Loading vehicle data from NHTSA...
NHTSA recalls, safety ratings, and consumer complaints for the 2000 Dodge Grand Caravan.
| Overall Rating | Not Rated |
| Frontal Crash | Not Rated |
| Side Crash | Not Rated |
| Rollover | Not Rated |
Component: VISIBILITY:GLASS, SIDE/REAR
CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 205, "GLAZING MATERIALS."
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT(S) MAY BE SERIOUSLY INJURED BY SHATTERED GLASS.
Remedy: SAFELITE WILL NOTIFY ITS RETAIL CUSTOMERS AND REPLACE THE GLASS FREE OF CHARGE. RETAIL CUSTOMERS CAN CONTACT SAFELITE TOLL FREE AT 1-888-843-2906. SAFELITE WILL NOTIFY ITS WHOLESALE CUSTOMERS AND REIMBURSE WHOLESALE CUSTOMERS FOR CURRENT INVENTORY AND AT A SPECIFIED RATE FOR REPLACING THEIR CUSTOMER'S GLASS. WHOLESALE CUSTOMERS CAN CONTACT SAFELITE'S WHOLESALE DIVISION, SERVICE AUTOGLASS TOLL FREE AT 1-888-246-6298. THE RECALL BEGAN ON JANUARY 15, 2008.
Component: SEATS
ACCESS OPTIONS IS RECALLING CERTAIN TRUCKS AND VANS BUILT ON FORD E150, E350, TOYOTA SIENNA, AND DODGE GRAND CARAVAN CHASSIS AND EQUIPPED WITH VMI/RICON 6-WAY POWER SEAT BASES. THE SIX WAY POWER SEAT BASE MAY HAVE A DEFECTIVE (COLD) WELD ON THE PIVOT PIN WHICH IS WELDED TO THE SWIVEL PLATE. THE WELD COULD FAIL.
Consequence: THE SEAT OCCUPANT MAY BE INJURED IF THE SEAT BASE PIN WERE TO BREAK.
Remedy: THE SWIVEL PLATE WILL BE REPLACED FREE OF CHARGE IF NECESSARY. THE RECALL BEGAN ON JUNE 8, 2010. OWNERS MAY CONTACT ACCESS OPTION AT 831-722-6804.
The contact owns a 2000 Dodge Grand Caravan. The contact stated that while driving at 55 MPH, there was an abnormal noise and noticed that the vehicle's windshield wiper and blinkers had become inoperable. No warning light was illuminated. The vehicle had been diagnosed by an independent mechanic. The contact was informed that the failure was due to a faulty wiper transmission linkage, a relay, and a switch. The relay and switch were replaced however, the wiper transmission linkage was not repaired due to parts not being available. The manufacturer was made aware of the failure and determined that parts were not available. The failure mileage was approximately 110.000
Fuel leak under vehicle. Possible fire. There are several recalls on 2000 dodge caravan, but none supposedly associated with this VIN. The van only has 45,000 miles on it.
At 65+ the back door alarm sounds and keeps sounding when doing freeway speeds.
I was driving at 75 MPH on an Interstate Highway. The 3.3 liter V6 engine, with 120,800 miles on it, threw a rod and cracked a 3 to 4" diameter hole in the block. I have cared for this car religiously for 14 years. It had full oil level. It is available for the next couple of weeks for examination if desired. I was able to get off the highway onto the shoulder safely.
The 2000 Dodge Grand Caravan has 8 NHTSA recalls and 472 consumer complaints on file. It received an overall safety rating of Not Rated out of 5 stars in NHTSA crash testing. The high number of complaints suggests potential reliability concerns — review the complaint details above before purchasing. For the most detailed information about a specific vehicle, decode its VIN using our free decoder above.
Enter a specific VIN to get the full report — specs, recalls, safety ratings, complaints, investigations, and technical service bulletins.
Component: FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Component: FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
CERTAIN AIRTEX FUEL PUMP MODULES, P/NOS. E7089M, E7094M, E7113M, AND E7129M, MANUFACTURED BETWEEN JUNE 1 AND SEPTEMBER 24, 2006. THESE FUEL PUMP MODULES WERE SOLD AS AFTERMARKET FOR USE IN CERTAIN DAIMLERCHRYSLER VEHICLES LISTED ABOVE. SILICONE MATERIAL USED IN MANUFACTURE OF THE FLAPPER VALVE WAS OUT-OF-SPECIFICATION, LEADING TO EXCESS SWELL OF THE FLAPPER VALVE RESTRICTING THE FLOW OF FUEL TO THE FUEL PUMP MODULE.
Consequence: FUEL RESTRICTION COULD RESULT IN LOSS OF POWER AND/OR ENGINE STALL, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy: AIRTEX WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE FUEL PUMP MODULES FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT AIRTEX TOLL-FREE AT 1-866-867-3759.
Component: FUEL SYSTEM, GASOLINE
CERTAIN AFTERMARKET REPLACEMENT FUEL FILTERS, MODELS WIX FILTER PART NUMBERS 33576, 33577, 33734; NAPA FILTER PART NUMBERS 3576, 3577, 3734; AND CARQUEST FILTER PART NUMBERS 86576, 86577, 86734 USED ON 1996-2000 DAIMLERCHRYSLER TOWN & COUNTRY, DODGE CARAVAN, AND PLYMOUTH VOYAGER VEHICLES, CAN CAUSE THE FUEL LINES TO LEAK.
Consequence: A POSSIBLE FIRE CAN OCCUR IN THE PRESENCE OF AN IGNITION SOURCE.
Remedy: WIX WILL NOTIFY ITS CUSTOMERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. NOTE: THIS DOES NOT INVOLVE ANY PRODUCTS MANUFACTURED BY THE DAIMLERCHRYSLER CORP. NOR ANY DAILMERCHRYSLER DEALERS. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT WIX AT 704-864-6711.
Component: EQUIPMENT:OTHER:LABELS
ON CERTAIN MINIVANS AND 4X2 PICKUP TRUCKS, THE VEHICLE CERTIFICATION LABEL MAY HAVE GROSS AXLE WEIGHT RATINGS (GAWR) THAT EXCEED THE MAXIMUM TIRE LOAD CAPACITY AS DEFINED IN FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
Consequence: IMPROPERLY LOADING YOUR VEHICLE CAN CAUSE TIRE FAILURE AND RESULT IN A CRASH.
Remedy: OWNERS WILL BE PROVIDED WITH VEHICLE CERTIFICATION LABEL OVERLAYS CONTAINING CORRECTED INFORMATION RELATIVE TO VEHICLE GAWR AND TIRE SIZE. OWNER NOTIFICATION BEGAN MARCH 1, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-992-1997.
Component: AIR BAGS
ON CERTAIN MINIVANS, THE DRIVER'S AIR BAG MAY BECOME DISABLED DUE TO A FAILURE OF THE CLOCKSPRING, WHICH IS LOCATED IN THE HUB OF THE STEERING WHEEL.
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL COVERED VEHICLES WITH 70,000 MILES OR LESS. FOR THOSE VEHICLES WITH MORE THAN 70,000 MILES, DAIMLERCHRYSLER WILL OFFER AN EXTENDED LIFETIME WARRANTY UNDER WHICH IT WILL REPLACE THE CLOCKSPRING AT NO CHARGE IF IT FAILS. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. THE RECALL BEGAN ON OCTOBER 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Component: STRUCTURE
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
Consequence: THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
Remedy: DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
AIRBAG WARNING LIGHT STAYS ON WHEN ENGINE STARTS.
TL* THE CONTACT OWNS A 2000 DODGE GRAND CARAVAN. WHILE DRIVING 35 MPH, THE CONTACT HEARD AN ABNORMAL NOISE AND THE STEERING WHEEL BECAME DIFFICULT TO TURN. IN ADDITION, THE BATTERY AND CHECK ENGINE WARNING INDICATORS ILLUMINATED. THE CONTACT WAS ABLE TO PARK THE VEHICLE IN A NEARBY PARKING LOT. WHEN THE IGNITION WAS STARTED, THE TEMPERATURE GAUGE INCREASED. THE CONTACT TURNED OFF THE IGNITION AND ALLOWED THE VEHICLE TO COOL DOWN FOR AWHILE. AFTERWARDS, THE VEHICLE WAS RESTARTED AND THE CONTACT CONTINUED DRIVING 15 MPH TO HIS RESIDENCE. THE CONTACT NOTICED THAT THE STEERING WHEEL BELT WAS LOOSE. THE CONTACT CALLED LITHIA CHRYSLER JEEP OF RENO (LOCATED AT 1050 E PLUMB LN #100, RENO, NV 89502, (775) 501-8593) AND INFORMED THEM OF THE FAILURE. THE CONTACT SCHEDULED AN APPOINTMENT WITH AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 147,000.
THE CHECK ENGINE LIGHT AND ABS LIGHT KEEP COMING ON AND THE LIGHT KEEP GOING OFF ON THE DASH BOARD FOR I BOUGHT THE VEHICLE WHILE DRIVING
TL* THE CONTACT OWNS A 2000 DODGE GRAND CARAVAN. WHILE DRIVING APPROXIMATELY 50 MPH WITH A FULL TANK OF FUEL, THE FUEL GAUGE DISPLAYED AS EMPTY. THE CONTACT PULLED OVER TO THE SIDE OF THE ROAD AND DEPRESSED THE RESET BUTTON SINCE THE VEHICLE HAD JUST BEEN FUELED. THE VEHICLE WAS RESTARTED AND OPERATED NORMALLY, BUT THE FAILURE RECURRED APPROXIMATELY EIGHT OTHER TIMES IN A FOUR MONTH PERIOD. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DETERMINED THAT THE RADIATOR NEEDED REPLACEMENT. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 75,000.
TL* THE CONTACT OWNS A 2000 DODGE GRAND CARAVAN. WHILE DRIVING AT UNKNOWN SPEEDS, THE VEHICLE STALLED. THE VEHICLE WAS RESTARTED AND THE REVOLUTIONS PER MINUTE DECREASED. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT THEY WERE UNABLE TO DUPLICATE THE FAILURE. THE LOCAL DEALER AND MANUFACTURER WERE NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 180,000.
STRUT TOWERS ON MY 2000 DODGE GRAND CARAVAN HAVE RUSTED THROUGH. VISIBLE, SIGNIFICANT RUST HAS BEEN PRESENT FOR AT LEAST 7 YEARS, HOWEVER, IT IS NOW NOT DRIVEABLE. I DID NOT REALIZE THIS IS SUCH A BROADSCALE, SIGNIFICANT PROBLEM TO MOST OWNERS OF 1996-2000 VANS. PLEASE RECALL THIS MESS! STRUT TOWERS ARE NOT COSMETIC!
FUEL GAGE DON'T WORK AFTER FUEL PUMP REPLACEMENT,,,,GASOLINE SPILLED ALL OVER ROAD
THE SERPENTINE BELT ON 96-2000 CHRYSLER MINIVANS SLIPPING OFF IS A KNOWN ISSUE AND HAS BEEN FOR YEARS. TIME AND TIME AGAIN CHRYSLER HAS REFUSED TO ISSUE A RECALL FOR IT. IT IS DUE TO A MANUFACTURING DEFECT IN ONE OF THE ENGINE MOUNTS CAUSING A PULLEY MISALIGNMENT. THE BELT SLIPPING OFF CAUSES LOSS OF POWER STEERING, WATER PUMP, AND ALTERNATOR. THE POWER STEERING LOSS CAN CAUSE A DRIVER TO NOT BE ABLE TO CORRECT IN TIME AND CAUSE AN ACCIDENT. THE LOSS OF THE WATER PUMP CAN CAUSE OVERHEATING RESULTING IN ENGINE DAMAGE. THE LOSS OF THE ALTERNATOR CAN CAUSE THE CAR TO EVENTUALLY STOP RUNNING WHEN THE BATTERY IS DRAINED, CAUSING MOTORISTS TO BE STRANDED. I LIVE IN ALASKA AND I'M NOT ALWAYS IN CELLULAR SIGNAL WHEN DRIVING AND TEMPERATURES IN THE WINTER GET DOWN TO -30 F AT TIMES. I CAN'T WAIT SOMETIMES SEVERAL HOURS FOR A TOW TRUCK TO GET TO ME WITHOUT RISKING HYPOTHERMIA AT THOSE TEMPERATURES. THIS NEEDS TO BE MADE INTO A RECALL SO IT CAN GET FIXED.
TL* THE CONTACT OWNS A 2000 DODGE GRAND CARAVAN. WHILE DRIVING THE VEHICLE ON SEVERAL OCCASIONS, THE SERPENTINE BELT DETACHED FROM THE DRIVE PULLEY. THE CONTACT STATED THAT AN INDEPENDENT MECHANIC WAS ABLE TO PLACE THE SERPENTINE BELT BACK ON THE DRIVE PULLEY. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED OR REPAIRED. THE FAILURE RECURRED SEVERAL TIMES ONLY WHILE IT WAS RAINING. THE CONTACT ALSO STATED THAT THE CLOCK SPRING IN THE STEERING WHEEL FAILED, WHICH CAUSED THE HORN TO FAIL AND THE FRONT DRIVER'S AIR BAG TO BECOME INOPERABLE. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 04V480000 (AIR BAGS). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 186,425.
TL* THE CONTACT OWNS A 2000 DODGE GRAND CARAVAN. WHILE DRIVING AT VARIOUS SPEEDS, THE AIR BAG WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE CLOCK SPRING FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 04V480000 (AIR BAGS). THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 238,000.
I HAVE A DODGE RICON ACTIVAN WHEELCHAIR VAN. IT IS A 2000 MODEL. I PURCHASED IT WITH ONLY 29000 MILES. AFTER DRIVING THE VAN FOR 60 MILES IT WILL START STALLING, LOOSES POWER AND DIE. THIS HAS HAPPENED TO ME 3 TIMES. THE FIRST TIME IT HAPPENED I HAD MY SON WITH ME (HE HAS SPASTIC QUAD CEREBRAL PALSY) WE BROKE DOWN NEXT TO A DODGE DEALERSHIP. GETTING MY SON HOME WAS A NIGHTMARE. THE DODGE DEALERSHIP WORKED ON THE VAN. YET,THE PROBLEM IS STILL THERE. AFTER 60 MILES IT STALLS AND DIES. ON SATURDAY I WAS BROKEN DOWN WITH MY CHILD ON THE INTERSTATE.IT WAS 92 DEGREES OUT SIDE, HOW HORRIFIC. I CAN SEE IF THE VAN HAD 100,000 MILES TO HAVE ISSUES. I WAS FORTUNATE TO GET THE VAN PULLED TO THE SIDE OF THE ROAD, IF NOT WE WOULD HAVE BEEN HIT AND KILLED.THIS IS A ISSUE THAT NEEDS RECALLED. THIS IS A SAFETY ISSUE.
Showing 15 of 472 complaints