2012 Volvo Xc60

On October 12, 2022 while driving home from the Schar Cancer Center in Fairfax, my 2012 Volvo XC60 experienced an end of life event. My check engine light came on when I entered my neighborhood. The car began sputtering and the gas pedal was delayed and at times, unresponsive. I was able to make it to my house and made an appointment to service my Volvo. My Volvo was towed to GT Peace Automotive on November 6. The three-week delay was due to their backlog of work. They are a trusted repair service and have provided service to all my vehicles over the past four years. The attached document indicates their assessment. Highlights include that the Volvo was a fire hazard in its current condition, the ignition coils were melted, and the circuits are shorted. GT Peace provided an estimate of $3,500 for repairs as a starting point to fully replace the engine harness. Their evaluation concluded that, based on other findings, the cost would easily go north of $3,500, possibly to $5,500. Based on this assessment and the CARFAX History Based Value of my vehicle (private party value of $10,170), it was in my best interest to donate the vehicle. I gave it to the Auto Tech program at Centreville High School on November 9, 2022.

A faulty radiator anti-tamper device caused loss of communication to the engine control computer. The check engine light turns on and “charging failure-service urgent” message pops up during driving. Which cause the drivers worry even panic. I talked to local dealer several times. I was told to change battery everytime. But my battery and alternator were both tested fine. The message could pop up right after full charged battery. There are many complains at Volvo forums. Volvo knows the issue, but they decided not to recall it. The check engine light and messages pops up on and off by itself. The DTC codes are normally U0286 and/or B1087. I am already changed one battery. The problem is still there. It could cause accident because the message pops up during driving on highway and cause unnecessary worry and panic.

"Failure Charging" warning advisory light came on the dashboard. This problem has been going on for the whole ten years I have owned this vehicle. I am the original owner of this Volvo and had some engine warning on the dashboard since the first month. I took vehicle in to the Culver City Volvo for 1000 miles check-up and annual oil change and check-up for 5 years under warranty and requested software update and reported the engine stalling during the first month. The "failure charging" or "engine check" or "dangerous" "immediate" repair needed signs came on sometimes and did not come on other time. When the "failure charging" sign comes on and the engine is turned off and restarted the warning would go away sometimes. I believe this is a Volvo vehicle computer software malfunction. I reported this problem to the dealer for 5 years during annual service appointments. This problem was not solved and I have lived with this, stupidly patient for 10 years. Today, problem light came on during biennial smog check for vehicle license renewal and failed the smog test. So, I informed the mechanic and tried a second test several minutes later and passed the second time because the software problem did not surface this time. So, my question is: has this Volvo software problem been reported by others as I have heard by word of mouth that this software problem is found on Volvo cars? And, has there been a recall to fix this Volvo software problem? When this "failure charging" sign comes on, it is very worrisome and makes me feel the vehicle may stop on the road.

The front windshield was not properly sealed during manufacturing and is now leaking when it rains. Water drips down the inside of the windshield in front of the driver resulting in distraction and poor visibility. I also fear that in an accident the windshield would not perform as it should and would be a safety issue. I brought it to the Volvo dealer and they just said I had to have it replaced but they do not provide that service. I brought it to a windshield service center and the technician was able to push on the windshield with only his hand and confirm that it was not sealed and showed movement. They also mentioned that have seen this issue many times with these cars. There were no warnings other than the leak which started a few months ago.

Lately my vehicle has been shutting off power when I hard right turn during parking everything shut off then I have to restart it again, but the scary part was what happened this morning I was driving on interstate and as I was charging lanes it almost powered off again but it picked up.

The windshield was not sealed properly during manufacturing because of a problem with the sealant used. This has caused a leak from the windshield on both the driver and passenger side from the top of the windshield when it rains. This creates lowered visibility when driving with water on the inside of the car, and also causes driving distractions while operating the vehicle. This improperly installed windshield also has caused malfunctions in electrical components in the windshield. There are no warning lights for this issue, but the windshield must be resealed by an auto glass technician.

Manufacturers original windshield began leaking. On inspection windshield is not properly bonded or adhered to vehicle body and is able to be pushed off the body of the vehicle with little pressure from the inside of the cabin. Windshield repair company advised me to look for a recall notice they were so concerned. Didn't find one, so I wanted to report a safety concern

Original front windshield separating from frame of car. Leaking water during rain / melting snow. In cold weather forms ICE/FROST on INTERIOR posing visibility hazard! Autobody worker showed me how the windshield MOVED when he pushed on it with nothing more than his hand - warned me this is also a structural risk in case of crash. He stated he has personally seen hundreds of these on same model car for this year and the two following. Doesn't know why the company doesn't issue a recall!

Our 2012 Volvo XC60 has a problem with the seal along the top of the windshield, which allows water into the interior of the car. It can end up dripping onto my lap while driving, which is distracting and a potential safety issue, and it also can obstruct visibility as water runs down the inside of the glass.

During heavy rains and movement there is water leaking into the vehicle along the top drivers inside of the windshield. It also drips onto the steering wheel which often startles me while actively driving. The windshield has no cracks and is the original windshield.