Loading vehicle data from NHTSA...
NHTSA recalls, safety ratings, and consumer complaints for the 2002 Volvo S80.
| Overall Rating | Not Rated |
| Frontal Crash | Not Rated |
| Side Crash | Not Rated |
| Rollover | Not Rated |
Component: AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE
Volvo Car USA, LLC (Volvo Car) is recalling certain 2001-2006 S80 and 2001-2009 S60 vehicles. The driver's air bag inflator may explode during deployment, due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will replace the driver's air bag, free of charge. Owner notification letters were mailed November 29, 2021. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo's number for this recall is R10125.
Component: AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE
Volvo Car USA LLC (Volvo Car) is recalling certain 2001-2003 S80 and S60 vehicles sold or ever registered in Alabama, Arkansas, Florida, Georgia, Hawaii, Louisiana, Mississippi, North Carolina, Oklahoma, South Carolina, Tennessee, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands. The driver side frontal air bag inflator may rupture, sending metal fragments into the passage compartment, when the driver side air bag is deployed.
Consequence: Metal fragments can strike vehicle occupants increasing the risk of serious injury or death.
Remedy: Volvo Car will notify owners, and dealers will replace the driver side air bag module, free of charge. The recall began April 20, 2021. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo Car's number for this recall is R10058.
The contact owns a 2002 Volvo S80. The contact received notification of NHTSA Campaign Number: 20V681000 (Air Bags) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The dealer was notified and informed the contact that the part was not yet available. The vehicle was not repaired. The manufacturer was notified of the issue. The contact had not experienced a failure. Parts distribution disconnect.
The contact owns a 2002 Volvo S80. The contact stated while driving at various speeds, the odometer would go black. The contact stated that the electrical system of the vehicle would fail causing all of the functions to start flashing, the brakes to stutter, and the transmission to fail. The contact stated no warning lights would be illuminated as the control panel would go black. The vehicle was not taken to a local dealer or independent mechanic to have it diagnosed. The vehicle was not repaired. The manufacturer had been informed of the failure and informed the contact that they could not assist. The failure mileage was approximately 220,000.
The contact owns a 2002 Volvo S80. The contact stated that the instrument panel malfunctioned and failed to illuminate while driving. The contact also stated that the vehicle failed to accelerate above 20 MPH while the accelerator pedal was depressed. There was no warning light illuminated. The vehicle was taken to the dealer to be diagnosed. The contact was informed of an electrical failure that affected the brakes and the transmission. The vehicle was not repaired. The manufacturer was made aware of the failure but provided no assistance. The contact also mentioned that she had received NHTSA Campaign Number: 20V681000 (Air Bags) however, the part was not yet available. The approximate failure mileage was 100,000.
The 2002 Volvo S80 has 5 NHTSA recalls and 45 consumer complaints on file. It received an overall safety rating of Not Rated out of 5 stars in NHTSA crash testing. For the most detailed information about a specific vehicle, decode its VIN using our free decoder above.
Enter a specific VIN to get the full report — specs, recalls, safety ratings, complaints, investigations, and technical service bulletins.
Component: EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)
VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
Consequence: AN OVERHEATED BATTERY COULD LEAD TO A FIRE.
Remedy: VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 18, 2010. OWNERS MAY CONTACT GARMIN AT 866-957-1981 OR VISIT GARMIN'S WEBSITE AT WWW.GARMIN.COM/NUVIBATTERYPCBRECALL.
Component: FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
VOLVO IS RECALLING CERTAIN MODEL YEAR 2001-2005 S80, MODEL YEAR 2001-2004 V70, S60, XC70 AND MODEL YEAR 2003-2005 XC90 VEHICLES SOLD IN OR REGISTERED IN THE STATES OF ALABAMA, ARIZONA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, KENTUCKY, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, NORTH CAROLINA, OKLAHOMA, SOUTH CAROLINA, TENNESSEE, TEXAS, UTAH, VIRGINIA AND THE U.S. TERRITORIES. WHEN EXPOSED TO CERTAIN ENVIRONMENTAL CONDITIONS (HOT CLIMATE AND TEMPERATURE CYCLING) OVER TIME AND IN COMBINATION WITH VARYING FUEL QUALITY, THE FUEL PUMP CAN DEVELOP CRACKS IN THE FUEL PUMP FLANGE.
Consequence: IF THE CONDITION OCCURS VEHICLE OWNERS MAY NOTICE FUEL SMELL AND/OR FUEL LEAK WHICH, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE FUEL PUMP INSTALLED IN THE VEHICLE, AND IF NECESSARY REPLACE THE FUEL PUMP WITH A PART OF A MODIFIED DESIGN. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 15, 2010. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
Component: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER
CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.
Consequence: LOSS OF BRAKE FLUID CAN RESULT IN POOR BRAKING PERFORMANCE, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy: CARDONE WILL NOTIFY OWNERS AND OFFER TO REPURCHASE ANY DEFECTIVE MASTER CYLINDERS. THE RECALL BEGAN DURING APRIL 2007. OWNERS CAN CONTACT CARDONE AT 1-800-777-4780.
WHEN THE VEHICLE WARMS UP FROM START IT WILL NOT MOVE FORWARD OR REVERSE IT STARTED AT LIKE 30 MILES AND I PARKED THE CAR TILL I COULD GET IT FIXED NOW WHEN THE CAR JUST WARMS UP (NOT GETS HOT) IT WILL NOT ENGAGE TRANS I HAVE ON MORE SENSER TO CHECK BUT THE CAR WILL MOVE WHEN YOU FIRST START IT BOTH FORWARD AND BACK BUT WHEN IT WARMS UP IT STOPS
WE HAVE A 2002 VOLVO S 80 THAT HAD A FUEL PUMP LEAK THAT LOOKS LIKE OUR MODEL HAD AN ISSUE WITH. WE HAD A STRONG GAS SMELL INSIDE THE CAR. THERE'S A CAMPAIGN NUMBER TO IT... 09V483000. WE'RE STILL HAVING AN ISSUE WITH IT.
FUEL PUMP FLANGE IS LEAKING FUEL, CAUSING FUEL SMELL THROUGHOUT CABIN OF VEHICLE. FUEL PUMP FLANGE RECALLED FOR DEFECTS DUE TO TEMPERATURE EXTREMES, THERMOCYCLING AND FUEL QUALITY,
I HAD A GAS LEAK AT 141,000 MILES.. HAVE TO PAY $889.00 BUCKS TO REPAIR OR THE SAID I COULD CATCH FIRE.. PLEASE GIVE ME A CALL [XXX] THANKS.. IT'S HAPPENS WHEN I WAS DRIVING WAS THIS A RECALLED PART? INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
TL* THE CONTACT OWNS A 2002 VOLVO S80. WHILE DRIVING 30 MPH, THE ACCELERATOR PEDAL TRAVELED TO THE FLOORBOARD AND SMOKE APPEARED UNDER THE HOOD. THE VEHICLE WAS TAKEN TO SEVERAL UNKNOWN INDEPENDENT MECHANICS WHO DETERMINED THAT THE FUEL PUMP NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 160,000.
MY VOLVO S80 SPONTANEOUSLY COMBUSTED IN MY DRIVEWAY, WHEN I WAS AWAY FROM HOME. THE CAR HAD NOT BEEN DRIVEN FOR APPROXIMATELY TWO HOURS, WHEN IT CAUGHT FIRE (UNDER THE HOOD) AND BURNED.
TL* THE CONTACT OWNS A 2002 VOLVO S80. THE CONTACT STATED THAT THE VEHICLE STALLED AND FAILED TO START WHEN THE KEY WAS TURNED IN THE IGNITION. THE CONTACT ALSO STATED THE VEHICLE HESITATED TO START EVEN WITH A FULL TANK OF FUEL. THE CONTACT NOTICED A FUEL LEAK AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 09V483000 (FUEL SYSTEM, GASOLINE), BUT THE VIN WAS NOT INCLUDED. THE FAILURE MILEAGE WAS 248,000.
TL* THE CONTACT OWNS A 2002 VOLVO S80. THE CONTACT STATED THAT THERE WAS A FUEL SMELL IN THE REAR OF THE VEHICLE BEHIND THE REAR SEATS. THE CONTACT STATED THAT THE FUEL COULD BE HEARD SPLASHING AROUND IN THE TANK WHEN THE VEHICLE WAS IN USE. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE FLANGE WAS CRACKED AND NEEDED TO BE REPAIRED. THE FAILURE CAUSED FUEL TO LEAK. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 09V483000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 112,000.
TL* THE CONTACT OWNS A 2002 VOLVO S80. THE CONTACT STATED THAT THERE WAS A STRONG FUEL ODOR INSIDE AND OUTSIDE OF THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 09V483000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 170,000.
TL* THE CONTACT OWNS A 2002 VOLVO S80. THE CONTACT STATED THAT THERE WERE STRONG FUEL FUMES EMITTING INTO THE INTERIOR OF THE VEHICLE AND THAT THE FAILURE WAS PROGRESSIVELY GETTING WORSE. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 09V483000 (FUEL SYSTEM, GASOLINE). THE VIN WAS NOT AVAILABLE. THE VEHICLE WAS TO BE TAKEN TO AN AUTHORIZED DEALER FOR INSPECTION AND DIAGNOSIS TO DETERMINE THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 120,000. UPDATED 7/1/15*CN
TL*THE CONTACT OWNS A 2002 VOLVO S80. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 5 MPH, THERE WAS A SUDDEN INCREASE IN ENGINES RPMS WITHOUT WARNING. THE CONTACT POWERED THE VEHICLE OFF AND BACK ON BUT THE FAILURE RECURRED. AFTER SEVERAL ATTEMPTS, THE VEHICLE WAS ABLE TO BE DRIVEN WITHOUT INCIDENT. THE VEHICLE WAS NOT TAKEN TO THE DEALER OR DIAGNOSED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 147,000.
WHILE DRIVING AT SPEED TACHOMETER DROPPED TO 900 RPM FROM ABOUT 3500 WITH AN 18 WHEELER NOT MORE THAN 6 CAR LENGTHS BEHIND ME, NEEDLESS TO SAY IF IT WEREN'T FOR DIVING ONTO THE SHOULDER AS IS DECELERATED RAPIDLY TO 20 MPH IN A MATTER OF SECONDS I WOULD HAVE BEEN REAR-ENDED WITH MY FAMILY IN THE CAR. THIS IS A KNOWN ISSUE. VOLVO HAS EXTENDED THE WARRANTY ON SOME OF THE ETMS TO 10 YEARS/200,000 MILES. WHEN I CALLED VOLVO TO ASK IF THIS MODEL WAS PART OF THAT EXTENDED WARRANTY THEY TOLD ME THAT IT ONLY COVERED '99-01' AND THAT THEY WOULD NOT REPAIR IT AS " THINGS BREAK WHEN THEY GET OLD", AND THAT I SHOULD DRIVE IT TO THE SHOP FOR DIAGNOSIS, AT MY OWN PERIL. THEY ALSO INFORMED ME IT WOULD TAKE A CLASS ACTION LAWSUIT TO CHANGE THIS. WHY SHOULD IT TAKE A LAWSUIT OR DEATH OF A WHOLE CAR FULL OF PEOPLE TO GET SOMEONE TO TAKE ACCOUNTABILITY FOR USE OF SUBSTANDARD PARTS? I DROVE THE CAR HOME IN "LIMP MODE " AND PARKED IT. TODAY I WENT OUT TO SEE IF IT WOULD RUN AND DRIVE, TO MY AMAZEMENT IT DID, SO I TOOK IT FOR A LITTLE TEST <5 MILES, AND IT DID THE SAME THING AGAIN, THIS TIME I WAS PREPARED. I CHECKED THE CODES AND IT HAD NONE IN THE SYSTEM. CALL ME FOR A FIRST HAND ACCOUNT. [XXX] PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Showing 15 of 45 complaints