Loading vehicle data from NHTSA...
NHTSA recalls, safety ratings, and consumer complaints for the 2003 Chrysler Voyager.
| Overall Rating | Not Rated |
| Frontal Crash | Not Rated |
| Side Crash | Not Rated |
| Rollover | Not Rated |
Component: EQUIPMENT
CURT MFG IS RECALLING CERTAIN CLASS 3 RECEIVER HITCHES, P/N 13347, SOLD AS AFTERMARKET EQUIPMENT FOR USE ON 1997-2007 CHRYSLER TOWN AND COUNTRY VANS, 1996-2007 DODGE CARAVANS, AND 1996-2004 PLYMOUTH VOYAGER VANS. WHEN THE HITCH IS LOADED TO THE MAXIMUM RATING, THE HITCH MAY FRACTURE OR BREAK AT THE BEND LOCATION WHERE THE MAIN BODY OF THE HITCH MEETS THE HITCH MUFFLER STRAP.
Consequence: IF THE AREA IN QUESTION FRACTURES OR BREAKS, THIS COULD CAUSE AN UNSTABLE DRIVING CONDITION, POSSIBLY RESULTING IN A CRASH.
Remedy: CURT MFG WILL NOTIFY OWNERS OF RECORD AND WILL REPLACE THE HITCH FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING AUGUST 2010. OWNERS MAY CONTACT CURT MFG AT 1-715-831-8713.
Component: STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS
ON CERTAIN MINIVANS EQUIPPED WITH 3.3 OR 3.8L V-6 ENGINE, THE UPPER POWER STEERING COOLER HOSE MAY SPLIT AND CAUSE A FLUID LEAK.
Consequence: POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDER HOOD FIRE.
Remedy: DEALERS WILL REPLACE THE UPPER POWER STEERING COOLER HOSE. THIS RECALL BEGAN ON SEPTEMBER 27, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Component: SERVICE BRAKES, HYDRAULIC
CERTAIN AFTERMARKET BRAKE HYDRAULIC MASTER CYLINDERS SOLD AS REPLACEMENT BRAKE CYLINDERS FOR CERTAIN FORD, DAIMLERCHRYSLER, AND JEEP PASSENGER VEHICLES. THESE BRAKE CYLINDERS WERE SOLD UNDER THE BRAND NAMES OF NAPA, RAYBESTOS, AIMCO, AC DELCO, CARQUEST, BENDIX, AND WAGNER. ONLY PRODUCTS THAT WERE MANUFACTURED FROM JULY 27, 2005 THROUGH JANUARY 17, 2006 (DATE CODES 0529 THROUGH 0602) ARE SUBJECT TO THIS RECALL. WHEN SUBJECT TO VERY COLD TEMPERATURES, AN INTERNAL SEAL IN THE MASTER CYLINDER COULD LOSE FLEXIBILITY AND MAY CAUSE BRAKE FLUID TO LEAK.
REVERSE LIGHTS DO NOT WORK. TOLD BY 2 MECHANICS THAT CHRYSLER HAD REPAIRED VIA RECALL OR LETTERS IN PAST. I WAS TOLD THIS IS A ROUTINE PROBLEM WITH THE CAR. THIS IS A MAJOR SAFETY ISSUE AND SHOULD BE COVERED.
SO I WAS DRIVING DOWN THE ROAD AND I HEARD A NOISE FROM THE REAR END OF THE VAN MIND YOU THE SPEED LIMIT IS 45MPH HERE. I DRIVE IT TO THE NEAREST SHOP TO HAVE THEM LOOK AT IT , THEY CAME IN AND TOLD ME I'M LUCKY TO HAVE MADE IT THIS FAR AS ( THE REAR CHASSIS HAS BROKE! ) THIS IS A SAFETY ISSUE AND NEEDS TO BE ADDRESSED JUST LIKE FORD MOTOR COMPANY DID WITH THEIR VANS !!! I HAVE HEARD ABOUT OTHER VOYAGER VANS HAVING THIS ISSUE IN SALT BELT STATES .
TL* THE CONTACT OWNS A 2003 CHRYSLER VOYAGER. WHILE DRIVING 35 MPH, THE VEHICLE SHOOK AND FAILED TO ACCELERATE OVER 50 MPH. THE VEHICLE FELT AS IF IT WOULD STALL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THERE WAS AN ELECTRICAL CABLE FAILURE THAT RAN THROUGH THE FUEL INJECTION AND NEEDED TO REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 217,000.
OUR VAN MODEL / YEAR ISN'T LISTED UNDER THE IGNITION SWITCH RECALL, BUT WE HAVE THE IDENTICAL ISSUE; YOU CAN REMOVE THE KEY IN ANY POSITION - WHETHER THE MOTOR IS RUNNING, OR IS ON ACCESSORY. *TR
The 2003 Chrysler Voyager has 5 NHTSA recalls and 32 consumer complaints on file. It received an overall safety rating of Not Rated out of 5 stars in NHTSA crash testing. For the most detailed information about a specific vehicle, decode its VIN using our free decoder above.
Enter a specific VIN to get the full report — specs, recalls, safety ratings, complaints, investigations, and technical service bulletins.
Consequence: LOSS OF BRAKE FLUID CAN LEAD TO A DECREASE IN BRAKE LINE PRESSURE AND AN INCREASE IN STOPPING DISTANCE, WHICH CAN RESULT IN A VEHICLE CRASH.
Remedy: AFFINIA (BRAKE PARTS, INC.) WILL REPLACE THE SUBJECT BRAKE HYDRAULIC MASTER CYLINDERS FREE OF CHARGE. THE RECALL BEGAN ON MARCH 20, 2006. OWNERS CAN CONTACT AFFINA GROUP CUSTOMER SERVICE AT 1-800-323-0354.
Component: FUEL SYSTEM, GASOLINE
CERTAIN AFTERMARKET REPLACEMENT FUEL FILTERS, MODELS WIX FILTER PART NUMBERS 33576, 33577, 33734; NAPA FILTER PART NUMBERS 3576, 3577, 3734; AND CARQUEST FILTER PART NUMBERS 86576, 86577, 86734 USED ON 1996-2000 DAIMLERCHRYSLER TOWN & COUNTRY, DODGE CARAVAN, AND PLYMOUTH VOYAGER VEHICLES, CAN CAUSE THE FUEL LINES TO LEAK.
Consequence: A POSSIBLE FIRE CAN OCCUR IN THE PRESENCE OF AN IGNITION SOURCE.
Remedy: WIX WILL NOTIFY ITS CUSTOMERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. NOTE: THIS DOES NOT INVOLVE ANY PRODUCTS MANUFACTURED BY THE DAIMLERCHRYSLER CORP. NOR ANY DAILMERCHRYSLER DEALERS. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT WIX AT 704-864-6711.
Component: EQUIPMENT
AFTERMARKET REPLACEMENT FUEL FILTERS MANUFACTURED BETWEEN SEPTEMBER 17, 2002, AND JANUARY 20, 2003, SOLD UNDER THE BRAND NAMES LISTED ABOVE. THE FILTER MAY EXPERIENCE MALFUNCTION OF THE QUICK CONNECTOR EITHER BLOCKING FUEL FLOW TO THE ENGINE OR CAUSING A FUEL LEAK. THIS DOES NOT INVOLVE ANY PRODUCTS MANUFACTURED BY THE DAIMLERCHRYSLER CORP. NOR ANY DAILMERCHRYSLER DEALERS.
Consequence: IF THIS CONDITION OCCURRED WHILE THE VEHICLE IS IN MOTION, THE ENGINE COULD STALL. ALSO, IN THE PRESENCE OF AN IGNITION SOURCE, THE FUEL LEAK COULD RESULT IN A VEHICLE FIRE.
Remedy: AFTERMARKET REPLACEMENT FUEL FILTERS FOR 1995-2000 SHORT WHEELBASE CHRYSLER TOWN & COUNTRY, PLYMOUTH VOYAGER AND DODGE CARAVAN MINIVANS PART NO. 18232 AND DATE CODE 0237, 0249, OR 0252. REPLACEMENT FUEL FILTERS FOR 1995-2000 LONG WHEELBASE CHRYSLER TOWN & COUNTRY, PLYMOUTH VOYAGER AND DODGE CARAVAN MINIVANS PART NO. 18230 AND DATE CODE 0237, 0249, 0251, OR 0304. REPLACEMENT FUEL FILTERS FOR 2001-2004 CHRYSLER TOWN & COUNTRY, PLYMOUTH VOYAGER AND DODGE CARAVAN MINIVANS PART NO. 28871 AND DATE CODE 0249. THESE PART NUMBERS AND DATE CODES APPEAR ON THE GOLD-TONE FILTER. DISTRIBUTORS AND RETAILERS WILL BE NOTIFIED TO ISOLATE AND RETURN AFFECTED INVENTORY. OWNERS WHO HAVE HAD THE FUEL FILTER SERVICED ON ONE OF THE APPLICABLE VEHICLES AFTER SEPTEMBER 17, 2002 SHOULD RETURN THEIR VEHICLE TO THE SERVICE FACILITY TO BE INSPECTED TO SEE IF THE FUEL FILTER THAT WAS INSTALLED IS ONE THAT IS INVOLVED IN THE RECALL. IF SO, THE OWNERS SHOULD HAVE THE FILTER REPLACED. TO RECEIVE A FULL REFUND PLUS THE COST OF POSTAGE, OWNERS SHOULD CUT THE CONNECTORS FROM THE HOSES, RINSE THE CONNECTORS AND RETURN THEM TOGETHER WITH PROOF OF THE AMOUNT PAID FOR THE REPLACEMENT PART AND LABOR, TO INTERCONTINENTAL AT INTERCONTINENTAL AUTO PARTS, INC., P.O. BOX 861, MAHWAH, NJ 07430, ATTN: FUEL FILTER RECALL. INTERCONTINENTAL WILL MAIL A FULL REFUND TO THE OWNER.
HEADLIGHTS AND ALL INSIDE LIGHTING FLICKER WHILE DRIVING. DEALER REPLACED ALT. AND BATT. STILL FLICKERS WHILE DRIVING. *TR
HEADLIGHTS FLICKER WHILE DRIVING OR STOPPED. VEHICLE HAS NEW ALTERNATOR. DASH LIGHTS, HEADLIGHTS DIM ON BRAKING. *TR
THE FAILURE CAME SUDDENLY. ONE DAY, WHILE DRIVING, THE AIRBAG LIGHT ILLUMINATED AND THEN WAS EXTINGUISHED A FEW MINUTES AFTER. THE SECOND OR THIRD TIME IT ON REMAINED LIT PERMANENTLY. I IMMEDIATELY REPORTED TO THE GARAGE IN WHICH I BOUGHT THE CAR ON OCCASION. COULD FIND THE FAILURE. HE ASKED ME TO GO DIRECTLY TO THE CHRYSLER DEALER. THE FAILURE HAS NOT REPAIRED, EVEN THE CRUISE CONTROL AND THE HORN ARE INOPERATIVE. I CAN NO LONGER TAKE THE VEHICLE. I CALLED THE CHRYSLER DEALER IN REGION TO TALK HIM ABOUT IT. HE TOLD ME THAT THIS FAILURE, WITHOUT ANY OTHER FAILURE WILL BE CHARGED AROUND 300-350 EUROS BECAUSE MY CAR IS NO LONGER ON SAFETY WARRANTY AND IT IS ALSO NOT AFFECTED BY THE RECALL OF THE CHRYSLER VOYAGER FOR THOSE SAME FAILURES. THE CHARGE IS VERY EXPENSIVE FOR ME. IT IS THEN I TRY TO FIND HELP ON INTERNET THAT I CAME ACROSS YOUR WEBSITE. THAT IS MY ENTIRE PROBLEM. THREE MAJOR PROBLEMS: 1 - AIRBAG LIGHT ILLUMINATED PERMANENTLY 2 - SPEED CONTROL (CRUISE CONTROL) NON FUNCTIONAL 3 - HORN INOPERATIVE
IN THE BEGINNING, IT BEGAN WITH THE AIRBAG LIGHT INTERMITTENT VIEWS. BUT QUICKLY, A FEW KILOMETERS LATER THIS LIGHT REMAINED LIT PERMANENTLY. AT THE TIME, THE CRUISE CONTROL WORKS ONCE ON THREE, AND THEN AFTER NOTHING. THE AIRBAG LIGHT REMAINS LIT CONTINUOUSLY, THE CRUISE CONTROL DOES NOT WORK, AND WORSE THE HORN IS INOPERATIVE. I CAN NO LONGER TAKE THE VEHICLE. I CALLED THE CHRYSLER DEALER IN MY REGION WHO TOLD ME THAT THIS WILL BE CHARGED AT AROUND 300 EUROS BECAUSE MY VEHICLE IS NOT AFFECTED BY THE RECALL OF THE CHRYSLER VOYAGER FOR THOSE SAME FAILURES. IT IS THEN BY SEARCHING ON THE INTERNET I CAME ACROSS YOUR SITE SORRY FOR MY APPROXIMATE ENGLISH. I SPEAK BETTER FRENCH. NOTE: I WRITE FROM FRANCE, BUT MY COUNTRY IS NOT LISTED BELLOW, SO I AM TO CHOOSE A TOWN AND PHONE NUMBER FROM AMERICA TO FIT THE FORMULA. *KB
TL* THE CONTACT OWNS A 2003 CHRYSLER VOYAGER. THE CONTACT STATED THAT SHE HEARD NOISE COMING FROM THE BRAKES WHEN SHE APPLIED PRESSURE. THE VEHICLE WAS TAKEN TO PRIVATE MECHANIC WHO ADVISED THE CONTACT TO REPLACE THE FRONT BRAKES. NEITHER THE DEALER NOR THE MANUFACTURER WAS NOTIFIED OF THE FAILURE NOR WAS THE VEHICLE REPAIRED. THE CURRENT AND THE FAILURE MILEAGES WERE UNKNOWN.
AIRBAG LIGHT INTERMITTENT WILL DRIVING.
RECENTLY I NOTICED THE BRAKE PEDAL WAS "SPONGY"- I INSPECTED THE BRAKE SYSTEM AND FOUND A STEEL PORTION OF LEFT REAR BRAKE LINE ASSEMBLY RUSTED AND LEAKING. THE LINE FELL APART COMPLETELY DURING REMOVAL. THE LINE ASSEMBLY WAS REPLACED. I DO HAVE THE OLD LINE ASSEMBLY FOR INSPECTION. THIS VEHICLE HAS BRAKES THAT WEAR OUT MORE FREQUENTLY THAN ANY OTHER VEHICLE I'VE EVER OWNED. I'VE HAD TO REPLACE THE FRONT BRAKES TWICE AND THE REAR BRAKES AND WHEEL CYLINDERS IN LESS THAN 60,000 MILES. WHEN I TRY TO OBTAIN REPLACEMENT PARTS FOR THE FRONT BRAKE SYSTEM I INVARIABLY RECEIVE THE WRONG PARTS- I HAVE TO GET PARTS LISTED FOR A 4 CYL. VEHICLE EVEN THOUGH MINE IS A V-6. I HAVE TRIED SEVERAL NAME-BRAND PARTS MANUFACTURERS AND ALL HAVE THE SAME ISSUE. I BELIEVE MY VEHICLE WAS ASSEMBLED AT THE FACTORY WITH THE WRONG FRONT BRAKE SYSTEM WHICH IS UNDERRATED AND RESULTS IN PREMATURE WEAR. I HAVE ALSO, ON A PREVIOUS OCCASION, HAD AN ISSUE WITH AN "ABS" LIGHT AND "BRAKE" LIGHT COMING ON- EVEN THOUGH MY VEHICLE DOES NOT HAVE ANTI-LOCK BRAKES. AT THAT TIME THERE WERE NO LEAKS OR OTHER FAULTS TO CAUSE THE WARNING LIGHTS. I WAS FORCED TO PAY THE DEALER TO "RE-FLASH" THE COMPUTER WHICH WAS IMPROPERLY PROGRAMMED BY THE MANUFACTURER. THE MANUFACTURER HAD A TSB FOR THIS CONDITION AND I BELIEVE THERE SHOULD NOT HAVE BEEN A CHARGE TO CORRECT A MANUFACTURING DEFECT. THIS VEHICLE HAS HAD SEVERAL BRAKE SYSTEM PROBLEMS WHICH SHOULD NOT BE OCCURRING ON A VEHICLE WITH LESS THAN 60,000 MILES! *TR
TL* THE CONTACT OWNS A 2003 CHRYSLER VOYAGER. THE CONTACT WAS DRIVING APPROXIMATELY 45 MPH, THE VEHICLE SUDDENLY DOWNSHIFTED INTO THE THIRD AND FORTH GEAR WITHOUT WARNING. THE FAILURE OCCURRED SPONTANEOUSLY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CONTACT WAS INFORMED THAT THE FAILURE COULD NOT BE REPRODUCED. THE CURRENT AND FAILURE MILEAGES WERE 66,000. UPDATED 06/02/10. *LJ THE CONSUMER STATED THE VAN WOULD HESITATE. UPDATED 07/16/10*JB
I HAVE 2003 CHRYSLER VOYAGER MINI-VAN LE THAT BOTH OF THE REAR RED COVERS SEPARATED FROM THEIR REAR LIGHT ASSEMBLE. THE WEATHER TEMPERATURE WAS ABOUT 90 DEGREES IN LOS ANGELES, CALIFORNIA. THE RED COVERS UNGLUED FROM THE REAR LIGHT ASSEMBLE AND FALL OFF THE VAN DURING DRIVING THE VAN. *TR
TL*THE CONTACT OWNS A 2003 PLYMOUTH VOYAGER 2003. WHILE DRIVING 50 MPH, THE VEHICLE'S LIGHTS FLASHED ON AND OFF AND THEN STOPPED. THE CONTACT HAS NOT TAKEN THE VEHICLE TO A MECHANIC. THE FAILURE HAS GOTTEN WORSE. THE CURRENT MILEAGE IS 45,000 AND FAILURE MILEAGE WAS 30,000. UPDATED 12/12/07 *TR
TL*THE CONTACT OWNS A 2003 CHRYSLER VOYAGER. THE CONTACT STATED THAT THE VEHICLE'S BRAKE PADS HAVE BEEN REPLACED SIX TIMES SINCE THE VEHICLE WAS PURCHASED IN JANUARY OF 2004. THE ENGINE SIZE WAS UNKNOWN. THE CURRENT MILEAGE IS 55,428 AND THE FAILURE MILEAGE WAS UNKNOWN.
Showing 15 of 32 complaints