Loading vehicle data from NHTSA...
NHTSA recalls, safety ratings, and consumer complaints for the 1996 Volkswagen Passat.
| Trim | City | Hwy | Combined | Annual fuel $ |
|---|---|---|---|---|
| 2.0L 4 cyl Automatic 4-spd | 18 | 25 | 20 | $3,000 |
| 2.8L 6 cyl Automatic 4-spd | 16 | 23 | 18 | $3,300 |
| 1.9L 4 cyl Manual 5-spd | 31 | 41 | 35 | $2,300 |
| 2.0L 4 cyl Manual 5-spd | 18 | 26 | 21 | $2,850 |
| 2.8L 6 cyl Manual 5-spd | 17 | 24 | 19 | $3,150 |
| Overall Rating | Not Rated |
| Frontal Crash | Not Rated |
| Side Crash | Not Rated |
| Rollover | Not Rated |
Component: ELECTRICAL SYSTEM:IGNITION:SWITCH
ON CERTAIN PASSENGER VEHICLES, THE ELECTRICAL PORTION OF THE IGNITION SWITCH ASSEMBLY CAN FAIL CAUSING THE HEADLIGHTS AND WINDSHIELD WIPERS TO BECOME INOPERATIVE.
Consequence: IF SUCH FAILURES OCCUR WHILE THE VEHICLE IS IN USE AT NIGHT OR IN RAINY OR SNOWY WEATHER, A CRASH COULD OCCUR.
Remedy: DEALERS WILL REPLACE THE ELECTRICAL PART OF THE IGNITION SWITCH ASSEMBLY. OWNER NOTIFICATION BEGAN NOVEMBER 20, 2002. OWNERS SHOULD CONTACT VWOA AT 1-800-822-8987.
TL*THE CONTACT OWNS A 1996 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT THE REAR PASSENGER SIDE DOOR HANDLES FAILED TO OPEN FROM THE OUTSIDE. THE CONTACT ALSO STATED THAT THE FRONT DRIVER SIDE AND THE FRONT PASSENGER SIDE DOOR HANDLES FAILED TO OPEN FROM THE OUTSIDE. THE CONTACT HAD TO USE THE KEY FROM THE OUTSIDE OF THE DOOR TO WIND THE WINDOW DOWN TO OPEN THE DOORS. THE VIN WAS NOT AVAILABLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.
I WAS DRIVING ON THE HIGHWAY IN MY 1996 VW PASSAT AT 65 MPH AND THE ENTIRE INSIDE OF MY CAR WAS ENGULFED WITH WATER AND ANTI FREEZE STEAM AND VAPOR. IT WAS QUICKLY AND WITH OUT WARNING IMPOSSIBLE TO SEE THROUGH THE WINDSHIELD. THE PROBABLE CAUSE OF THE PROBLEM IS A DEFECTIVE HEATER CORE. THIS IS A VERY SERIOUS SAFETY ISSUE AND COULD HAVE LEAD TO A MAJOR ACCIDENT RESULTING IN INJURY OR DEATH. *TR
HEATER CORE FAILED WHILE DRIVING, BLOWING HOT STEAM OUT OF THE VENTS, DUMPING HOT COOLANT ONTO MY FEET AND FOGGING UP THE WINDSHIELD INSTANTLY. *TR
The 1996 Volkswagen Passat has 1 NHTSA recall and 159 consumer complaints on file. It received an overall safety rating of Not Rated out of 5 stars in NHTSA crash testing. The high number of complaints suggests potential reliability concerns — review the complaint details above before purchasing. For the most detailed information about a specific vehicle, decode its VIN using our free decoder above.
Enter a specific VIN to get the full report — specs, recalls, safety ratings, complaints, investigations, and technical service bulletins.
TL*THE CONTACT OWNS A 1996 VOLKSWAGEN PASSAT. UPON PURCHASING THE VEHICLE, THE CHECK ENGINE LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE SELLER STATED THAT IT WAS A MINOR ISSUE. THE CHECK ENGINE LIGHT WAS RESET AND ILLUMINATED AGAIN TWO DAYS LATER. IN ADDITION, THE VEHICLE WOULD CONSTANTLY OVERHEAT. THERE WERE NO SIGNS OF THE VEHICLE OVERHEATING WHILE DRIVING; HOWEVER, RADIATOR FLUID WOULD SPILL OUT OF THE VEHICLE WHEN IT WAS PARKED. THE RADIATOR, TIMER, WATER PUMP, AND SENSORS WERE REPLACED ON THE VEHICLE, BUT NONE OF THE REPAIRS REMEDIED THE FAILURE. NHTSA CAMPAIGN ID NUMBER 95V178000 (ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN) FOR THE 1995 PASSAT IS IDENTICAL TO THE FAILURE SHE IS EXPERIENCING. THE FAILURE MILEAGE WAS 117,000 AND CURRENT MILEAGE WAS 136,000. UPDATED 09/10/08. *LJ UPDATED 09/16/08. *JB
TL*THE CONTACT OWNS A 1996 VOLKSWAGEN PASSAT. THE CONTACT STARTED THE IGNITION AND THE ANTILOCK BRAKE SYSTEM WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. WHILE THE LIGHT WAS ILLUMINATED, THE AIR CONDITIONER UNIT, WINDSHIELD WIPERS, AND HEADLIGHTS WERE INOPERATIVE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND THEY STATED THAT THE FAILURE WAS RELATED TO THE ELECTRICAL COMPONENT IN THE IGNITION SWITCH. THE VEHICLE HAS NOT BEEN REPAIRED. THE CONTACT WAS DISPLEASED TO KNOW THAT HIS VIN WAS NOT INCLUDED IN THE RECALL, ESPECIALLY SINCE THE FAILURES WERE IDENTICAL. THE RECALL NUMBER WAS UNKNOWN. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 120,000.
TL*THE CONTACT OWNS A 1996 VOLKSWAGEN PASSAT. WHILE DRIVING 40 MPH AT NIGHT, THE EXTERIOR HEADLAMPS FAILED. THE DEALER STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 02V256000 (ELECTRICAL SYSTEM:IGNITION:SWITCH), ALTHOUGH THE FAILURES WERE IDENTICAL. THE CONTACT WOULD BE RESPONSIBLE FOR THE REPAIRS AT THE COST OF $250. HE IS CURRENTLY IN THE PROCESS OF HAVING THE VEHICLE REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 140,000.
HEATERCORE FAILED FOGED UP ALL MY WINDOWS,SOAKED CARPET AND FILLED CABIN WITH TOXIC ANTIFREEZE VAPOR ON MY WAY HOME FROM MY UNCLES FUNERAL. *CN
THE IGNITION SWITCH ON MY 1996 VW PASSAT WENT OUT WHILE DRIVING AT NIGHT, WHICH SHUT DOWN THE HEADLIGHTS. THIS IS EXACTLY THE SAME AS DESCRIBED IN NHTSA CAMPAIGN ID NUMBER : 02V256000 I WAS INFORMED BY VW CUSTOMER SERVICE THIS RECALL DIDN'T APPLY TO MY VIN#, DESPITE IT BEING A 1996 PASSAT. I THINK IT SHOULD. *TR
HEATER CORE FAILURE. VENTING OF NOXIOUS FUMES INTO PASSANGER COMPARTMENT. *NM
DT*: THE CONTACT STATED THE VEHICLE WOULD NOT START SOMETIMES AND THE WINDSHIELD WIPERS WORKED INTERMITTENTLY. THE VEHICLE FINALLY STARTED AFTER SEVERAL ATTEMPTS. THERE WAS A NHTSA RECALL, # 02V256000, REGARDING THE ELECTRICAL SYSTEM: IGNITION: SWITCH. THE MANUFACTURER INFORMED THE CONTACT THAT PREVIOUS RECALL REPAIR INFORMATION WAS AVAILABLE THROUGH THE DEALER. THE DEALERSHIP WAS NOT CONTACTED.
I HAVE HAD ONGOING ISSUES WITH ELECTRONIC AND EMISSIONS SENSORS FOR THIS VEHICLE AND RECENTLY SPENT $756.54 TO (AGAIN!) REPLACE SENSORS SO THAT THE VEHICLE WOULD PASS ITS ANNUAL EMISSIONS TEST (AS MANDATED BY THE EPA). I WROTE TO VW CUSTOMER CARE TO SEEK REIMBURSEMENT OF THIS (AND PAST) CHARGES AND WAS TOLD TODAY (7/13/06) THAT NO RECALLS OR SERVICE BULLETINS WERE ISSUED, SO NO REIMBURSEMENT WILL BE MADE. I TOLD THEM THAT NHTSA ISSUED RECALL 99V131 (WHICH ADDRESSES SOME OF THE AREAS) BUT VW TOLD ME THAT IT DID NOT APPLY, AS ALL REIMBURSEMENTS ARE VIN-SPECIFIC. CAN ANYONE PLEASE HELP? THANK YOU. *JB
DT*: THE CONTACT STATED THE HEADLIGHTS AND WINDSHIELD WIPERS BECAME INOPERABLE, THEN THE VEHICLE WOULD NOT START. THE VEHICLE HAS NOT BEEN SEEN BY A MECHANIC. THE RECALL, #02V256000 CONCERNING THE IGNITION SWITCH WAS PERFORMED ON THE VEHICLE IN AUGUST 2002. THE VEHICLE IS HAVING THE SAME PROBLEM AS INDICATED IN THE RECALL. THE MANUFACTURER WAS CONTACTED. *AK
HEATER CORE IS LEAKING, AND MAKES DRIVING IMPOSSIBLE DUE TO DECREASED VISIBILITY, AND THE FUMES COMING OFF THE HEATER CORE CAUSE ME TO COUGH FOR A FEW DAYS IF I ACTUALLY DRIVE MY CAR. *NM
CONSUMER HAD 1996 VW PASSAT IGNITION SWITCH REPLACED. AFTER ABOUT A YEAR SWITCH NEEDED TO BE REPLACED AGAIN. *TS THE FIRST TIME THE SWITCH WAS REPLACED IT WAS FREE OF CHARGE AND NOW THAT IT HAS FAILED AGAIN THE DEALER DOESN'T WANT TO REPLACE THE IGNITION SWITCH UNDER THE RECALL AGAIN BECAUSE THEY STATED THE VEHICLE WAS MORE THAN 8 YEARS OLD. *JB
1996 CLUTCH PEDAL ASSEMBLY FAILED ON THE 1996 VOLKSWAGEN PASSAT.*MR THE CONSUMER BELIEVED THE PART WAS POORLY DESIGNED.*JB
Showing 15 of 159 complaints