Loading vehicle data from NHTSA...
NHTSA recalls, safety ratings, and consumer complaints for the 1998 Dodge Grand Caravan.
| Overall Rating | Not Rated |
| Frontal Crash | Not Rated |
| Side Crash | Not Rated |
| Rollover | Not Rated |
Component: VISIBILITY:GLASS, SIDE/REAR
CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 205, "GLAZING MATERIALS."
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT(S) MAY BE SERIOUSLY INJURED BY SHATTERED GLASS.
Remedy: SAFELITE WILL NOTIFY ITS RETAIL CUSTOMERS AND REPLACE THE GLASS FREE OF CHARGE. RETAIL CUSTOMERS CAN CONTACT SAFELITE TOLL FREE AT 1-888-843-2906. SAFELITE WILL NOTIFY ITS WHOLESALE CUSTOMERS AND REIMBURSE WHOLESALE CUSTOMERS FOR CURRENT INVENTORY AND AT A SPECIFIED RATE FOR REPLACING THEIR CUSTOMER'S GLASS. WHOLESALE CUSTOMERS CAN CONTACT SAFELITE'S WHOLESALE DIVISION, SERVICE AUTOGLASS TOLL FREE AT 1-888-246-6298. THE RECALL BEGAN ON JANUARY 15, 2008.
Component: FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
The contact owns a 1998 Dodge Grand Caravan. The contact stated that while her husband was driving at an undisclosed speed, the vehicle experienced a loss of power steering assist and then stalled. Additionally, the odometer failed to display the correct mileage and the speedometer failed to display the correct speed of the vehicle while the engine revved. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 152,000.
THE DRIVER'S HORN DOES NOT WORK AND HASN'T SINCE IT WAS TAKEN IN TO REPLACE THE CLOCK SPRING ASSEMBLY. THIS WAS DONE AS PER A RECALL ISSUED BY NHTSA AND DAIMLERCHRYSTLER CORPORATION RELATING TO DRIVER'S AIRBAG BY THE ORIGINAL OWNER. HE ALSO DID NOT HAVE THE ORIGINAL PAPERWORK ON THE VAN. I AM THE SECOND OWNER AND WHEN I DISCOVERED THE HORN DID NOT WORK. AFTER RESEARCHING AND SUBSCRIBING TO THE THE NHTSA RECALL ALERTS I DETERMINED THAT THIS MAY HAVE BEEN CAUSED BY THE CLOCK SPRING REPLACEMENT. I WAS ALSO TOLD THAT THE REPLACEMENT CLOCK SPRING COULD HAVE BEEN DEFECTIVE AS WELL, BECAUSE IT WAS DONE SO SOON AFTER THE RECALL WAS ISSUED. I TOOK IT TO A LOCAL DEALERSHIP WHERE I LIVE AND THEY CONFIRMED THAT THERE HAD BEEN A RECALL ISSUED AND THEY WERE SORRY, BUT THEY COULDN'T REPLACE IT AGAIN. THEY SUGGESTED THAT I TAKE IT BACK TO THE DEALERSHIP WHERE IT WAS PURCHASED. I EXPLAINED TO THEM THAT I WAS NOT THE ORIGINAL OWNER AND DIDN'T KNOW WHERE IT WAS PURCHASED FROM ORIGINALLY. EVEN WHEN I TOLD THEM THAT I WOULD PAY THE COST OF THE REPAIR, THEY WERE NOT INTERESTED. I TOOK IT TO A LOCAL MECHANIC AND HE DIDN'T WANT TO TOUCH IT BECAUSE THERE WAS SO MUCH INVOLVED IN THE STEERING COLUMN THAT COULD GO WRONG AND HE DIDN'T HAVE THE EXPERTISE TO DO IT. THE VEHICLE IS NOT SAFE AND HASN'T BEEN SINCE BEFORE AND AFTER I PURCHASED IT. MY CONCERN IS IF THE HORN DOESN'T WORK'THEN HOW CAN I BE SURE THE AIRBAG DOES. I'M STILL DRIVING THIS VEHICLE BECAUSE I CAN'T SELL IT TO SOMEONE ELSE IN THIS CONDITION. IS THERE NO RECOURSE IF THE VEHICLE AS NOT REPAIRED AS PER THE NHTSA'S RECALL? THIS VEHICLE ONLY HAS 91054 MILES ON IT AS OF THIS DATE.
The 1998 Dodge Grand Caravan has 6 NHTSA recalls and 597 consumer complaints on file. It received an overall safety rating of Not Rated out of 5 stars in NHTSA crash testing. The high number of complaints suggests potential reliability concerns — review the complaint details above before purchasing. For the most detailed information about a specific vehicle, decode its VIN using our free decoder above.
Enter a specific VIN to get the full report — specs, recalls, safety ratings, complaints, investigations, and technical service bulletins.
Component: FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
CERTAIN AIRTEX FUEL PUMP MODULES, P/NOS. E7089M, E7094M, E7113M, AND E7129M, MANUFACTURED BETWEEN JUNE 1 AND SEPTEMBER 24, 2006. THESE FUEL PUMP MODULES WERE SOLD AS AFTERMARKET FOR USE IN CERTAIN DAIMLERCHRYSLER VEHICLES LISTED ABOVE. SILICONE MATERIAL USED IN MANUFACTURE OF THE FLAPPER VALVE WAS OUT-OF-SPECIFICATION, LEADING TO EXCESS SWELL OF THE FLAPPER VALVE RESTRICTING THE FLOW OF FUEL TO THE FUEL PUMP MODULE.
Consequence: FUEL RESTRICTION COULD RESULT IN LOSS OF POWER AND/OR ENGINE STALL, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy: AIRTEX WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE FUEL PUMP MODULES FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT AIRTEX TOLL-FREE AT 1-866-867-3759.
Component: AIR BAGS:FRONTAL
ON CERTAIN MINI VANS, THE CLOCKSPRING ASSEMBLY MAY HAVE BEEN WOUND INCORRECTLY DURING THE VEHICLE ASSEMBLY PROCESS.
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL VEHICLES WITH 70,000 MILES OR LESS. AN EXTENDED LIFETIME WARRANTY WILL ALSO BE PLACED ON THIS COMPONENT FOR ALL AFFECTED VEHICLES, REGARDLESS OF MILEAGE. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. OWNER NOTIFICATION BEGAN NOVEMBER 18, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Component: AIR BAGS
ON CERTAIN MINIVANS, THE DRIVER'S AIR BAG MAY BECOME DISABLED DUE TO A FAILURE OF THE CLOCKSPRING, WHICH IS LOCATED IN THE HUB OF THE STEERING WHEEL.
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL COVERED VEHICLES WITH 70,000 MILES OR LESS. FOR THOSE VEHICLES WITH MORE THAN 70,000 MILES, DAIMLERCHRYSLER WILL OFFER AN EXTENDED LIFETIME WARRANTY UNDER WHICH IT WILL REPLACE THE CLOCKSPRING AT NO CHARGE IF IT FAILS. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. THE RECALL BEGAN ON OCTOBER 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Component: CHILD SEAT
VEHICLE DESCRIPTION: PASSENGER MINIVANS EQUIPPED WITH INTEGRATED CHILD SEATS. THE SHOULDER HARNESS RESTRAINT WEBBING WAS INCORRECTLY ROUTED AROUND THE METAL REINFORCEMENT BAR ON THESE SEATS.
Consequence: THE CHILD SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED IN THE EVENT OF A COLLISION.
Remedy: DEALERS WILL INSPECT THE ROUTING OF THE SHOULDER BELT WEBBING AND ANY FOUND INCORRECT WILL BE PROPERLY ROUTED.
TL* THE CONTACT OWNS A 1998 DODGE GRAND CARAVAN. WHILE OPERATING THE VEHICLE, A KNOCKING NOISE WAS HEARD COMING FROM THE ENGINE AND THE VEHICLE HESITATED WHEN ACCELERATING. THE VEHICLE WAS EXAMINED BY AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FAILURE WAS DUE TO LOW OIL PRESSURE CAUSED BY FAULTY ENGINE CONNECTING RODS. THE VEHICLE WAS NOT REPAIRED. SWANTYS DODGE (2494 SOUTH HWY 95, BULLHEAD CITY, AZ) AND THE MANUFACTURER WERE NOTIFIED OF THE FAILURE AND DID NOT ASSIST. THE FAILURE MILEAGE WAS 261,000.
TL* THE CONTACT OWNS A 1998 DODGE GRAND CARAVAN. WHILE DRIVING 60 MPH, ALL THE WARNING INDICATORS ILLUMINATED AND THE HORN, SPEEDOMETER, FUEL GAUGE, AND CRUISE CONTROL FAILED TO FUNCTION. THE CONTACT CALLED STEW HANSEN DODGE RAM CHRYSLER JEEP AT (515) 331-2900 (LOCATED AT 12103 HICKMAN RD, URBANDALE, IA 50323) AND WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 165,000.
SERVICE BRAKE FAILURE WHILE DRIVING, DIAGNOSED BY REPAIR SHOP AS A RUPTURED BRAKE LINE. INSPECTION OF OTHER BRAKE LINES SHOWED HEAVY CORROSION. VEHICLE WAS IN MOTION (STRAIGHT LINE) ON A CITY STREET AND RETAINED MINIMAL BRAKING. I WAS ABLE TO STOP AT A STOP LIGHT (NO COLLISION) AND 'LIMP' TO THE REPAIR SHOP. REPAIRS CONSISTED OF REPLACING THE HYDRAULIC BRAKE LINES.
TL* THE CONTACT OWNED A 1998 DODGE GRAND CARAVAN. WHILE THE CONTACT'S WIFE WAS DRIVING 45 MPH, ANOTHER VEHICLE TRAVELING APPROXIMATELY 70 MPH STRUCK THE REAR OF THE CONTACT'S VEHICLE. THE AIR BAGS DID NOT DEPLOY. THE FRONT PASSENGER SEAT (THE CONTACT'S SEAT) SEPARATED FROM THE SEAT TRACK. THE CONTACT STRUCK THE SIDE DOOR AND WAS THROWN INTO THE REAR OF THE VEHICLE. THE SEAT BELT FAILED TO RESTRAIN THE CONTACT AND HE WAS THEN STRUCK BY THE SEAT. THE CONTACT SUSTAINED INJURIES TO THE NECK AND BACK. THREE OCCUPANTS IN THE OTHER VEHICLE WERE ALSO INJURED, AS THE FRONT PASSENGER'S FEET WENT THROUGH THE WINDSHIELD AND TWO OF THE OCCUPANTS SUFFERED WHIPLASH. MEDICAL ATTENTION WAS REQUIRED FOR ALL THE INJURED OCCUPANTS. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED FROM THE SCENE AND THE CONTACT'S INSURANCE COMPANY CONFIRMED THAT THE VEHICLE WAS DESTROYED. THE MANUFACTURER AND DEALER WERE NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 180,000. SEE ALSO 11004763. *DSY ..UPDATED 08/04/17 *BF UPDATED 10/11/2017*JS *JS *JS
I WAS INVOLVED IN A REAR END CRASH AND THE FRONT PASSENGER SEAT INCAS IN CAME APART AT THE ADJUSTER TRACKS. THIS CAUSED ME TO BE THROWN INTO THE REAR OF THE VAN MAKING MY INJURES MUCH WORSE. SEE ALSO 11004775. *DSY
TL* THE CONTACT OWNS A 1998 DODGE GRAND CARAVAN. WITHOUT WARNING, THE SERPENTINE BELT DETACHED OUT OF PLACE. THE CONTACT REPLACED THE SERPENTINE BELTS AND THE PULLEYS, BUT THE FAILURE CONTINUED. THE DEALER INDICATED THAT THERE WAS NO SERVICE CAMPAIGN AND RECALL TO PROVIDE A SOLUTION. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN. UPDATED 05/30/17*LJ UPDATED 09/25/2017*JS
TL* THE CONTACT OWNS A 1998 DODGE GRAND CARAVAN. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V373000 (AIR BAGS, ELECTRICAL SYSTEM) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
THE CAR JUST STOPPED WORKING IT WOULD'T START ANY MORE
TL* THE CONTACT OWNS A 1998 DODGE GRAND CARAVAN. WHILE DRIVING AT 60 MPH, THE VEHICLE'S MUFFLER BECAME LOUDER AND THE ENGINE STALLED. THE VEHICLE COULD NOT RESTART. THE CONTACT STATED THAT THE VEHICLE HAD AN ABNORMAL FUEL ODOR PRIOR TO THE FAILURE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE MUFFLER, FUEL TANK, AND WIRING HARNESS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS 156,563.
I APPROACHED A RED LIGHT HIT THE BRAKES. THE CAR DID NOT STOP. I HIT TWO CARS AND THE MEDIAN. THE PASSENGER AIR BAG DEPLOYED NUT NOT THE DRIVER SIDE. I HAD MAJOR INJURIES INCLUDING BROKEN ANKLE, HAND, RIBS AND BREATHING. I SPENT 3 MONTHS IN THE HOSPITAL. *TR
THERE ARE AT LEAST 4 RECALL ITEMS LISTED FOR THIS VEHICLE. I HAVE NEVER BEEN CONTACTED BY THE MANUFACTURER. SHOULD I BE CONCERNED? IF YES, WHAT SHOULD I DO? *TR
THE INSTRUMENT CLUSTER LOSES THE ELECTRICITY AND THE GAUGES COMPLETELY DIE OFF. THIS IS NOT SAFE AND I HAVE NO WAY OF FIXING THIS. *TR
TL* THE CONTACT OWNS A 1998 DODGE GRAND CARAVAN. THE CONTACT STATED THAT WHILE STARTING THE IGNITION THE AIR BAG WARNING INDICATOR ILLUMINATED AS THE ENTIRE INSTRUMENT PANEL FAILED TO FUNCTION. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 40,000. THE VIN WAS UNAVAILABLE.
Showing 15 of 597 complaints