Loading vehicle data from NHTSA...
NHTSA recalls, safety ratings, and consumer complaints for the 2004 Chevrolet Venture.
| Overall Rating | Not Rated |
| Frontal Crash | Not Rated |
| Side Crash | Not Rated |
| Rollover | Not Rated |
Component: STEERING
DORMAN IS RECALLING 979 STEERING KNUCKLES, DORMAN P/NOS. 697-902 AND 697-903, SOLD UNDER DORMAN'S "OE SOLUTIONS<SUP>TM</SUP>" BRAND NAME, AND NAPA P/NOS. 7-8502 AND 7-8503 WHICH WERE SOLD FOR REPLACEMENT USE ON THE VARIOUS VEHICLES LISTED ABOVE. A POTENTIAL MATERIAL OR DESIGN DEFECT COULD RESULT IN THE STEERING KNUCKLE BREAKING IN THE HUB AREA.
Consequence: A BROKEN STEERING KNUCKLE COULD RESULT IN LOSS OF STEERING CONTROL AND A POSSIBLE CRASH WITHOUT WARNING.
Remedy: DORMAN WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE STEERING KNUCKLES FREE OF CHARGE AND REIMBURSE THE REPAIR FACILITY OR OWNER FOR LABOR. THE RECALL BEGAN ON FEBRUARY 23, 2009. OWNERS MAY CONTACT DORMAN'S TOLL-FREE HOTLINE AT 1-800-523-2492 AND PRESS 5.
Component: LATCHES/LOCKS/LINKAGES:DOORS:LATCH
ON CERTAIN MINIVANS EQUIPPED WITH SECOND-ROW BUCKET SEATS OR CAPTAIN'S CHAIRS AND A POWER SLIDING DOOR ON THE PASSENGER SIDE OF THE VEHICLE, A PASSENGER USING THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR COULD BE INJURED.
Consequence: IF A PASSENGER USES THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR AND HOLDS ONTO THE HANDLE WHILE IT IS BEING OPENED BY THE MOTOR, THE PASSENGER'S ARM MAY BE PUSHED INTO THE SEAT BACK OR ARMREST AND A WRIST OR LOWER ARM INJURY MAY RESULT.
Remedy: DEALERS WILL REPLACE THE POWER SLIDING DOOR INTERIOR HANDLE ON THE PASSENGER-SIDE. IF THE VEHICLE IS EQUIPPED WITH A POWER OR MANUAL SLIDING DOOR ON THE DRIVER-SIDE, THE INTERIOR HANDLE WILL ALSO BE REPLACED FOR APPEARANCE REASONS. NOTE: BEFORE THE VEHICLE IS SERVICED, GM ADVISES OWNERS TO NOT USE THE INTERIOR DOOR HANDLE TO OPEN THE DOOR. THE DRIVER CAN OPEN AND CLOSE THE DOOR FROM SWITCHES AT THE DRIVER'S POSITION OR BY USING THE REMOTE KEY FOB. THE DRIVER SHOULD TELL PASSENGERS TO USE THE SWITCH LOCATED IN FRONT OF THE DOOR TO OPEN OR CLOSE IT. THE DRIVER SHOULD USE THE OVERRIDE SWITCH TO PREVENT OPERATION OF THE POWER DOOR BY CHILDREN OR BY OTHERS WHO ARE NOT FAMILIAR WITH ITS USE. THE OWNER NOTIFICATION LETTER MAILING WILL BE CONDUCTED IN PHASES WITH THE FIRST PHASE BEGINNING ON MAY 31, 2005. THE SECOND PHASE MAILING BEGAN ON JULY 18, 2005. THE RECALL BEGAN ON MAY 31, 2005. PHASE 2 BEGAN ON JULY 18, 2005. PHASE 3 (FINAL PHASE) BEGAN ON AUGUST 24, 2005, TO ALL REMAINING CUSTOMERS. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; PONTIAC AT 1-800-620-7668; OR OLDSMOBILE AT 1-800-630-6537.
[XXX] 2021, Purchased 4 tires Walmart, Radar Dimax AS-8 size: 225/60R16. June 2023 tire badly separated. Denied warranty because Walmart did not install. Purchase 2 more identical tires and picked up [XXX] 2023 and installed both. Bad tire trashed no longer have in possession. Several months later had another tire separate so installed the extra tire I had. In March 2024 the wife told me the van was shaking again. Found two tires separating. One was from the newer purchase. Tried calling the Manufacture numerous times (800) 725-1482 to let them know of the problems with their tires and possible safety. Received no responses. I have never in my life had tires like the separate. Had a couple trailer tires years ago but probable heavy load and older tires, so expected. I have since purchased some Goodyear tires for replacement and currently have three of the separated tires and the one remaining good tire, which my wife will not let me install on anything she drives. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The contact owns a 2004 Chevrolet Venture. The contact stated while driving 30 mph, when a police officer ran the red traffic light and crashed into the driver's side door, and pushed the vehicle into a school bus. The air bags did not deploy. The contact stated she has a broken right foot and did seek medical attention at the hospital and was waiting for a pending surgery. The police report was filed. The vehicle was not drivable. The vehicle was towed to towing lot. The contact called the local dealer and made them aware of the failure. The vehicle was not diagnosed or repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 59,072.
The 2004 Chevrolet Venture has 5 NHTSA recalls and 124 consumer complaints on file. It received an overall safety rating of Not Rated out of 5 stars in NHTSA crash testing. The high number of complaints suggests potential reliability concerns — review the complaint details above before purchasing. For the most detailed information about a specific vehicle, decode its VIN using our free decoder above.
Enter a specific VIN to get the full report — specs, recalls, safety ratings, complaints, investigations, and technical service bulletins.
Component: FUEL SYSTEM, GASOLINE:STORAGE
ON CERTAIN VEHICLES, VARIATIONS IN THE MANUFACTURING PROCESS OR EXPOSURE TO HIGH AMBIENT TEMPERATURES MAY LEAD TO FRACTURE OF THE FUEL TANK INLET CHECK VALVE (ICV).
Consequence: A FRACTURE MAY ALLOW FUEL VAPORS TO PASS THROUGH AND ALLOW DROPLETS OF FUEL TO ACCUMULATE ON THE SIDE OF THE FUEL TANK. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL TANK. THE RECALL WILL BE MAILED IN TWO PHASES WITH THE FIRST PHASE BEGINNING ON DECEMBER 4, 2007. THE SECOND PHASE WILL BE MAILED ON DECEMBER 13, 2007. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OR PONTIAC AT 1-800-620-7668. THE VEHICLE POPULATION INCLUDES BUICK RENDEZVOUS AND PONTIAC AZTEK VEHICLE BUILT IN MAY 2003; CHEVROLET VENTURE AND PONTIAC MONTANA VEHICLES BUILT FROM JUNE THROUGH AUGUST 2002; AND ALL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO, AND HAWAII.
Component: FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Consequence: FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Remedy: DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Component: EQUIPMENT:OTHER:LABELS
CERTAIN MINIVANS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 213, "CHILD RESTRAINT SYSTEMS." THESE VEHICLES DO NOT HAVE TEXT AND FORMATTING ON THE WARNING LABEL ATTACHED TO THE AVAILABLE SECOND-ROW INTEGRAL CHILD RESTRAINT AS SPECIFIED BY AMENDMENTS TO THE STANDARD.
Remedy: OWNERS WILL BE PROVIDED WITH REPLACEMENT LABELS AND INSTALLATION INSTRUCTIONS. OWNER NOTIFICATION BEGAN ON JULY 23, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR PONTIAC AT 1-800-620-7668.
THE INSTRUMENT CLUSTER GAUGES WENT OUT AND MY ABS LIGHT STAYS ON AND I'M IN MOTION
TL* THE CONTACT OWNED A 2004 CHEVROLET VENTURE. WHILE THE CONTACT'S VEHICLE WAS AT A COMPLETE STOP, IT WAS REAR ENDED BY ANOTHER VEHICLE TRAVELING APPROXIMATELY 50 MPH. NONE OF THE AIR BAGS DEPLOYED. THE CONTACT WAS PREGNANT AND HAD TO BE TRANSPORTED TO THE HOSPITAL VIA AMBULANCE. A POLICE REPORT WAS FILED. THE DRIVER OF THE OTHER VEHICLE WAS INTOXICATED. THERE WERE TWO PASSENGERS WHO ALSO HAD TO BE HOSPITALIZED AND TRANSPORTED VIA AMBULANCE. THE VEHICLE WAS TOTALED AND TOWED TO A JUNK YARD. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE FAILURE MILEAGE WAS 270,000.
TRANSMISSION SLIPS AND JERKS WHEN DRIVING , GAS SOMETIMES SPUPS.
(XXXXXXXXX) CRAIGSLIST LEMON LAW PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
DASH DISPLAYS INACCURATE OR NOT WORKING GAUGES. TEMPERATURE AND SPEEDOMETER OFTEN DOESN'T WORK AT ALL OR SHOWS 120MPH WHEN DRIVING AT APPROX 55MPH! TEMP WILL OFTEN SHOW HOT WHEN CAR IS AT NORMAL TEMP.
TL* THE CONTACT OWNS A 2004 CHEVROLET VENTURE. WHILE DRIVING 35 MPH, THE BRAKE LIGHTS FAILED TO ILLUMINATE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 220,000.
HEADLIGHTS ARE DANGEROUSLY DIM AT NIGHT. NEW BULBS, NEW HEADLIGHT LENSES, NO SOLUTION. SAME PROBLEM WITH MY 1999 CHEVY VENTURE.
TL* THE CONTACT OWNS A 2004 CHEVROLET VENTURE. AFTER THE VEHICLE WAS FUELED, THERE WAS A STRONG ODOR OF FUEL COMING FROM THE VEHICLE. THE CONTACT OBSERVED A PUDDLE OF FUEL UNDER THE REAR DRIVER SIDE OF THE VEHICLE. THE FAILURE RECURRED CONTINUOUSLY. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 07V349000 (FUEL SYSTEM, GASOLINE). THE FAILURE MILEAGE WAS APPROXIMATELY 136,000.
CIGARETTE LIGHTER SHORTED WITH THE PHONE CHARGER PLUGGED IN. THE FUSE DID NOT BLOW, WHICH CAUSED AN ELECTRICAL FIRE WHICH TOTALED THE VAN. *TR
TL* THE CONTACT OWNS A 2004 CHEVROLET VENTURE. THE CONTACT STATED THAT THERE WAS A FUEL ODOR PRESENT COMING FROM THE VEHICLE. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 07V349000 (FUEL SYSTEM, GASOLINE). THE VEHICLE WAS TAKEN TO A DEALER, WHO DIAGNOSED THAT THE VENT TUBE AT TOP OF FUEL TANK WAS CORRODED AND THAT THE FUEL TANK NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 43,000.
TL* THE CONTACT OWNS A 2004 CHEVROLET VENTURE. THE CONTACT STATED THAT THE ABS LIGHT CONTINUOUSLY ILLUMINATED AND THE POWER WINDOWS FAILED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 135,000.
TL* THE CONTACT OWNS A 2004 CHEVROLET VENTURE. THE CONTACT STATED THAT THE ROCKER PANELS WERE RUSTED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE INTEGRAL BODY STRUCTURE WAS WEAKENED BY RUST AND FORMED HOLES. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 94,000.
MY WIFE TOOK HER CHEVROLET VAN IN FOR SERVICE DUE TO THE INTERIOR LIGHT NOT FUNCTIONING IT WAS TAKEN TO MAHONEY CHEVROLET AND BLOSSOM CHEVROLET. THEY TOLD HER IT WAS CORROSION CAUSING THE PROBLEM AND DID NOTHING TO REPAIR THE PROBLEM AS THEY SAID IT WAS NOT COVERED. I BEING A CERTIFIED MECHANIC AND HAVING AN ASSOCIATES DEGREE IN ELECTRONICS TROUBLE SHOT THE PROBLEM AND FOUND THE BODY CONTROL MODULE TO BE THE CAUSE OF THE PROBLEM. THE MODULE ALSO CAUSED THE POWER WINDOWS,DOOR LOCKS,REMOTES AND ALL OTHER INTERIOR THINGS TO FAIL. I FEEL THIS IS A VERY SERIOUS SAFETY ISSUE AS THERE ARE MILLIONS OF THESE VANS ON THE ROAD AND THESE MODULES FAIL ON THIS AND ALL OTHER MODELS OF THIS VAN SUCH AS THE PONTIAC ETC... IN A PANIC SITUATION SUCH AS AN ACCIDENT THE DRIVER WOULD HAVE TO MANUALLY OPERATE THE LOCKS OR SMASH OUT A WINDOW IF THEY WERE ABLE TO DO SO IF THERE WERE A FIRE AND IT WAS URGENT TO GET OUT OF THE VAN MANY MAY PANIC AND NOT BE ABLE TO GET OUT. I CONTACTED GM OVER THIS ISSUE AND THEY APPEARED TO AGREE WITH ME AND GAVE ME A SERVICE # OF 71-1331263820. I HAVE SENT THEM NUMEROUS E-MAILS AND PHONE CALLS BUT HAVE GOTTEN NO RESPONSE. I FEEL THIS IS THE SAME OLD GM AND THEY WONT REPAIR AN OBVIOUS DEFECT UNLESS ORDERED TO OR IF THERE ARE DEATHS FROM THE PROBLEM. I AM HOPING CONTACTING YOU WILL FORCE THEM TO DO THE RIGHT THING AND REPAIR THIS PROBLEM BEFORE SOMEONE DOES DIE BECAUSE THEY CANT GET OUT OF THEIR VAN OR THE MODULE CATCHES FIRE FROM AN OVERHEATED CHIP THAT CONTROLS THIS MODULE. THANK YOU AND I HOPE TO HEAR FROM YOU SOON *TR
Showing 15 of 124 complaints