Loading vehicle data from NHTSA...
NHTSA recalls, safety ratings, and consumer complaints for the 1996 Chevrolet Monte Carlo.
| Overall Rating | Not Rated |
| Frontal Crash | Not Rated |
| Side Crash | Not Rated |
| Rollover | Not Rated |
Component: FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Consequence: FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Remedy: DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Component: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 1995-1999 CHEVROLET MONTE CARLO Z34 PASSENGER VEHICLES. THE BRAKING PERFORMANCE IN WET WEATHER OR WET ROAD CONDITIONS IS REDUCED MORE THAN A DRIVER WOULD EXPECT.
Consequence: THE BRAKING COULD FEEL DELAYED MOMENTARILY WHEN LIGHT OR MODERATE FORCE IS APPLIED ON THE BRAKE PEDAL WHILE DRIVING ON WET ROADS OR AFTER GOING THROUGH A CAR WASH.
Remedy: DEALER WILL MODIFY THE FRONT FENDER LINERS TO REMOVE A PORTION OF THE CLOSEOUT PANELS IN THE FRONT WHEEL WELLS AT NO CHARGE TO THE CONSUMER. THIS SERVICE WILL BE AVAILABLE THROUGH AUGUST 2004.
TL* THE CONTACT OWNS A 1996 CHEVROLET MONTE CARLO. WHILE DRIVING APPROXIMATELY 45 MPH, THE ENGINE SEIZED WITHOUT WARNING. THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 50,000.
TL* THE CONTACT OWNS A 1996 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT WHILE MAKING A LEFT TURN, THE VEHICLE CRASHED INTO ANOTHER VEHICLE AND THE FRONT AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED. THE DRIVER AND THE REAR PASSENGER SUSTAINED UNKNOWN INJURIES THAT REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN. THE VIN WAS UNAVAILABLE.
THE FUEL PRESSURE REGULATOR IN THE ENGINE COMPARTMENT DEVELOPED A SEVERE LEAK. THE LEAK CAUSED FUEL TO BE RELEASED IN LARGE QUANTITIES DIRECTLY INTO THE UPPER INTAKE MANIFOLD AND OUT THE THROTTLE BODY. FUEL CONTINUED TO FLOW OUT INTO THE AIR CLEANER HOUSING AND EVENTUALLY THE ENGINE COMPARTMENT AND ONTO THE GROUND. SEVERAL GALLONS OF FUEL WERE DISCHARGED IN THIS FASHION. THE VEHICLE WAS RUNNING POORLY BUT GAVE NO INDICATION THAT THERE WAS A LEAK UNTIL THE AIR CLEAN WAS OPENED. THE PART THAT FAILED WAS A STANDARD MOTOR PRODUCTS PART NUMBER PR216T PURCHASED FROM ROCKAUTO.COM ON 5/15/2013 AND INSTALLED SHORTLY THEREAFTER. VEHICLE MILEAGE AT INSTALLATION WAS APPROXIMATELY 131000. THE PART FAILED ON 10/20/2014 AT VEHICLE MILEAGE148243 MILES. THE PART WAS INSTALLED TO CORRECT A SIMILAR SITUATION INVOLVING A MUCH LESS SEVERE LEAK IN AN OLDER PART. THE FUEL LEAKAGE WITH THE OLDER PART DID NOT ESCAPE THE UPPER INTAKE MANIFOLD. AGE AND ORIGIN OF THE OLDER PART ARE NOT KNOWN. THE OLDER PART MAY HAVE BEEN ORIGINAL TO THE VEHICLE. GIVEN THE SIGNIFICANT QUANTITY OF FUEL DISCHARGED AND THE REPEATED NATURE OF THE FAILURE, I FEEL AN INVESTIGATION IS WARRANTED. *TR
The 1996 Chevrolet Monte Carlo has 3 NHTSA recalls and 206 consumer complaints on file. It received an overall safety rating of Not Rated out of 5 stars in NHTSA crash testing. The high number of complaints suggests potential reliability concerns — review the complaint details above before purchasing. For the most detailed information about a specific vehicle, decode its VIN using our free decoder above.
Enter a specific VIN to get the full report — specs, recalls, safety ratings, complaints, investigations, and technical service bulletins.
Component: SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM
THESE VEHICLES WERE ASSEMBLED WITH ONE OF THE FOUR BRAKE BOOSTER TABS NOT PROPERLY LOCATED IN THE FRONT OF DASH REINFORCEMENT ASSEMBLY.
Consequence: IF THIS CONDITION WERE PRESENT IN A SITUATION WHERE STOPPING DISTANCES WERE SMALL, A VEHICLE CRASH COULD OCCUR.
Remedy: DEALERS WILL INSPECT FOR PROPER BOOSTER INSTALLATION. BOOSTERS FOUND TO BE IMPROPERLY LOCATED WILL BE REMOVED AND REINSTALLED PROPERLY.
TL*THE CONTACT OWNS A 1996 CHEVROLET MONTE CARLO. WHILE DRIVING 25 MPH, THE TRANSMISSION GEARS SLIPPED OUT OF PLACE. A LOCAL MECHANIC ATTEMPTED TO REPLACE THE TRANSMISSION AND DID NOT HAVE ALL OF THE NECESSARY COMPONENTS TO DO SO. THE MANUFACTURER COULD NOT IDENTIFY OR LOCATE THE CORRECT TRANSMISSION FOR HIS MODEL. NO REPAIRS WERE MADE. THE FAILURE MILEAGE WAS 80,000. THE CURRENT MILEAGE WAS 100,000.
MY CHEVY MALIBU IS HAVING POWERSTEERING ISSUES. IT FREEZES UP WHILE TRYING TO TURN CORNERS. THIS CAR HAS NOTHING WRONG WITH IT. THE POWERSTEERING FLUID IS AT A GOOD LEVEL AND THERE ARE NO LEAKS IN THE SYSTEM. *TR
DT*: THE CONTACT STATED THE VEHICLE STALLED IMMEDIATELY UPON STARTING THE ENGINE. THE VEHICLE WAS RESTARTED BUT IMMEDIATELY STALLED AGAIN. THE ABS LIGHT ALSO ILLUMINATED INTERMITTENTLY. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR SERVICE.
1996 CHEVROLET MONTE CARLO Z34, POWER DRIVER SEAT FRAME DEFECT. BOTTOM OF SEAT DETACHED FROM FRAME, WHICH MADE DRIVER FALL BACKWARD TOWARD REAR SEATS. *NM
I HAVE BEEN HAVING PROBLEMS WITH THE AUTOMOBILE HAVING A TICKING NOISE AFTER I START IT UP IN THE MORNING SO I BROUGHT IT TO THE DEALER TO FIND OUT WHAT WAS WRONG WITH IT. IT WAS THE HEAD GASKET. THE AUTO ONLY HAS 75000 MILES ON IT. I WOULD LIKE TO KNOW WHAT YOU CAN DO FOR ME. THERE WAS A TSB #57-61-24A JUN98 ON THIS PROBLEM. *NM
1996 CHEVROLET MONTE CARLO EXPERIENCED PROBLEMS WITH THE FUEL REGULATOR.*MR THE CONSUMER DROVE ABOUT 7 MILES AND NOTICED THAT THE FUEL TANK NEEDLE MOVED FROM FULL TANK TO HALF TANK DURING THE SHORT RIDE AND SAW SMOKE COMING FORM UNDER THE HOOD. THE NEXT DAY A STRONG SMELL OF GASOLINE COULD BE SMELLED. THE CONSUMER OPENED THE HOOD AND NOTICED FUEL WAS LEAKING ONTO THE GROUND. IT WAS LATER DETERMINED THAT THE FUEL REGULATOR HAD FAILED. THE CONSUMER HAS THE FAULTY REGULATOR. *NM
1996 CHEVROLET MONTE CARLO EXPERIENCING PROBLEMS WITH FUEL REGULATOR.*MR THE CONSUMER DROVE ABOUT 7 MILES AND NOTICED THAT THE FUEL TANK NEEDLE MOVED FROM FULL TANK TO HALF TANK DURING THE SHORT RIDE AND SAW SMOKE COMING FORM UNDER THE HOOD. THE NEXT DAY A STRONG SMELL OF GASOLINE COULD BE SMELLED. THE CONSUMER OPENED THE HOOD AND NOTICED FUEL WAS LEAKING ONTO THE GROUND. IT WAS LATER DETERMINED THAT THE FUEL REGULATOR HAD FAILED. *BF *NM
THE PROBLEM DESCRIBED BELOW HAS OCCURRED ON 3 PREVIOUS OCCASIONS.(1) EVENTS LEADING UP TO THE FAILURE - "DEX COOL" COOLANT LEAK FROM INTAKE MANIFOLD GASKET. 2) FAILURE AND ITS CONSEQUENCES - LOSS OF COOLANT LEADING TO ENGINE OVERHEATING OR FAILURE. (3) WHAT WAS DONE TO CORRECT THE FAILURE; I.E, PARTS REPAIRED OR REPLACED (AND IF OLD PART IS AVAILABLE) - GM STARTED USING "DEX-COOL" EXTENDED LIFE COOLANT IN 1996 IT DIDN'T TEST THE LONG TERM AFFECTS ON IT'S EXISTING GASKET TECHNOLOGY. ONE ARTICLE I READ STATED "IT APPEARS THAT ON SOME ENGINES, THE USE OF CONVENTIONAL PLASTIC-AND-RUBBER GASKETS IN COMBINATION WITH MORE AGGRESSIVE OAT (ORGANIC ACID TECHNOLOGY) ENGINE COOLANTS HAS CAUSED A SIGNIFICANT NUMBER OF SEALING RELATED ISSUES FOR CONSUMERS AND AUTOMOTIVE SERVICE PROVIDERS", SAID FEL-PRO CHIEF ENGINEER JERRY ROSENQUIST -- PER P://WWW.THEAUTOCHANNEL.COM/NEWS/2004/10/14/252583.HTML. DEX-COOL IS AN OAT COOLANT MANUFACTURED BY TEXACO FOR GM. OVER THE PAST FEW DAYS I'VE READ MANY COMPLAINTS ABOUT GM INTAKE GASKET LEAKS AND IT SEEMS MORE LIKELY THAT THE COOLANT, RATHER THAN THE GASKET ITSELF, IS CAUSING THE PROBLEM.*AK
ROUGH IDLE, RANDOM MISFIRES, STRONG ODOR WHEN MISFIRE OCCURS, FLUCTUATING GAS GAUGE. *AK
DUE TO INTAKE MANIFOLD GASKET LEAK (THIS IS THE FOURTH TIME FOR THIS PROBLEM ON THIS VEHICLE) I HAD TO STOP TO ADD COOLANT IN ORDER TO SAFELY DRIVE THE VEHICLE. HAD I NOT NOTICED THE PROBLEM THIS POTENTIALLY COULD HAVE LEFT ME STRANDED ON THE SIDE OF THE HIGHWAY. AFTER GETTING TO A SAFE LOCATION I HAD THE VEHICLE TOWED TO A DEALER FOR REPAIR. ALSO, AS I STATED ABOVE THIS IS MY FOURTH TIME DEALING WITH THIS ISSUE; IN ADDITION, I KNOW OF PERSONALLY 3 OTHER VEHICLES WITH THE SAME ENGINE THAT HAVE HAD THE SAME PROBLEM AND THEY TOO HAVE CHANGED THE INTAKE GASKET SEVERAL TIMES.*AK
I HAD TO REPLACE THE LOWER INTAKE MANIFOLD GASKET DUE TO ANTIFREEZE LEAK, AND NOW THE HEAD GASKET IS LEAKING ANTIFREEZE.*AK
RACK AND PINION HAVE HAD TO BE REPLACED 5 TIMES. EACH TIME CAUSES METAL SHAVINGS IN THE POWER STEERING PUMP CAUSING LOSS OF STEERING. *CB
Showing 15 of 206 complaints