE BEEN OUT OF POCKET AT $800-$1200. I HAVE CALLED FORD CUSTOMER RELATIONS; NO HELP. NO RECALLS AND NO TSB'S. THE VEHICLE HAS BEEN REPAIRED BY A FORD DEALER SERVICE DEPT. FOR ALL A/C REPAIRS. WHAT IS THE PROBLEMS?

WHILE TAKING MY KIDS TO DAYCARE THE ENGINE FAIL SAFE LIGHT CAME ON AND THE ENGINE SHUT DOWN. I WAS SITTING AT A LIGHT WAITING TO GO STRAIGHT UNDER A BRIDGE AND AT THIS PARTICULAR LIGHT ONLY ONE LANE CAN GO STRAIGHT SINCE THE ENGINE SHUT DOWN AND I COULD NOT MOVE THIS CAUSED MAJOR BACKUP. LUCKILY THERE WAS AN EMERGENCY VEHICLE A FEW CARS BEHIND AND HE WAS ABLE TO PUSH ME THROUGH THE LIGHT AND INTO A PARKING LOT. AFTER A FEW MINUTES OF SITTING THERE THE TRUCK STARTED AND I WAS ABLE TO GET THEM TO DAYCARE AND CONTINUE ON TO WORK. VERY DANGEROUS SITUATION AND SOMETHING SHOULD BE DONE.

MY VEHICLE HAS COMPLETELY SHUT DOWN IN THE MIDDLE OF DRIVING ON SEVERAL OCCASIONS. I HAVE HAD DIAGNOSTIC REPORTS RUN AND THEY DO NOT FIND ANY PROBLEMS. THE FIRST TIME I WAS GOING 45 MPH AND WAS ABLE TO COAST INTO A SONIC. I WAITED ABOUT 15 MINUTES AND THE CAR STARTED BACK UP. THE SECOND TIME WAS AT A GAS STATION AND MY CAR WOULD NOT START. I HAD A DIAGNOSTIC RUN AND WAS TOLD IT WAS MY BATTERY. I REPLACED THE BATTERY AND MY VEHICLE DIED AGAIN THE NEXT DAY, BUT STARTED BACK UP ONE I LET IT SIT FOR A FEW MINUTES. THIS MORNING I WAS PULLING INTO A PARKING LOT AT WORK AND IT DIED. AFTER ABOUT 10 MINUTES IT STARTED BACK UP AND I WAS ABLE TO PULL INTO A PARKING SPOT. I WENT TO LEAVE FOR LUNCH AND NOW MY VEHICLE WILL NOT START AT ALL. THIS COULD HAVE BEEN MUCH WORSE IF I WERE DRIVING DOWN THE INTERSTATE AND THE CAR SHUT OFF ON ME LIKE IT HAS DONE OTHER TIMES. I HAVE TWO CHILDREN AND THE THOUGHT OF THEM IN THIS CAR DOES NOT MAKE ME FEEL SAFE!!

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE FAIL SAFE WARNING INDICATOR ILLUMINATED AS THE ENGINE STALLED. THE CONTACT STATED THAT THE VEHICLE HAD TO BE SHIFTED INTO THE PARK POSITION IN ORDER TO BE RESTARTED. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS NOT TAKEN TO A DEALER TO BE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 110,000.

I WAS DRIVING DOWN THE FREEWAY APPROXIMATELY 50 MPH WHEN MY ENGINE COMPLETELY SHUT DOWN. THERE WAS A BEEP AND A LIGHT CAME ON THAT SAID "ENGINER FAIL SAFE MODE". THE ENGINE SHUT OFF, BUT LUCKILY I STILL HAD FULL MOVEMENT OF MY STEERING WHEEL SO I WAS ABLE TO CHANGE LANES AND GET OFF TO THE SHOULDER. I PANICKED FOR A MOMENT, BUT STARTED THE CAR AND IT STARTED RIGHT BACK UP. I ATTEMPTED MY DRIVE TO WORK AND MADE IT THERE. NOT SURE WHAT TO DO ABOUT THE PROBLEM, BUT I'M SCARED TO DRIVE IT ANYMORE. ESPECIALLY WITH MY CHILDREN IN THE VEHICLE AND MY HUSBAND IS OUT OF TOWN FOR WORK. THIS IS A MAJOR SAFETY ISSUE AND NEEDS TO BE RECALLED.

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. WHILE DRIVING 35 MPH, THE VEHICLE SUDDENLY LOST POWER AND THE "ENGINE FAIL SAFE MODE" WARNINIG ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT COASTED TO THE SIDE OF THE ROAD AND SHUT OFF THE ENGINE. THE VEHICLE WAS RESTARTED AFTER A FEW MINUTES, BUT THE WARNING INDICATOR RECURRED. THE CONTACT CALLED A LOCAL DEALER WHO WAS UNABLE TO EXPLAIN THE FAILURE, BUT ASKED TO SEE THE VEHICLE FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 95,962.

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. WHILE DRIVING AT APPROXIMATELY 35 MPH, THE "ENGINE SAFE FAIL MODE" WARNING MESSAGE ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHO WAS UNABLE TO DETERMINE THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 190,000.

I HAVE HAD TWO SITUATIONS WHERE MY SUV ENGINE EXPECTEDLY SHUTS OFF. 1.) WHILE DRIVING IN STOP AND GO TRAFFIC 2.) TURNING INTO A PARKING LOT AFTER PUTTING THE SUV IN PARK, I CAN IMMEDIATE TURN BACK ON.

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. WHILE DRIVING 45 MPH, THE VEHICLE LOST POWER. WHEN THE ACCELERATOR PEDAL WAS DEPRESSED, THE VEHICLE FAILED TO ACCELERATE AND THE RPMS INCREASED. THE CHECK ENGINE AND SERVICE VEHICLE SOON WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 141,000.

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. WHILE DRIVING AT 60 MPH, THE VEHICLE STALLED AND THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION FAILED AND THE SECOND GEAR FAILED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 134,587.

THE PAINT ON THE LIFT GATE IS BUBBLING AND PEELING, CAUSED BY A PROBLEM WITH THE ALUMINUM. A PROBLEM THAT FORD WAS AWARE OF BEFORE MY CAR WAS SOLD.

WE WERE EXPERIENCING STALLS AND OVERALL SLUGGISHNESS AND TOOK IT TO A MECHANIC WHO TOLD US WE NEEDED A TUNE UP. MY HUSBAND USUALLY DOES MINOR UPKEEP, THANKED THE MAN AND WAS ABOUT TO TAKE OUR TRUCK HOME WHEN THE MECHANIC INFORMED US THAT THE PLUGS WERE A BEAR TO CHANGE SINCE WE WOULD NEED A SPECIAL TOOL AND CHANCES ARE, THE PLUGS WOULD BREAK OFF. WE WERE SKEPTICAL BUT TRUSTED HIM TO DO THE JOB. IT COST SO MUCH AND TOOK SO LONG, WE BOUGHT A BEATER CAR IN THE INTERIM SO WE COULD GET TO WORK! AND IT COST OVER $1000...FOR A TUNE UP!!! IT LOOKS LIKE FORD KNOWS FULL WELL ABOUT THIS BUILT IN MONEY MAKER SINCE I SEE WE ARE IN GOOD COMPANY WITH MANY OWNERS COMPLAINING ABOUT THE EXACT SAME ISSUE. SHAME ON FORD.

IT TAKES FOREVER TO DRIBBLE GAS INTO THE TANK AT THE FILLING STATION; THE BACK PRESSURE IN THE FILLER PIPE CUTS OUT THE PUMP SO BAD IT TAKES OVER 20 MINUTES TO FILL THE LARGE TANK; THIS IS UNACCEPTABLE IN BAD WEATHER AND MORE THAN ANNOYING ON A TIGHT SCHEDULE AS IT ENCOURAGES SPEEDING TO MAKE UP FOR LOST TIME!

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THAT THE VEHICLE STALLED. ON ANOTHER OCCASION, THE VEHICLE STALLED AFTER THE VEHICLE ENGINE SAFETY MODE WAS INITIATED WHILE DRIVING APPROXIMATELY 5 MPH. THE VEHICLE WAS RESTARTED BUT THE FAILURE RECURRED FIVE MINUTES LATER. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE THROTTLE BODY SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 140,000.

MY 2006 FORD EXPEDITION WAS PARKED IN MY DRIVEWAY AT 7:00 AM WHEN I HEARD A CRASH. I LOOKED OUT THE WINDOW TO SEE THE BACK LIFT GATE GLASS HAD EXPLODED, ALL ELSE IN MY NEIGHBORHOOD WAS QUIET AT THAT HOUR. AS FAR AS I CAN TELL NO IMPACT FROM AN EXTERNAL SOURCE, IT WAS BACKED IN CLOSE TO A BOAT. I HAD DRIVEN THE VEHICLE TWO DAYS PRIOR AND HAD NOTICED NO PROBLEM WITH THE REAR WINDOW. WHEN I CLEANED UP THE MESS I FOUND A GOOD AMOUNT OF THE SMALL GLASS PIECES WERE INSIDE THE VEHICLE, THE REMAINDER WERE ON THE GROUND BEHIND THE VEHICLE WITHIN TEN FEET OR SO. THE LARGEST PIECES OF GLASS WERE SMALLER THAN MY PALM.

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. WHILE PARKED, THE VEHICLE STALLED SHORTLY AFTER BEING STARTED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE, BUT THE ENGINE WARNING INDICATOR ILLUMINATED. THIS WAS A RECURRING FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 111,000.

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. WHILE DRIVING 60 MPH, THE VEHICLE MADE A RATTLING NOISE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE VEHICLE'S ENGINE NEEDED TO BE REPAIRED OR REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 194,549.

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. WHILE DRIVING 65 MPH, THE ENGINE WARNING LIGHT ILLUMINATED AND FLICKERED WHEN ACCELERATING. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 164,500.

FIRST OCCURRENCE EXHIBITED FLICKERING DASHBOARD LIGHTS BEFORE THE ELECTRICAL SYSTEM WENT COMPLETELY DEAD AND THE ENGINE QUIT WHILE ACCELERATING AT APPROXIMATELY 20 MPH. PUT VEHICLE IN NEUTRAL AND WAS ABLE TO RESTART ENGINE NORMALLY BEFORE COMING TO A STOP. HAVE EXPERIENCED SEVERAL SHORT INSTANCES OF DASH FLICKERING OVER THE PAST COUPLE OF WEEKS WITH NO APPARENT ENGINE PROBLEMS. DURING THAT SAME PERIOD THERE HAVE BEEN APPROXIMATELY 4 INSTANCES OF THE ELECTRICAL SYSTEM BEING COMPLETELY DEAD UPON THE INITIAL ATTEMPT TO START THE ENGINE. WHEN THIS HAPPENS, THE ONLY LIGHT THAT IS ILLUMINATED ON THE DASH (OR ANYWHERE ELSE FOR THAT MATTER) IS WHAT I THINK IS THE AIRBAG LIGHT; HOWEVER, NORMAL ELECTRICAL POWER HAS, THUS FAR, RE-APPEARED WITHIN 5 MINUTES AND THE ENGINE THEN STARTS AND RUNS NORMALLY. YESTERDAY THE "CHECK ENGINE" LIGHT CAME ON AND I WAS ABLE TO PULL A CODE OF P0119 (ENGINE COOLANT TEMPERATURE CIRCUIT INTERMITTENT) UPON RETURNING HOME. I SUBSEQUENTLY CLEARED THE CODE, BUT THE READER INDICATES ANOTHER CODE IS "PENDING". I BELIEVE THIS IS A SYMPTOM OF A LARGER PROBLEM. I HAVE NOT EXPERIENCED A "ENGINE FAILSAFE MODE" WARNING MESSAGE, BUT THIS COMPLAINT IS VERY SIMILAR TO MANY OTHERS ALREADY POSTED AND I AGREE WITH THE RELATED SAFETY CONCERNS AND NEED FOR A RECALL. *TR

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THAT WHILE DRIVING AT AN UNKNOWN SPEED, THE VEHICLE JERKED AND LOST POWER AS THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

I WAS DRIVING ABOUT 25-30MPH AND MAKING A LEFT TURN. THE VEHICLE SUDDENLY SHUT OFF. I HAD NO POWER STEERING OR ANYTHING. IT WAS TOTALLY OFF AND STOPPED IN THE MIDDLE OF THE ROAD. IF A CAR HAD BEEN COMING IT WOULD HAVE HIT US. I WAS ABLE TO TURN OFF THE KEY, PUT IT IN PARK AND START IT UP AND PULL OFF THE ROAD. I DECIDED TO CAREFULLY TRY TO GET HOME. ON THE WAY HOME I WAS STOPPED AT A RED LIGHT AND IT SHUT OFF AGAIN, NO WARNING. I WAS BLOCKING TRAFFIC. I WAS AGAIN ABLE TO TURN OFF THE KEY, PUT IT IN PARK, AND START IT UP. I MADE IT HOME A SHORT DISTANCE. THIS IS VERY DANGEROUS AND SOMEONE COULD GET KILLED ON A HIGHWAY BY A CAR RANDOMLY SHUTTING OFF AND BECOMING UNSTEERABLE. *TR

DRIVING DOWN HIGHWAY AT 45 MPH WHEN ENGINE FAIL SAFE MODE CAME ON. WITH NO POWER, HAD TO VEER OFF TO A TURN LANE PUT IN PARK AND RESTART CAR. THIS IS THE SECOND TIME THIS HAS HAPPENED. FIRST WAS ON HIGHWAY AS WELL AROUND 40 MPH, SAME THING HAPPENED; NO POWER HAD TO VEER OFF TO THE SIDE OF THE HIGHWAY, PARK AND RESTART CAR. EXTREMELY DANGEROUS TO BE DRIVING ON A BUSY HIGHWAY AND HAVE EXPEDITION SHUT OFF COMPLETELY. *TR

WAS DRIVING ABOUT 35 MPH WHEN ENGINE FAIL SAFE MODE CAME ON AND TRUCK JUST SHUT OFF. THIS HAPPENED 4 TIMES BETWEEN LOCATION AND HOME. ALMOST GOT REARENDED WHEN IT HAPPENED. *JS

IT WAS SNOWING ON MY WAY TO AN APPOINTMENT AND MY WIPERS STOPPED WORKING. I COULDN'T SEE OUT OF THE WINDOWS AND ANOTHER VEHICLE HIT THE FRONT END OF MY 2006 FORD EXPEDITION. ALSO THE OTHER DRIVERS AIRBAGS DEPLOYED BUT MINE DID NOT. MY TRUCK WAS TOTALED. I SPENT THE NIGHT IN THE HOSPITAL WITH BACK INJURIES AND LEG INJURIES, AS WELL AS A HEAD INJURIES WHICH CAUSED ME TO TEMPORARILY LOSE MY MEMORY AND CONSCIOUSNESS. *TR

SUV ENTERED SAFE MODE ... ENGINE SHUDDERED, LOW POWER IN LOW RPM BANDS.. WOULD NOT ACCELERATE. HAD SPARK PLUGS REPLACED IN 2014 AT 88000 MILES. IN 2015, 115,000 MILES ENGINE DOES AGAIN WHILE DRIVING INTERSTATE PUTTING ME AT RISK ON ROAD OF COLLISION DUE TO POWER LOSS. DID NOT ENTER SAFE MODE SECOND TIME... JUST COULD NOT GET POWER - HAD TO PUSH HARD ON GAS TO GET IT INTO LOWER GEAR/HIGHER RPMS. TOOK TO REPAIR SHOP THINKING COILS (COP) NEEDED REPLACED. TOLD ENGINE IS NO GOOD AND NEEDS FULL REPLACEMENT. A WRECK COULD OCCUR WHEN ENGINE FAILS LIKE THIS. ENGINES SHOULD NOT BE DEAD AT 115,000 MILES. I MAINTAINED ACCORDING TO MFG SUGGESTED MAINTENANCE SCHEDULE. *TR

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 20 MPH, THE VEHICLE STALLED WITHOUT WARNING. IN ADDITION, THE FAIL SAFE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 135,000.

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 65 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE RESTARTED HOWEVER, THE FAILURE RECURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS TAKEN TO THE DEALER AND WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 99,000. THE VIN WAS UNAVAILABLE.

ENGINE FREQUENTLY GOES IN TO ENGINE FAILSAFE MODE. THIS HAPPENS TYPICALLY WHEN THE CAR IS BEING LIGHTLY THROTTLED SUCH AS AROUND CORNERS OR IN RUSH HOUR TRAFFIC. THE CAR RESTARTS FINE, BUT MUST BE COMPLETELY TURNED OFF, WHICH DISABLES AIRBAGS, MAKES POWER STEERING AND POWER BRAKES IMPOSSIBLE TO USE. PREVIOUSLY I HAVE CLEANED THE THROTTLE BODY OF THE CAR AT THE SUGGESTION OF NUMEROUS MECHANICS, AND THIS RESOLVED THE ISSUE FOR NEARLY A YEAR. NOW THE PROBLEM IS BACK AGAIN. I'M CONCERNED FOR MY WIFE'S SAFETY. THE THROTTLE BODY NEEDS TO BE REDESIGNED AS THE THROTTLE PLATE STICKING RETURNING INVALID DATA TO THE COMPUTER SENDING THE ENGINE INTO FAILSAFE MODE. *JS

AS I AM DRIVING DOWN THE ROAD I LOSE POWER AND DEACCELERATE AND GO INTO FAIL SAFE MODE. THE LITTLE WRENCH LIGHT COMES ON THE DASH. THEN THE ENGINE CUTS OFF COMPLETELY. THIS HAS HAPPENED AT MULTIPLE SPEEDS. IT IS EXTREMELY DANGEROUS! ONCE I TURN THE KEY OFF I RESTART THE ENGINE AND IT MAY NOT HAPPEN AGAIN FOR A MONTH. I REPLACED THE THROTTLE POSITION SENSOR AND IT DID NOT DO THIS FOR ABOUT A YEAR, NOW IT IS STARTING AGAIN AND IT HAS HAPPENED 5 TIMES IN THE LAST 3 MONTHS. IT HAS HAPPENED AT 65MPH, 40MPH, 25MPH, 55MPH, 30 MPH. THERE IS NO PATTERN. I HAVE BEEN LUCKY THAT I HAVE BEEN ABLE TO PULL OVER TO THE SIDE OF THE ROAD OR TURN INTO A PARKING LOT EACH TIME THIS HAPPENS, IT SCARES ME! I HAVE READ MULTIPLE ACCOUNTS OF THIS HAPPENING ONLINE TO THE 2006 AND WONDER WHY IT HAS NOT BEEN RECALLED IF THERE ARE SO MANY PROBLEMS WITH IT. I HAVE TAKEN IT TO FORD TWICE AND BC THE LIGHT DOES NOT STAY ON AND IT IS NOT HAPPENING WHEN I BRING IT TO THEM THEY TELL ME THERE IS NOTHING THEY CAN DO. *TR

ENGINE SHUT DOWN AT HIGHWAY SPEED. LOSS OF POWER STEERING AND POWER BRAKES. WAS ABLE TO COAST TO EMERGENCY LANE THEN RESTART CAR. HAPPENED TWO ADDITIONAL TIMES. TOOK TO SHOP WHERE THE THROTTLE BODY WAS REPLACED. NO ISSUES SINCE THEN (~ 1 YEAR AGO). SOUNDS LIKE MANUFACTURER DEFECT. THIS IS A SAFETY ISSUE. *TR

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THAT THE ELECTRONIC THROTTLE CONTROL AND THE SERVICE ENGINE WARNING INDICATORS ILLUMINATED. THE VEHICLE STALLED, BUT WAS ABLE TO BE RESTARTED AND RESUME NORMAL OPERATION. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 120,000.

ENGINE JUST SHUTS OFF, ESPECIALLY AT A STAND STILL & A/C ON. NOT AS OFTEN IF A/C IS NOT ON. *TR

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 5 MPH, THE BRAKES AND ACCELERATOR PEDAL FAILED. THE FAILURE RECURRED THREE TIMES. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS. THE TECHNICIAN WAS UNABLE TO LOCATE A FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 79,000. UPDATED 09/30/14*LJ UPDATED 2/27/2015 *JS

AS I WAS SLOWING DOWN AND MADE A RIGHT TURN INTO A PARKING SPACE, THE VEHICLE ACCELERATED ON ITS OWN, RUNNING OVER THE CONCRETE STOP AND THE CURVE. THE CAR CONTINUED TO ACCELERATE AND RAN HEAD ON INTO A TREE THAT WAS APPROXIMATELY 10 FEET AWAY FROM THE PARKING SPACE. THE DRIVER AIRBAG DID NOT DEPLOY. MY CAR WAS TOTALED AS A RESULT OF THIS ACCIDENT. *TR

ENGINE WENT IN TO FAIL SAFE MODE AND STALLED WHILE COASTING TO PULL OFF. PUT IN NEUTRAL SHUT OFF KEY AND THEN RESTARTED. NO MORE PROBLEM..UNTIL A YEAR LATER. FAIL SAFE THEN STALL. RESTARTED AND CHECK ENGINE LIGHT ON. AFTER 10 MILES FAIL SAFE AND STALL. RESTARTED CHECK ENGINE LIGHT ON TOOK TO DEALER. DIAGNOSED AS THROTTLE BODY $650 REPAIR. OBVIOUSLY; I AM NOT THE FIRST VICTIM! SHAME ON YOU FORD FOR NOT STEPPING UP AND TAKING CARE OF YOUR CUSTOMERS AND REPLACING THE THROTTLE BODIES. TO CONSUMERS..FAIL SAFE DOESN'T MEAN SAFE TO KEEP DRIVING, IT IS DESIGNED TO KEEP THE ENGINE RUNNING JUST LONG ENOUGH TO MAINTAIN POWER STEERING AND BRAKES WHILE YOU PULL OVER. GOOD LUCK! *TR

THE CAR STALLED WHILE TURNING NO WARNING AT 25MPH START AND SHUT DOES IT 6 TIMES GOING HOME. *JS

DRIVING IN TOWN ON FOUR LANE AT 45 MPH. FAIL SAFE LIGHT APPEARED AND ENGINE CUT OFF AND LOST POWER STEERING. ALMOST REAR ENDED AS THERE WAS NO PLACE TO PULL OFF THE ROAD! ENGINE WAS RESTARTED AND DID NOT OCCUR AGAIN WHILE RETURNING HOME. *TR

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 60 MPH, THE VEHICLE STALLED AND THE ENTIRE INSTRUMENT PANEL ILLUMINATED. THIS FAILURE OCCURRED SIX TIMES OVER A PERIOD OF SIX MONTHS. THE VEHICLE WAS TAKEN TO A DEALER WHO WAS UNABLE TO DUPLICATE THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 123,000.

LESS THAN 3 MINUTES AFTER CAR PARKED, FIRE DEVELOPED FROM TOP OF FUEL TANK AND IN 15 MINUTES, VEHICLE WAS DESTROYED. *TR

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THAT WHILE ATTEMPTING TO MERGE INTO TRAFFIC, THE VEHICLE HESITATED TO ACCELERATE AND MISFIRED WITHOUT ANY WARNING. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE SPARK PLUGS NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 97,000 AND THE CURRENT MILEAGE WAS 98,500.

2006 EXPEDITION FAIL SAFE MODE CAME ON WHILE DRIVING MY CHILDREN TO SCHOOL. CAR IMMEDIATELY SLOWED TO UNDER 10MPH. WAS BARELY ABLE TO PULL OVER AND RESTART IT. THANK GOODNESS I WAS NOT ON THE EXPRESSWAY DOING 60+ MPH. THERE ARE NUMEROUS COMPLAINTS ON THIS ISSUE WITH THIS CAR. IT WAS VERY SCARY! *TR

WAS DRIVING DOWN THE ROAD WHEN EXPEDITION STARTED TO LURCH AND NOT SHIFT PROPERLY. TOOK IT IN TO AUTO SHOP AND THEY DIAGNOSED THAT PISTONS 3 AND 7 WERE MISFIRING. WENT TO CHANGE SPARK PLUGS AND PLUGS BROKE OFF IN THE ENGINE. HAD TO ORDER SPECIAL TOOL TO REMOVE THEM, SECOND TIME THEY HAVE HAD TO BE REPLACED BOTH TIMES THEY HAVE BROKEN OFF. COST WAS OVER 1500.00 *TR

WAS DRIVING DOWN OFF RAMP LOST ALL POWER TO THE VEHICLE, NO STEERING, NO BRAKES. I HAD MY 3 CHILDREN IN THE VEHICLE WITH ME AND THANKFULLY I WAS ABLE TO COST TO THE SHOULDER UNTIL HELP ARRIVED. EXTREMELY SCARY HAD IT HAPPEN 2 MINUTES EARLIER WOULD OF BEEN OFF THE RAMP AND INTO ONCOMING TRAFFIC! THIS IS UNACCEPTABLE!! MY MECHANIC SAYS IT'S THE FUEL PUMP, AND JUST THE PART IS 500 DOLLARS?!? THIS COULD OF ENDED VERY BADLY AND I HAVE HAD NOTHING BUT ISSUES WITH THIS PIECE OF JUNK. THE PAINT IS PEELING OFF, LOOKS LIKE NO PRIMER OR SEALER WAS USED IT LITERALLY IS FLAKING OFF ON THE HOOD AND REAR GATE RIGHT WHERE YOU WOULD PUT YOUR HANDS TO OPEN IT. IN THE MANUAL IN VERY SMALL PRINT IT SAYS THE OIL FROM YOUR FINGERS MAY CAUSE PAINT TO CORRODE, ARE YOU KIDDING ME??? YOUR NOT SUPPOSED TO OPEN YOUR HOOD OR TAILGATE??? RIDICULOUS!! THIS VEHICLE IN MY OPINION IS A LEMON!! *TR

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THAT WHILE DRIVING 50 MPH, THE FAIL SAFE WARNING LAMP ILLUMINATED AS THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE SPARK PLUGS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 82,000 AND THE CURRENT MILEAGE WAS 83,000.

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THAT THE OVER-DRIVE FUNCTION WOULD DISENGAGE INDEPENDENTLY. CAUSING THE VEHICLE TO DECELERATE AND THEN RETURN TO NORMAL SPEED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE CRUISE CONTROL WAS ALTERING THE TRANSMISSION. THE VEHICLE WAS REPAIRED BUT THE CONTACT WAS NOT ADVISED OF THE SPECIFIC REPAIRS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 110 AND THE CURRENT MILEAGE WAS 98,421.

AS I WAS DRIVING MY EXPEDITION, THE TRUCK SUDDENLY SHUT COMPLETELY OFF AND I HAD TO POWER STEERING AND THEN IN THE MESSAGE CENTER IT SHOWED "ENGINE FAILSAFE MODE". I HAD TO PUT MY FLASHERS ON AND COAST TO A STOP IN THE LANE I WAS IN AND COME TO A COMPLETE STOP BEFORE I COULD RESTART MY TRUCK. I WAS UNABLE TO SWITCH LANES OR MOVE TO A SAFER LOCATION BECAUSE I HAD NO POWER STEERING. I HAD THE SAME THING HAPPEN IN MARCH OF 2009 WHEN I WAS GOING 60 ON THE INTERSTATE IN THE MIDDLE LANE AND LOST ALL POWER AND HAD TO COAST TO A STOP IN THAT LANE WITH MY FLASHERS ON HOPING EVERYONE AROUND ME WOULD SEE I WAS HAVING CAR TROUBLE. I HAD 3 OF MY KIDS IN THE TRUCK WITH ME. IN 2009 I TOOK IT INTO THE FORD DEALERSHIP AND THEY SAID IT WAS THE THROTTLE BODY AND REPLACED IT WHICH COST ME $536.00. IN 2009 IT HAPPENED 5 TIMES BEFORE IT WAS FIXED. I TOOK THE TRUCK IN TODAY AND THEY SAID AGAIN ITS THE THROTTLE BODY AND BECAUSE IT'S BEEN 5 YEARS THE OTHER ONE IS NO LONGER UNDER WARRANTY. SO NOW I'M GETTING A NEW THROTTLE BODY PUT IN. I EMAILED FORD CORPORATE AND WAS BASICALLY TOLD THAT THERE IS NO CURRENT RECALL NOR PLANS FOR ONE SO THERE'S NOTHING THEY CAN DO FOR ME! *TR

THIS IS THE SECOND INCIDENT: THE FIST WAS ABOUT 3 MONTHS AGO. I WAS DRIVING DOWN A RESIDENTIAL STREET YESTERDAY WHEN THE "FAIL SAFE MODE" INDICATOR CAME ON AND SAID ENGINE SHUTTING DOWN. CAR TURNS OFF, CANNOT STEER. VERY DANGEROUS. I WAS ON A RESIDENTIAL STREET AND WAS ABLE TO PULL OFF. TURNED THE CAR OFF FOR A FEW MINUTES AND IT STARTED AND I DROVE TO WORK, BUT THE ENGINE LIGHT REMAINED ON. I TOOK IT TO AN AUTO PARTS STORE WHO RAN IT AND IT CAME UP AS THROTTLE BODY FORCES IMMEDIATE IDLE. WHICH IS EXACTLY WHAT THE 10 PAGES ON COMPLAINTS ON CARCOMPLAINTS.COM SAID IT WOULD SAY - HOWEVER INFORMATION ON THAT SITE ALSO SAID IT'S ACTUALLY THE FUEL PUMP MODULATOR, BUT THE COMPUTER DID NOT INDICATE THAT AT ALL. THERE WERE ALMOST 60 COMPLAINTS OF THE SAME SITUATIONS - WHEN I PULLED OUT INTO TRAFFIC TODAY THE CAR 'HESITATED' AND DID NOT ACCELERATE CORRECTLY. THE FIRST INCIDENT OCCURRED ON A MAJOR HIGHWAY - AND AGAIN I WAS LUCKY ENOUGH TO BE IN THE RIGHT LANE AND WAS ABLE TO PULL OVER. THIS DEFECT IS GOING TO CAUSE AN INJURY OR EVEN DEATH AND IT NEEDS TO BE RECALLED AND CORRECTED. I WILL BE CONTACTING FORD CORPORATE; BUT WITH THE RECENT INCIDENTS WITH GM I WOULD HATE TO SEE AN ACCIDENT OR FATALITY OCCUR WHEN FORD AND OTHERS ARE AWARE OF THIS PROBLEM. OBVIOUSLY I HAVE TO GET THIS FIXED, I'M HOPING MY FORD DEALER WILL WORK WITH ME, BUT I HAVE A 4 YEAR OLD SO TIME IS OF THE ESSENCE AND I'M GUESSING MONEY WILL BE TOO. REGARDLESS OF FORD'S CORPORATE RESPONSE, I WILL BE CONTACTING THE MEDIA. THIS IS A SAFETY ISSUE AND IS UNACCEPTABLE THAT FORD IS NOT TAKING RESPONSIBILITY. *TR

RUST IN THE CHANNELS OF THE ROOF HAS PENETRATED COMPLETELY THROUGH THE SHEET METAL. VEHICLE HAS BEEN WELL MAINTAINED AND IS OTHERWISE IN PERFECT CONDITION. *TR

CAR JUST DIED ON HIGHWAY JUST SHUT OFF WOULD NOT RESTART. AFTER LOOKING AT IT THE FPDM WAS CORRODED AND BAD. THIS HAS BEEN A INTERRMTINT PROBLEM AND HAS ALMOST CAUSED ACCIDENTS WHEN CAR STALLS WHEN DRIVING AT INTERSECTIONS AND SUCH ALUMINUM AND STEEL DONT WORK WELL UNDER A CAR AND CORRODE VERY BADLY. *TR

I WAS DRIVING AROUND 46MPH, AND IN THE MIDDLE OF DRIVING, MY TRUCK CUT OFF FOR AROUND 5 SECONDS. I ALMOST GOT BY THE TRUCK BEHIND ME. MY TRUCK KICKED BACK ON BY ITSELF, ALL WHY I WAS DRIVING. I WAS SO TERRIFIED THE TRUCK BEHIND ALMOST REAR ENDED ME. *TR

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE FAIL SAFE MODE WARNING LIGHT ILLUMINATED AS THE VEHICLE INDEPENDENTLY DECELERATED AND STALLED. THE VEHICLE WAS TOWED TO THE DEALER, WHO STATED THAT THE THROTTLE BODY WOULD NEED CLEANING. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED SEVERAL MONTHS LATER. THE VEHICLE WAS TAKEN BACK TO THE DEALER, WHO STATED THAT THE ENTIRE THROTTLE BODY WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURE WAS CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 96,000.

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THAT THE VEHICLE WOULD ENGAGE INTO SAFE MODE WHEN STARTED, CAUSING THE VEHICLE TO STALL. THE FAILURE WAS RECURRING OVER A THREE YEAR SPAN. THE VEHICLE WAS TAKEN TO A DEALER AND REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE WAS 70,000.

WHILE DRIVING APPROXIMATELY 35 KPH MY ABS LIGHT CAME ON FOLLOWED BY THE BRAKE LIGHT THEN THE AIRBAG LIGHT. (CHECK ENGINE NEVER GOES OFF. REPLACE ALL PLUGS AND COILS. REPLACE OF SENSORS AND SEVERAL FUSES.) THE HEADLIGHTS BEGIN TO FLASH OFF AND ON THEN TRUCK STARTED SPUTTERING. THE FUEL LIGHT WENT FROM 3/4 TANK TO E. I PULLED INTO SHOPPING CENTER PLACED IT IN PARK. WENT TO PUT IT BACK IN DRIVE AND COULDN'T SOMETHING WAS DRAINING BATTERY THAT IS ONLY 3 MONTHS OLD. DON'T KNOW RESOLUTION BUT TIRED OF THIS TRUCK! IT IS RIDICULOUS THAT THIS TRUCK HAS SO MANY REPEAT ISSUES AND NO RECALL. FORD NEEDS TO BE SUED. I DAILY HAVE TO TURN ON MY HAZARDS AND RESTART CAR BECAUSE IT SPONTANEOUSLY GOES INTO LIMP MODE, ESPECIALLY IN TRAFFIC. *TR

DRIVING AT 25MPH THE VEHICLE ENGINE SHUT DOWN AND WENT INTO FAILSAFE MODE, POWER STEERING ALSO DISABLED CAUSING A VERY DANGEROUS SITUATION TRYING TO STEER THE CAR FROM TRAFFIC TO A SAFE AREA WITHOUT ASSISTED STEERING. THIS PROBLEM HAS OCCURRED SEVERAL TIMES OVER THE PAST 2 YEARS AND USUALLY IN COLDER WEATHER. LAST TIME IT HAPPENED WAS ON A MAIN HIGHWAY BUT LUCKILY I WAS ALONE WITHOUT MY FAMILY AND IN THE INSIDE LANE SO I WAS ABLE TO PULL OVER THANKFULLY IT DIDN'T HAPPEN IN THE OVERTAKING LANE AS THERE IS NO TIME TO SAFELY CHANGE LANES WHEN IT SHUTS DOWN. SURPRISED THERE HAS BEEN NO FATALITIES DUE TO THIS AS IT IS A COMMON PROBLEM WITH 2006 FORD TRUCKS. *TR

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THAT WHILE DRIVING BETWEEN 45 TO 50 MPH, THE VEHICLE STALLED AND THE ENGINE FAIL SAFE LIGHT ILLUMINATED. THE CONTACT WAS ABLE TO COAST TO THE SHOULDER WHERE THE VEHICLE WAS RESTARTED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO STATED THAT THE THROTTLE BODY WAS NOT OPENING AND CLOSING CORRECTLY. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 60,000 AND THE CURRENT MILEAGE WAS 75,000.

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, THE FAIL SAFETY ENGINE WARNING LIGHT ILLUMINATED AS THE VEHICLE STALLED. THE FAILURE WAS RECURRING. THE VEHICLE WAS NEITHER DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 110,000.

VEHICLE SIMPLY SHUTS OFF AT ANY TIME AND SHOWS 'ENGINE FAIL SAFE MODE'. THIS HAS HAPPENED APPROXIMATELY 15 TIMES SINCE WE BOUGHT THE VEHICLE (USED) IN MARCH 2012 (MOST RECENTLY ON 10/13). I HAVE RESEARCHED THIS ONLINE AND MANY OTHER OWNERS HAVE THE SAME COMPLAINT. WE REPLACED THE TPS AT A COST OF AROUND $300 AS A POSSIBLE FIX AND THIS WORKED FOR ABOUT 6 MONTHS - NOW THE PROBLEM IS BACK AND MY RESEARCH INDICATES WE NEED TO HAVE THE THROTTLE BODY REPLACED. THIS WILL COST US AROUND $500 - FOR A TOTAL REPAIR COST OF AROUND $800 - WHICH WE CANNOT AFFORD! FORD HAS LITERALLY $HUNDREDS OF MILLIONS TO TAKE CARE OF THIS AND MUST RECALL DUE TO THIS ISSUE - THERE IS NO EXCUSE TO ALLOW THIS DANGEROUS PROBLEM TO CONTINUE. FORD MOTOR CO. OWES ME $800 DUE TO THEIR POOR ENGINEERING AND UNWILLINGNESS TO SOLVE THIS ISSUE - THEY ARE GREEDY CROOKS. *TR

LEMON! 2006 FORD EXPEDITION BEGINNING OF JUNE IT STARTED "BOGGING" DOWN WHILE DRIVING. WE TOOK IT TO AUTOZONE, MISFIRE. TOOK IT TO A MECHANIC WE KNOW AND HE TOLD US THE CODES SHOWED 6,7,8 SPARKPLUGS. TRYING TO SAVE $.THIS HELPED A LITTLE, STARTED DOING IT AGAIN BUT WORSE, THIS TIME IT WAS DECELERATING WE WERE GOING 75 & CHECK ENGINE LIGHT STARTED FLASHING & BOGGED DOWN TO 50 ON THE HWY ALMOST CAUSE SEVERAL WRECKS AS I TRIED TO PULL OVER TO THE SIDE (WITH MY KIDS IN THE CAR) TOOK IT INTO THE MECHANIC & OTHER SPARK PLUGS COIL PACKS & 1 INJECTOR GOT IT FIXED PICKED IT UP & DIDN'T EVEN GET DOWN THE ROAD & IT DID IT AGAIN.THIS TIME CHECK ENGINE LIGHT WENT OFF AFTER FLASHING.TOOK IT BACK TO HIM & NO CODES COULDN'T FIND ANYTHING.WENT HM & ALMOST GOT IN A WRECK AGAIN! IT DECELERATE TO 45 AFTER GOING 70. WE WENT HM, NEXT MORNING GOING TO TAKE IT BACK TO HIM AGAIN!! WHILE DRIVING, A/C TURNED OFF, DOOR SENSOR ALARM FAIL POPPED UP, ANOTHER SENSOR FAIL, &PULLED OVER PUT IN PARK & WOULDN'T COME OUT OF PARK.CALLED MECHANIC,AFTER SO MANY LOOK OVERS THINKING IT WAS PCM, SECURITY MODULE, HE GIVES UP AFTER 2 WKS OF WORKING ON IT.WE GET IT HM & START LOOKING ON HERE & FIND SO MUCH ABOUT THIS LIKE ITS GOING IN SAFE FAIL MODE WITHOUT SHUTTING OFF. START LOOKING AT ALL THE OTHER FORUMS & THIS YR MODEL HAD 362 COMPLAINS ON ANOTHER SITE & MANY ON HERE, SEVERAL OF THIS SAME DEAL.WE STARTED WITH FUSES #5 BLOWN, CHANGE BLOWS IMMEDIATELY, CHANGE AGAIN BLOWS AGAIN. START CHASING WIRES, CHANGE AGAIN STARTS UP.OKAY GREAT!!! NOW ROUGH IDLE, WAY BAD WHO CARES IT STARTS! DRIVE IT TO WORK, WE DESPERATELY NEED MY CAR & FORD CANT GET TO IT FOR 1 1/2 MONTHS.STARTS STALLING WHILE DRIVING AGAIN A/C SHUTS OFF AND SLOWS DOWN. FORD NEEDS TO FIX THIS BEFORE IT KILLS SOMEONE! THIS IS A MAJOR DEFECT THAT WILL KILL! I HAVE FOUND THIS SAME ISSUE ON THIS SAME SITE A LOT! WHY ISN'T ANYTHING BEING DONE? HELP!!!!!!!!! *TR

I BELIEVE THAT FORD EXPEDITIONS FROM YEARS 2003 - 2006 HAVE A SERIOUS DEFECT. I AM EXPERIENCING RADIATOR SUPPORT MOUNT ROT. MY MECHANIC SAYS THIS SHOULD NOT BE OCCURRING ON A VEHICLE THAT IS ONLY 6 YEARS OLD. I HAVE DONE SOME RESEARCH AND HAVE READ ON THE FORD EXPEDITION FORUM THAT MANY EXPEDITION DRIVERS ARE NOW FINDING THIS TO BE THE CASE WITH THEIR VEHICLES AS WELL. I SERIOUSLY BELIEVE A RECALL SHOULD BE IN PLACE TO ADDRESS THIS PROBLEM. THE A/C CONDENSER IS NOW FALLING THROUGH AND THE BODY MOUNTS ARE BEING COMPROMISED. *TR

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED WHILE DRIVING 55 MPH SHE ATTEMPTED TO ACCELERATE THE VEHICLE AND IT BEGAN TO LUNGE AND HESITATE. THE VEHICLE ALSO STALLED. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS UNAVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 101,000.

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 60 MPH, THE VEHICLE STALLED AND THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE ENGINE AND SPARK PLUGS NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE APPROXIMATE FAILURE MILEAGE WAS 70,500 AND THE CURRENT MILEAGE WAS 70,628. *TR

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THAT WHILE DRIVING 70 MPH, THE FAIL SAFE WARNING LIGHT ILLUMINATED AS THE VEHICLE STALLED. THE VEHICLE WAS RESTARTED AND OPERATED AS DESIGNED. THE FAILURE RECURRED THREE TIMES. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 95,000.

I WENT TO MOVE MY VEHICLE FROM THE FRONT OF MY HOUSE TO THE DRIVE WAY AND IT WOULDN'T STOP, I PRESSED ON THE BRAKE PEDAL AND HEARD NOTHING BUT AIR AS THE BRAKE PEDAL WENT STRAIGHT TO THE FLOOR. I STEPPED ON THE EMERGENCY BRAKE TO STOP THE VEHICLE AND WHEN I GOT OUT.. THERE WAS A HUGE PUDDLE OF BRAKE FLUID BENEATH THE VEHICLE. *TR

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED WHILE DRIVING 65 MPH, THE ENGINE FAIL SAFE MODE LIGHT ILLUMINATED AND THE VEHICLE STOPPED ACCELERATING. THE VEHICLE WAS RESTARTED AND OPERATED AS DESIGNED. IT WAS THE SECOND TIME THE FAILURE HAD OCCURRED. THE MANUFACTURER WAS NOTIFIED AND ADVISED THE CONTACT TO TAKE THE VEHICLE TO A DEALER FOR DIAGNOSIS. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 103,000.

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, THE ENGINE LIGHT ILLUMINATED AND THE STEERING BECAME DIFFICULT. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSIS AND THE CONTACT WAS INFORMED THAT FIVE OF HER SPARK PLUGS HAD FRACTURED INSIDE THE CYLINDER. THE VEHICLE WAS REPAIRED. THREE MONTHS AFTER THE REPAIR, THE ENGINE LIGHT ILLUMINATED AND THE VEHICLE WAS RETURNED TO THE DEALER WHO STATED THAT THE SPARK PLUG FAILURE HAD CAUSED THE CATALYTIC CONVERTER TO FAIL AND IT WOULD NEED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 85,000.

DRIVING 30MPH IN (D) WITH O/D ON AND LOST FORWARD MOMENTUM JUST LIKE I PUT IT IN NEUTRAL. HAD TO DRIVE IN L2 TO GET HOME.THIS WAS THE FIRST AND ONLY TIME THIS HAPPENED. TOOK A TEST DRIVE AFTER I CHECKED FLUID LEVELS THAT WERE FULL AND PROPER WHICH I WISHED WERE LOW(EASY FIX).I TOOK IT DOWN THE ROAD IN D BUT SLIPPED OUT ABOUT 50' LATER BUT I TOOK IT OUT OF O/D OVERDRIVE AND WENT DOWN THE ROAD FINE FOR 2 MILES BUT DIDN'T WANT TO DRIVE IT ANYMORE UNTIL I TOOK IT TO THE TRANSMISSION GARAGE. WE TREAT OUR VEHICLES EXCELLENT AND I HAVE NEVER HAULED ANYTHING BUT FAMILY AROUND,NO TRAILERS,NO PLOWS..NO PULLING OF ANY KIND.THERE WERE NO PRIOR INDICATORS EXCEPT A SMALL WHINE THAT GOT A LITTLE LOUDER WHEN I ACCELERATED BUT ONLY HEARD IT MAYBE 10 TIMES AT MOST BUT DON'T KNOW IF THAT MEANS ANYTHING WITH THE TRANSMISSION...PLEASE HELP WERE NOT RICH$$ *TR

ENGINE SHUTS OFF WHILE DRIVING AND SHOWS 'ENGINE FAIL SAFE MODE'. THIS HAS HAPPENED 6 TIMES SINCE I BOUGHT THE VEHICLE IN MARCH 2012 (I'VE HAD THE VEHICLE A LITTLE OVER A YEAR NOW). IT HAS HAPPENED IN 1) A RESTAURANT PARKING LOT WHILE ON VACATION; 2) IN A PARKING GARAGE AT WORK; 3) IN A STORE PARKING LOT; 4) IN A STORE PARKING LOT; 5) ON A ROAD; 6) IN A STORE PARKING LOT. (#5/#6 JUST HAPPENED YESTERDAY TO MY WIFE WHILE SHOPPING WITH OUR 3YR. OLD SON). THIS IS A SERIOUS SAFETY ISSUE BECAUSE IT CAN HAPPEN ANY TIME, ANYWHERE, WITHOUT WARNING. I HAVE CONTACTED FORD AND OF COURSE THEY SAY THEY ARE NOT AWARE OF THE PROBLEM - EVEN THOUGH I HAVE FOUND HUNDREDS OF COMPLAINTS ON VARIOUS ONLINE FORUMS AND RIGHT HERE ON THE NHTSA WEBSITE. IT SEEMS (FROM MY RESEARCH ONLINE) THAT THE PROBLEM CAN BE FIXED BY REPLACING THE THROTTLE BODY AND TPS - WHICH IS A COSTLY REPAIR FOR WHICH I DO NOT HAVE THE MONEY (AFTER JUST BUYING NEW TIRES IN ADDITION TO A SEPARATE $500 REPAIR). FORD NEEDS TO RECALL AND FIX THIS ISSUE BEFORE SOMEONE IS INJURED OR KILLED!! *TR

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 20 MPH, THE ENGINE STALLED AND THE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS RESTARTED AND RESUMED NORMALLY. THE FAILURE OCCURRED FOUR TIMES. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSIS. THE TROUBLE CODES DETECTED A FAULTY THROTTLE BODY. THE VEHICLE HAD NOT BEE REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 62,000.

WHILE TRAVELING ON THE HIGHWAY AT APPROXIMATELY 75 MPH IN A 2006 FORD EXPEDITION, THE VEHICLE'S ENGINE SUDDENLY AND WITHOUT WARNING SHUT DOWN. DUE TO THE LOSS OF POWER, THE STEERING AND BRAKES WERE EXTREMELY DIFFICULT TO CONTROL. THE VEHICLE COASTED ON THE HIGHWAY UNTIL I WAS SAFELY ABLE TO DIRECT THE VEHICLE TO THE SIDE OF THE ROADWAY. AFTER STOPPING AND PARKING THE VEHICLE SAFELY, I WAS ABLE TO RESTART THE VEHICLE WITHOUT FURTHER INCIDENT. THIS OCCURED A TOTAL OF THREE TIMES IN MONTHS THAT FOLLOWED. I TOOK THE VEHICLE TO A FORD DEALERSHIP AND THEY COULD NOT FIND A PROBLEM WITH THE VEHICLE. AFTER RESEARCHING THE INCIDENT ONLINE, I LEARNED THAT THE THROTTLE CONTROL SWITCH MAY HAVE BEEN THE CAUSE OF THE PROBLEM. I NOTIFIED THE DEALERSHIP OF MY RESEARCH AND THEY DID NOT AGREE. I REPLACED THE SWITCH ON MY OWN AND I HAVE NOT ENCOUNTERED ANY ADDITIONAL ENGINE FAILURES SINCE. *TR

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED WHILE DRIVING AND DEPRESSING THE BRAKES IN ORDER TO STOP THE VEHICLE, IT ACCELERATED. RECENTLY, THE CONTACT BEGAN TO DRIVE IN REVERSE OUT OF A PARKING SPACE AND THE VEHICLE ACCELERATED AND CRASHED INTO ANOTHER VEHICLE. THE POLICE WERE NOTIFIED BUT A REPORT WAS NOT FILED. THERE WERE NO INJURIES ASSOCIATED WITH THE CRASH. THE VEHICLE WAS NOT INSPECTED BY A DEALER NOR AN INDEPENDENT MECHANIC. THE MANUFACTURER WAS CONTACTED AND THEY OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 49,000. THE CURRENT MILEAGE WAS APPROXIMATELY 69,000. *TR

RELATING TO ARTICLE HTTP://EDITORIAL.AUTOS.MSN.COM/BLOGS/AUTOSBLOGPOST-ROS.ASPX?POST=9D5D443C-A8B6-43A1-8CC6-5942B4C36E39&ICID=AUTOS_4051 MY VEHICLE HAS EXPERIENCED THE SAME ISSUE DOZENS OF TIME. I TOOK THE VEHICLE TO A DEALERSHIP, GUS MACHADO FORD IN MIAMI, FL AND MENTIONED THIS ISSUE. I WAS TOLD THEY WERE NOT AWARE OF THE PROBLEM WITH THE CAR GOING INTO ENGINE FAILSAFE MODE AND LOOSING POWER WHILE THE VEHICLE WAS STILL RUNNING. THE VEHICLE WAS UNDER FACTORY WARRANTY AT THAT POINT AND THEY REFUSED TO FIX IT. AT THAT TIME, I WAS NOT REALLY AWARE OF THE PROBLEM. AFTER IT HAPPENED AGAIN AND AGAIN, I DID SOME RESEARCH ONLINE AND FOUND OUT THAT THOUSANDS OF OWNERS ARE HAVING THE SAME PROBLEM. AT THE TIME THE VEHICLE WAS OUT OF FACTORY WARRANTY. I CONTACTED FORD A COUPLE OF YEAR AGO AND AGAIN THEY TOLD ME THEY WERE NOT AWARE OF THE PROBLEM, EVEN IF THEY ARE HUNDREDS AND HUNDREDS OF OWNERS THAT HAVE REPORTED THIS PROBLEM TO FORD AS DESCRIBED IN DIFFERENT BLOGS ONLINE. WHEN THIS HAPPENS, I HAVE TO FIND A PLACE TO STOP SINCE THE VEHICLE DOES NOT RESPOND TO THE GAS PEDAL EVEN IF IT IS STILL RUNNING. THE VEHICLE MUST BE TURNED OFF AND STARTED AGAIN. THIS IS A HUGE SAFETY CONCERN FOR ME A MY FAMILY, EVEN MORE NOW WITH A NEWBORN. IF IT HAPPENS WHILE ON THE EXPRESSWAY OR HIGHWAY, WE CAN BE REAR ENDED BY ANOTHER DRIVE OR TRUCK SINCE THE VEHICLE LOOSES POWER AND THE VEHICLE MUST BE TURNED OFF. HERE IN MIAMI, THERE IS A LOT OF CONSTRUCTION GOING ON AND HIGHWAYS ARE BEING EXPANDED. MUST OF THE CONSTRUCTION HAS ELIMINATED THE EMERGENCY LANE, WHICH MEANS THAT IF THAT HAPPENS, WE ARE GOING TO BE STRANDED IN THE MIDDLE OF THE HIGHWAY. I CONTACTED FORD AGAIN A FEW WEEKS AGO AND MENTIONED THE PROBLEM AGAIN, THEY STILL ""DON'T KNOW"" ABOUT THIS EVEN IF IT IS BEING INVESTIGATED BY THE NHTSA. PLEASE HELP. MY VEHICLE IS A FORD EXPEDITION 2006. *TR

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 25 MPH, THE ENGINE LOST POWER. THE CONTACT ALSO STATED THAT THE ACTIVATING FAIL SAFE MODE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO A MECHANIC FOR DIAGNOSIS. THE MECHANIC WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE MILEAGE WAS 71,000.

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, THE TRANSMISSION SLIPPED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR INSPECTION AND THEY STATED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 130,000. *TR

ON 1/9/2013, I WAS DRIVING AT APPROX. 35 MPH WHEN THE ENGINE TURNED ITSELF OFF. I ATTEMPTED RESTARTING THE ENGINE TO NO AVAIL. I COASTED TO THE SIDE OF THE ROAD WHERE THE ENGINE STILL WOULD NOT START. AFTER WAITING ABOUT FIVE MINUTES, I WAS ABLE TO RESTART THE ENGINE. THE CAR SEEMED TO RUN SLOWLY ON THE WAY BACK HOME. THE NEXT TIME I DROVE THE CAR, IT SEEMED TO RUN NORMALLY. ON 2/12/2013, MY WIFE WAS DRIVING THE CAR AT 25 MPH WHEN THE ENGINE DIED AGAIN. SHE HAD TO COAST TO THE SIDE OF THE ROAD & WAIT TO RESTART THE CAR. SHE SLOWLY DROVE BACK HOME WITH THE VEHICLE. NEXT TIME THE CAR WAS TAKEN OUT, IT RAN NORMALLY. I AM CONCERNED THAT THIS PROBLEM COULD OCCUR ON THE INTERSTATE HIGHWAYS AT A HIGHER SPEED & THE RESULT COULD HAVE BEEN VASTLY DIFFERENT. *TR

THIS IS THE 1ST COMPLAINT ON THIS ISSUE. WHILE DRIVING DOWN THE ROAD, THE ENGINE FAIL SAFE MODE ENGAGES, THE ENGINE LOSES POWER, FOR NO APPARENT REASON. YOU PULL OVER IF YOU CAN. PUT THE VEHICLE IN PARK. TURN EVERYTHING OFF. SHUT OFF ENGINE. RESTART AND IF YOU ARE LUCKY, PUT IT IN DRIVE AND CONTINUE ON. THIS IS VERY DANGEROUS, IF SOMEONE IS TAILGATING YOU AND THIS HAPPENS, THEY COULD REAR END YOUR VEHICLE AND PEOPLE COULD HAVE A MAJOR ACCIDENT AND DIE. THIS HAS HAPPENED 4 TIMES NOW. THERE'S ARE HUNDREDS OF COMPLAINTS ON THIS ISSUE ONLINE. THANK YOU. *TR

ENGINE LOST THROTTLE CONTROL, REDUCED TO IDLE AND THEN STALLED. I COASTED OFF ROAD, AND RESTARTED AFTER 2 ATTEMPTS. *TR

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 20-60 MPH, THE SAFE MODE OPERATION ENGAGED AND CAUSED THE VEHICLE TO STALL. THE VEHICLE WAS TAKEN TO THE DEALER AND AN INDEPENDENT MECHANIC FOR DIAGNOSIS, AND NEITHER WAS ABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 70,000. THE CURRENT MILEAGE WAS APPROXIMATELY 98,000. THE VIN WAS UNAVAILABLE. .. UPDATED 02-07-13 *BF UPDATED 02/13/2013 *JS

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THAT WHILE ATTEMPTING TO STOP AT A TRAFFIC STOP, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE THROTTLE BODY WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 85,000 AND THE CURRENT MILEAGE WAS 94,000.

TWICE IN LAST WEEK, DRIVING AT SLOW SPEED AND "ENGINE FAIL SAFE MODE" LIGHT COMES ON. LOST POWER, BRAKING, AND STEERING. FORCED TO PUT CAR IN NEUTRAL WHILE CAR WAS ROLLING TO RESTART. ROLLED RIGHT THRU STOP SIGN. RESTARTED FINE, LUCKILY. IN SECOND EVENT, ALMOST GOT HIT WHEN TURNING LEFT ACROSS ONCOMING TRAFFIC! STARTED TURN AND COULDN'T STOP TURN DUE TO LOSS OF BRAKING. FORTUNATELY, FIRST TIME I TRIED THE RESTART IN NEUTRAL AND IT WORKED, OTHERWISE I WOULD HAVE BEEN HIT IN SECOND EVENT OR HIT SOMETHING SINCE I COULDN'T STEER. *TR

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THAT THE VEHICLE STALLED WHILE DRIVING 75 MPH. THE WARNING LIGHT STARTED TO ILLUMINATE AND SHOWED THAT THE ENGINE FAIL SAFE MODE HAD ENGAGED. THE VEHICLE WAS TAKEN TO THE DEALER WHO PREVIOUSLY RAN A DIAGNOSTIC TEST BUT COULD NOT FIND A FAILURE. THE CONTACT WAS ABLE TO SECURE AN APPOINTMENT TO HAVE THE DEALER FURTHER INSPECT THE VEHICLE. THE MANUFACTURER WAS NOTIFIED AND A COMPLAINT WAS FILED. THERE WERE NO RECALLS FOR THE FAILURE. THE FAILURE MILEAGE WAS 140,000.

I BOUGHT MY TRUCK USED FROM A DEALERSHIP IN JANUARY 2012. I HAD DRIVEN IT FOR ABOUT 8 WEEKS WHEN IT COMPLETELY DIED ON ME AT A STOP LIGHT BEFORE TAKE OFF. EVERYTHING WAS ON EXCEPT IT WOULD NOT GO AND THE MESSAGE CAME UP SAYING FAIL SAFE MODE. IT DID IT A COUPLE WEEKS LATER TAKING OFF FROM A STOP SIGN AND THEN AFTER THAT IT SEEMED TO DO IT ONCE A MONTH. THIS LAST TIME ON FRIDAY OCTOBER 26, 2012 IT DID IT WHILE I WAS PULLING OUT OF A STORE INTO THE MIDDLE OF TRAFFIC. I WAS LUCKY ENOUGH MY 3 YEAR OLD SON WAS NOT IN THE CAR TO WHERE IT WOULD HAVE HURT HIM AS WELL AS OTHERS AND MYSELF. I HAVE READ MANY ARTICLES AND COMPLAINTS FROM OTHER EXPEDITION OWNERS ABOUT THE EXPEDITIONS GOING INTO FAIL SAFE MODE IN THE MIDDLE OF TRAFFIC. IT IS VERY CONCERNING THAT THEY DO THIS AND THE DEALERSHIP HAS EVEN MADE COMMENTS ABOUT IT WHEN IT WAS EXAMINED. MY MOTHER WORKS FOR FORD AND SHE HAS SEEN MULTIPLE ISSUES WITH THIS. FORD NEEDS TO ISSUE A RECALL ON THESE HOWEVER THEY WILL NOT SEE ANYTHING WRONG UNLESS MULTIPLE PEOPLE ARE INJURED OR EVEN DEAD. IT IS FRUSTRATING TO KNOW I PAID OVER $20,000 ON A VEHICLE THAT I LOVE AND NEED BUT IS NOT SAFE FOR MYSELF AND MY FAMILY. I HAVE PRICED A THROTTLE BODY WITH MY MOTHER'S DISCOUNT AT WORK AND IT WAS ABOUT $210.00 AFTER TAX AND THE LABOR TO PUT IT IN IS AROUND $450.00. IF FORD WOULD FIX THIS PROBLEM PEOPLE WOULD NOT HAVE TO PAY SO MUCH JUST TO BE SAFE IN A VEHICLE THEY SPEND SO MUCH MONEY. PLEASE LOOK INTO ISSUING SOMETHING AGAINST THIS VEHICLE PROBLEM SO THAT OTHERS ARE SAFE. *TR

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THAT THE VEHICLE WENT INTO SAFE MODE AT 65 MPH AND STALLED. THE FAILURE OCCURRED WITHOUT WARNING. THE CONTACT MENTIONED THAT THE FAILURE OCCURRED ON THREE DIFFERENT OCCASIONS AND THE CHECK ENGINE LIGHT ILLUMINATED IMMEDIATELLY AFTER THE FAILURE. THE VEHICLE WAS TAKEN TO THE DEALER AFTER THE FIRST FAILURE AND THE CATALYTIC CONVERTER WAS REPLACED. THE REMEDY FAILED TO REPAIR THE PROBLEM. THE VEHICLE WAS TAKEN TO A MECHANIC THE SECOND TIME WHO DIAGNOSED THAT THE CATALYTIC CONVERTER HAD FAILED AGAIN AND NEEDED TO BE REPLACED. THE FAILURE MILEAGE WAS UNKNOW AND THE CURRENT MILEAGE WAS 96,000.

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THAT THE CHECK ENGINE WARNING LIGHT ILLUMINATED ON THE DASHBOARD. IN ADDITION, THE VEHICLE WOULD STALL SPORADICALLY WHILE DRIVING 30 MPH. THE CONTACT TOOK THE VEHICLE TO A DEALER WHERE THE DEALER ADVISED THAT THE WIRING HARNESS NEEDED TO BE REPLACED. AFTER THE WIRING HARNESS WAS REPLACED, THE VEHICLE CONTINUED TO STALL SPORADICALLY. THE CONTACT TOOK THE VEHICLE BACK TO THE DEALER AND THE DEALER ADVISED THAT THE ENGINE NEEDED TO BE REPLACED. THE CONTACT HAD THE VEHICLE TOWED TO ANOTHER DEALER FOR A SECOND OPINION AND THE SECOND DEALER ADVISED THAT THE ENGINE NEEDED TO BE REPLACED. THE FAILURE MILEAGE WAS 82,000.

I WAS DRIVING ON A TWO LANE HIGHWAY, FM 185. I WAS DRIVING NORTHEAST WHILE THE OTHER DRIVER WAS SOMEWHAT STOPPED HEADING WEST, TRYING TO TURN SOUTH ONTO CATTLE DRIVE. THE OTHER DRIVER WAS STOPPED AT AN INTERSECTION AWAITING TO TURN LEFT. THE OTHER DRIVER TURNED LEFT IN FRONT OF ME AS I WAS HEADED STRAIGHT. THE INITIAL IMPACT WAS DRIVER'S FRONT SIDE AND THEN DOWN THE DRIVERS SIDE DOOR. WE HIT, AND THEN MY VEHICLE DID A 180 DEGREE TURN WHICH TURNED MY VEHICLE AROUND FACING MY INITIAL PATH OF DIRECTION. MY AIRBAGS DID NOT DEPLOY. I HAD CURTAIN SIDE AIRBAGS, DRIVER, AND PASSENGER AIR BAGS AS WELL. THE AIRBAGS OF THE CAR CAUSING THE ACCIDENT DID DEPLOY. *TR

MY 2006 FORD EXPEDITION HAS SHUT OFF MULTIPLE TIMES SINCE THE SUMMER OF 2010. IT WAS SERVICED IN THE SUMMER OF 2010 AND RAN FINE FOR A WHILE. IN 2011, IT STARTED CUTTING OFF AT RANDOM TIMES. I COULD BE AT A STOP LIGHT, INTERSECTION, DRIVING, OR TURNING THE CORNER. I HAVE HAD THE VEHICLE TESTED ABOUT 3 TIMES OVER THE LAST YEAR AND NO ONE CAN SEEM TO FIGURE OUT THE PROBLEM. THE SCARIEST INCIDENT HAPPENED WHILE I WAS MAKING A LEFT TURN AT A BUSY INTERSECTION AND THE VEHICLE SHUT OFF AND THE POWER STEERING WENT OUT. I TURNED ON THE HAZARD LIGHT, PUT THE CAR IN PARK AND STARTED IT VERY QUICKLY. THE VEHICLE STARTED UP WITH NO PROBLEM. LUCKILY NO ONE WAS BEHIND ME OR COMING TOWARDS ME. THIS PROBLEM NEEDS TO BE FIXED. I HAVE READ MULTIPLE POST ABOUT THIS PROBLEM AND FORD HAS NOT RECALLED THE VEHICLE YET. PLEASE HELP! *TR

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THAT VEHICLE STALLED WITH THE ILLUMINATION OF THE CHECK ENGINE WARNING LIGHT. THE VEHICLE WAS TAKEN TO A REPAIR SHOP WHERE A DIAGNOSTIC WAS PERFORMED. THE CONTACT WAS ADVISED THAT CYLINDERS 5, 6 AND 8 HAD MISFIRED. THE CONTACT REPLACED THE THREE SPARK PLUGS HOWEVER, TOW BECAME FRACTURED. ONLY ONE OF THE FRACTURED SPARK PLUGS WAS REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO OFFERED TO ASSIST THE CONTACT WITH THE REPAIR. THE FAILURE MILEAGE WAS 109,000. THE CURRENT MILEAGE WAS 109,889. THE VIN WAS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT WAS TRAVELING 55 MPH WHEN THE ENGINE FAIL SAFE MODE WARNING LIGHT ILLUMINATED, CAUSING THE VEHICLE TO LOOSE POWER. THE VEHICLE WAS TAKEN TO THE DEALER AND THE CONTACT WAS TOLD THAT THE THROTTLE BODY NEEDED TO BE REPLACED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND THE CURRENT MILEAGES WERE 113,000.

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THAT WHILE DRIVING 55 MPH THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO THE DEALER WHO WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE AND REFERRED HIM TO THE DEALER. THE FAILURE MILEAGE WAS 53,754.

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, THE VEHICLE STALLED AND THE ENGINE ENGAGED IN FAIL SAFE MODE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE AIR CONTROL VALVE WAS DEFECTIVE AND NEEDED TO BE REPLACED. AFTER THE REPAIR, THE VEHICLE FAILED TO ACCELERATE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 107,000. THE VIN WAS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THAT THE COMPRESSOR AND THE AIR CONDITIONING FAILED. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS TOLD THAT THE COMPRESSOR WAS LEAKING, CAUSING THE AIR CONDITIONER FROM FUNCTIONING PROPERLY. THE CURRENT MILEAGE WAS 59,174 AND THE FAILURE MILEAGE WAS UNAVAILABLE.

3RD TIME PROBLEMS WITH SPARK PLUGS AND FUEL INJECTOR....WAS TOLD BY DEALER THAT THIS YEAR MODEL THE INJECTORS ARE BAD FOR STICKING....LEAVING THE OWNER TO PAY FOR REPAIR COST AND THE EXPENSE OF CHANGING FORDS FAULTY SPARK PLUGS. *TR

ENGINE WAS LOSING POWER UNDER LOAD (ONLY WHILE ACCELERATING). NO CHECK ENGINE LIGHT EVER CAME ON. AT 88,000 MILES FIGURED THAT NOT ONLY WILL I REPLACE ALL 8 SPARK PLUGS, BUT WOULD REPLACE ALL 8 COIL PACKS AS WELL. UPON REMOVAL ON THE SPARK PLUGS, 1 SPARK PLUG BROKE (SO FAR) LEAVING THE BOTTOM PIECE INSIDE THE HEAD. FORD KNOWS ABOUT THIS PROBLEM, AS IT CAN LEAD MANY LIKE MYSELF WITH AN OUTRAGEOUS EXPENSE TO PROPERLY REMOVE THE BROKEN SPARK PLUG AND CAN IN THE LONG RUN DAMAGE THE ALUMINUM HEAD TOO. THEY ARE MOTOR CRAFT PLATINUM (CERAMIC INSIDE) SPARK PLUGS. NAPA SELLS A TOOL TO EXTRACT THE BROKE PLUG OUT. WHY IN THE WORLD THIS IS ALLOWED TO CONTINUE ON WITHOUT A RECALL IS BEYOND ME. FORD KNOWS ABOUT THESE ISSUES AND SHOULD HAVE A MASSIVE RECALL FOR THE ANY VEHICLE THAT CONTAINS THESE SPARK PLUGS, LIKE MY 2006 MODEL WITH A 5.3L DOES. I HAVE CALLED FORD AND FILED A FORMER COMPLAINT AND MANY OTHERS NEED TO DO SO AS WELL. I AM ALSO GOING TO FILE A COMPLAINT WITH THE BBB, AS I SPENT A HUGE CHUNK OF CHANGE AND PROPERLY MAINTAIN MY VEHICLE ON A DAILY BASIS. IF MY TRUCK HAS TO GO INTO A REPAIR SHOP TO HAVE THIS PLUG REMOVED, I WILL BE VERY DISAPPOINTED IN FORD'S CUSTOMER SERVICE. I HAVE 4 FORDS TODAY.......NOTHING HAS EVER BEEN THIS COSTLY! I HAVE A 71 BRONCO, 98 EXPLORER, 01 RANGER, AND 06 EXPEDITION. I GUESS THIS WILL DETERMINE IF I WILL STAY AS A FORD OWNER IN THE FUTURE. *TR

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH, THE ENGINE STALLED WITH THE WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS COASTED TO THE SIDE OF THE ROAD AND THE ENGINE TURNED OFF. THE VEHICLE RESTARTED AND RESUMED NORMALLY. THE VEHICLE HAD NOT BEEN DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 80,000.

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THAT SOMEONE BROKE INTO THE VEHICLE AS A RESULT OF POORLY MANUFACTURED DOOR HANDLES. THE CONTACT STATED THAT THE DOORS WERE BROKEN INTO BY USING A SCREWDRIVER. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO PROVIDED NO ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 77,000.

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THAT WHILE DRIVING 70 MPH THE VEHICLE STALLED AND THE FAIL SAFE MODE WARNING LIGHT ILLUMINATED. THE CONTACT WAS ABLE TO RESTART THE ENGINE AFTER SEVERAL MINUTES. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE DEALER WAS ALSO CONTACTED WHO ADVISED THE CONTACT THAT THE THROTTLE COULD HAVE FAILED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 102,000.

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THAT WHILE THE BRAKES WERE DEPRESSED, THE ENGINE SAFE MODE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS CONTACTED BUT THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 79,000.

I WAS ON HWY DOING 55 GETTING READY TO TAKE MY TURN OFF WHEN ENGINE SAFE MODE MESSAGE CAME ON. I THEN REALIZED THAT I HAD NO POWER EVEN THOUGH LIGHTS, RADIO, AND A/C WAS STILL ON. NOT BEING ABLE TO ACCELERATE I COASTED THE VEHICLE TO SIDE OF HWY AS FAR AS POSSIBLE, TURNED KEY TO OFF AND THAN BACK ON AND IT STARTED UP. I WAS ABLE TO GET HOME WITHOUT FURTHER PROBLEM AND BACK TO WORK. UNFORTUNATELY I HAVE A 45 MINUTE DRIVE EVERY NIGHT AND EARLY MORNING TO AND FROM MY WORK WHICH IT COULD HAPPEN AGAIN AND NOT HAVE SUCH A GOOD CIRCUMSTANCE. THERE HAVE BEEN SEVERAL COMPLAINTS OVER SEVERAL YEARS TO FORD ON THIS WHY HAS IT NOT BEEN RECALLED? *JS

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, THE VEHICLE STALLED IN THE MIDDLE OF THE ROAD. THE VEHICLE WAS SAFELY MERGED ONTO THE SHOULDER AND THE CONTACT TURNED THE ENGINE OFF. THE CHECK ENGINE LIGHT ILLUMINATED PRIOR TO THE FAILURE. THE VEHICLE WAS TAKEN TO THE DEALER, WHO REPLACED THE OXYGEN SENSOR, SPARKS PLUGS, AND ENGINE COILS. THE FAILURE CONTINUED. THE VEHICLE WAS TAKEN BACK TO THE DEALER AND THE CATALYTIC CONVERTER WAS REPLACED. THE FAILURE CONTINUED. THE CONTACT PLANNED ON TAKING THE VEHICLE BACK TO THE DEALER. THE MANUFACTURER WAS NOTIFIED AND STATED THAT THERE WERE NO RECALLS ADDRESSING THE FAILURE. NO FURTHER ASSISTANCE WAS OFFERED. THE FAILURE MILEAGE WAS 109,000.

MY CUSTOMER CALLED TO INFORM ME THAT HE WAS SMELLING RAW FUEL INSIDE THE VEHICLE ON APRIL 13,2012. I TOLD HIM IT WAS PROBABLY A STUCK INJECTOR. BEING A FORD SENIOR MASTER CERTIFIED AUTO REPAIR TECHNICIAN/ASE MASTER CERTIFIED FOR FORD DEALERSHIPS FOR OVER 14 YEARS I WAS AWARE OF THE INJECTOR CONCERNS WITH THESE VEHICLES. I CHECKED THE ENGINE OIL TO FIND THAT IT WAS OVERFILLED A QUART AND SMELLED OF FUEL. MY DIAGNOSIS WAS CORRECT #2 INJECTOR WAS LEAKING BADLY. I REPLACED #2 INJECTOR AND CHANGED THE OIL,FOUND SMALL SHARDS OF RUST IN THE INJECTOR THAT COULD ONLY HAVE COME FROM THE FUEL RAIL AS THEY WERE TOO LARGE TO HAVE BY-PASSED THE FUEL FILTER. 2005 F SERIESEXPEDITIONS/NAVIGATORS HAD A RECALL ON INJECTORS AND THE 2006-2007 VEHICLES SHOULD HAVE HAD THE RECALL. THIS COULD BE A POTENTIAL FIRE HAZZARD CAUSING MAJOR ENGINE DAMAGE IF IT OCCURS AGAIN.RESEARCH ONLINE AND FOUND THAT THOUSANDS OF FORD EXPEDITION,LICOLN NAVIGATOR AND F-150-250 OWNERS HAVE HAD THE SAME PROBLEMS WITH INJECTORS. I AM ALSO AWARE OF A RECALL THAT WAS ON CERTAIN EXPEDITIONS AND NAVIGATORS FOR A NEW FUEL RAIL THAT WAS RUSTING INTERNALLY CAUSING THE SAME PROBLEMS BUT THE RECALL JUST CLAIMS THAT THE FUEL RAILS WERE "DEFECTIVE".FORD MOTOR COMPANY IS AWARE OF THESE CONCERNS AND REFUSES TO RESOLVE OR HELP ANY OWNERS OF THE AFFECTED VEHICLES OUTSIDE THE RECALL. IF THESE VEHICLES ARE ALLOWED TO CONTINUE TO OPERATE WITHOUT BEING PROPERLY REPAIRED EVENTUALLY SOMEONE IS GOING TO BE INJURED OR WORSE. I HAVE WITNESSED ENGINE EXPLOSIONS AND FIRES CAUSED BY LEAKING INJECTORS. THIS IS CLEARLY A MANUFACTURE DEFECT AND SHOULD BE ADRESSED BY FORD MOTOR COMPANY.I URGE ANY FORD OWNERS WITH THIS PROBLEM TO FILE A CLAIM WITH NHTSA AS WELL AS FORD MOTOR COMPANY SO THEY CAN RESOLVE THESE CONCERN BEFORE ANYONE IS HARMED.ALL MY CUSTOMER WANTS IS THE FUEL RAIL AND INJECTORS REPLACED. *TR

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT WAS DRIVING 55 TO 65 MPH WHEN THE ENGINE SAFE MODE WARNING LIGHT ILLUMINATED AND THE ENGINE STALLED. THE VEHICLE RESTARTED AFTER THE FAILURE. THE FAILURE OCCURRED SEVEN DIFFERENT TIMES. THE VEHICLE WAS TAKEN TO THE DEALER. THE MANUFACTURER WAS ALSO NOTIFIED. THE VEHICLE WAS NOT REPAIRED AND THE VIN WAS UNKNOWN. THE FAILURE AND CURRENT MILEAGES WERE UNKNOWN.

2006 FORD EXPEDITION LIMITED. CONSUMER WRITES IN REGARDS WARRANTY REPAIR DISPUTE AND DRIVER'S SIDE POWER WINDOW BEING EXTREMELY SLOW IN THE CLOSING OPERATION *TGW THE DEALER LUBED THE WINDOW AND STATED THERE WAS NO PROBLEM FOUND. AFTER COMPLAINING SEVERAL TIMES ABOUT THE WINDOW, THE DEALER FINALLY DETERMINED THERE WAS A PROBLEM. HOWEVER, THE CONSUMER WAS INFORMED THE PARTS AND LABOR WERE NOT COVERED UNDER THE EXTENDED WARRANTY. THE CONSUMER STATED THE PROBLEM EXISTED GOING BACK TO DEC 11, 2006 AND THE DEFECT WAS NOT ADDRESSED OR CORRECTED WHILE THE VEHICLE WAS UNDER THE ORIGINAL FACTORY WARRANTY. THE CONSUMER STATED HE SHOULD NOT BE RESPONSIBLE FOR REPAIRS THAT WERE CALLOUSLY OVERLOOKED AND IGNORED BY THE DEALER. ALSO, THE LOWER RADIATOR SUPPORT TO THE BODY MOUNT WAS SEVERELY RUSTED AND SHOWED SIGNS OF ACTUAL MATERIAL FAILURE. THE CONSUMER STATED THE CONDITION CAN AND WILL EVOLVE INTO THE ROOT CAUSE OF BOTH MECHANICAL AND SAFETY RELATED FAILURES. THE MAJOR BODY AND FRONT FRAME SUPPORT FAILING UNDER DRIVING CONDITIONS COULD LEAD TO ENGINE FAILURE, AND LOSS OF CONTROL OF THE VEHICLE. THE MOST SERIOUS SAFETY CONCERN, WAS THE FRONT BRAKE LINES WHICH WERE SHOWING SIGNS OF SERIOUS RUST. THE DEALER INFORMED THE CONSUMER THE LINES COULD ONLY BE REPLACED UNDER WARRANTY IF THERE WERE SIGNS OF LEAKAGE. THE CONSUMER STATED CORROSION IN THE FORM OF RUST WOULD COMPROMISE THE INTEGRITY OF THE STEEL BRAKE LINES, ALLOWING BRAKE FLUID TO LEAK OUT RESULTING IN A TOTAL LOSS OF BRAKING POWER. THE LEFT REAR DOOR WOULD NOT OPEN FROM THE INSIDE, THE DRIVER'S FRONT DOOR HAD TO BE SLAMMED IN ORDER FOR IT TO CLOSE PROPERLY, THE FRONT AXLE DRIVE PINION WAS LEAKING AND HAD TO BE REPLACED.*JB

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THAT THE VEHICLE DECELERATED AND ENTERED INTO FAIL SAFE MODE WHILE DRIVING 55 MPH. THE VEHICLE WOULD NOT ACCELERATE FURTHER ONCE IT ENTERED FAIL SAFE MODE. THE CONTACT SHUT THE VEHICLE OFF AND UPON RESTART, THE VEHICLE OPERATED AS NORMAL. THE FAILURE RECURRED ONCE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THE CONTACT WAS INFORMED THAT THE THROTTLE BODY NEEDED TO BE REPLACED. THE VEHICLE WAS IN THE PROCESS OF BEING REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 103,000. UPDATED 8/23/12 *CN UPDATED 09/06/2012 *JS

I HAVE THIS PROBLEM WHERE MY TRUCK IS LOSING POWER AND THEN DYING WHILE I AM DRIVING. THIS IS VERY DANGEROUS ON THE ROADWAYS. I HAVE A SPECIAL NEEDS CHILD AND GRAND CHILDREN THAT I TRANSPORT. FORD NEEDS TO RECALL THESE TRUCKS AND FIX THEM. *TR

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THAT THE VEHICLE STALLED WHILE DRIVING AT VARIOUS SPEEDS AND THE ENGINE SAFE MODE WARNING INDICATOR ILLUMINATED. THE CONTACT STATED THAT THE FAILURE OCCURRED ON THREE PRIOR OCCASIONS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHO WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT OFFERED NO ASSISTANCE AND REFERRED THE CONTACT TO NHTSA. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 82,000.

ENGINE FAIL SAFE MODE RESULTING IN COMPLETE SHUTDOWN WHILE GOING AT HIGHWAY SPEED. VEHICLE LOSSES ALL POWER AND HAS TO BE RESTARTED. *TR

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THAT THE VEHICLE WOULD ONLY SHIFT INTO REVERSE. UPON EXAMINING THE VEHICLE, THE CONTACT NOTICED THAT A WIRING HARNESS WITHIN THE ENGINE MELTED AGAINST THE EXHAUST MANIFOLD. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THE CONTACT WAS INFORMED THAT THE WIRING HARNESS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 90,000.

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THAT THE VEHICLE STALLED NUMEROUS TIMES WITH THE ILLUMINATION OF THE CHECK ENGINE LIGHT AFTER THE FAILURE OCCURRED. THE VEHICLE WAS TAKEN TO THE DEALER AND A DIAGNOSTIC WAS PERFORMED, WHICH LOCATED THE FAILURE AT THE THROTTLE BODY. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 88,000.

WHILE INFLATING TIRES DURING A SERVICE THE CUSTOMER'S VALVE STEM BROKE. *TR

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. WHILE DRIVING APPROXIMATELY 25 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE FAILURE RECURRED SPORADICALLY AND AT DIFFERENT SPEEDS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTICS. THE CONTACT WAS NOT AWARE OF THE REPAIRS NEEDED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 40,000.

TL* THE CONTACT OWN A 2006 FORD EXPEDITION. THE CONTACT STATED WAS DRIVING 25 MPH WHEN THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS RESTARTED AND THE CONTACT DROVE THE VEHICLE HOME. THE CONTACT ATTEMPTED TO RESTART THE VEHICLE BUT TO NO AVAIL. THE CONTACT HAD THE VEHICLE TOWED TO A DEALER WHERE THE DEALER REPLACED THE CAM PHASERS. THE FAILURE MILEAGE WAS 160,000. THE VIN WAS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THAT WHILE DRIVING 15 MPH ON THE HIGHWAY, THE VEHICLE UNEXPECTEDLY STALLED. AN ENGINE FAIL SAFE LIGHT ALSO BEGAN TO ILLUMINATE ON THE INSTRUMENT PANEL. BOTH THE DEALER AND MANUFACTURER WERE NOTIFIED, BUT DENIED ANY ASSISTANCE WITH REPAIRS OF THE FAILURE. THE VEHICLE WAS ON 01/06/12 AT THE CONTACT'S EXPENSE. THE APPROXIMATE FAILURE AND CURRENT MILEAGES WERE 86,280. THE THROTTLE BODY AND MOTOR ASSEMBLY WERE REPLACED. UPDATED 06/27/12*JB

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. WHILE DRIVING APPROXIMATELY 40 MPH, THE ENGINE STALLED WITH THE ILLUMINATION OF THE CHECK ENGINE WARNING INDICATOR. THE ENGINE RESTARTED AFTER WAITING A FEW MOMENTS. THE SAME FAILURE RECURRED FOUR TIMES. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THEY WERE UNABLE TO DUPLICATE THE PROBLEM. THE MANUFACTURER WAS NOTIFIED OF THE MALFUNCTION. THE APPROXIMATE FAILURE MILEAGE WAS 90,000.

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THAT WHEN DRIVING AT VARIOUS SPEEDS, THE ENGINE SAFETY MODE FAILURE WARNING LAMP WOULD ILLUMINATE AND THE VEHICLE WOULD STALL. THE CONTACT MENTIONED THAT THE FAILURE OCCURRED THREE TIMES. THE VEHICLE WAS TAKEN TO THE DEALER WHO WAS UNABLE TO DUPLICATE THE FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 117,000.

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THAT WHILE DRIVING 70 MPH THE VEHICLE WENT INTO ENGINE FAIL SAFE MODE AND STALLED WITH WARNING. THE VEHICLE WAS LEFT WITH BRAKES, BUT THE VEHICLE WOULD NO LONGER ACCELERATE AND LOSS POWER STEERING. THE VEHICLE WAS TAKEN TO THE DEALER AND IT WAS DETERMINED THAT THE THROTTLE ACTUATOR SENSOR FAILED ON THE VEHICLE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE AND CURRENT MILEAGES WERE 150,000.RL

A WARNING LIGHT "ENGINE FAIL SAFE" FLASHED AND THE ENGINE STALLED. I WAS FORTUNATE THERE WAS A PARKING LOT I COULD FORCE THE VEHICLE INTO, AS I WAS IN MORNING RUSH HOUR TRAFFIC IN HOUSTON TX, AND WAS ALMOST REAR ENDED. APPARENTLY THIS IS A VERY COMMON PROBLEM AMONG THE 2006 FORD EXPEDITION, I HAVE DONE SOME RESEARCH ON-LINE AND VIEWED MANY COMPLAINTS ABOUT THIS SAME THING. I CHECKED WITH ONE AUTO SHOP, WHICH SAYS THE THROTTLE BODY NEEDS TO BE REPLACED AT A COST OF $800.00, THE FORD DEALER/SERVICE DEPT QUOTED 686.85. THEY BOTH TOLD ME THEY EACH HAVE ANOTHER 2006 EXPEDITION IN THEIR SHOP AT THIS TIME FOR THE SAME REPAIR, AND HAVE HAD SEVERAL REPAIRS FOR THIS SAME ISSUE. I BELIEVE THIS IS A VERY DANGEROUS DEFECT WITH AN ENGINE SHUTTING DOWN WITH ONLY A HALF SECOND NOTICE. I AM GLAD I WAS NOT ON THE FREEWAY (IN HOUSTON!) DOING 60 MPH. MY VEHICLE HAS A LITTLE OVER 38,000 MILES ON IT. *KB

WHILE DRIVING MY 2006 FORD EXPEDITION EDDIE BAUER, THE ENGINE COMPLETELY SHUTS OFF. SOMETIMES WHILE SITTING IDLE AND OTHER TIMES WHILE DRIVING 70 MPH ON THE INTERSTATE. TONIGHT, WITHIN 1 HOUR THIS HAPPENED ABOUT 15 TIMES WHERE THE ENGINE CUT OFF, I LOST POWER STEERING, HAD TO ROLL OVER TO THE SHOULDER, TURN THE KEY OFF AND BACK ON TO RESTART...SOMETIMES IT WOULD TAKE UP TO 10 MINUTES TO RESTART. I WAS LUCKY WE WERE NOT HIT FROM BEHIND. I HAVE 2 KIDS IN CARSEATS STILL THAT COULD HAVE BEEN INJURED. RESEARCH ONLINE REVEALS THAT I AM NOT ALONE. THIS IS A VERY DANGEROUS DEFECT THAT COULD GET SOMEBODY KILLED. *TR

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT WAS DRIVING APPROXIMATELY 10 MPH APPROACHING A STOP SIGNAL AND FROM A COMPLETE STOP, THE ENGINE STALLED WHEN THE WARNING LIGHT ILLUMINATED; HOWEVER, THE VEHICLE RESTARTED WITHIN A FEW MINUTES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND WAS CURRENTLY BEING DIAGNOSED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 71,200.

2006 FORD EXPEDITION. CONSUMER STATES MECHANICAL ISSUES WITH THE VEHICLE *TGW THE DEALER INFORMED THE CONSUMER A NEW ENGINE WAS NEEDED. THE WARRANTY DEPT. DENIED THE CONSUMERS CLAIM, BECAUSE MAINTENANCE RECORDS COULD NOT BE PRODUCED. THE CONSUMER'S HOUSE WAS SET ON FIRE, AND THEREFORE, NO MAINTENANCE RECORDS WERE AVAILABLE. *JB

THE VEHICLE HAS DONE THIS TWICE. DRIVING ALONG, IT GOES INTO FAIL SAFE MODE AND STOPS DEAD. THE MANUAL STATES THIS IS A COOLANT ISSUE WHICH WAS NOT THE CASE; THERE WAS ADEQUATE COOLANT. DOING SOME RESEARCH ON VARIOUS INTERNET SITES, THIS SEEMS TO BE A COMMON PROBLEM WITH 2006 EXPEDITIONS. I CALLED FORD CUSTOMER SERVICE AND WAS TOLD THEY WERE UNAWARE OF A PROBLEM. I FIND THIS DIFFICULT TO BELIEVE GIVEN ALL THE SITES REPORTING THIS SAME ISSUE. *TR

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THAT THE REAR MIDDLE SEAT SAFETY RESTRAINT WOULD DETACH AT ANYTIME. THE DEALER DIAGNOSED NO FAILURE WITH THE REAR SAFETY BELT, BUT THE PASSENGER SEAT WAS REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 79,000 AND THE CURRENT MILEAGE WAS 80,500.

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THAT THE VEHICLE WOULD STALL AT ANYTIME WHILE IN MOTION. THE DEALER ATTEMPTED TO REPAIR THE DEFECT, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE AND THE CURRENT MILEAGE WAS 80,000. UPDATED 02/22/12*LJ THE CONSUMER STATED THE VEHICLE WOULD STALL WHILE AT A STOP. UPDATED 03/01/12

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT WAS DRIVING 20 MPH THE VEHICLE STALLED WITH THE ILLUMINATION OF THE CHECK ENGINE FAIL SAFE LIGHT. THE VEHICLE WAS NOT TAKEN TO THE DEALER TO BE DIAGNOSED OR REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 168,000.

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THAT THE ENGINE FAIL SAFE MODE WARNING LIGHT ILLUMINATED, CAUSING THE VEHICLE TO STALL. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CURRENT MILEAGE WAS 46,000 AND THE APPROXIMATE FAILURE MILEAGE WAS 39,000.

TOOK MY 2006 FORD EXPEDITION LIMITED TO THE DEALERSHIP FOR A TUNE-UP AND WAS TOLD OF AN ISSUE THAT THE 5.4L ENGINES HAVE. THEY MENTIONED THAT SOME 2004-2008 F-150, 2006-2008 MARK LT, 2005-2008 F-SUPER DUTY, EXPEDITION, AND NAVIGATOR, WITH 5.4L 3-V ENGINE; 2005-2008 MUSTANG, 2006-2008 EXPLORER, MOUNTAINEER, AND 2007-2008 EXPLORER SPORT TRAC WITH 4.6L 3-V ENGINE; 2005-2008 F-SUPER DUTY, 2006-2008 AND F-STRIPPED CHASSIS, WITH 6.8L 3-V ENGINE MAY EXPERIENCE DIFFICULTY WITH SPARK PLUG REMOVAL. THIS MAY CAUSE DAMAGE TO THE SPARK PLUG AND LEAVE PART OF THE SPARK PLUG IN THE CYLINDER HEAD. AFFECTED ENGINE BUILD DATES ARE AS FOLLOWS: 5.4L 3-V AND 6.8L 3-V BEFORE 10/9/07, 4.6L 3-V BEFORE 11/30/07. FORD APPERANTLY KNOWS ABOUT THIS SINCE THEY PUBLISHED A TECHNICAL BULLITIN (TSB 08-7-6) TO THE DEALERSHIPS. NOW THE CONSUMER, WHO WAS NEVER TOLD ABOUT THIS WHEN THEY PURCHASE THE VEHICLE HAS TO PAY AN ADDITIONAL COST FOR A STANDARD TUNE-UP. WHEN ASKED WHY, THE SERVICE DEPARTMENT MENTIONED THAT THE COST IS FOR THE REMOVAL OF BROKEN PLUGS THAT THEY KNOW THEY WILL BREAK. WHY WOULD I HAVE TO PAY ADDITIONAL MONEY FOR DAMAGE DONE BY THE SERVICE DEPARTMENT FOR AN ISSUE CREATED BY FORD MOTOR CO. IF THE PLUGS ARE DEFECTIVE AND FORD KNOWS ABOUT THIS, THEY SHOULD BE RESPONSABLE OR A RECALL SHOULD BE ISSUED. THIS TO ME IS FRAUD BY HAVING THE COSTUMER PAY FOR THEIR MISTAKES. *TT

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT WAS DRIVING 55 MPH WHEN THE VEHICLE STALLED. THE ENGINE SAFE MODE LIGHT ILLUMINATED AFTER THE FAILURE AND THE VEHICLE WAS TOWED TO THE DEALER. THE MANUFACTURER WAS CONTACTED TO REPORT THE FAILURE. THE VEHICLE WAS NOT REPAIRED AND THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS 114,000 AND THE CURRENT MILEAGE WAS 116,000.

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT WAS DRIVING 45 MPH WHEN THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE RESTARTED AFTER THE FAILURE BUT WAS NOT TAKEN TO THE DEALER FOR INSPECTION OR REPAIRS. THE MANUFACTURER WAS CONTACTED BUT PROVIDED NO ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS UNAVAILABLE. THE FAILURE AND CURRENT MILEAGES WERE 80,000.

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THAT THE ENGINE FAIL SAFE MODE ACTIVATED WITHOUT WARNING WHILE THE VEHICLE WAS BEING DRIVEN, CAUSING THE VEHICLE TO STALL. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER THREE TIMES AND THEY HAD NOT BEEN ABLE TO DUPLICATE THE FAILURE. THE FAILURE MILEAGE WAS 65,000 AND THE CURRENT MILEAGE WAS 77,000.

2006 FORD EXPEDITION ON 2/2/11 WHILE I WAS DRIVING ON FREEWAY THE VEHICLE GOES INTO "ENGINE FAIL SAFE MODE." NOT KNOWING WHAT THIS MEANT I WAS GOING TO PROCEED TO EXIT UP AHEAD WHICH WAS AN EXIT UP A HILL. WHEN I STEPPED ON THE GAS I REALIZED THE ENGINE WAS OFF. I WAS ABLE TO MOVE SLIGHTLY TO THE LEFT TO STOP ON THE SHOULDER AT THE BOTTOM OF THE EXIT. THIS IS VERY DANGEROUS AND FORD NEEDS TO MAKE A RECALL BEFORE A LIFE IS LOST! *KB

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION EQUIPPED WITH CONTINENTAL CONTITRAC TR TIRES, SIZED 265/70/R17 WITH A DOT NUMBER OF A3T645RW. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 70 MPH, THE TREAD ON THE DRIVERS SIDE REAR TIRE SEPARATED AND THE CONTACT BEGAN TO LOSE CONTROL OF THE VEHICLE. AS A RESULT, EXTENSIVE DAMAGED WAS INFLICTED ON THE REAR BUMPED AND TAIL LIGHTS. THE CONTACT WAS ABLE TO REGAIN CONTROL OF THE VEHICLE. THE MANUFACTURER WAS NOTIFIED AND INFORMED THE CONTACT THAT THERE WERE NO RECALLS FOR THE STATED TIRES. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 60,000.

WHILE DRIVING MY 2006 FORD EXPEDITION ON THE HIGHWAY, THERE WAS A COMPLETE THREAD SEPARATION IN ONE OF THE REAR TIRES, (CONTINENTAL, CONTITRAC SUV, P265-70R17), THE TRIMMING BEHIND THE TIRE WELL WAS DAMAGED. THE VEHICLE'S ODOMETER REGISTERS 43,993 MILES. *TR

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THAT WHILE DRIVING 65 MPH THE VEHICLE STALLED WITHOUT WARNING. THE FAILURE WAS EXPERIENCED ON SEVERAL OCCASIONS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO LOCATED A FAILURE WITHIN THE THROTTLE BODY. THE LOCAL MECHANIC CLEANED THE FUEL SYSTEM AND REPLACED THE THROTTLE SENSOR. THE FAILURE CONTINUED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED A SECOND TIME. THE FAILURE MILEAGE WAS 36,849 AND THE CURRENT MILEAGE WAS 92,000.

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THAT THE SPARK PLUGS WAS CAUSING DAMAGE TO THE ENGINE. THE DEALER ADVISED THE CONTACT TO HAVE THE SPARK PLUGS REMOVED AND REPLACED WITH A DIFFERENT MODEL SPARK PLUG. THE MANUFACTURER WAS AWARE OF THE FAILURE. NO REPAIRS WERE PERFORMED. THE CURRENT AND FAILURE MILEAGES WERE 45,000.

TL*THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THAT CARBON BUILT UP AROUND THE SPARK PLUGS AND HE WAS UNABLE TO REMOVE IT SINCE ONE OF THE SPARK PLUGS FRACTURED IN HALF AND THE OTHER PART WAS STUCK IN THE VEHICLE; HOWEVER, IF HE WERE TO REMOVE THEM IT WOULD CAUSE SERIOUS DAMAGE TO THE ENGINE. THE DEALER ADVISED THE CONTACT TO BRING THE VEHICLE IN FOR SERVICE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS AWARE OF THE FAILURE. THE CURRENT AND FAILURE MILEAGE WAS 104,000. THE VIN WAS UNAVAILABLE.

2006 FORD EXPEDITION INVOLVED IN HEAD ON ACCIDENT AND AIRBAGS DID NOT DEPLOY. FORD EXPEDITION WAS DRIVING SOUTHBOUND ON A FOUR LANE DIVIDED STREET ABOUT 30-35 MPH WHEN A MINIVAN TRAVELING NORTHBOUND BLINDLY TRIED TO MAKE A LEFT TURN INTO A SHOPPING PLAZA AND TURNED RIGHT IN FRONT OF ME. AN RV WAS SITTING IN THE CENTER MEDIAN BLOCKING HER VIEW. I HIT HER PASSENGER REAR SIDE HEAD ON. I HAD 3 CHILDREN IN THE CAR. NO AIRBAGS DEPLOYED. WHY THE HECK DO I EVEN HAVE THEM IF THEY AREN'T GOING TO WORK WHEN NEEDED? I AM CONCERNED ABOUT THE AIRBAGS NOT DEPLOYING. I DON'T FEEL SAFE IN MY EXPEDITION AND I AM AFRAID TO DRIVE IT AGAIN. I DON'T FEEL IT IS SAFE... ISN'T THE SAFETY EQUIPMENT SUPPOSED TO PROTECT US AND KEEP US SAFE AND WORK?? *TR

FALSE ACTIVATION OF "ENGINE FAILURE MODE" SYSTEM. ENGINE WENT TO IDLE SPEED, ALL GAUGES READ NORMALLY AND NO WARNING LIGHTS CAME ON. ENGINE TEMPERATURE WAS IN NORMAL RANGE. "ENGINE FAILURE MODE" MESSAGE WAS DISPLAYED ON MESSAGE PANEL. I WAS ABLE TO SAFELY COAST OFF THE ROAD AND STOP THE VEHICLE. I TURNED THE IGNITION OFF, AND OBSERVED THAT THE ENGINE COOLANT LEVEL IN THE COOLANT TANK WAS NORMAL. I THEN RESTARTED THE ENGINE, AND VEHICLE THEN OPERATED NORMALLY.

TL*THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED WHILE DRIVING 65 MPH THE VEHICLE STALLED WITHOUT ANY WARNING. THE VEHICLE WAS TAKEN TO THE DEALER WHO WAS UNABLE TO DUPLICATE THE FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 80,000 AND THE CURRENT MILEAGE WAS 142,000.

I WAS COMING ACROSS ARIZONA, INTERSTATE 10 IN MY 2006 EXPEDITION HEADING HOME TO SAN DIEGO WHEN MY "ENGINE FAILSAFE MODE" INDICATOR CAME ON, THE ENGINE WARNING LIGHT WAS ON AND SHUT THE ENGINE DOWN. THE ENGINE WARNING LIGHT NEVER WENT OFF UNTIL I TOOK IT TO A MECHANIC THE FOLLOWING MORNING. THE MECHANIC STATED THAT I NEED TO HAVE THE THROTTLE CLEANED OUT AND MAY NEED A NEW SENSOR FOR THE SIDE OF THE THROTTLE REPLACED. I HAVE 59K MILES ON MY VEHICLE AND HAVE THE MAINT. COMPLETED EVERY 4K TO 6K AND HAVE OWNED THIS VEHICLE FROM THE START. I HAD 2 MILES ON THE VEHICLE WHEN WE PURCHASED THIS VEHICLE IN OCT 2005. AFTER READING ABOUT THIS PROBLEM WITH OTHER OWNERS I THINK FORD SHOULD BE ABLE TO REPAIR OR REPLACE THE PROBLEM WITHOUT CHARGING THE CUSTOMER. THIS IS THE SECOND TIME THIS HAS HAPPENED TO ME. BOTH TIMES WE HAD THE CRUISE CONTROL TURNED ON. AFTER STOPPING IN THE MIDDLE PART OF ARIZONA ON THE SIDE OF THE ROAD, WE RESTARTED THE MOTOR AND MADE IT BACK HOME AFTER OUR VACATION. *TR

WAS INVOLVED IN A (3) THREE VEHICLE ACCIDENT IN JANUARY 2011 ON STATE ROUTE 28 ON BLACK ICE CONDITIONS. VEHICLE #1 HIT BLACK ICE AND LOST CONTROL STRIKING MY 2006 FORD EXPEDITION SEVERAL TIMES AND THEN MY EXPEDITION WAS REAR-ENDED BY ANOTHER VEHICLE DURING THE COLLISION. I DID HAVE MY SEAT BELT ON AND LUCKILY WAS NOT SEVERELY INJURED. NEITHER OF MY FRONT AIR-BAGS DEPLOYED AND MY EXPEDITION SUFFERED $14,000 DOLLARS IN FRONT END DAMAGE ALONE. THE AIRBAG SENSOR WAS DAMAGED AND SHOULD OF DEPLOYED THE AIR-BAGS BUT DID NOT. MY VEHICLE WAS REPAIRED BUT REPAIR SHOP AND STATE POLICE WERE BOTH SURPRISED AIR BAGS DID NOT DEPLOY. NOW I AM HAVING PROBLEMS WITH THE AIRBAG SENSOR AS IT LIGHTS UP ALL THE TIME AND NO PROBLEMS CAN BE FOUND WHEN DIAGNOSED. THIS IS A SERIOUS SAFETY CONCERN AND NEED TO BE ADDRESSED. I STILL OWN MY EXPEDITION AND WORRY FOR SAFETY IF ANOTHER COLLISION OCCURS WILL THE AIR-BAGS DEPLOY TO SAVE A LIFE. *TR

TL*THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THE COOLANT HOSE IN THE VEHICLE WAS LEAKING INTO THE VEHICLE. THE FAILURE CAUSED THE RADIATOR TO MALFUNCTION. THE CONTACT TOOK THE VEHICLE DEALER TO HAVE THE HOSE REPLACED, THE DEALER STATED THE HOSE WAS NO LONGER AVAILABLE. THE CONTACT STATED THE VEHICLE WOULD SHUT OFF INTERMITTENTLY DUE TO THE FAULTY HOSE. THE FAILURE MILEAGE WAS 85,000.

THERE IS NO WARNING - MY FORD EXPEDITION JUST GOES INTO ENGINE FAIL SAFE MODE AND SHUTS OFF - NO ABILITY TO STEER, DRIVE ETC. WAS TRAVELING ON HIGHWAY AT HIGHWAY SPEEDS (55+ MPH) WHEN THIS HAPPENED. THE ENGINE FAIL SAFE HAD COME ON BEFORE BUT WAS A BIT SCARY UPON DRIVING AT A SPEED. THE DEALERSHIP STATES THAT THE THROTTLE BODY NEEDS TO BE REPLACED. MY VEHICLE ONLY HAS 55000 MILES ON IT - AND FROM READING OTHER FORUMS I SEE THAT THIS IS A PROBLEM WITH A LOT OF FORD EXPEDITIONS. IT IS IN THE SHOP NOW (AT A COST OF $700) BEING FIXED, I AM GOING TO REQUEST TO HAVE THE OLD PARTS SAVED SO I CAN KEEP FOR FUTURE REFERENCE. I BELIEVE THIS IS A MAJOR DEFECT THAT NEEDS TO BE FIXED AS IT WILL CAUSE A DEATH ONE DAY SOON - AS THE VEHICLE SHUTS OFF DURING DRIVING. *TR

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT WAS DRIVING APPROXIMATELY 55 MPH WHEN THE VEHICLE BEGAN TO DECELERATE INDEPENDENTLY. THE VEHICLE WAS MOVED FROM THE ROADWAY AND WHEN THE CONTAC EXITED, THERE WAS AN ABNORMAL BURNING ODOR AND BLACK SMOKE EMITTING FROM THE TAILPIPE. THE POLICE WERE DISPATCHED AND WHEN THEY ARRIVED AND OPENED THE REAR DRIVER SIDE DOOR, THICK BLACK SMOKE WAS POURING OUT FROM THE INSIDE OF THE VEHICLE. THERE WERE ALSO FLAMES FROM THE INTERIOR AND UNDER THE FRAME. THE FIRE WAS EXTINGUISHED BY THE LOCAL FIRE DEPARTMENT. THE FIRE CHIEF ADVISED THAT THERE WAS A HOLE IN THE FUEL LINE AND AN ELECTRICAL PROBLEM THAT COULD HAVE CAUSED THE FIRE BUT THE RESULTS WERE INCONCLUSIVE. THE VEHICLE WAS TOWED BY THE CONTACTS INSURANCE COMPANY. THE INSURANCE ADJUSTER INFORMED THE CONTACT THAT THE VEHICLE WAS DESTROYED AND THEY WERE UNABLE TO DETERMINE THE CAUSE OF THE FIRE. THERE WERE NO INJURIES. THE MANUFACTURER WAS NOT CONTACTED TO REPORT THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 125,000.

1/8/09 WHILE DRIVING AT 65 MPH ON HIGHWAY VEHICLE'S "ENGINE FAIL SAFE MODE" ALARM SOUNDED & MESSAGE FLASHED ON PANEL. VEHICLE IMMEDIATELY LOST POWER. I WAS ABLE TO COAST TO SHOULDER OF ROAD. TURNED OFF VEHICLE, RESTARTED AND WAS ABLE TO DRIVE APPROXIMATELY 1 1/2 MILES. I WAS IN TURN LANE, STARTED TO TURN LEFT, ALARM SOUNDED, MESSAGE FLASHED AND ALL POWER WAS GONE. I QUICKLY TURNED VEHICLE OFF AND BACK ON TO TRY AND GET OUT OF PATH OF ONCOMING TRACTOR TRAILER. I WAS ABLE TO GET JUST OFF ROADWAY AFTER 15 MINS STARTED VEHICLE, DROVE 4 MILES FAILED AGAIN. IT WAS TOWED TO MECHANIC. AFTER CALLS TO FORD AND FURTHER TESTING THE ELECTRONIC THROTTLE BODY ASSEMBLY WAS REPLACED. ON 1/30/10, 35 MILES FROM HOME, DRIVING ON HIGHWAY AT 55 MPH WHEN "ENGINE FAIL SAFE MODE" ALARM SOUNDED & MESSAGE FLASHED ON PANEL. AGAIN I WAS ABLE TO SAFELY PULL TO SHOULDER OF ROAD TO AVOID ACCIDENT. I CALLED FORD DEALER LOCATED IN THAT TOWN, HAD VEHICLE AGAIN TOWED TO SHOP AND THEY REPLACED AN ADDITIONAL PART. I CALLED FORD AFTER 2ND EVENT, I WAS TOLD BY FORD THAT THEY ARE AWARE OF THE PROBLEM, HOWEVER SINCE THEY DON'T HAVE A SOLUTION TO IT THEY DO NOT HAVE A RECALL ON THIS. ON 4/20/11 WHILE DRIVING HOME FROM WORK ON HIGHWAY AT 60 MPH THE "ENGINE FAIL SAFE MODE" ALARM & MESSAGE FLASHING ON PANEL. I WAS IN FAR RIGHT LANE SO AGAIN WAS ABLE TO COAST TO SHOULDER BEFORE STEERING LOCKED FROM NO POWER. IF I HAD BEEN IN LEFT LANE I WOULD NOT HAVE BEEN ABLE TO GET OFF ROADWAY. (ON 4/19/11 I HAD VEHICLE INSPECTED, IN NYS, NO CODES WERE ON THIS VEHICLE). TOWED TO SHOP, AFTER RUNNING TESTS AND CALLS TO FORD THEY HAVE AGAIN REPLACED THE ELECTRONIC THROTTLE BODY ASSEMBLY AS IT HAD FAILED. STILL NO RECALL. THIS IS EXTREME SAFETY ISSUE. I HAVE AVOIDED ACCIDENTS 3 TIMES, IF I HAD BEEN IN LEFT LANES I WOULD NOT HAVE BEEN SO LUCKY. THIS HAPPENS WITH NO ADVANCE WARNING. FORD KNOWS THERE IS A PROBLEM.

I WAS DRIVING MY 2006 FORD EXPEDITION & THE FAIL SAFE ENGINE LIGHT CAME ON & THAT STOPS THE GAS PEDAL FROM WORKING. YOU THEN COAST OVER TO THE SIDE OF THE ROAD & TURN THE TRUCK OFF & RESTART IT LIKE NOTHING HAPPENED. THIS HAS HAPPENED 2 TIMES ABOUT 3 MONTHS APART. I HAD THE TRUCK CHECK BY BOB BOYD FORD & THEY SAID IT NEEDED THE THROTTLE BODY & GAS PEDAL SENSOR REPLACED,I CALLED FORD & FILED A COMPLAINT OF HOW DANGEROUS THIS IS, ESPECIALLY IF YOU ARE MAKING A LEFT TURN IN ON COMING TRAFFIC( MY FORD CASE NUMBER [XXX]) I THEN WENT ON A FORD TRUCK FORUM & FOUND THAT MANY OTHERS HAD THE SAME PROBLEM WITH FORD F-150 & EXPEDITIONS ALL 2006 MODELS. A PERSON RECOMMENDED THAT I REPLACE THE THROTTLE POSITION SENSOR ,SO I DID AT BOB BOYD FORD FOR $196.58. I ALSO KEPT THE OLD PART.THE NEW PART IS DIFFERENT IN SIZE & HAS METAL KEY HOLES INSTEAD OF PLASTIC. THE FAIL SAFE ENGINE IS ONLY SUPPOSE TO COME ON IF THE ENGINE COOLANT IS VERY LOW ACCORDING TO THE FORD OWNERS MANUAL, THERE WAS NO REASON FOR IT TO COME ON AT ANY TIME IN MY SUV TRUCK. FORD WROTE ME & THE OHIO ATTORNEY GENERALS OFFICE & SAID THAT I HAVE FIXED THE PROBLEM BY REPLACING THE THROTTLE POSITION SENSOR ON MY OWN & ME PAYING FOR IT ( CASE CLOSED). FORD NEVER SAID ANY THING TO ME ABOUT REPLACING THE THROTTLE POSITION SENSOR TO FIX THIS PROBLEM. AGAIN THEY SAID IT WAS THE THROTTLE BODY & GAS PEDAL SENSOR. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

SEAT BELT BOLTS ON DRIVER AND PASSENGER SIDE SHOULDER MOUNTS WERE DISCOVERED TO BE NEARLY COMPLETELY LOOSENED, POTENTIALLY CAUSING INJURY OR DEATH IN EVENT OF AN ACCIDENT. BROUGHT IT TO THE ATTENTION OF THE DEALER, AND THEY CHARGED FOR THE TIGHTENING OF THE BOLTS. *TR

VEHICLE HAS BEEN SPUTTERING WHEN ACCELERATING AT ABOUT 40MPH. SPARK PLUGS ARE "SEERED" AND FORD MECHANIC TELLS US ITS A KNOWN PROBLEM, BUT NOT COVERED UNDER THE WARRANTY BECAUSE SPARK PLUGS ARE CONSIDERED MAINTENANCE. THE MANUAL SAYS WE THE SCHEDULED MAINTENANCE IS 100,000 MILES AND WE ARE ONLY AT 76,000. IF THEY ARE KNOWN TO BE FAULTY AND WE ARE NOT NEAR THE SCHEDULED/RECOMMENDED MAINTEANCE THEN SHOULDN'T THIS BE A WARRANTY ISSUE? I THINK FORD IS MILKING ITS CUSTOMERS WITH FAULTY PARTS AS I HAD THE SAME ISSUE WITH MY BRAKES. IT FEELS AS IF I AM LANDING A PLANE WHEN I COME TO A STOP WITH ALL THE SHAKNIG AN RATTLING. I WAS TOLD THIS IS A KNOWN ISSUE WITH THE FORD BRAKES - THEY JUST WARP. *TR

THE VEHICLE ENTERS ENGINE FAIL SAFE MODE. AT THIS POINT, THE VEHICLE WILL SHUT OFF AND YOU WILL LOSE ENGINE POWER AND STEERING CAPABILITIES. THIS IS PARTICULARLY DANGEROUS WHEN DRIVING 70 MILES PER HOUR ON THE HIGHWAY. IT WILL EVENTUALLY KILL SOMEONE IF IT HAS NOT ALREADY. FORD HAS DROPPED THE BALL ON THIS ONE. THE REPAIR IS A $600 - $800 THROTTLE BODY ASSEMBLY. FORD SHOULD BE EATING THIS COST.

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT WAS DRIVING 30 MPH WHEN THE VEHICLE STALLED WITHOUT WARNING. THE FAILURE WOULD RECUR SPORADICALLY WHEN TRAVELING AT VARIOUS SPEEDS. THE VEHICLE WAS ABLE TO BE RESTARTED AND WAS TAKEN TO THE DEALER WHO REPAIRED THE THROTTLE BODY AND MOTOR ASSEMBLY, STATING THAT THE VEHICLE HAD ENGAGED IN FAIL-SAFE MODE. THE MANUFACTURER WAS CONTACTED AND A COMPLAINT WAS FILED BUT NO FURTHER ASSISTANCE WAS PROVIDED. THE CURRENT MILEAGE WAS APPROXIMATELY 51,000 AND THE FAILURE MILEAGE WAS APPROXIMATELY 50,500.

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. WHILE DRIVING APPROXIMATELY 50 MPH, THE CONTACT STATED THAT THE FAIL SAFE MODE SYMBOL ILLUMINATED ON THE DASHBOARD AS THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO THE DEALER BUT THEY WERE UNABLE TO DUPLICATE THE FAILURE. A PRIVATE MECHANIC DIAGNOSED THE VEHICLE WITH A THROTTLE BODY FAILURE. THE CONTACT DID NOT INFORM THE MANUFACTURER NOR WAS THE VEHICLE REPAIRED. THE CURRENT AND FAILURE MILEAGE WAS 102,000.

2006 FORD EXPEDITION. CONSUMER STATES VEHICLE WILL ACTIVATE THE ENGINE FAIL SAFE MODE AND VEHICLE WILL SHUT DOWN WHILE DRIVING *TGW THE CONSUMER STATED WHEN THE VEHICLE SHUT DOWN, LOSS OF POWER STEERING OCCURRED. THE CONSUMER STATED UPON STOPPING, HE DISCOVERED THAT TURNING THE IGNITION SWITCH TO THE OFF POSITION AND TURNING IT BACK TO THE ON POSITION, THE ENGINE WOULD RE-START. THE DEALERSHIP WAS UNABLE TO FIND ANY PROBLEM BY RUNNING A DIAGNOSTIC CHECK. THE CONSUMER STATED NO WARNING LIGHTS APPEARED, EXCEPT WHEN THE ENGINE FAIL SAFE MODE ACTIVATED. THE ENGINE SAFE MODE WARNING DISAPPEARED UPON STARTING THE VEHICLE. *JB

2006 FORD EXPEDITION E.B. AND ENGINE FAILSAFE MODE 1. THE EVENTS LEADING UP TO THE FAILURE: THERE ARE NO DETECTABLE EVENTS PRECEDING WHATEVER CAUSES THE VEHICLE TO GO INTO "ENGINE FAILSAFE" MODE. THE VEHICLE RUNS FINE AS IT ALWAYS DOES AND THEN IT JUST HAPPENS RANDOMLY. 2. THE FAILURE, HOW OFTEN IT OCCURS, ITS CONSEQUENCES: FAILURE OCCURS AT RANDOM AND IS NOT PREDICTABLE IT JUST HAPPENS. THE VEHICLE OPERATES NORMALLY AS IT SHOULD AND IN A SPILT SECOND IT IS LIKE THE VEHICLE JUST SHUTS OFF, THE INFORMATION CENTER DISPLAYS "ENGINE IN FAILSAFE MODE". THE ENGINE IS ACTUALLY RUNNING IN FAILSAFE MODE BUT ONLY AT AN IDLE, THE POWER STEERING AND BRAKES FUNCTION HOWEVER THE THROTTLE IS TOTALLY UNRESPONSIVE IN FAILSAFE MODE, THE VEHICLE SLOWS TO A CREEP AND WILL STOP AT THE SLIGHTEST INCLINE. WHEN THE VEHICLE STOPS THE ONLY AVAILABLE OPTION IS TO TURN THE KEY OFF AND RESTART. THE VEHICLE ALWAYS RESTARTS AND RESUMES NORMAL OPERATION AND DRIVEABILTY IS FINE, JUST AS THOUGH NOTHING EVER HAPPENED. THE OCCURRENCE FIRST HAPPENED EARLY IN JANUARY 2010, AGAIN IN LATE JANUARY, THEN IN SEPTEMBER 2010 THEN AGAIN ON FEBRUARY 26 THEN TWICE TODAY FEBRUARY 28 ABOUT 20 MINUTES APART. THE CONSEQUENCES: SCARY, DANGEROUS, HAZARDOUS. FEELS LIKE AN INSURANCE CLAIM AND/OR A LAWSUIT WAITING TO HAPPEN. WHEN A VEHICLE UNDER POWER JUST SHUTS OFF INSTANTLY FOR NO APPARENT REASON IT IS LOGICAL SERIOUS INJURY OR WORSE IS A REALISTIC CONSEQUENCE. 3. WHAT WAS DONE TO CORRECT THE FAILURE: SO FAR JUST A LOT OF FORD GUESSWORK. THE INTERNET HAS A SIGNIFICANT NUMBER OF CONSUMER POSTS REGARDING VARIOUS REPAIRS MADE. THE REPORTED REPAIRS RANGE FROM SENSORS, SPARK PLUGS, COILS, CATS,FILTERS, CONVERTERS AND MORE. THE COMMON THREAD IN THESE CONSUMER REPORTS IS THE PROBLEM STILL EXISTS AND OCCURS RANDOMLY AFTER REPAIR. *TR

FOR THE FOURTH TIME IN THE PAST 2 YEARS THE SUV HAS SHUT DOWN WHILE DRIVING THE VEHICLE. THE DASHBOAD LIGHTS UP, THE STEERING WHEEL LOCKS UP, AND COMPLETELY SHUTS DOWN WHILE IN TRAFFIC. NO WARNING. HAVE TAKEN THE VEHICLE IN TWICE, BUT NO CODES HAVE SHOWN UP ON THE DIAGNOSTICS. THIS IS EXTREMELTY UNSAFE AND COULD RESULT IN A AN ACCIDENT HARMING MY FAMILY, ANOTHER FAMILY OR BOTH. *TR

I WAS PREPARING TO MAKE A LEFT HAND TURN INTO A BUSY OFFICE COMPLEX, AND THE ENGINE IN MY 2006 FORD EXPEDITION CUT OFF. THE SYSTEM GENERATED CODE WAS 'ENGINE FAILSAFE MODE". I TURNED ON MY HAZARDS, PUT THE CAR IN PARK AND WAITED A FEW MINUTES TO RESTART. THE ENGINE CAR STARTED, BUT THE FACT THAT IT CUT OFF, WITHOUT WARNING IS EXTREMELY ALARMING. I'VE CONTACTED FORD CORPORATE WHO SAID THAT THERE WERE NO RECALLS, AND THAT I NEEDED TO GO TO A SERVICE CENTER. AFTER RESEARCHING THE INTERNET AND THIS SITE, I AM CONVINCED THAT THIS ISSUE SHOULD PROMPT A RECALL, BUT FORD'S COST-BENEFIT ANALYSIS INDICATES THAT IT IS WAITING UNTIL THERE ARE ENOUGH FATALITIES TO MAKE THE DETERMINATION TO FIX WHAT APPEARS TO BE A $600-800 ISSUE. FORD SHOULD BE AND CAN BE HELD LIABLE FOR GROSS NEGLIGENCE IN THEIR DELIBERATE DECISION TO DISREGARD THE ENGINE FAILURE COMPLAINTS. I HAVE BEEN A LOYAL FORD CUSTOMER FOR SEVERAL DECADES. THAT IS NO LONGER THE CASE. *TR

'06 EXPEDITION WENT INTO ENGINE FAIL SAFE MODE AS MY WIFE WAS ATTEMPTING TO MAKE A LEFT HAND TURN CROSSING 2 LANES OF TRAFFIC AT A BUSY INTERSECTION. AFTER COASTING INTO A PARKING LOT, SHE TURNED IT OFF AND TURNED IT BACK ON. IT STARTED RIGHT UP AND SHE WENT ON HER WAY. TOOK IT TO A MECHANIC WHO SAID HE COULD FIND NOTHING WRONG. UPON FURTHER INVESTIGATION, I HAVE FOUND 100'S OF '06 EXPEDITIONS WITH THE SAME PROBLEM AND IT SEEMS TO POINT TO THE THROTTLE BODY. A RECENT AC REPAIR TO THIS CAR WAS ALMOST $800.00 AND NOW I AM HEARING TO REPAIR THE THROTTLE BODY IS UPWARD TO $700-$800. $1500 OF REPAIRS ON A CAR WITH ONLY 45,000 MILES IS UNACCEPTABLE. THE THROTTLE BODY PROBLEM IS VERY DANGEROUS AND FORD SHOULD RECALL THESE CARS AND FIND OUT WHY THIS IS HAPPENING BEFORE SOMEONE GETS HURT OR EVEN WORSE, KILLED. *LN

I WAS TRAVELING DOWN THE ROAD HIT BLACK ICE AND THEN SLIDE INTO A TREE HEAD ON. BOTH THE DRIVERSIDE AND PASSENGER SIDE AIRBAGS FAILED TO DEPLOY. I WAS WEARING MY SEAT BELT BUT STILL SUFFERED FACIAL TRAUMA. I RECEIVED SEVERAL SUTURES IN MY LIPS AND THE INSIDE OF MY MOUTH. I THINK FORD SHOULD INVESTIGATE AND DO SOMETHING ABOUT THIS PROBLEM. I FEEL THAT IF MY AIRBAGS WOULD HAVE DEPLOYED I WOULDN'T HAVE SUFFERED THE TRAUMA TO MY FACE. *TR

2006 FORD EXPEDITION SHUTS OFF WHILE DRIVING. EXTREMELY DANGEROUS. CAR WILL START BACK UP WITHOUT ANY PROBLEMS BUT WILL SHUT DOWN SPORADICALLY. *TR

MY WIFE WAS DRIVING HER 2006 FORD EXPEDITION DOWN A BUSY ROAD AT A SPEED OF ABOUT 40 MPH. SHE WAS DRIVING WITH ANOTHER FRIEND AND OUR 2 CHILDREN (18 MONTHS AND 1 WEEK!) A WRENCH SYMBOL WARNING LIGHT CAME ON AND THE VEHICLE SHUT DOWN. SHE PUT ON HER HAZARDS AND WAS ABLE TO SAFELY COME TO A STOP. SHE TURNED THE IGNITION KEY TO THE OFF POSITION AND THEN WAS ABLE TO START THE ENGINE AGAIN. AFTER TALKING TO A MECHANIC AND DOING INTERNET RESEARCH I FOUND THIS IS A VERY COMMON PROBLEM WHICH CONSISTS OF THE ELECTRONIC CONTROL OF THE THROTTLE. THE FIX IS UPWARDS OF $500; SO A RECALL OF SOMETHING THAT EXPENSIVE CAN EASILY BE BRUSHED UNDER THE TABLE BY FORD. THIS PROBLEM NEEDS TO BE ADDRESSED BY FORD. IF MORE VEHICLES KEEP SHUTTING DOWN ON THEIR OWN SOMEONE WILL SOON BE INJURED OR KILLED. *TR

I AM FILING A COMPLAINT DUE TO MY 2006 FORD EXPEDITION. OVER THE FEW YEARS THAT I HAVE OWNED THE S.U.V., FOR NO APPARENT REASON THE VEHICLE JUST QUITS RUNNING, ENTERS A FAIL SAFE MODE, AND ALL POWER IS LOST TO THE VEHICLE. THIS HAS HAPPENED NOW ON MANY OCCASIONS AND WITHOUT ANY WARNING. ITS HAPPENED ON INTERSTATES, BRIDGES, AS WELL AS CROSSING MULTIPLE LANED HIGHWAYS. THIS IS A TREMENDOUS SAFETY ISSUE THAT NEEDS TO BE ADDRESSED. AT FIRST I THOUGHT MY CASE MIGHT BE ISOLATED, BUT THEN AFTER SOME RESEARCH, I FOUND THAT THOUSANDS ARE HAVING THE SAME PROBLEM WITH THEIR EXPEDITION AS WELL. I FEEL FORD SHOULD FIND THE PROBLEM AND FIX IT BEFORE LIVES ARE DESTROYED. MY WIFE AND CHILDREN ARE IN THIS VEHICLE EVERYDAY. PLEASE IF THERE'S ANYTHING YOU CAN DO.....HELP US!! *TR

2006 FORD EXPEDITION, "ENGINE FAIL SAFE MODE" CAR HAS SHUT OFF WHILE DRIVING 5 TIMES IN THE LAST 6 MONTHS. THE ONLY WAY TO GET THE CAR MOVING IS TO START IT AGAIN. EXTREMELY UNSAFE. THIS VEHICLE WAS COVERED UNDER AN EXTENDED WARRANTY AND HAS GONE IN FOR SERVICE TO CORRECT THE PROBLEM. FORD CANNOT IDENTIFY THE PROBLEM! COMES UP WITH "NO CODE". I'M NOW OFF WARRANTY AND STUCK WITH A VERY UNSAFE VEHICLE! FORD NEEDS TO ADDRESS THIS PROBLEM IMMEDIATELY! *TR

COMPLAINT FILED REGARDING A PERSONALLY OWNED 2006 FORD EXPEDITION XLT, OWNED FROM 2/2010 TO PRESENT (12/2010)> THREE SEPARATE INSTANCES WHEN DRIVING THE VEHICLE WHEN THE "FAILSAFE MODE" WARNING LIGHTS AND ALL LOSS OF VEHICLE CONTROL:STEERING, BRAKES, ACCELERATION, ETC. OCCURRED/ RANDOMLY DURING THIS PERIOD OF OWNERSHIP WITH NO APPARENT REASON. VEHICLE RESTARTED IMMEDIATELY. ALL INSTANCES OF THE CONDITION OCCURRED WHEN OUTSIDE TEMPERATURE WAS BELOW FREEZING (WINTER MONTHS) INTO A RIGHT OR LEFT TURN. NO EVIDENCE OF LOSS OF ANTIFREEZE, ENGINE OVERHEATING, COOLANT LEAKS, ETC. MECHANIC ASSESSMENT COULD NOT FIND A REASON FOR THE ENGINE FAIL SAFE ACTIVATION. THIS IS A SIGNIFICANT, POTENTIAL SAFETY PROBLEM FOR THE DRIVER/PASSENGERS OF 2006 FORD EXPEDITIONS EXPERIENCING THE RANDOM OCCURRING ENGINE FAILURE ATTRIBUTABLE TO THE FAILSAFE FEATURE OF THIS VEHICLE. *TR

I WAS STOPPED AT A RED LIGHT, CONSTRUCTION TRUCK RAN INTO BACK OF MY 2006 FORD EXPEDITION. THE IMPACT PUSHED ME 20 FEET INTO THE VEHICLE IN FRONT OF ME, SANDWICHING MY VEHICLE IN BETWEEN THE OTHER TWO; THE IMPACT FIRST THREW ME BACK THEN FORWARD & SENT MY GLASSES OFF MY HEAD BUT THE AIRBAG DID NOT DEPLOY. I GOT A CONCUSSION & SHOULDER INJURY DUE TO FORCE. POLICE & MEDICAL PERSONS WERE AMAZED THAT AIRBAG DID NOT DEPLOY. VEHICLE HAD FRONT END & REAR DAMAGE, WAS UNDRIVEABLE & HAD TO BE TOWED AWAY. I AM WAITING TO FIND OUT IF IT WILL BE TOTALED OUT.

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT WAS TRAVELING 35 MPH WHEN THE BRAKES ON THE VEHICLE FAILED. THE VEHICLE WAS TAKEN TO THE DEALER, AND THE CONTACT WAS ADVISED THAT THE BRAKE LINES HAD RUSTED THROUGH. THE MANUFACTURER STATED THAT CORROSION DAMAGE TO THE VEHICLE IS WHAT CAUSED THE BRAKE FAILURE. THE CONTACT HAS FILED A COMPLAINT WITH THE MANUFACTURER. THE CONTACT FEELS THAT THE CORROSION SHOULD NOT BE A FACTOR BECAUSE THEY DO NOT LIVE IN A SNOW ENVIRONMENT. THE FAILURE MILEAGE 66710 AND THE CURRENT MILEAGE 68000.

WAS DRIVING ON FREEWAY AT ABOUT 60 VEHICLE WENT INTO ENGINE FAILURE MODE VEHICLE CUT OFF COMPLETED I HAD TO HURRY PUT THE TRUCK IN PARK TURN ON MY HAZARDS AND KEEP RESTARTING THE TRUCK UNTIL I GOT IT RESTARTED WHEN IT RESTARTED THE AIR DIDN'T WORK ANY MORE I HAVE NO COLD AIR BUT THE HEAT WORKS AND THE TRUCK ONLY HAS 27000 MILES ON IT AS OF TODAY FORD WOULD NOT FIX IT I HAVE FULL BUMPER TO BUMPER WARRANTY AT THE TIME AND STILL HAVE EXTENDED WARRANTY UP TO 75000 MILES THE VEHICLES SHUTS OFF LIKE ONCE A MONTH AND IT JUST DID IT THIS MORNING I DON'T KNOW HOW TO SOLVE THIS PROBLEM FORD DID NOT HONOR MY CONTRACT I COULD HAVE BEEN KILLED ON A FREEWAY IN TRAFFIC HERE A BEEP AND CAR GO INTO FAILURE MODE SOMEONE COULD HAVE RAN INTO THE BACK OF ME BY NOT KNOWING WHAT WAS GOING ON ANY THING WHAT IF I WAS GOING UP A HILL AND MY ENGINE GOES INTO FAILURE MODE I NEED HELP SOLVING THIS PROBLEM. *TR

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THE VEHICLE STALLS WITHOUT WARNING. THE VEHICLE WILL THEN START WITHOUT ANY PROBLEMS. THIS FAILURE HAS OCCURRED RANDOMLY OVER THE FOUR YEARS THE CONTACT HAS OWNED THE VEHICLE. THE VEHICLE WAS INSPECTED BY THE DEALER A WEEK AGO AND NOTHING WAS FOUND TO BE WRONG WITH THE VEHICLE. THE VIN WAS REJECTED FROM THE SYSTEM. THE FAILURE MILEAGE WAS 25000 AND THE CURRENT MILEAGE 74000.

TL*THE CONTACT OWNS A 2006 FORD EXPEDITION. WHILE DRIVING APPROXIMATELY 70 MPH ALL OF THE INTERIOR AND EXTERIOR LIGHTS BEGAN TO DIM. THE RADIO SHUT OFF AND THE VEHICLE THEN STALLED. THE VEHICLE WAS TOWED HOME WHERE SHE REPLACED THE ALTERNATOR. APPROXIMATELY 5 MONTHS LATER THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE STARTER WAS REPLACED. APPROXIMATELY 1 MONTH LATER THE FAILURE BEGAN TO INTERMITTENTLY RECUR. DURING ONE OF THE FAILURES THE CHECK ENGINE LIGHT ALSO BEGAN TO ILLUMINATE ON THE DASHBOARD. THE VEHICLE WAS TAKEN BACK TO AN AUTHORIZED DEALER WHERE SHE WAS INFORMED THE FAILURE WAS DUE TO THE THROTTLE BODY. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 70,000 AND THE CURRENT MILEAGE WAS 87,000. THE VIN WAS UNAVAILABLE.

I WAS DRIVING 45 MILES AN HOUR DOWN A MAJOR HIGHWAY WHEN MY ENGINE IN MY 2006 FOR EXPEDITION JUST SHUT DOWN WITHOUT WARNING AND WENT INTO "FAIL -SAFE MODE". THANK GOD I WAS ABLE TO CROSS 3 LANES OF TRAFFIC WITHOUT INCIDENT TO GET TO THE SHOULDER. I SHUT OFF MY CAR AS THE MANUAL TOLD ME TOO. AFTER 20 MINS I WAS ABLE TO RESTART THE CAR. I DROVE TO THE NEAREST DEALERSHIP SO THEY COULD LOOK INTO THE ISSUE. IT WAS DIAGNOSED AS NEEDING A REPLACEMENT THROTTLE BODY. WHEN I ASKED "WHAT HAPPENED? WHY DID THIS HAPPEN?", I WAS TOLD "IT JUST HAPPENS," AND "THERE IS NOTHING PREVENTATIVE THAT CAN BE DONE.". CONVENIENTLY THIS PART WAS NOT COVERED BY MY 100,000 MILE POWERTRAIN WARRANTY THAT FORD IS SO PROUD OF ON ITS USED VEHICLES. THIS REPAIR COST ME $609. THE NEXT DAY I DID SOME RESEARCH AND FOUND NUMEROUS COMPLAINTS ON THE EXACT SAME ISSUE FOR THE SAME MAKE AND MODEL (2006 FORD EXPEDITION) ON THE FOLLOWING WEBSITE: HTTP://WWW.ABOUTAUTOMOBILE.COM/COMPLAINT/2006/FORD/EXPEDITION/ENGINE+AND+ENGINE+COOLING+SYSTEM . I CALLED THE SERVICE MANAGER TO DISCUSS AND HE AGREED HE HAS BEEN SEEING ALOT OF THESE THROTTLE BODY REPLACEMENTS AND ENGINE SHUTDOWNS ON THIS MODEL AND AGREES A RECALL NEEDS TO BE DONE BEFORE SOMEONE GETS SERIOUSLY HURT. I AM JUST THANKFUL MY 3 KIDS WERE NOT IN THE CAR WITH ME AND PRAY THIS DOESN'T HAPPEN AGAIN. THE SERVICE MANAGER GAVE ME THIS WEB ADDRESS TO MAKE AN OFFICIAL COMPLAINT, HOPING A RECALL WOULD TAKE PLACE. *TR

WITH NO WARNING, MY 2006 FORD EXPEDITION WILL LOSE ALL POWER WHILE DRIVING. THE LIGHT ON THE CONTROL PANEL COMES ON SAYING "ENGINE FAIL SAFE MODE." AFTER COASTING TO THE SIDE OF THE ROAD, I RESTART THE CAR AND ALL IS FINE. I HAVE TAKEN IT TO TWO MECHANICS AND THEY SAY THERE IS NOTHING WRONG WITH THE CAR. IT HAS HAPPENED TWICE SO FAR. *TR

MY FAMILY (ME, WIFE AND TWO CHILDREN) WERE ON OUR WAY HOME FROM A RESTAURANT. WE NORMALLY TAKE THE HIGHWAY BUT DECIDED TO TAKE THE SIDE ROAD HOME AND THANK GOD. DRIVING 45 MPH THE "ENGINE FAIL SAFE MODE" CAME ON AND IT COMPLETELY SHUT OFF. I PULLED OVER TO THE SIDE OF THE ROAD AND TURNED THE ENGINE OFF. AFTER A FEW MINUTES, I RESTARTED THE VEHICLE AND IT STARTED FINE AND NO WARNING SIGNS.THIS IS THE FIRST TIME IT OCCURRED BUT I DO NOT WANT THIS TO HAPPEN AGAIN. THE VEHICLE IS INSIDE THE GARAGE AND I'M CALLING THE DEALERSHIP TOMORROW TO MAKE AN APPOINTMENT. THIS IS A FAMILY CAR AND WE ARE ALWAYS ON THE HIGHWAY. THIS IS A FATAL FAIL THAT NEEDS TO BE CORRECTED. THIS FAILURE OCCURRED AT 61,408 MILES. I CHECKED THE FORD WEBSITE AND THERE IS NO RECALL. HOWEVER, THERE ARE NUMEROUS COMPLAINTS ON THE INTERNET FOR THE SAME ISSUE. I'M AFRAID FOR MY WIFE AND CHILDREN WHILE THEY ARE OPERATING THIS VEHICLE. *TR

BOLTS ON FRONT PASSENGER AND DRIVER SIDE SEATBELT RESTRAINT ANCHORS TO HE SIDE WALL LOOSENED ALMOST COMPLETELY OFF. THIS POSES A SERIOUS SAFETY CONCERN. THE FORD DEALERSHIP HAS NEVER NOTICED OR CORRECTED THE PROBLEM IN THE FOUR YEARS WE HAVE OWNED THE VEHICLE. *TR

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT WAS DRIVING UNDER 20 MPH WHEN HE APPLIED THE BRAKES. THERE WAS AN INCREASE IN ENGINE RPMS AND THE VEHICLE ABNORMALLY ACCELERATED. THE BRAKE PEDAL WAS APPLIED WITH FORCE AND THE VEHICLE CONTINUED TO ACCELERATE. WHEN THE GEAR SELECTOR WAS SHIFTED INTO THE NEUTRAL POSITION, THE VEHICLE CAME TO A COMPLETE STOP. THE ENGINE WAS TURNED OFF AND RESTARTED. THE VEHICLE WAS ABLE TO RESUME NORMAL OPERATIONS. THE CONTACT WAS IN THE PROCESS OF TAKING THE VEHICLE TO AN AUTHORIZED DEALER FOR DIAGNOSTIC TESTING. THE FAILURE MILEAGE WAS 44,000.

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. WHILE DRIVING AT 5 MPH, THE CONTACT DEPRESSED THE ACCELERATOR PEDAL BUT THE VEHICLE WOULD NOT ACCELERATE. THE CONTACT WOULD LIGHTLY TAP ON THE ACCELERATOR PEDAL IN ORDER TO GET IT TO ENGAGE. THE CHECK ENGINE WARNING LIGHT WAS ALSO ILLUMINATED. THE DEALER ADVISED THAT ONE OF THE COIL PACKS WAS DEFECTIVE AND IT WS REPLACED. THE FAILURE RECURRED. THE CONTACT STATED ONLY ONE COIL PACK WAS REPLACED BY THE DEALER BUT THERE WERE TWO ADDITIONAL COIL PACKS THAT NEEDED TO BE REPLACED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 130,000 AND THE CURRENT MILEAGE WAS 135,000.

I HAVE A 2006 FORD EXPEDITION AND MY WIFE ALMOST LOST CONTROL AND HIT A CAR WHEN THE BRAKES WENT TO THE FLOOR. THE VEHICLE HAS HAD "SPONGY BRAKES" SINCE I BOUGHT IT AND HAD IT TO THE DEALER TWICE. THERE IS A TSB TO REPLACE THE FRONT CALIPER/ROTOR AND PADS AND FORD DID THIS BUT IT STILL FEELS SPONGY AND IS NOW LEAKING FLUID. THIS HAS BEEN AN ISSUE ON MANY EXPEDITIONS AND SHOULD HAVE BEEN A RECALL RATHER THAN A TSB. THIS IS AN INCREDIBLY DANGEROUS SITUATION WHEN THE BRAKES FAIL. I KNOW I HAVE HAD INSTANCES WHERE I LITERALLY NEED TO STAND ON THE BRAKES TO GET THE VEHICLE TO STOP. *TR

TL* CONTACT OWNS A 2005 FORD EXPEDITION. THE CONTACT STATED WHILE DRIVING AT 50 MPH, THE VEHICLE SUDDENLY STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE BUT IT STALLED A SECOND TIME WITHIN SECONDS. THE VEHICLE WAS TOWED TO HIS RESIDENCE. THE CONTACT WAS ABLE TO LOCATE NUMEROUS COMPLAINTS REGARDING THE THROTTLE CONTROL AND BELIEVED IT TO BE THE CAUSE OF THE FAILURE. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE FAILURE MILEAGE WAS 80,000.

MY WIFE, THREE KIDS AND MYSELF WERE IN OUR 2006 FORD EXPEDITION LIMITED COMING DOWN A MOUNTAIN PASS IN LAKE TAHOE WHEN ALL OF A SUDDEN THE ENGINE STOPPED! A CODE ON THE DASH READ "FAIL SAFE ENGINE MODE". THE STEERING WHEEL LOCKED AND THERE WAS NO POWER, NO ACCELERATION. I WAS LUCKY TO PULL TO THE SIDE OF THE ROAD. THE FOLLOWING DAY, I TOOK THE TRUCK TO THE CARSON CITY, NV FORD DEALER AND PAID FOR A DIAGNOSTIC. NOTES FROM DEALER: ROAD TEST COULD NOT VERIFY. PERFORMED EEC SELF TEST, HAS CODE P0104. PERFORMED WIGGLE TEST AND PINPOINT TESTS. PERFORMED RECORDER-MONITOR TEST ALL THE PIDS LOOKED GOOD. REMOVED THE MAF SENSOR. HAS DEBRIS ON THE MAF SENSOR WIRES. RECOMMEND A NEW MAF SENSOR." I PUT IN A NEW MAF SENSOR AND AIR FILTER. IN DRIVING LESS THAN 3 MILES AFTER THIS WAS DONE, THE TRUCK DID THE SAME THING. THE "FAIL SAFE ENGINE MODE" CAME ON, LOSS OF POWER AND ACCELERATION. I HAD TO TURN THE TRUCK OFF COMPLETELY, REMOVE KEY AND RESTART. THEN THE TRUCK DID NOT HOLD THE IDLE AND DIED. AFTER A SECOND TIME, THE TRUCK RESTARTED. I AM STILL DRIVING WITH THE CHECK ENGINE LIGHT OFF AND HAVE ANOTHER APPOINTMENT WITH THE FORD DEALER TOMORROW MORNING (6-24-10) TO SEE WHAT IS GOING ON. WE ARE SUPPOSED TO LEAVE TOMORROW AND DRIVE 1100 MILES TO RETURN TO DENVER. *TR

TL*THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THAT WHILE DRIVING THE CHECK ENGINE LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALERSHIP WHERE THE CONTACT WAS INFORMED THAT THE FUEL INJECTORS WERE STUCK OPEN AND FLOODED THE ENGINE. THE DEALER ALSO STATED THAT BOTH CATALYTIC CONVERTERS WERE RUINED AND NEEDED TO BE REPLACED, AND THE ENGINE WAS POSSIBLY DAMAGED. THE CONTACT STATED THAT THERE WAS A RECALL RELATED TO THE FAILURE FOR PREVIOUS MODEL YEARS AND WARRANTIES WERE EXTENDED AS A RESULT. THE CONTACT CALLED THE MANUFACTURER WHO STATED THAT THEY WOULD NOT EXTEND THE WARRANTY ON THE VEHICLE. THE CONTACT FILED A COMPLAINT. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 65,000. UPDATED 11/19/10. *LJ UPDATED 10/27/10. *LJ THE CONSUMER STATED A NEW ENGINE WAS PUT IN THE VEHICLE. HOWEVER, HE CONTINUED TO EXPERIENCE PROBLEMS. THE DEALER STATED THE #6 CYLINDER HAD COMPRESSED CAUSING THE PISTON TO STOP A HALF INCH FROM THE TOP WHICH CAUSED THE VEHICLE TO SHUT DOWN. UPDATED 11/24/10

ON 2 SEPARATE OCCASIONS (BOTH AROUND 40,000 MILES), THE CAR JUST SHUT ITSELF OFF, WITHOUT WARNING, WHILE DRIVING DOWN THE ROAD AT ABOUT 40 MPH. POWER STEERING AND POWER BRAKING BOTH FAILED. I WAS JUST ABLE TO COAST ACROSS SEVERAL BUSY LANES OF TRAFFIC TO GET TO THE SIDE OF THE ROAD. THIS COULD BE EXTREMELY DANGEROUS, PARTICULARLY IF I WAS ON A FREEWAY OR INTERSTATE. THE DEALER'S DIAGNOSIS WAS THAT THE THROTTLE HAD GOTTEN STUCK WIDE OPEN, AND THAT THE CAR HAD TO GO INTO FAILSAFE MODE TO PREVENT IT FROM ACCELERATING OUT OF CONTROL. WHAT IF THE FAILSAFE MODE FAILS? I'VE READ NUMEROUS OTHER COMPLAINTS OF THE SAME THING HAPPENING ON OTHER 2006 FORD EXPEDITIONS. THERE IS CLEARLY A DEFECTIVE PART HERE, AND IT IS CLEARLY A SAFETY ISSUE. *TR

2006 FORD EXPEDITION SHUTS DOWN WHILE DRIVING ENGINE GOES INTO FAIL SAFE MODE WHICH IS LIKE NEUTRAL WITH LIMITED STEERING CAPABILITIES AND NO GAS PEDAL USE. BOUGHT VEHICLE IN DEC 09. THIS VEHICLE HAS DONE THIS APPROX 7 TIMES. HAS HAPPENED WHILE ON SURFACE STREETS AS WELL AS THE FREEWAY. VERY DANGEROUS. AT DEALER FOR THIRD TIME AND THEY ARE GIVING A THIRD REASON FOR IT HAPPENING. CHECKED INTERNET AND IT IS FULL OF COMPLAINTS OF EXACTLY SAME PROBLEM WITH NO RESOLUTION FROM ANY MECHANICS BUT SEVERAL DIFFERENT REASONS THEY WERE GIVEN. A DEFINITE SAFETY ISSUE! ON THE PHONE WITH FORD CUSTOMER SERVICE TODAY ABOUT THE ISSUE. THEY WILL GET BACK TO ME TOMORROW. NO RECALLS ON THIS, APPARENTLY UNTIL SOMEONE GETS HURT. THIS IS ANOTHER TOYOTA ISSUE WAITING TO HAPPEN. I AM A STATE TROOPER AND YOU CAN BELIEVE I FEEL THIS IS SERIOUS AND NEEDS TO BE ADDRESSED. SOMEONE COULD BE SERIOUSLY HURT OR KILLED ESPECIALLY ON THE FREEWAY WHEN THIS HAPPENS. *TR

ENGINE SAFE FAIL MODE CAME ON WHILE DRIVING MY 2006 FORD EXPEDITION WHICH ALSO LEAD TO THE VEHICLE SHUTTING DOWN IN THE MIDDLE OF THE HIGHWAY. THE NEXT READING THAT WAS CONNECTED TO THIS WARNING WAS...ENGINE OFF...LOW FUEL OIL PRESSURE. I CHECKED UNDER THE HOOD OF THE VEHICLE TO SEE IF THERE WAS ANY OIL LEAKS OR IF THE READING WAS REALLY LOW AND ALL SEEN FINE. THIS IS A VERY SCARY INCIDENT BECAUSE THE VEHICLE JUST SHUTS DOWN IN THE MIDDLE OF TRASH WHICH COULD CAUSE AN ACCIDENT MAYBE FATAL. *TR

MY FAMILY, WHICH I HAVE FIVE CHILDREN IN THE TRUCK. ON 10FWY ON MOTHERS DAY EXPEDITION LOST POWER IN SECOND LANE 65MPH FLOWING W/ TRAFFIC. WE MANAGED TO GET IN EMERGENCY LANE. HAD NO IDEA WHAT WAS HAPPENING! AMBER LIGHT APPEARS (WRENCH)?? CLUELESS. PUT TRUCK IN "PARK" TURNED OFF TRUCK WAITED 5 MINUTES. TRUCK STARTED?? DROVE HOME AS TRUCK IS NOT UNSAFE. PARKED TRUCK FOR 3-DAYS NOW TRUCK WILL NOT TURN ON. DEALER WILL LOOK AT TRUCK FOR CHARGE OF COURSE. *TR

DRIVING TO WORK VIA FREEWAY, HAD JUST REACHED THE BOTTOM OF A FREEWAY OFF-RAMP, AT A STOPLIGHT. LIGHT TURNED GREEN, HAD JUST STARTED TO GO AND THE "FAIL SAFE ENGINE MODE" LIGHT ON MY 2006 FORD EXPEDITION CAME ON THE DASHBOARD, WITHIN 5 SECONDS THE CAR TURNED OFF ON ITS OWN, LIKE TAKING THE KEY OUT OF THE IGNITION. HAD IT TOWED TO A FORD DEALERSHIP, THEY RAN DIAGNOSTICS, SAID THE THROTTLE BODY ASSEMBLY NEEDED REPLACING. I LOOKED ON THE INTERNET, GOOGLING "FAIL SAFE ENGINE MODE" AND "FORD" AND FOUND THIS TO BE A COMMON PROBLEM. ASKED WHY IT'S NOT A RECALL ITEM OR HAS A TECHNICAL BULLETIN WITH SO MANY CASES OF IT, PLUS IT'S VERY DANGEROUS. MANY IN THEIR INTERNET POSTINGS SAID THE PROBLEM COMES BACK. DEALERSHIP SAID TO CONTACT FORD CORPORATE, OPENED A CUDL CASE FOR ME TO REQUEST REIMBURSEMENT. WROTE A LETTER TO FORD CORPORATE, INCLUDED INTERNET LINKS TO ALL THE POSTINGS OF OTHER PEOPLE HAVING THE SAME PROBLEM, ASKED FOR $480.35 REIMBURSEMENT, ALSO ASKED WHAT THEY ARE DOING ABOUT THIS DANGEROUS SITUATION WITH THE THROTTLE BODY ASSEMBLY. FORD CORPORATE SEND ME A LETTER BACK, SIMPLY SAID I'M PAST WARRANTY AND UNABLE TO PROVIDE REIMBURSEMENT. THEY DID NOT REPLY REGARDING MY QUESTION ABOUT WHAT'S BEING DONE ABOUT THIS DANGEROUS PROBLEM. *TR

I HAVE A 2006 FORD EXPEDITION EDDIE BAUER UNDER 5 YEARS OLD THAT THE TAILGATE IS SEVERELY BLISTERED ALL OVER, PAINT HAS EVEN POPPED OFF OF IT. THERE IS ALSO SOME ON THE HOOD. THE LOCAL FORD DEALERSHIP ADMITTED THAT FORD HAD A PROBLEM WITH THE BLISTERING PAINT AND TOLD ME HOW BAD MY VEHICLE WAS. THEY TOOK PICTURES AND SENT TO FORD. FORD REP DENIED IT AND I WAS TOLD THAT EVEN IF HOLES APPEARED AS A RESULT NOW THEY WOULD DO NOTHING FOR ME BECAUSE THEY HAD ALREADY DENIED AND ONLY LOOK AT A CLAIM FOR ONE THING ONE TIME. I PURSUED FURTHER BY CALLING CUSTOMER SERVICE AND EMAILING THEM AS WELL. THE CUSTOMER SERVICE REP ALSO ADMITTED THERE WAS A PROBLEM WITH PAINT BLISTER BUT COULD DO NOTHING FOR ME BECAUSE IT HAD ALREADY BEEN DENIED. I HAVE OWNED FORDS ALL OF MY LIFE AND EVEN WORKED FOR A LINCOLN MERCURY DEALERSHIP FOR SEVERAL YEARS. I AM CONTINUING TO PURSUE THIS AS FAR AS I CAN AND ASK FOR ANY HELP THAT CAN BE OFFERED IN THIS MATTER. *TR

2006 FORD EXPEDITION (LAW ENFORCEMENT PACKAGE) WITH STEEL WHEELS AND APPROX. 120,000 MILES; WHEEL SEPARATION (CRACKED ALONG WELD). PRIOR TO THE FAILURE, THIS VEHICLE WAS USED DAILY FOR ROUTINE LAW ENFORCEMENT PATROL DUTIES. WE HAVE HAD THIS ISSUE ON SEVERAL 2006 EXPEDITIONS. UPON LEARNING OF THE POTENTIAL FOR THE WHEEL FAILURE, WE HAVE IMPLEMENTED PROCEDURES TO INSPECT THE WHEELS FOR CRACKS AND OTHER DAMAGE REGULARLY. IN ALL CASES, THERE HAVE BEEN NO OBVIOUS WARNING SIGNS BEFORE FAILURE. THIS PROBLEM WAS DISCOVERED WHEN THE OFFICER NOTICED A FLAT TIRE PRIOR TO STARTING HIS SHIFT FOR THE DAY. UPON FINDING THE CRACKED WHEEL A NEW REPLACEMENT WHEEL WAS INSTALLED ON THE VEHICLE. *TR

2006 FORD EXPEDITION FAILSAFE MODE COMES ON. IT HAS HAPPENED 4 TIMES IN 4 MONTHS. HAVE LOSS OF STEERING AND ENGINE HAS NO POWER. VERY DANGEROUS. *TR

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. WHILE DRIVING IN A PARKING LOT AT ABOUT 15MPH, THE VEHICLE JUST SHUT OFF. A LIGHT ON THE INSTRUMENT PANEL INDICATED THAT THE VEHICLE WAS IN " ENGINE FAIL SAFE MODE". THE CONTACT PUT HER HAZARD LIGHTS ON, PUT THE VEHICLE IN PARK AND TURNED THE ENGINE OFF. SHE RESTARTED THE VEHICLE AND IT OPERATED NORMALLY. THE CONTACT STATED THAT THIS HAS HAPPENED ABOUT 6-7 TIMES. SHE REPORTED THE FAILURE TO THE MANUFACTURER AND THEY STATED THAT THEY NEVER HEARD OF ANYTHING LIKE THIS. THE DRIVER DOES NOT FEEL HER VEHICLE IS SAFE. THE FAILURE MILEAGE WAS 40,000 AND THE CURRENT MILEAGE IS 52,691.

SPARKS PLUGS BLEW OUT RIGHT AT 60,000 MILES ON 2006 FORD EXPEDITION ON OUR WAY FROM MARYLAND TO LOUISIANA. STARTED GETTING PROBLEMS IN NORTH CAROLINA. AFTER SPENDING 2000.00 FOR HOTEL, RENTAL CAR AND POSSIBLE FIX BY FIRESTONE..IT STILL WAS NOT WORKING. BROUGHT TO FORD DEALERSHIP AND SAID IT WAS SPARK PLUGS THAT BLEW AND A COMMON THING FOR F150S AND IT WOULD COST OVER 7,000.00 TO FIX IT AND RECOMMENDED TRADING IT IN. SO WE DID CAUSE WE HAD NO CHOICE WITH THE TRUCK BEING IN NC. *TR

TL*THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THAT THE FAIL SAFE MODE WAS ACTIVATED AND MADE IT IMPOSSIBLE TO CONTINUE DRIVING AFTER THE VEHICLE WAS STOPPED. THE VEHICLE WOULD NOT ACCELERATE OR TURN IN ANY DIRECTION. IF THE VEHICLE WAS TURNED OFF AND RESTARTED THE VEHICLE WOULD FUNCTION PROPERLY. THE VEHICLE MALFUNCTIONED WHENEVER THE VEHICLE WAS PULLING OFF FROM A STOP. THE VEHICLE HAD 38,000 AT THE TIME OF THE FAILURE AND THE CURRENT MILEAGE WAS 38,500 CURRENT MILES.

REAR DOOR PAINT BLISTERS. *TR

ENGINE SHUTS OFF WHILE RUNNING. LAST TIME ON THE FREEWAY. MY MECHANIC SAYS THE SYSTEMS READS OK ON COMPUTER DIAGNOSTIC, BUT THE FAIL-SAFE SYSTEM DEFINITELY SHUT THE ENGINE DOWN DUE TO A POSSIBLE GLITCH IN THE SYSTEM. DEALERS "SEE" GOOD READINGS FOR THROTTLE SYSTEM AND WILL NOT REPLACE A "GOOD" PART. WHEN THIS HAPPENS, CAR HAS NO POWER WITH NO WARNING. IT HAS HAPPENED TWICE AND WE DON'T KNOW WHEN IT WILL HAPPEN AGAIN. *TR

TIRE RIM FAILURE ON A 2006 FORD EXPEDITION USED BY A U.S. FOREST SERVICE LAW ENFORCEMENT OFFICER. THE VEHICLE CURRENTLY HAS 88,607 MILES. AFTER REPORT 10307412, WE COMPLETED A FLEET WIDE INSPECTION OF FORD VEHICLES WITH STEEL WHEELS. THIS IS THE 4TH INCIDENT OF THIS NATURE TO OCCUR WITHIN 2 YEARS. THE OTHER 3 TIMES THE FAILURE OCCURRED ON OTHER FORD EXPEDITIONS. REPORTS WERE FILED HERE. SEE COMPLAINT 10286279, 10307412. BASED ON PRIOR 3 FAILURES, A UNIT-08 FOREST WIDE INSPECTION OF FORD VEHICLES WITH STEEL WHEELS IS UNDERWAY. I CURRENTLY HAVE TWO RIMS WITH TYPICAL RIM FAILURE AT THE BEAD FACE WELD FROM TWO DIFFERENT VEHICLES. PLEASE ADVISE IF PHOTO DOCUMENTATION IS REQUIRED. AFTER INSPECTION BY FORD TECHNICIAN, ALL 4 WHEELS WERE REPLACED. RECOMMEND FORD INITIATE A RECALL ON STEEL WHEEL FOR CRACK INSPECTION ASSOCIATED WITH 2003 AND NEWER FORD VEHICLES WITH STEEL WHEELS. *TR

TIRE RIM FAILURE ON A 2006 FORD EXPEDITION USED BY A U.S. FOREST SERVICE LAW ENFORCEMENT OFFICER. THE VEHICLE CURRENTLY HAS 71,000 MILES, THIS IS THE 3RD INCIDENT OF THIS NATURE TO OCCUR WITH 2 YEARS. THE OTHER 2 TIMES THE FAILURE OCCURRED ON ANOTHER FORD EXPEDITION. UNKNOWN IF REPORTS WERE FILED HERE. SEE COMPLAINT 10286279. BASED ON PRIOR 2 FAILURES, A REGION WIDE INSPECTION OF FORD VEHICLES WITH STEEL WHEELS IS UNDERWAY. IF A PHOTO IS NEEDED, I HAVE THAT AS WELL

TL*THE CONTACT OWNS A 2006 FORD EXPEDITION WHICH WAS PURCHASED BRAND NEW. WHILE STEPPING ON THE ACCELERATOR PEDAL AT ANY SPEED INCLUDING APPROXIMATELY 25 MPH, THE PEDAL BECAME STUCK IN THE OPEN THROTTLE POSITION. THE VEHICLE WAS TAKEN TO THE DEALER; HOWEVER, THE FAILURE COULD NOT BE DUPLICATED. THE FAILURE WAS ALSO REPORTED TO THE MANUFACTURER. THERE WERE NO RECALLS. NO REPAIRS WERE MADE TO DATE. THE FAILURE MILEAGE WAS 10,000 AND THE CURRENT MILEAGE WAS 45,000.

I HAVE A 2006 FORD EXPEDITION WITH APPROX. 42,000 MILES. THE INCIDENT THAT OCCURRED WITH THIS VEHICLE, WHICH IS DANGEROUS, IS WHEN THE VEHICLE'S ENGINE FAILSAFE MODE ENGAGES. I WAS ACCELERATING FROM A STOP ON A TWO LANE ROAD WHEN THE ENGINE FAILSAFE MODE ENGAGED. WHEN THIS OCCURRED, I LOST THROTTLE CONTROL, ALMOST CAUSING ANOTHER VEHICLE TO STRIKE THE REAR OF MY VEHICLE. THE SECOND INCIDENT WAS ON DEC. 28, 2009. I WAS MAKING A LEFT TURN ONTO A SIDESTREET WHEN THE ENGINE FAILSAFE MODE OCCURRED AGAIN CAUSING ME TO LOSE CONTROL OF THE ACCELERATOR. I WAS ALMOST HIT BROADSIDE WHEN THIS INCIDENT OCCURRED. THE ONLY WAY TO REGAIN THROTTLE CONTROL IS TO TURN THE VEHICLE OFF AND RESTART THE VEHICLE. BY TURNING OFF THE VEHICLE IT ALSO RESETS THE ENGINE FAILSAFE MODE. UPON CHECKING THE ENGINE FAILSAFE MODE ON THE INTERNET, IT APPEARS TO BE A COMMON PROBLEM. SOMEONE SHOULD MAKE FORD FIX THIS PROBLEM BEFORE SOMEONE GETS SERIOUS INJURED OR KILLED. *TR

FORD EXPEDITION STEEL WHEEL RIM FAILURE. *TR

THREE SEPARATE TIMES THE CAR SHUT OFF IN DIFFERENT TYPES OF "ENGINE FAILSAFE MODE" WITHIN THE PAST 7WEEKS. ENGINE FAILSAFE MODE CAUSES THE VEHICLE TO LOSE ALL POWER. LAST TIME THIS HAPPENED ON THE HIGHWAY AT 60 MPH WITH TWO SMALL CHILDREN IN THE VEHICLE. OTHER TWO TIMES IT OCCURRED WHEN SLOWING DOWN TO TURN. THERE IS GREAT POTENTIAL FOR THIS TO LEAD TO A VERY DANGEROUS SITUATION. OWNER'S MANUAL POINTS TO CRUISE CONTROL OR THROTTLE SYSTEM STUCK ALTHOUGH THE CRUISE CONTROL WAS NOT IN USE. EACH TIME VEHICLE RESTARTED WITH NO ISSUES. DEALER REPORTED IT WAS AN ISSUE WITH THE THROTTLE BODY AND POSSIBLY THE THROTTLE GETTING STUCK WIDE OPEN . NO EXPLANATION OR INVESTIGATION WAS DONE TO DETERMINE SPECIFIC ISSUES WITH THE THROTTLE BODY, EXCEPT IT JUST NEEDED TO BE REPLACED. REPAIR AT THIS PARTICULAR DEALER RUNS $800. NO DIAGNOSTICS WERE DONE ON THE THROTTLE POSITION SENSOR. ALTHOUGH COMPLETELY UNRELATED, THE DEALER OFFERED HALF OFF THE $600 60K TUNE-UP IF I REPLACED THE THROTTLE BODY. RESEARCH INDICATES THIS HAS HAPPENED TO A LOT OF 05/06 EXPEDITION VEHICLES WITH APPROX. 50-65K MILES, SIMILAR TO MY VEHICLE. I HAVE YET TO REPAIR THE VEHICLE, PART IS STILL ON IT. *TR

DRIVING VEHICLE AND CAR SHUT OFF. A WRENCH SYMBOL APPEARED. AFTER 2 ATTEMPTS, I WAS ABLE TO GET THE VEHICLE RESTARTED. TOOK CAR TO GARAGE FOR SERVICE AND WAS INFORMED THAT THE COMPUTER CODE WHICH CAME BACK WAS THE "CRUISE CONTROL CIRCUITRY" AND I WOULD NEED TO TAKE THE VEHICLE TO A FORD DEALERSHIP FOR SERVICE DUE TO THE NATURE OF THE REPAIR. *TR

THIS COMPLAINT IS IN REFERENCE TO OUR 2006 FORD EXPEDITION. THIS FAILURE AT THIS TIME SEEMS TO BE OCCURRING DURING NORMAL VEHICLE OPERATION, AT RANDOM INTERVALS. THE FAILURE IS BEING REPORTED BY THE OBD TO BE "THROTTLE BODY STUCK WIDE OPEN" WHICH RESULTS IN THE VEHICLE ENTERING FAILSAFE MODE, WHICH APPEARS TO RESTRICT THE RPM'S OF THE ENGINE. UPON ENTERING FAILSAFE MODE THE VEHICLE TENDS TO STALL AND SUBSEQUENTLY WILL NOT START FOR A SHORT PERIOD OF TIME FOLLOWING THE FAILURE. THIS FAILURE OCCURS WEEKLY AT VARIOUS TIMES OF THE DAY. AT THIS TIME THE CONCERN IS THAT IF THERE IS ANY FAILURE ON THE PART OF THE "FAILSAFE" MODE, THE VEHICLE WILL BE UNRESPONSIVE TO THE OPERATORS THROTTLE CONTROL AND IF THE THROTTLE BODY IS IN FACT STUCK WIDE OPEN THE VEHICLE WILL PROCEED TO INCREASE SPEED WITHOUT REGARD TO THE OPERATORS CONTROLS, RENDERING THE VEHICLE OUT OF CONTROL. AFTER SPEAKING WITH THE SERVICE DEPARTMENT AT OUR LOCAL FORD DEALERSHIP THE RECOMMENDED COURSE OF ACTION IS TO REPLACE THE THROTTLE BODY AS THIS IS A "COMMON OCCURRENCE". SEARCHES OF THIS ISSUE ONLINE RESULT IN MANY 2006 EXPEDITION OWNERS REPORTING THIS ISSUE FOR VEHICLES WITH MILEAGES RANGING FROM 50,000-55,000. THE FORD SERVICE DEPARTMENT STATED THAT THERE WAS A SERVICE BULLETIN ON THIS ISSUE BUT THAT IT DID NOT APPLY TO OUR VIN. SEARCHING THE ODI SERVICE BULLETIN DATABASE YIELDED NO RESULTS REGARDING THIS ISSUE. *TR

I HAVE A 2006 FORD EXPEDITION WITH 50,000 MILES ON IT. MY WIFE DRIVES THIS CAR WITH OUR CHILDREN. ABOUT 7 OR 8 TIMES NOW THE CHECK ENGINE OR (WRENCH LIGHT) COMES ON GOING DOWN THE ROAD AND SHUTS THE CAR OFF COMPLETELY. I HAVE LOOKED ONLINE AND HAVE SEEN THAT THOUSANDS OF PEOPLE ARE HAVING THE SAME THING HAPPEN TO THEM. FROM WHAT I READ IT HAS SOMETHING TO DO WITH THE ELECTRONIC THROTTLE CONTROL. I KNOW YOU PROBABLY GET COMPLAINTS ALL THE TIME BUT THIS IS VERY SERIOUS. EVERY POST ON THE WEB SAYS THAT FORD HAS NO RECALL AND THAT THE DEALERSHIPS ARE DOING NOTHING TO FIX THIS PROBLEM BUT PUTTING A NEW PART ON AND CHARGING FOR IT. THIS IS ABSOLUTELY RIDICULOUS. THERE IS OBVIOUSLY A PROBLEM. PLEASE HELP ME AND OTHERS TO FIX THIS PROBLEM BEFORE SOMEONE GETS HURT. *TR

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE PAINT ON THE TAIL GATE AND FRONT HOOD HAD BEGUN TO CRACK AND BUBBLE. THE VEHICLE WAS TAKEN TO THE DEALERSHIP FOR INSPECTION. THE TECHNICIAN CONCLUDED THAT NONE OF THE PAINT CAN BE SERVICED UNTIL CORROSION WAS EXHIBITED. THE CURRENT AND FAILURE MILEAGES WERE 82000.

TIRE RIM FAILURE ON A 2006 FORD EXPEDITION USED BY A U.S. FOREST SERVICE LAW ENFORCEMENT OFFICER. THE VEHICLE CURRENTLY HAS 90,200 MILES, THIS IS THE 4TH INCIDENT OF THIS NATURE TO OCCUR. THE OTHER 3 TIMES THE FAILURE OCCURRED ON ANOTHER FORD EXPEDITION AND REPORTS WERE FILED HERE WITH THE NHTSA. *TR

OUR 2006 FORD EXPEDITION ONLY HAD 35,490 MILES, AND WOULD START UP WITH A RATTLE. THE AIR WAS OK, BUT IT STOPPED WORKING OVER THE WEEKEND AND THE START UP RATTLE IN THE MORNING WENT AWAY. WE TOOK IT TO FORD, AS WE HAD 19 DAYS LEFT ON THE MANUFACTURE WARRANTY, AND IT NEEDED A NEW COMPRESSOR ASSEMBLY AND MANIFOLD AND TUBE ASSEMBLY, SUCTION AND DISCHARGE. NOW OUR AIR IS JUST LIKE NEW, NO START UP RATTLE. I SEARCHED THE INTERNET AND SEEMS MANY PEOPLE WITH THIS RATTLE, HAVE BEEN TOLD IT'S JUST SOMETHING THAT THE FORD EXPEDITION DOES. WE NOTICED DIE IN THE DISCHARGE THAT CAME FROM THE COMPRESSOR WHEN IT FAILED, LIKE SOMEONE HAD LOOKED AT THIS BEFORE AND JUST PATCHED IT. WE BOUGHT IT FROM CARMAX JAN 2009. I THINK A RECALL NEEDS TO TAKE PLACE FOR ALL 2006 FORD EXPEDITION OWNERS CAN GET THEIR AC COMPRESSOR AND MANIFOLD AND TUBE REPLACED. *TR

MY CAR STALLED AT AN INTERSECTION LIGHT. IT WAS DRIVING POORLY-MAKING LOUD NOISES AND STICKING AS I PRESSED THE GAS PEDAL AS IF THE TRANSMISSION WAS GOING OUT. WE WERE TOLD IT WAS COVERED UNDER THE POWERTRAIN WARRANTY AND WE TOOK IT IN TO FORD. THEY TOLD US IT WAS THE TIMING CHAIN BUT BECAUSE THERE WAS EVIDENCE OF SLUDGE, THE WARRANTY CLAIM WAS DENIED BY FORD. THEY CLAIM WE DID NOT MAINTAIN OUR VEHICLE. WE BELIEVE IT IS A DEFECT IN THE SYSTEM. WE HAVE MAINTAINED THE OIL ON A REGULAR BASIS AND HAVE HAD OTHER MAJOR REPAIRS WITH THIS CAR. IT HAS HAD A NEW TRANSMISSION AT 35,000 AS WELL AS A NEW SUSPENSION SYSTEM AND ELECTRICAL FAILURE WITH THE STEREO/DVD SYSTEM. THERE HAS NEVER BEEN ANY PRIOR EVIDENCE OF SLUDGE. AN ACCIDENT COULD HAVE OCCURRED WHEN THE CAR STALLED. *TR

DEFECTIVE PAINT. *TR

LOW DRIVER SIDE TIRE INDICATOR SOUNDED A FEW HOURS PRIOR TO ACCIDENT WHERE VEHICLE FLIPPED OVER 4 TIMES 70-80 FEET END OVER END BOUNCED OFF A TELEPHONE POLE THEN LANDED IN THE OPPOSITE LANE BACK WARDS. THE LOW TIRE INDICATOR HAD GONE OFF TWICE TO WHICH THE TIRE WAS TAKEN TO THE STATION TO BE REFILLED UP TO AIR PRESSURE AS RECOMMENDED BY THE SERVICE MANUAL. DRIVING SPEED WAS CLOSE TO 50 MPH ON A SLIGHTLY RURAL ROAD WITH NOT MANY TURNS MOSTLY STRAIGHTAWAYS. JUST COMING OUT OF A SMALL RIGHT TURN THE TIRE MUST HAVE LOST AIR JERKED THE STEERING CAUSING THE VEHICLE TO ROLL OVER END OVER END CARTWHEELING AND LANDING IN 4 SPOTS ACCORDING TO TIRE MARKS ON THE ROAD ITSELF EACH DOUBLE LINED MARK WAS ON THE CENTER LINE OF THE ROAD ABOUT 70-80 FEET APART BEFORE HITTING THE POLE AND BOUNCING THE VEHICLE INTO THE OPPOSITE LANE FACING THE OTHER DIRECTION. WHERE UPON AIDE OF OTHERS IT COULD NOT BE RESTARTED AND THE DRIVERS SIDE TIRE WAS COMPLETELY UNUSABLE. THE VEHICLE BROKE OUT 3 WINDOWS AND THE WINDSHIELD IS WASTED, CAN BE STARTED BUT GRINDS WHEN PUT IN GEAR, CAN NOT BE DRIVEN EVEN AFTER TIRE REPLACEMENT. *TR

ENGINE FAILURE OF 2006 FORD EXPEDITION. DEALERSHIP EXPLAINED THE ENGINE HAD A BENT INJECTOR ROD . ADVISED NEW ENGINE WAS NECESSARY. COST ESTIMATE $4000-$7000. *TR

PAINTED METAL TRIM AT THE BOTTOM OF SIDE WINDOWS IS RUSTING AND THE PAINT IS PEELING. IF PAINTED CORRECTLY AT THE FACTORY NO WAY THIS WOULD BE HAPPENING. I HAVE ALSO NOTICED THIS SAME PRBLEM ON MANY OTHER EXPEDITIONS, YET FORD SAYS NOT THERE PROBLEM. *TR

TL*THE CONTACT OWNS A 2006 FORD EXPEDITION. WHILE DRIVING 20 MPH, THE VEHICLE STALLED. THE ENGINE WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL AND READ, "ENGINE FAIL SAFE MODE." AFTER SEVERAL ATTEMPTS, THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE DEALER REPLACED THE THROTTLE BODY ASSEMBLY. AFTER THE REPAIR, THE CONTACT BEGAN SMELLING A BURNING OIL ODOR IN THE VEHICLE. THE SMELL BECAME STRONGER AND THEN TURNED INTO A GASEOUS ODOR, WHICH WAS ALSO ENTERING THROUGH THE INTERIOR VENTS. THE CONTACT INSPECTED THE VEHICLE, BUT COULD NOT LOCATE ANY GAS LEAK. THE ODOR BECAME SO OVERPOWERING THAT ONE OF THE OCCUPANTS HAD A NOSE BLEED AND SEVERAL OTHER OCCUPANTS SUFFERED HEADACHES AND STOMACH ACHES. THE DEALER STATED THAT THE OIL LEVEL WAS TOO HIGH AND CAUSED THE FUEL ODOR. THE ODOR IS STILL PRESENT. THE CURRENT AND FAILURE MILEAGES WERE LESS THAN 66,000.

I HAVE A 2006 FORD EXPEDITION THAT HAS BUBBLING AND PEELING PAINT ON THE HOOD AND BACK HATCH. *TR

2006 FORD EXPEDITION, HAS STOPPED SEVERAL TIMES WHILE IN ROUTE SOMEWHERE. JUST STOPS AT ONCE AND SAFE MODE FAILURE LIGHT COMES ON. POWER STEERING FAILS, AS WELL AS ENGINE STOPPING. HAVE HAD REBUILT TRANSMISSION, REPLACE THE THROTTLE, AND SEVERAL OTHER THINGS INCLUDING I BELIEVE AIR PUMP. NONE OF THIS CHEAP. BUT BIGGEST CONCERN IS THE SAFETY OF THE VEHICLE. HAVE BEEN VERY BLESSED THAT NO ONE HAS BEEN BEHIND ME WHEN THIS HAS HAPPENED OR ON THE HIGHWAY. THIS IS VERY SCARY AND FORD NEEDS TO RECALL AND FIGURE OUT WHAT IS CAUSING THIS TO OCCUR. *TR

MY 2006 EXPEDITION HAD A SPARK PLUG BLOWOUT. I UNDERSTAND THIS IS A FREQUENT PROBLEM AND IS A DESIGN DEFECT VERSUS A MAINTENANCE ISSUE. I DID BUY THE EXTENDED WARRANTY AND HAVE BEEN TOLD IT IS NOT COVERED. *TR

A WHEEL SEPARATED ON A 2006 FORD EXPEDITION. WE REPLACED THE WHEEL AND I HAVE THE ORIGINAL THAT FAILED. *TR

ENGINE SHUTS OFF WHILE DRIVING DOWN THE STREET. ENGINE FAIL-SAFE LIGHT IS DISPLAYED. WAS BARELY ABLE TO STEER THE VEHICLE TO A SAFE AREA. RESTARTED ENGINE, EVERYTHING CAME BACK UP AGAIN. *TR

MY TRUCK WENT INTO FAIL SAFE MODE WHILE ON THE HIGHWAY. THIS CAUSED THE TRUCK TO STOP SUDDENLY WITH NO USE OF GAS PEDAL BUT THE ENGINE WAS STILL RUNNING. THIS ALMOST CAUSED AN ACCIDENT. I WAS ABLE TO DRIFT OVER AND SHUT THE ENGINE OFF AND RESTART IT AND IT RAN FINE THE REST OF THE DAY. NOW I AM AFRAID TO DRIVE IT. *TR

TAIL GATE CORROSION ROOF CORROSION HOOD CORROSION 2006 EXPEDITION 26,000 MILES. *TR

MY TRUCK WENT INTO FAIL SAFE MODE WHILE ON THE HIGHWAY. THIS CAUSES THE TRUCK TO STOP SUDDENLY WITH NO POWER TO ACCELERATE BUT THE ENGINE STILL RUNS. THIS CAUSED ME TO ALMOST BE CRUSHED BY A TRACTOR TRAILER BEHIND ME. I HAD SEVERAL CHILDREN IN THE CAR TOO!! *TR

THANKFULLY NO CRASH HAS HAPPENED YET. HOWEVER, MY COMPLAINT DEALS WITH MY 2006 LIMITED FORD EXPEDITION. IN THE BACK WHERE THE THIRD ROW SEATS ARE LOCATED, THERE IS NO POSSIBLE WAY FOR THOSE PASSENGERS TO ESCAPE IN THE EVENT OF A CRASH. THE BACK WINDOW DOES NOT HAVE A SWITCH/RELEASE TO OPEN ANY WINDOWS. THE DOOR DOES NOT HAVE ANY TYPE OF DEVICE TO OPEN THE TAIL GATE. *TR

DRIVING ON HIGHWAY AND SUV JUST SHUTS DOWN, WITHOUT WARNING. THIS IS THE 2ND TIME THIS HAS HAPPENED. *TR

DRIVER SIDE AIRBAG FAILURE TO DEPLOY-WAS INVOLVED IN A SINGLE CAR ACCIDENT ON NOV. 24, 2008...HIT BLACK ICE PATCH, ENDED UP IN A DEEP DITCH AND CREEK BED. WAS TRAVELING APPROX 35 TO 40 MPH. FRONT END OF CAR EXPERIENCED HEAVY DAMAGE. DRIVER WAS WEARING SEAT BELT. PASSENGER AIRBAG DID DEPLOY, NO PASSENGER PRESENT IN VEHICLE. DRIVER SIDE AIRBAG DID NOT DEPLOY. THIS IS A SERIOUS SAFETY ISSUE!!!! VEHICLE SUSTAINED $13,000 IN ESTIMATED REPAIRS. MILEAGE ON VEHICLE WAS 53,000. DUE TO EXTENSIVE REPAIR ESTIMATE, VEHICLE WAS DEEMED TOTALED. WE ARE SEEING SEVERAL OTHERS IN THIS WEBSITE AND OTHERS ON THE INTERNET WHO HAVE EXPERIENCED FRONT END AND REAR END CRASHES WITH THIS MODEL AND YEAR AUTO AND OBVIOUSLY NO ONE AT FORD IS BOTHERING TO PHONE PEOPLE BACK, NOR INVESTIGATE THE PROBLEM OR DO A RECALL. HOW MANY LIVES WILL BE TAKEN BEFORE ANYONE DOES ANYTHING?? LUCKILY I WAS NOT INJURED IN THE CRASH OTHER THAN A SORE NECK FROM THE SEATBELT LASHING. WE PAY FOR THESE "SAFETY" ITEMS ON OUR VEHICLES BUT WHAT GOOD ARE THEY WHEN THEY DO NOT WORK????????? IT'S INSANE. *TR

TL*THE CONTACT OWNS A 2006 FORD EXPEDITION. ON FOUR SEPARATE OCCASIONS, WHILE DRIVING WITH THE ACCELERATOR PEDAL DEPRESSED, THE VEHICLE SHUT OFF. A WRENCH SYMBOL APPEARED ON THE INSTRUMENT PANEL AND THE VEHICLE HAD TO BE RESTARTED. THE DEALER COULD NOT DUPLICATE OR DETERMINE THE CAUSE OF THE FAILURE. THE SPEED WAS UNKNOWN. THE CURRENT MILEAGE WAS 64,749 AND FAILURE MILEAGE WAS 63,000.

A 17" TIRE RIM ON A 2006 FORD EXPEDITION HAS FAILED FOR THE SECOND TIME. THE FIRST FAILED RIM WAS REPLACED BY FORD MOTOR CO. WITH A NEW RIM AND NOW ONLY A COUPLE OF MONTHS LATER THIS SECOND RIM HAS FAILED. THE WELD HAS FAILED ON THE RIM CAUSING SEPARATION AND A SERIOUS SAFETY HAZARD FOR ANY VEHICLE OCCUPANTS. *TR

I AM DRIVING A 2006 FORD EXPEDITION. THE OTHER MORNING, I PUT MY CHILD IN THE CAR SEAT BEHIND THE DRIVERS SEAT. I HALF ENTERED THE CAR TO TURN ON THE ENGINE, AS IT WAS CHILLY OUT. ABOUT 5-10 SECONDS AFTER TURNING THE CAR ON, I HEARD A HUGE EXPLOSION. SOUNDED AS IF A RIFLE HAD BEEN SHOT NEXT TO MY HEAD. THE BABY WENT NUTS. I LOOKED AROUND, AND THE SIDE AIRBAGS HAD DEPLOYED. THIS WAS THE FIRST TIME I HAD TURNED THE CAR ON THAT DAY. LUCKILY NO ONE WAS HURT. IF IT HAD HAPPENED ON MY SIDE, IT WOULD HAVE SLAMMED INTO ME PRETTY GOOD, AS WELL AS MY CHILD. THE DEALERSHIP I BOUGHT IT FROM MADE ME PAY TO HAVE IT DRIVEN TO THEM AND THE RENTAL CAR. THEY WOULD NOT DRIVE IT THEMSELVES FOR FEAR OF ANOTHER AIR BAG DEPLOYING WHILE THEY WERE DRIVING. THIS IS OF COURSE WHY I WOULDN'T DRIVE IT EITHER. MY CAR IS OUT OF WARRANTY. THEY ARE INSISTING I PAY FOR THE REPAIR. IT IS $2500. I THINK THIS IS A SERIOUS SITUATION AND AM CONCERNED IT COULD HAPPEN AGAIN, MAYBE WHILE I AM DRIVING. THE DEALERSHIP SAID SINCE NO ONE WAS HURT IN THIS INSTANCE IT WASN'T THERE PROBLEM. DO I HAVE ANY RECOURSE? SINCERELY, JENNIFER VESTAL *TR

MY BEST FRIEND FATHER AND GRANDMOTHER DIED INSIDE AN SUV ACCIDENT THAT EMERGED INTO A SWIMMING POOL. WINDOWS WERE CLOSED. THERE WAS NO WAY OUT OF THE SUV DUE TO POWER WINDOWS. THEY SAT THERE WAITING FOR DEATH. SOMETHING HAS TO BE DONE TO ALL VEHICLES WHO ARE BUILT WITH POWER WINDOWS. THE SAME WAY THAT MOST MODERN VEHICLES NOW HAVE A WAY OF ESCAPING FROM THE TRUNK OF A CAR WHY ISN'T THERE SOMETHING WHERE THERE IS A WAY OF ESCAPING FROM A CAR WINDOW IF THE CAR GOES INTO A POOL OF DEEP WATER ABOVE 5 FEET. THESE AUTOMOBILE COMPANIES NEED TO CREATE AN EMERGENCY MECHANISM IN ALL POWER WINDOWS IN CASE OF THE CAR GOING INTO A LAKE, RIVER, POOL, ETC. ALL WINDOWS FRONT AND BACK WINDOWS SHOULD HAVE A MANUAL ROLL DOWN KNOB OR WHATEVER IT IS CALLED FOR SUCH ACCIDENTS. I'M PRETTY SURE THAT IF MY FRIENDS FATHER HAD SOME KIND OF TOOL TO BREAK THE WINDOWS HE WOULD OF BUT WHO IS TO SAY THAT THE RUSHING WATERS WOULD HAVE STILL KILLED THEM. THEY WERE SENIOR CITIZENS THAT DIED SO TRAGICALLY AND THEY ARE NOT THE ONLY ONE. I'M NOT SURE IF THIS IS THE RIGHT DEPARTMENT FOR SUCH A COMPLAINT, BUT IF THIS IS THE WRONG DEPARTMENT CAN SOMEONE PLEASE DIRECT ME TO THE PROPER CHANNELS. THIS INCIDENT IS STILL UNDER INVESTIGATION BUT IT IS NOT KNOWN HOW THEY ENDED UP INSIDE A SWIMMING POOL. IF SUCH MECHANISM IS INVENTED, IT SHOULD NOT BE AN OPTIONAL IT SHOULD BE MANDATORY JUST LIKE SEATBELTS AND AIRBAGS AND SHOULD NOT BE COSTLY TO THE CONSUMER DUE TO THAT IT IS A LIFE SAVING TO HUMANS AND ANIMALS FOR THAT FACT. I HOPE I AM UNDERSTOOD AND THAT THIS COMPLAINT SHOULD BE TAKEN SERIOUSLY AS IT WILL SAVE A LOT OF LIVES. I ALSO HOPE THAT I HAVE MADE MY SELF CLEAR AND UNDERSTANDABLE. THANK YOU. *TR

AUGUST 21 ON THE WAY TO WORK (4 MILE DRIVE) THE TRUCK STARTED TO SHAKE AND LOST POWER,CHECK ENGINE LIGHT CAME ON, WE TOOK THE TRUCK TO THE DEALER,AND THEY CAN NOT FIGURE WHAT IS GOING ON,SO THEY SAID THE ENGINE NEEDS TO BE REPLACED. THE CODES ARE P0022-P0305-P0307-P1184-P2198-P2273 MY FAMILY JUST CAME BACK FROM A 3000 TRIP ,I CAN ONLY IMAGINE HAVING THIS HAPPENING TO US DURING THIS TIME. I BEEN LOOKING FOR THE SAME TYPE OF TROUBLE TO THIS TRUCKS AND FOUND THAT THERE IS A NUMBER OF SIMILAR COMPLAINTS ABOUT HAVING TO REPLACE ENGINES RANGING FROM 38,000 MILES TO ABOUT 60,000MILES. THE PRICE OF THIS CARS ARE WELL OVER $35,000 TO HAVING TO SPEND ANOTHER $7,000 WITH ALL THE PROBLEMS OF OUR ECONOMY RIGHT NOW A NORMAL PERSON LIKE ME CAN NOT AFFORD ANOTHER RIP OFF BY ONE OF THE BIG COMPANIES,LIKE FORD. ALL I'M ASKING IS THAT THEY TAKE RESPONSIBILITY FOR THIS ENGINE TROUBLES AND REPAIR LIKE THEY SUPPOSED TO. *TR

TL*THE CONTACT OWNS A 2006 FORD EXPEDITION. WHILE DRIVING BETWEEN 25-55 MPH, THE VEHICLE BEGAN TO VIBRATE AND SHAKE VIOLENTLY, THE ENGINE LIGHT ILLUMINATED, AND SMOKE APPEARED FROM THE TAIL PIPE. THE VEHICLE COULD NOT BE DRIVEN GREATER THAN 60 MPH. THE HIGHER THE SPEED, THE MORE THE VEHICLE WOULD SHAKE AND VIBRATE. THE FAILURE OCCURRED EVERYTIME THE VEHICLE WAS DRIVEN. THE DEALER HAS HAD THE VEHICLE SINCE JUNE 24, 2008, BUT THEY STILL CANNOT DETERMINE THE CAUSE OF THE FAILURE. THE CURRENT AND FAILURE MILEAGES WERE UNAVAILABLE. UPDATED 09/29/08.*LJ THE DEALER REPLACED THE CONVERTER. UPDATED 09/29/08. *JB

THE 17" STEEL TIRE RIM ON THE 2006 FORD EXPEDITION HAD SPLIT. *TR

TL*THE CONTACT OWNS A 2006 FORD EXPEDITION. WHILE DRIVING APPROXIMATELY 70 MPH, THE VEHICLE COMPLETELY SHUT OFF WITHOUT WARNING. THE VEHICLE HAD TO BE MANEUVERED ACROSS FOUR LANES OF TRAFFIC, BUT WAS RESTARTED ON THE FIRST ATTEMPT. THE CURRENT AND FAILURE MILEAGES WERE 30,000. UPDATED 09/10/08. *LJ UPDATED 09/11/08.*JB

I HAVE A 2006 FORD EXPEDITION. 31,000 MILES. I HAVE PAINT BUBBLES ON THE HOOD AND REAR TAIL GATE ON THE INSIDE AND OUTSIDE. FORD TOLD ME TO TAKE IT TO A SERVICE CENTER. SERVICE CENTER SAID THEY WON'T FIX IT UNTIL IT BECOME A HOLE IN THE METAL. ARE YOU KIDDING ME! $35,000 SUV 2YRS. OLD AND I HAVE TO SPEND $1,200.00 OUT OF POCKET TO FIX IT. LAST FORD I'LL EVER OWN! *TR

MY 2006 FORD EXPEDITION SUDDENLY SHUTS DOWN FOR THE THIRD TIME NOW WHILE DRIVING ON THE ROAD. THE ENGINE SHUTS DOWN SUDDENLY AND GIVES OUT THE ENGINE FAIL SAFE MODE MESSAGE ON THE BOARD. DEALER SAYS NOTHING SHOWING UP ON THE DIAGNOSTICS. HOW COULD THAT BE. THERE'S GOT TO BE A REASON WHY THAT SUV SUDDENLY SHUT ITS ENGINE DOWN. ACCIDENT WILL HAPPEN IF THIS WILL NOT BE RESOLVED. *TR

2006 FORD EXPEDITION HAS SAFETY ISSUES WITH ENGINE. CONSUMER STATES THAT THE ENGINE GAGS OR SHAKES UPON IGNITION. CONSUMER IS MOSTLY WORRIED ABOUT THE WOBBLING WHEN MAKING TURNS. CLAIMS THERE IS LOSS OF POWER. *KB THE REAR LATCH WOULD STICK AT TIMES TO THE POINT WHERE THE DOOR WOULD NOT CLOSE. *JB

2006 FORD EXPEDITION THAT CUTS OUT WHILE DRIVING, STARTED AT APPROX 18K AND HAS BEEN TO SAME FORD DEALER 5 TIMES. PROBLEM HAS NOT RECURRED SINCE LAST VISIT TO DEALER BUT COULD COME BACK AND IS SERIOUS SAFETY FACTOR AS A TOTAL LOSS OF POWER WITHOUT WARNING. LAST REPAIR NOTED A ADJUSTMENT OR REPAIR TO THROTTLEBODY. *TR

VEHICLE VIBRATION, SLOW LEAK OF TIRE PRESSURE. NEED FOR REPAIR INDICATED A WHEEL FAILURE WITH 25% TO 50% OF OUTER RIM CRACKING AWAY FROM WHEEL. VEHICLES ARE FORD EXPEDITIONS ONE A MODEL YR 2004 AND THE OTHER A MODEL YEAR 2006. USED IN LAW ENFORCEMENT. LOCAL FORD DEALERSHIP CONTACTED. *TR

TL*THE CONTACT OWNS A 2006 FORD EXPEDITION. THE VEHICLE HAS CONTINENTAL CONTITRAC, SIZE P265/70R18 TIRES. THE CONTACT NOTICED THAT THE REAR DRIVER SIDE TIRE WOULD CONTINUOUSLY FLATTEN EVEN AFTER REFILLING IT WITH AIR. THE DEALER STATED THAT THE TIRES WERE NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 05T022000 (TIRES:TREAD/BELT) ALTHOUGH SHE WAS EXPERIENCING THE SAME FAILURE. AFTER INSPECTING THE TIRE, THE CONTACT NOTICED THAT THE SEAM WAS SEPARATING FROM THE TIRE. PRIOR TO OPERATING THE VEHICLE, THE TIRE PRESSURE WAS NORMAL AND THE TIRE TREAD WAS 5/30 SECONDS. THE TIRES HAVE NOT BEEN REPLACED. THE CURRENT AND FAILURE MILEAGES WERE 23,000. UPDATED 02/12/08. *LJ THE CONSUMER STATED ALL 4 TIRES WERE REPLACED AND THEY WERE ONLY A YEAR OLD.

I PURCHASED A 2006 FORD EXPEDITION IN APRIL OF '06, BEGINNING IN NOVEMBER OF '06 MY ENGINE BEGAN STALLING. THE CONSEQUENCES INCLUDED LOSS OF BRAKING POWER, FREEZING OF STEERING, VEHICLE SLOWING WITH NO CONTROL. I BROUGHT THIS TO MY DEALERS ATTENTION ON NUMEROUS OCCASIONS AS THE PROBLEM HAS CONTINUED THROUGHOUT 2007. I AM VERY CONCERNED OF THE POTENTIAL FOR ACCIDENTS AND INJURIES. *TR

FACTORY PAINT IS BUBBLING THE WARRANTY DOES NOT COVER IT. *TR

NO INCIDENT YET. VEHICLES TRACTION CONTROL FAILS, ABS FAILS AND 4 WHEEL DRIVE FAILS ALL AT THE SAME TIME. *TR

THE VEHICLE SMELLED LIKE IT WAS ON FIRE UP FRONT IN THE ENGINE COMPARTMENT. THE FRONT TIRE WERE EXTREMELY HOT. MY WIFE DID NOT HAVE ANY BRAKES TO AMOUNT TO ANYTHING WHEN SHE PRESSED THE BRAKE PEDAL TO STOP. THE DEALERSHIP STATED THAT THE BRAKE MASTER CYLINDER WAS BAD. THEY REPLACED THE BRAKE MASTER CYLINDER. *TR

PURCHASED VEHICLE IN JANUARY 2006, BRAND NEW FROM THE DEALER. SHORTLY THEREAFTER, THE BACK WINDOW WAS LEAKING. HAD THE BACK WINDOW REPAIRED, STILL LEAKS. THE SEAL ON BOTH THE DRIVER AND PASSENGER'S FRONT WINDOWS WERE MISSING. TOOK THE VEHICLE BACK 3 TIMES BEFORE THIS WAS FIXED. AFTER THAT, THE ENGINE BEGAN MAKING A LOUD GRINDING NOISE. VEHICLE HAS BEEN BACK IN THE SHOP AT LEAST 3 TIMES, ONE TIME THEY KEPT IT FOR A WEEK, CLAIM THEY CAN NOT DUPLICATE. THEY THEN DECIDED IT WAS THE A/C COMPRESSOR AND WE SHOULD HAVE THE A/C OFF WHEN STARTING THE VEHICLE. TRIED IT, DOES NOT WORK. NOW THAT THE VEHICLE IS OUT OF WARRANTY, IT IS MAKING THE LOUD GRINDING NOISE EVEN MORE. AT ONE POINT, WE WERE TOLD BY A SALESMAN THAT WE SHOULD JUST CALL ROADSIDE ASSISTANCE IF WE BREAK DOWN WHILE ON VACATION. JUST WHAT WE WANTED WAS TO HAVE OUR VACATION RUINED BY A FORD SCREW UP. THE DEALER WON'T ACKNOWLEDGE THAT THERE IS A PROBLEM AND WON'T FIX IT. ON TOP OF THAT THE DVD ENTERTAINMENT SYSTEM THAT CAME WITH THE VEHICLE WON'T STAY CLOSED, THE COVER OVER THE MOTOR FOR THE THIRD SEAT HAS COME DETACHED AND DOESN'T FOLD UP RIGHT AND THE AIR CONDITIONER IS WARM WHEN SITTING STILL. ALL PROBLEMS THAT A MAJOR CORPORATION SHOULD NOT HAVE ON A VEHICLE THAT HAS BEEN ON THE MARKET FOR SEVERAL YEARS. WOULD REALLY LIKE ALL THE PROBLEMS COMPLETELY FIXED OR A REPLACEMENT. DRIVER'S SIDE AIRBAG DID NOT DEPLOY WHEN HAD VERY HARD FRONTAL IMPACT EITHER.

THE DEALERSHIP HAD JUST FINISHED REMOVING AN EXTRA ALARM THEY HAD INSTALLED ON THE 2006 FORD EXPEDITION. I WAS SITTING IN THE FRONT SEAT AND WAS EXCITED ABOUT GETTING A NEW TRUCK, AND ENDED UP SHIFTING IT OUT OF GEAR WITHOUT MY FOOT BEING ON THE BRAKE. I TOLD OUR SALES PERSON AND THEY WANTED TO FIX IT BEFORE WE TOOK DELIVERY OF THE TRUCK. THE NEXT DAY THEY CALLED AND TOLD US IT WAS READY. THEY HAD REPLACED THE SHIFT ACTUATOR. WE CHECKED IT AND IT SEEMED TO WORK FINE. A YEAR LATER, MY KIDS WERE GETTING IN THE CAR, I WENT BACK INTO THE HOUSE TO GET SOMETHING I FORGOT, AND MY 2 YEAR OLD CLIMBED IN O THE FRONT SEAT AND WAS PLAYING AND PULLED THE TRUCK OUT OF GEAR WITHOUT HER FOOT BEING ON THE BRAKE AND NO KEYS IN THE IGNITION. THE TRUCK ROLLED OUT OF DRIVEWAY ACROSS THE STREET AND DOWN MY NEIGHBOR'S YARD AND HIT A TREE. LUCKILY NO ONE WAS HURT. MY 10 YEAR OLD WAS IN THE BACK SEAT AND MY 7 YEAR OLD WAS STANDING NEXT TO THE TRUCK. THE DEALERSHIP SAID THEY WOULD FIX THE PROBLEM BECAUSE IT? WAS STILL UNDER WARRANTY. NEITHER FORD NOR DEALERSHIP FELT THAT THEY SHOULD PAY FOR THE $1,343.18 WORTH OF DAMAGES TO OUR VEHICLE.*AK

TL*THE CONTACT OWNS A 2006 FORD EXPEDITION. WHILE ATTEMPTING TO STOP THE VEHICLE, THE BRAKE PEDAL EXTENDED TO THE FLOOR. ON NOVEMBER 6, 2006, THE CONTACT WAS UNABLE TO ENGAGE THE BRAKES AND CRASHED INTO A VEHICLE. THE CONTACT WAS INJURED AND THE AIR BAGS DEPLOYED. THERE WERE NO PASSENGERS IN THE VEHICLE AT THE TIME. THE MOST RECENT FAILURE OCCURRED ON JUNE 1, 2007. THE VEHICLE WAS REPAIRED AND MOST OF THE BRAKING SYSTEM WAS REPLACED. A MONTH LATER THE ANOTHER CRASH OCCURRED WHILE DRIVING 25MPH AND ATTEMPTING TO ENGAGE THE BRAKE PEDAL. THERE WERE NO INJURIES. THE TOTAL COST OF REPAIRS WERE $2,300. THE VEHICLE IS EQUIPPED WITH AN ELECTRONIC STABILITY THAT TAKES OVER AND IT LEAVES THE CONTACT WITH NO CONTROL OF THE BRAKING SYSTEM. THE DEALER STATED THAT HE WAS ALSO UNABLE TO DIAGNOSE THE RECENT FAILURE AND THERE WERE NO INDICATIONS FROM THE COMPUTER CODES. THERE WERE A TOTAL OF 4 VEHICLES INVOLVED IN THE CRASH AND 3 OF THEM WERE DAMAGED INCLUDING THE CONTACTS VEHICLE. THE CURRENT MILEAGE WAS 19,783 AND THE FAILURE MILEAGE WAS 13,000.

TL*THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THAT THE AUTOMATIC DOOR LOCKS PINCHED HER SISTERS ARM AND LEFT A BRUISE. THE DEALER HAS NOT INSPECTED THE VEHICLE. THE CURRENT AND FAILURE MILEAGES WERE 21,000. REMAILED REQUEST 04/09/08. *LJ

I WAS INVOLVED IN AN ACCIDENT GOING ABOUT 35 MPH AT THE TIME. I PRESSED THE BRAKES AND HIT THE CAR IN FRONT OF ME. THE AIRBAGS NEVER DEPLOYED . DRIVER HAD ALL CHILDREN IN THE VEHICLE . THOUGHT THERE WAS SOMETHING WRONG WITH THE SENSOR THAT MADE THE AIRBAGS NOT DEPLOY. HAD THE TRUCK CHECKED BY GALPIN FORD, BUT THEY SAID THAT NOTHING WAS WRONG WITH THE VEHICLE. I AM EXTREMELY CONCERNED ABOUT THIS BECAUSE I AM AFRAID THAT THE AIR BAGS WILL DEPLOY AT ANY TIME FOR ANY APPARENT REASON SINCE THEY DID NOT DEPLOY AT THE TIME OF THE ACCIDENT. *AK

I LOST CONTROL OF THE 2006 FORD EXPEDITION ON ICY ROADS AND WENT INTO DITCH AND HIT ENBANKMENT HEAD ON. MY PASSENGER SIDE AIR BAG DEPLOYED, BY THE DRIVER SIDE DID NOT. I WAS WEARING A SEATBELT. BECAUSE THE AIR BAG DID NOT DEPLOY, I HIT THE STEERING WHEEL WITH MY CHEST AND PART OF MY STOMACH. THIS WAS A CONCERN BECAUSE I AM 19 WEEKS PREGNANT.*AK

FRONT ROTORS TURNED BY DEALER SEVERAL WEEKS PRIOR DUE TO VIBRATION WHEN STOPPING. SAME PROBLEM RETURNED AND DEALER THIS TIME REPLACED ROTORS AND CALIPERS. NOW BRAKES FEEL WEAK, AND TRAVEL OF PEDAL HAS INCREASED BEFORE BRAKES ENGAGE. DEALER CLAIMS THIS IS WITHIN NORMAL OPERATION . DEALER CLAIMS NEW CALIPERS HAVE LARGER PISTON SO THIS IS REASON FOR INCREASED PEDEL TRAVEL AND DIFFERENT FEEL OF BRAKES ? BRAKES DO NOT FEEL AS IF STOPPING VEHICLE AS BEFORE PROBLEM BEGAN . RETURNED AGAIN TO ASK DEALER 3-19-07 TO BLEED SYSTEM DUE TO SOFT PEDAL AND CONCERN. SYSTEM BLED MANUALLY THIS TIME AND PEDAL GOT SOME WHAT BETTER . STILL NOT AS FIRM AS WHEN PROBLEM STARTED. PEDAL TRAVEL INCREASE IS STILL PRESENT BEFORE BRAKES ENGAGE. VEH DOES NOT STOP AS WELL AS BEFORE PROBLEM BEGAN .

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION, EDDIE BAUER EDITION. THE VEHICLE WAS PURCHASED IN 03/2006. ON 10/15/06 THE CONTACT HEARD A LOUD NOISE AND EXPERIENCED VIBRATION IN THE STEERING WHEEL WHILE DRIVING SPEEDS RANGING FROM 5 TO 50MPH. ON 10/21/06 THE DEALER REPLACED THE STEERING RACK. THE FAILURE MILEAGE WAS 9,087. THE NOISE AND THE VIBRATION CONTINUED TO OCCUR AFTER THE VEHICLE WAS REPAIRED. ON 11/13/06 THE STEERING RACK WAS REPLACED AGAIN FOR THE SAME FAILURE. TWO TO THREE DAYS AFTER THE VEHICLE WAS REPAIRED, THE NOISE AND VIBRATION REOCCURRED. THE DEALER WAS INFORMED OF THE FAILURE AND ADVISED THE CONTACT TO BRING THE VEHICLE IN TO DIAGNOSE IT ON 12/06/2006. THE DEALER ADVISED THE CONTACT THAT THEY WERE UNABLE TO REPAIR IT UNTIL A FORD ENGINEER INVESTIGATED THE FAILURE. ON 02/12/07, THE CONTACT RECEIVED A LETTER FROM THE DEALER STATING THAT THE FAILURE WAS NOT UNCOMMON FOR THIS TYPE OF VEHICLE. THE MANUFACTURER STATED THAT NO FURTHER ACTION WAS NEEDED. THE CONTACT FILED A LEMON LAW CASE IN HIS STATE WITH A COURT DATE FOR 09/28/07. ON TWO ATTEMPTS THE VEHICLE FAILED INSPECTION. THE CONTACT STATED THAT THIS WAS A SAFETY ISSUE ANDWAS REQUESTING THAT THE VEHICLE BE REPAIRED. THE CURRENT MILEAGE WAS 10,000. *AK

AT ABOUT 11,000 MILES I HAD THE FIRST INCIDENT WHILE IN NORMAL TRAFFIC GOING ABOUT 45 MPH. FELT LIKE THE TRANSMISSION SLIPPED. NO POWER DURING 1ST AND 2ND GEAR CHANGE. A FEW DAYS LATER THE SAME THING HAPPEN WHILE ENTERING THE INTERSTATE. WHILE TRYING TO ACCELERATE THERE WAS NO POWER, NEARLY HIT BY SEMI-TRUCK, COULDN'T GET OVER 60 MPH AND THE CHECK ENGINE LIGHT CAME ON. I SLOWED BACK ON THE ACCELERATOR AND LIGHT WENT OFF AND POWER SLOWLY CAME BACK. TOOK VEHICLE TO FORD AT 12,000+ MILES, KEPT IT FOR SEVERAL DAYS. SAID IT WAS A COMPUTER MODULE, CHANGED IT, PICKED VEHICLE UP AND NOT 2 MILES DOWN THE ROAD THE SAME THING HAPPENED AGAIN. DIDN'T HAVE THE TIME TO TAKE IT RIGHT BACK IN NOT TO MENTION THERE RENTAL CAR EXPERIENCE WAS EQUALLY HORRIBLE. IT'S IN THEIR SHOP NOW 3/10 AND I'M AT 22,000 MILES AND IT HAPPENS EVERY TIME I ACCELERATE. IT'S A VERY DANGEROUS PROBLEM. NOW THEY SAY THEY THINK IT'S SOMETHING TO DO WITH THE TORQUE CONVERTER AND HAVE ORDERED PARTS. I'M ALSO HAVING A PROBLEM WITH IT NOT STARTING AFTER DRIVING, GETTING OUT AND GETTING BACK IN WITHIN ABOUT 30 MINUTES. WE'LL SEE NEXT WEEK WHAT THE OUTCOME IS! *JB

BRAKES FAILED IN PANIC SITUATION ON DRY ROAD. BRAKES GRABBED AND THEN COMPLETELY LET GO WHEN ANTILOCK SYSTEM TOOK OVER. THERE WAS NO SURGE IN THE PEDAL AS IT WENT COMPLETELY TO THE FLOOR. MY ROAD SPEED WAS 35 MPH WHEN I HIT THE BRAKES AND I WOULD SAY THEIR WAS AT LEAST 100FT BETWEEN MINE AND THE STOPPED VEHICLE IN FRONT OF ME. I THOUGHT OF SWERVING TO MISS IT BUT WAS SURE I WOULD AT LEAST SLOW ENOUGH TO ONLY BUMP THE VEC. IN FRONT OF ME. THE GUY I HIT SAID HE HEARD A CHIRP AND A COUPLE SECONDS LATER GOT HIT. THERE WHERE NO SKID MARKS THAT I KNOW OF. THEIR WAS 21000 DOLLARS DAMAGE TO THE FRONT OF MY 2006 EXPIDITION. *NM

WHEN EXITING INTERSTATE, CHANGES LANE AND AS GAS PETAL WAS PUSHED, NO POWER TO SUV, ENGINE DID NOT RACE OR SHAKE, JUST NO POWER. PUT SUV INTO FIRST GEAR AND IT JERKED AHEAD AT 10 MPH TO STOP LIGHT. WHILE STOPPED, SUV WOULD ROLL BACKWARD IF BRAKE NOT ON. MADE LEFT HAND TURN AND PUT BACK INTO GEAR, ABOUT ONE MILE LATER SAME LOSS OF POWER UNTIL PUT INTO 1ST GEAR. ONE MONTH LATER, ALSO WHILE EXITING INTERSTATE HAD SAME LOSS OF ALL POWER AT BOTTOM OF RAMP WHEN TRYING TO MERGE INTO LEFT LANE. SUV WOULD ONLY MOVE AFTER PUT INTO 1ST GEAR, ONLY AT 10 MPH. DEALERSHIP COULD FIND NOTHING WRONG AFTER A WEEK WITH THE FIRST INCIDENT, DEALER KEPT FOR 3 AND A HALF WEEKS AND THE P&S DIRECTOR DROVE 716 MILES AND COULD NOT DUPLICATE THIS PROBLEM. (NOTE BOTH HAPPEN WITHIN ONE WEEK OF DEALER OIL CHANGE) P&S DIRECTOR SUSPECTS FLY BY WIRE ISSUE, SAID THAT COMPARED TO OTHER 2005/2006 MODELS OURS HAS A DEAD PEDAL FEELING. *JB

ON A 2006 EXPEDITION, UPON START UP (NOT EVERY TIME) THERE IS A NOISE THAT I DESCRIBE AS WINDSHIELD WIPERS DRAGGING ACROSS A DRY WINDOW OR A WINDING SOUND THAT ALSO SOUNDS LIKE THE MOTOR OF THE WINDSHIELD WIPERS. IT SEEMS TO MAKE THIS NOISE AFTER THE VEHICLE HAS SAT FOR A PERIOD OF TIME, USUALLY AFTER A DAY AT WORK. BUT IT HAS MADE THIS NOISE FIRST THING IN THE MORNING AFTER SITTING ALL NIGHT. IT HAS NEVER DONE IT ON A SECOND IMMEDIATE START UP. FORD HAS REPLACED THE STARTER, NO HELP. FORD HAS REPLACED THE SPARK PLUGS (THIS WAS A 2005 RECALL I WAS TOLD), NO HELP AND THEY HAVE REPLACED THE OIL FILTER, AGAIN NO HELP. UNFORTUNATELY NO-ONE AT FORD HAS HEARD THIS NOISE, BUT ONE TECH SEEMED TO KNOW ABOUT IT FROM ANOTHER CUSTOMER WITH THE SAME ISSUE. I HAVE MADE SUGGESTIONS TO THE FORD TECH'S SO THAT THEY COULD EXPERIENCE THIS SAME EVENT (THAT WENT ON DEAF EARS), THEY HAVE LOTS OF THOUGHTS THAT IT COULD BE THE BLENDER (SP) AND THAT I SHOULD NOT TURN THE A/C ON UPON START UP. I TRIED THAT AS WELL, I WILL TRY ANY SUGGESTION THEY PUT OUT, BUT STILL THE SAME NOISE. THEY HAVE THOUGHTS ABOUT THE CAM, AND THEY STOOD THERE AND AGREED THAT THE OIL FILTER CHANGE WOULD NOT FIX THE PROBLEM. BUT WHAT THE HECK TRY IT. FORD HAS STATED THAT THEY CAN NOT KEEP THE VEHICLE TO TRY AND FIND OUT WHAT IS WRONG. I AM VERY CONCERNED THAT THIS IS GOING TO BECOME SOMETHING BIGGER AND FAR WORSE. I FEAR OF A FIRE IN THE VEHICLE. SINCE FORD DOES NOT WANT TO TAKE THE TIME TO TRY AND ISOLATE THE PROBLEM I SUGGESTED THEY PUT IN WRITING AN EXTENDED WARRANTY ON THIS VEHICLE. *NM

VEHICLE HAD BEEN DISPLAYING THE LOW AIR PRESSURE LIGHT AND THE CHECK ENGINE LIGHT ( SMOG CONTROL). TIRES WERE CHECKED AND FOUND TO BE PROPERLY INFLATED, ALL FLUIDS, FILTERS, ETC, WERE CHECKED AND FOUND TO BE IN WORKING ORDER. VEHICLE WAS DRIVEN APPROXIMATELY 15-20 MILES. BOTH BEFORE MENTION LIGHTS CONTINUED TO COME ON AND OFF. VEHICLE WAS PARKED. APPROX 1 HOUR LATER VEHICLE HORN SOUNDED, I WALKED TO CHECK HORN AND FOUND THE VEHICLE INTERIOR IN FLAMES. I WAS ABLE TO PUT THE FIRE OUT, AND KEEP THE DAMAGE TO THE DRIVERS SIDE DASH, STEERING AREA. VEHICLE INTERIOR SUFFERED HEAVY SMOKE DAMAGE, FRONT WINDSHIELD CRACKED. CONTACTED INSURANCE COMPANY AND FORD MOTOR COMPANY. VEHICLE IS ONLY 9 MONTHS OLD AND STILL UNDER WARRANTY. I REQUESTED THAT FORD REPLACE MY VEHICLE WITH ANOTHER VEHICLE JUST LIKE I PURCHASED. FORD SENT LETTER SAYING THAT SINCE INSURANCE COMPANY IS INVOLVED THEY PROPOSE NO FURTHER ACTION. BUT SINCE VEHICLE IS USED, INSURANCE COMPANY WILL ONLY PAY FAIR MARKET VALUE, LEAVING ME TO PAY FOR THE BALANCE. ALL I WANT IS FOR FORD TO REPLACE MY DEFECTIVE VEHICLE. *JB

WHILE MAKING A HARD LEFT TURN TO AVOID A CRASH , I WAS UNABLE TO RECOVER TO THE RIGHT EVEN WITH MY STEERING WHEEL TURNED AL THE WAY TO THE RIGHT. MY VEHICLE CONTINUED LEFT AND COLLIDED WITH THE GUARD RAIL AT ABOUT THIRTY MPH. INSPECTION OF THE DAMAGE FOUND THAT THE LEFT FRONT TIE ROD ON MY BRAND NEW EXPEDITION WAS BROKEN IN HALF. THERE WAS MARKS ON THE TIE ROD TO INDICATE THAT IT WAS CUT. INSTEAD IT WAS FRACTURED . THIS IS THE REASON FOR LOSS OF STEERING CONTROL. *NM

THE AIR CONDITIONING SYSTEM WORKS FINE WHEN THE VEHICLE IN MOTION (AT HIGHER THAN IDLE RPM), BUT SEEMS TO BLOW DISTINCTLY WARMER WHEN AT IDLE( E.G. AT A STOP LIGHT). BROUGHT IN TO THE DEALER TWICE AND WAS TOLD THERE IS NOTHING WRONG, THAT THE COMPRESSOR FAN IS TURNING SLOWER AT IDLE. IF THIS IS TRUE IT IS AN OBVIOUS DESIGN FLAW. WE HAVE HAD PREVIOUS MODEL YEARS OF THIS MODEL AND NOT HAD THIS PROBLEM. *JB

I BOUGHT A 2006 FORD EXPEDITION AND 3 MONTHS LATER WHILE MY DAD WAS DRIVING IT ACCELERATED BY IT SELF AND MY DAD DIE IN THE ACCIDENT CAUSED BY UNEXPECTED ACCELERATION OF THE VEHICLE. *NM

LOUD GRINDING NOISE ON INITIAL START UP ON 2006 FORD EXPEDITION, FORD MOTOR CLAIMS IT IS FROM A/C COMPRESSOR, YET, CANNOT GIVE ME A WRITTEN GUARANTEE THAT THE VEHICLE WILL NOT CATCH ON FIRE, BLOW UP OR STALL. VEHICLE SITTING ON DEALER LOT BECAUSE I AM AFRAID TO DRIVE IT. *JB

DT*: THE CONTACT STATED THE PASSENGER SIDE AIR BAG HAS TOO MUCH PLAY IN IT. THE AIRBAG HAS BEEN REPLACED BY THE DEALERSHIP BEFORE, BUT THE AIR BAG HAS NEVER DEPLOYED AND THE VEHICLE HAS NEVER BEEN IN AN ACCIDENT.

1. FREQUENT HORRIBLE GRINDING NOISE ON COLD START-UP. 2. LOUD CLUNKING NOISE AND FEEL VEHICLE SHUDDER IN REVERSE UNDER LIGHT ACCELERATION. *JB

PROBLEM: FORD DVD ENTERTAINMENT SYSTEM AND THE FORD DEALER INSTALLED SATELLITE RADIO DO NOT WORK WITH THE DUAL PLAY (BACK SEAT SHOULD BE ABLE TO WATCH A MOVIE WHILE FRONT SEAT GETS TO LISTEN TO SATELLITE RADIO). WE FOUND OUT THROUGH OUR 2 WEEKS OF (THE PHONE RUN AROUND) INVESTIGATION THAT THIS PROBLEM HAS BEEN ON GOING FOR 2 YEARS. WE ALSO FOUND OUT THAT EVERYTHING FORD HAS WITH DUAL PLAY THE DVD/CD FACTORY ENTERTAINMENT DOESN'T WORK WITH SATELLITE RADIO, NAVIGATION SYSTEM, IPOD INTERFACE ECT. FORD HAS TOLD US THAT IT IS OUR PROBLEM BECAUSE IN THEIR OWNERS MANUAL IT DOESN'T SAY THEY WORK TOGETHER??? WHY THEN IS IT AN OPTION??? FORD DOESN'T WANT TO HELP US, THEY DON'T WANT TO PURCHASE BACK THE DVD PLAYER. WHY IS IT BIG COMPANIES CAN TAKE ADVANTAGE OF US BLUE COLLAR HARD WORKING FOLKS? WHAT DOES AN AVERAGE PERSON DO, I PURCHASED A $50,000 VEHICLE THAT IS AN INVESTMENT AND FORD IGNORES US. DO YOU KNOW WHERE I CAN GET HELPED? THANK YOU VERY MUCH TRENA ANDERSON GILLETTE, WYOMING. *NM

THE VEHICLE (2006 FORD EXPEDITION - EDDIE BAUER) HAS HAD FOR THE LAST 8 MONTHS OF PURCHASING IT, GRINDING NOISE TO THE START WHEN IT DOES START AND THIS HAPPENS ABOUT 4-5 TIMES A WEEK, DRIVER SIDE WINDOW RATTLES AND SCREECHES WHEN ROLLED UP AND DOWN, THE BACK SEATS RATTLE, THE BACK GLASS LEAKS. THE VEHICLE HAS BEEN TAKEN TO THE SHOP A TOTAL OF 5 TIMES AND WAS WORKED ON THE SECOND TIME AND AFTER THAT THEY CAN'T DUPLICATE THE PROBLEM ANY MORE BUT THE PROBLEM IS STILL THERE. THEY DON'T, WON'T OR WANT TO WORK ON IT ANYMORE. WE WANT A REPLACEMENT OR RE-PURCHASE OF THE VEHICLE. *JB

2006 EXPEDITION HORN MUST BE HIT IN EXACTLY THE SPOT WHERE THE HORN SYMBOL IS LOCATED, ON EITHER SIDE OF THE STEERING WHEEL/AIR BAG CENTER. CONSUMER FEELS THIS IS A SAFETY ISSUE. *TS *NM UPDATED 03/20/06. *JB UPDATED 05/30/06

CONSUMER FEELS THE 2006 EXPEDITION HORN HAS A SAFETY ISSUE. CONSUMER MUST HIT HORN IN THE EXACT SPOT OR HORN WILL NOT SOUND. *TS *JB

DT*: THE CONTACT STATED WHILE DRIVING ON ICE AT VARIOUS SPEEDS, THE BRAKES LOCK UP. THE VEHICLE HAS BEEN TO THE DEALERSHIP, AND THE MANUFACTURER DETERMINED THIS IS HOW THE ADVANCE TRACK BRAKING SYSTEM IS MANUFACTURED.

TIRES ARE BAD. *NM

ABS, ROLL STABILITY CONTROL AND GENERAL BRAKE SYSTEM LIGHTS CAME ON AT TIME OF DELIVERY OF NEW CAR. DEALER "FIXED" PROBLEM. SAME SYMPTOMS OCCURRED APPROXIMATELY 50 MILES AFTER TAKING DELIVERY OF CAR. DEALER TECHS. CANNOT PROVIDE INFORMATION IF IT IS FAULTY SENSOR OR IF THERE IS, IN FACT A FAULT IN THE BRAKING SYSTEM. BRAKES SEEM TO WORK, BUT AM UNWILLING TO TEST ABS/RSC FEATURES WITH KNOWN PROBLEM WITH SYSTEM. *NM