Loading vehicle data from NHTSA...
NHTSA recalls, safety ratings, and consumer complaints for the 2010 Volvo S80.
| Overall Rating | Not Rated |
| Frontal Crash | Not Rated |
| Side Crash | Not Rated |
| Rollover | Not Rated |
Component: SEAT BELTS:FRONT
Volvo Cars of N.A., LLC (Volvo) is recalling certain 2008-2016 V70 and XC70, 2007-2016 S80, 2011-2018 S60 and V60, 2016-2018 S60 Cross Country, 2014-2020 S60L, 2009-2015 S80L, 2009-2016 XC60 and 2015-2018 V60 Cross Country vehicles. The flexible steel cable that connects the seat belt to the front outboard seating positions may fatigue over time, causing the seat belt to not secure the occupant in the event of a crash.
Consequence: An unsecured occupant has an increased risk of injury in the event of a crash.
Remedy: Volvo will notify owners, and dealers will replace the seat belt anchor cable for both front seats. The recall began December 10, 2020. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R10029.
Component: EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)
VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
Consequence: AN OVERHEATED BATTERY COULD LEAD TO A FIRE.
Remedy: VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 18, 2010. OWNERS MAY CONTACT GARMIN AT 866-957-1981 OR VISIT GARMIN'S WEBSITE AT WWW.GARMIN.COM/NUVIBATTERYPCBRECALL.
Component: AIR BAGS:FRONTAL
VOLVO IS RECALLING CERTAIN MODEL YEAR 2010-2011 S80, XC70, MODEL YEAR 2011 XC60 AND MODEL YEAR 2010 V70 VEHICLES. THERE MAY BE AN INTERMITTENT FAULT IN THE DRIVER'S AIRBAG CLOCKSPRING WIRING CONNECTOR FOR THE SUPPLEMENTAL RESTRAINT SYSTEM.
Car would not crank, got fuel system replaced. Week later after being parked, while driving car cut off on highway. Mechanic has vehicle and has determined the issue is Central Electronic Module. Car is 2010 Volvo S80 with active recall but vin number is not apart of recall while experiencing same problem that almost caused a major accident. Vin [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
On [XXX] I was driving from Opelika, AL to Birmingham, AL. About 20 miles from home while driving on [XXX] in the left lane, my car would not accelerate. I pushe9 it down to the floor and there was no gas, so I had to get over to the right lane while rolling to get out of danger of the traffic and large trucks. MY car has been towed three time in about 3 month in 2025. I had it towed from my work parking lot twice because it would not crank. We bought new batteries, changed out the key batteries and this last incident. We had just got the car out of the shop for a fuel pump & fuel pump control module. (see receipt). I learned there was a Safety Recall from the NHTSA. However, when I called only to learn that my car had not been recalled. Therefore, I am quite confused because the safety issue recall no 09V343000 for 2010,S80 appears to be having the same issue. the software within the Central Electronic module (CEM) is not sending the signal to the fuel pump that was just replaced to the electronic module (PEM). The missing signal to the PEM inhibits the start of the fuel pump. This was a very frightening experience having a car stop on the highway while in the fast lane. Now the fear of it happening again is quite frightening, that's why I confused as to the seriousness of this electrical system software issue is not being taken for granted on my vehicle. If it was a problem for some, why would it not be a problem for all. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The contact owns a 2010 Volvo S80. The contact stated that there was condensation inside the vehicle. Additionally, the contact's daughter informed the contact that there was mold on the front passenger's side seat belt. The contact stated that there was mold on the lower seal near the front passenger's side door jam. The vehicle was taken to the dealer, where it was inspected. The dealer informed the contact that the upper part of the windshield was detaching on the passenger's and driver's sides. The contact stated that after the dealer removed the carpet on the passenger's side, the contact noticed water inside the vehicle and the wiring was wet. The dealer determined that the windshield needed to be replaced. The dealer advised the contact to file an insurance claim for the windshield replacement and another claim for the water damages. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 89,500.
The 2010 Volvo S80 has 5 NHTSA recalls and 27 consumer complaints on file. It received an overall safety rating of Not Rated out of 5 stars in NHTSA crash testing. For the most detailed information about a specific vehicle, decode its VIN using our free decoder above.
Enter a specific VIN to get the full report — specs, recalls, safety ratings, complaints, investigations, and technical service bulletins.
Consequence: IN THE EVENT OF A CRASH, THE DRIVER'S FRONTAL AIRBAG MAY NOT DEPLOY AS INTENDED OR AT ALL, AND THEREFORE WILL NOT BE ABLE TO PROPERLY PROTECT THE DRIVER, INCREASING THE RISK OF INJURIES.
Remedy: DEALERS WILL INSTALL A METAL SHIM IN THE DRIVER'S AIR BAG CLOCKSPRING WIRING CONNECTOR. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 20, 2010. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
Component: TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS
VOLVO IS RECALLING CERTAIN MODEL YEAR 2007-2010 S80 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE TIRE AND LOADING INFORMATION LABEL AND A PAGE IN THE OWNER'S MANUAL CONTAIN INCORRECT MAXIMUM PERMISSIBLE INFLATION PRESSURE AND THE TIRE PRESSURE MONITORING SYSTEM (TPMS) SOFTWARE HAS AN INCORRECT TRIGGER LEVEL.
Consequence: THESE VEHICLES DO NOT MEET THE REQUIRED SAFETY STANDARDS.
Remedy: DEALERS WILL UPDATE THE VEHICLES WITH A NEW TIRE AND LOADING INFORMATION LABEL, OWNER'S MANUAL LABEL AND TPMS SOFTWARE. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT AUGUST 27, 2010. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552 OR CUSTOMERCARE@VOLVOFORLIFE.COM .
Component: ELECTRICAL SYSTEM:SOFTWARE
VOLVO IS RECALLING MY 2008-2010 S80, MODEL YEAR 2009-2010 XC70 AND MODEL YEAR 2010 XC60 VEHICLES. UNDER CERTAIN CONDITIONS THE SOFTWARE WITHIN THE CENTRAL ELECTRONIC MODULE (CEM) MAY NOT SEND A SIGNAL TO THE FUEL PUMP ELECTRONIC MODULE (PEM). THIS MISSING SIGNAL TO THE PEM INHIBITS THE START OF THE FUEL PUMP. THE DRIVER MAY BE ABLE TO START THE ENGINE IN SPITE OF THE FUEL PUMP NOT BEING ACTIVATED DUE TO RESIDUAL PRESSURE IN THE FUEL SYSTEM. IN SOME CASES, THE DRIVER MAY BE ABLE TO DRIVE THE VEHICLE A SHORT DISTANCE AT IDLE BUT THEN THE ENGINE MAY STALL.
Consequence: IF THE VEHICLE STALLS IN CERTAIN CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL DOWNLOAD SOFTWARE TO THE VEHICLES' CEM FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 30, 2009. VEHICLES IN DEALER'S INVENTORY WILL BE REPAIRED PRIOR TO DELIVERY. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
Driving down [XXX] headed west to Charlottesville and debris flew off of another truck with a trailer attached . Came off the back of their truck and smashed into the top of my car into my sunroof glass. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The air bag warning randomly popped up on my screen. They will not deploy if I get into a wreck. Non working air bag. I also have issues that come and go with the electrical component. Sometimes my door won't open, sometimes my seats won't move, and my license plate light is out due to something electrical. My gas tank spits gas back at me and makes weird noises sometimes.
I was driving down the road at 60mph, and my car started to wobble a little bit. I pulled over to see if something was obviously wrong and I didn't notice anything. At this point I thought that maybe I needed a new rear shock, but when I got back on the road, the wobble was so bad that I couldn't drive 25mph. I drove about 20mph until I could get to a safe place to pull over which was only about a mile. I took the wheel off and this was the moment that I noticed the tire had swelled up to the point that it wouldn't stand upright. It just fell over. I bought the tire (Riken Raptor) brand new 11 months ago. There is still a lot of tread on the tire. I had the presence of mind to pull over as soon as I noticed something wasn't right. I fear that if I had been on an interstate highway going 70mph, then something really bad may have happened.
Leaking windshield. Notice Glass loose from top of windshield.Water leaking down into car on passenger and driver side. Floors soak and wet. Unable to drive in rain car smells due to wet floors. This windshield never was changed, it is the original. This is a Safety issue. This should be a recall. Made an appointment with Volvo dealership on 5/22/2023, they confirmed the windshield leak, water coming in from the top of the windshield. Advise to reseal or replace was told glass will continue to come loose if not taken care of. The windshield can cause an injury or accident if it comes a part while I'm driving. Many volvo's owners have this defective windshield. The leak is due to poor sealing during manufacturing of the vehicle's. This issue should be on the recall list and repairs done for free. All owners who had to pay for this repair should be reimbursed.The floor rugs should also be included in the recall, because it can cause health issue like mold, which is unhealthy. Safety for your customers should always come first.
The warning, charging failure service urgent is displayed the service engine light comes on. Several mechanics have not be able to repair. The front passenger seat belt is not stable to fasten properly. The TMPS has yet another warning, inoperable
The exhaust for the car is routed within inches of the subframe which does not have a heat shield. The paint has since deteriorated and large rust holes have formed.
The stock oem windshield has come away from the body. This a common on-going issue with p3 volvos. My car leaks water into the cabin. It is dangerous not having a windshield glued down to the body.
There is a leak or gap at the top of the windshield allowing water to get into the car. Most notable when there is a heavy rain and the car sits overnight. Then what happens is that the water that gets in either fills up in the interior dome light areas or splashes out onto the gear shifter creating puddles. This can be distracting while driving as water will splash on one's face from the water that is pooled in the dome light areas. Also there is a fear that this can cause further electrical damage, Some of the lights on the gear shifter are already not working as a result. This moisture has also begun to deteriorate areas of the instrument panel as well.
The sub frame located near the front exhaust has premature rust and corrosion to the point there are holes in the frame.
TL* THE CONTACT OWNS A 2010 VOLVO S80. THE CONTACT STATED THAT THE FRONT WINDSHIELD BONDING DETACHED CAUSING SEPARATION OF THE WINDSHIELDS AND WATER LEAKING INTO THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO A DEALER OR AN INDEPENDENT MECHANIC FOR A DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 124,000.
WINSHEILD LEAKS INSIDE WHEN IT RAINS ACROSS PASSENGER AND DRIVERS SIDE
THE CAR WAS JUST PURCHASED AT 127K MILES. THE CARFAX SHOWS 0 ACCIDENTS YET THE BALL BEARINGS IS NOW IN ITS 2ND REPLACEMENT. WHEN I TEST DROVE IT MCGRATH VOLVO STATED THAT THERE HAD BEEN A SAFETY CHECK, BUT THE NOISE WAS NOTICABLE BUT THE SALESMAN PULLED IT OFF AS WEAR AND TEAR. 2 DAYS INTO OWNERSHIP SUSPENSION, BEARINGS (FRONT) NEED REPLACEMENT FOR SAFETY.
Showing 15 of 27 complaints