NHTSA recalls, safety ratings, and consumer complaints for the 2009 Volkswagen Routan.
| Overall Rating | Not Rated |
| Frontal Crash | Not Rated |
| Side Crash | Not Rated |
| Rollover | Not Rated |
Component: ELECTRICAL SYSTEM:IGNITION:SWITCH
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009 Routan vehicles manufactured June 25, 2008, to July 8, 2009, and 2010 Routan vehicles manufactured October 1, 2009, to August 11, 2010. This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including, but not limited to, air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Volkswagen will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on June 23, 2015. Owners may contact Volkswagen customer service at 1-800-822-8987. Volkswagen's number for this recall is 28H1. Note: This recall supersedes recalls 11V151 and 14V396. Vehicles that previously received an ignition switch trim ring as a recall remedy must have their vehicles remedied again under this campaign. Vehicles that have already received a new ignition switch are not covered by this campaign.
Component: SUSPENSION:REAR:AXLE:NON-POWERED AXLE ASSEMBLY
Freedom Motors Inc., (Freedom Motors) of Savaria Vehicle Group (formerly The Liberty Motor Company) is recalling one model year 2009 Volkswagen Routan and certain model year 2008-2010 Dodge Grand Caravan and Chrysler Town & Country wheelchair accessible vehicles modified by The Liberty Motor Company from February 2008 through January 2011. Over time and with use, the vehicle's rear axle may develop cracks which could lead to axle failure.
The contact owned a 2009 Volkswagen Routan. The contact stated that while driving at 65 MPH, the contact suffered a medical emergency and lost control of the vehicle. The contact's vehicle crashed into the rear of a semi-truck. In addition, the contact's vehicle crashed into a ditch. The contact stated that the air bags did not deploy. The paramedics and the Police arrived on the scene. A Police report was filed, however thePolice report information was unavailable. The contact sustained eight broken ribs on the left side and two broken ribs on the right side, injury to the left eye which needed stitches, major trauma to the left lung and bruises and cuts. The contact was taken to the local hospital by ambulance. The vehicle was condemned a total loss. The vehicle was towed to the contact's residence. The manufacturer was not made aware of the failure. The failure mileage was approximately 150,000.
Volkswagen dealership does not want to fulfill the recall.
The contact owns a 2009 Volkswagen Routan. The contact received notification of the NHTSA Campaign Number: 15V194000 (Electrical System) however, the parts to do the recall repair were not yet available. The contact stated while attempting to start the vehicle, the engine failed to turn over. No warning lights were illuminated. The vehicle was towed to the dealer where it was diagnosed that the ignition switch failed and needed to be replaced; however, the dealer confirmed that parts were not available for the recall repair. The vehicle had not yet been repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the failure and the contact was advised to take the vehicle to the dealer for assistance. The failure mileage was approximately 170,000. Parts distribution disconnect.
The 2009 Volkswagen Routan has 6 NHTSA recalls and 293 consumer complaints on file. It received an overall safety rating of Not Rated out of 5 stars in NHTSA crash testing. The high number of complaints suggests potential reliability concerns — review the complaint details above before purchasing. For the most detailed information about a specific vehicle, decode its VIN using our free decoder above.
Enter a specific VIN to get the full report — specs, recalls, safety ratings, complaints, investigations, and technical service bulletins.
Consequence: Failure of the rear axle may increase the risk of a crash.
Remedy: Freedom Motors will notify owners, and dealers will replace the affected axles, free of charge. The recall began on April 1, 2014. Owners can contact Freedom Motors at 1-800-561-9600. Freedom Motors' number for this recall is ENGF0216-3.
Component: AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE-INACTIVE
Volkswagen Group of America, Inc. (VW) is recalling certain model year 2009 Volkswagen Routan vehicles manufactured February 7, 2008, to August 28, 2008. In the affected vehicles, the air bag control units may corrode and fail.
Consequence: If the air bag control unit fails, the air bags may not deploy in the event of a crash, increasing the risk of occupant injury. Additionally, the air bags may inadvertently deploy, increasing the risk of a crash.
Remedy: VW will notify owners, and dealers will replace the air bag control unit, free of charge. The recall began April 2016. Owners may contact Volkswagen customer service at 1-800-893-5298.
Component: ELECTRICAL SYSTEM:IGNITION
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009 Routan vehicles. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Volkswagen will notify owners, and dealers will modify the ignition switch, free of charge. Owners may contact Volkswagen customer service at 1- 800-822-8987. An interim notice was mailed to owners on August 29, 2014. Volkswagen's number for this recall is 28G1/U8. Note: This campaign is an expansion of NHTSA Recall No. 11V-151.
Component: EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
VOLKSWAGEN IS RECALLING 18,500 MY 2009 ROUTAN VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." THE OWNER'S MANUAL WAS PRINTED WITHOUT THE FMVSS NO. 208 REQUIRED INFORMATION EXPLAINING THAT NO OBJECTS SHOULD BE PLACED OVER THE OR NEAR THE AIR BAG ON THE INSTRUMENT PANEL.
Consequence: ANY SUCH OBJECTS COULD CAUSE INJURY TO THE VEHICLE'S OCCUPANTS IN THE EVENT OF A CRASH SEVERE ENOUGH TO CAUSE THE AIR BAG TO INFLATE.
Remedy: DEALERS WILL SEND AN OWNER'S MANUAL INSERT CONTAINING THE REQUIRED AIR BAG INFORMATION FOR OWNER INSTALLATION OR DEALERS WILL INSTALL IN THE EVENT THE OWNER PREFERS ASSISTANCE FROM THE DEALER. THE RECALL BEGAN ON JULY 31, 2009. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.
Component: ELECTRICAL SYSTEM:WIRING
VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2009 ROUTAN VEHICLES MANUFACTURED FROM JUNE 2008 THROUGH JULY 2009. THESE VEHICLES MAY HAVE BEEN BUILT WITH AN IMPROPER ROUTED WIRE HARNESS THAT MAY HAVE A CONDITION WHERE THE LOWER SLIDING DOOR HINGE BRACKET CAN MAKE CONTACT AND WEAR THROUGH THE WIRE INSULATION. CONTACT WITH A 12V POWER FEED CIRCUIT WITHIN THE HARNESS MAY CAUSE A HIGH RESISTIVE SHORT CIRCUIT WITHIN THE LATCH MECHANISM LOCATED INSIDE OF THE SLIDING DOOR.
Consequence: THIS COULD RESULT IN AN OVERHEATED LATCH AND A FIRE WITHIN THE REAR SLIDING DOOR COULD OCCUR.
Remedy: VOLKSWAGEN WILL INSPECT THE SLIDING DOOR WIRE TRACK WIRE ASSEMBLY AND THE SLIDING DOOR POWER DRIVE UNIT WIRE ASSEMBLY FOR DAMAGE, REPAIR/REPLACE AS NECESSARY, TIE STRAP THE TWO HARNESSES TOGETHER AND ROUTE THE HARNESSES UNDER THE SLIDING DOOR WEATHER STRIP. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 15, 2010. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.
While driving the vehicle flashed several of the dashboard waring lights, starting dinging and then stopped, started flashing and dinging again then the vehicle completely turned off. I was able to pull over out of traffic but the vehicle would not restart. None of the interior lights would come one and the emergency lights would not come on. I could not unlock any of the doors. The battery has been replaced with in the last year and is working correctly.
the car shuts off while driving which is scary. requires restarting while in traffic. there was a recall in past and the fix clearly did not work. This incident has occurred multiple times.
The contact owns a 2009 Volkswagen Routan. The contact received notification of NHTSA Campaign Number: 15V194000 (Electrical System) however, the part to do the recall repair was not yet available. The dealer was made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. Parts distribution disconnect
After getting wires regrounded at the mechanic, the car continues to malfunction. The wiper blades turn on, the entire dash blinks, the seat moves back and forth, resetting repeatedly. If seat is disconnected for safety, the seatbelt does not register as secured. Eventually doors stop functioning, have completely lost lock function, tried replacing battery and sending to mechanic specialist. Still the car malfunctions at random.
My vehicle shows no pending recalls, but ignition switch still malfunctioning whenever it is bumped or a lanyard is on the key. Brakes malfunction, car seat moves, windshield wipers move, car seems to think it is resetting as original recall states is a problem.
The contact owns a 2009 Volkswagen Routan. The contact stated while at a stoplight, the vehicle stalled. There was an abnormally high pitch noise detected. There were no warning lights illuminated. The vehicle was jump-started by the police and was restarted. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The vehicle was taken to an independent mechanic and the contact was informed that the starter needed to be replaced. The failure mileage was approximately 54,000.
The brackets that hold the automatic door wires brake continuously. Then the wire gets pinched in the door and it causes a large amount of electrical problems. The abs, esp bad, brake, and traction control lights come on when the wire gets pinched. These doors were made very poorly and should have been looked over before this vehicle was made.
THANK GOD I WAS NOT GOING FAST. VEHICLE SHUT DOWN COMPLETELY WHILE DRIVING. WAS ABLE TO PUT IN PARK AND WAS ABLE TO START IT BACK UP. APPARENTLY, THE ROUTAN IS MANUFACTURED BY CRYSLER AND THIS ISSUE ALSO HAPPENS WITH THE 09 TOWN AND COUNTRIES AS WELL.
TL* THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 25 MPH, THE ESC WARNING LIGHT SUDDENLY DISPLAYED, AND THE BRAKING SYSTEM ERRONEOUSLY ACTIVATED CAUSING THE VEHICLE TO ABRUPTLY STOP. THE CONTACT STATED THAT AFTER TURNING OFF AND RESTARTING THE VEHICLE, THE VEHICLE OPERATED NORMALLY. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE LOCAL DEALER AND MANUFACTURER WERE NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 140,000.
TL* THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. THE CONTACT STATED THE AIR BAGS WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND THE CONTACT WAS INFORMED THAT THE ORC MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED AS OF YET. A DEALER WAS CONTACTED. UPON INVESTIGATION, THE CONTACT ASSOCIATED THE FAILURE WITH NHTSA CAMPAIGN NUMBER: 16V083000 (AIR BAGS) HOWEVER, THE VIN WAS NOT INCLUDED. THE MANUFACTURER HAD BEEN INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 115,000.*DT*JB
VAN HAS STALLED WHILE DRIVING ON MULTIPLE OCCASIONS. POWER STEERING IS LOST. VEHICLE WILL THEN START RIGHT BACK UP. THIS IS EXTREMELY DANGEROUS FOR A MINIVAN USED TO TRANSPORT MULTIPLE CHILDREN. NO CODES OR FAULTS ARE RECORDED.
FIVE TIMES IN THE PAST 6 MONTHS THE POWER IN THE VAN BASICALLY TURNS OFF. THE STEERING BECOMES NEXT TO IMPOSSIBLE AND THE BRAKES BECOME EXTREMELY TIGHT TO THE POINT YOU CAN'T EVEN USE THEM. IT IS TERRIFYING TO HAVE ZERO CONTROL OVER YOUR CAR CONSIDERING I HAVE 4 CHILDREN. IT HAS HAPPENED WHILE I WAS GOING ONLY 30MPH AND ALSO WHEN I WAS GOING 45 MPH. IT HAPPENS WHEN I'M GOING STRAIGHT AND HAS ALSO HAPPENED WHILE TURNING. SINCE THE LATEST ISSUE I REFUSE TO DRIVE ANYWHERE THAT I CAN'T TAKE BACK ROADS TO.
Showing 15 of 293 complaints