2006 Volkswagen Jetta

Component: FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2006-2010 JETTA, NEW BEETLE, NEW BEETLE CONVERTIBLE, MODEL YEAR 2009 JETTA SPORTWAGEN AND MODEL YEAR 2007-2009 RABBIT VEHICLES EQUIPPED WITH 2.5L ENGINES. THE JETTA, JETTA SPORTWAGEN, AND RABBIT VEHICLES MAY HAVE A SMALL PLASTIC TAB LOCATED ON THE WINDSHIELD WASHER FLUID RESERVOIR THAT MAY CHAFE AGAINST AN UNDERHOOD FUEL SUPPLY LINE. THE NEW BEETLE AND THE NEW BEETLE CONVERTIBLE VEHICLES MAY HAVE A FASTENING CLAMP ON A HYDRAULIC HOSE OF THE POWER STEERING SYSTEM THAT MAY BE LOCATED IN AN IMPROPER POSITION WHICH COULD CAUSE CHAFING AGAINST AN UNDERHOOD FUEL SUPPLY LINE.

Consequence: IF CHAFING OCCURS, THERE IS THE POTENTIAL FOR A FUEL LEAK TO DEVELOP. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy: DEALERS WILL INSPECT AND IF NECESSARY REPLACE THE UNDERHOOD FUEL LINE. ADDITIONALLY, DEPENDING ON THE VEHICLE MODEL, DEALERS WILL EITHER REMOVE THE PLASTIC TAB FROM THE WINDSHIELD WASHER FLUID RESERVOIR, OR INSPECT THE POSITION OF THE FASTENING CLAMP AND ADJUST THE RELATED FASTENING CLAMP INTO THE CORRECT POSITION. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE JANUARY 31, 2011. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

Full recall detail →

Component: POWER TRAIN:DRIVELINE:DRIVESHAFT

VOLKSWAGEN IS RECALLING 25,594 MY 2006-2009 JETTA 5TH GENERATION EQUIPPED WITH 2.01 ENGINE. THE FASTENING SCREW CONTACT SURFACES ON THE DRIVESHAFT COVER PLATE MAY NOT HAVE BEEN MANUFACTURED TO FACTORY SPECIFICATIONS. SOME SCREWS MAY NOT HAVE BEEN TORQUED PROPERLY DURING ASSEMBLY AND COULD LOOSEN OVER TIME, CAUSING A KNOCKING SOUND WHEN THE VEHICLE IS IN MOTION. THE DRIVESHAFT SCREWS COULD LOOSEN TO THE POINT WHERE THE DRIVESHAFT DETACHES FROM THE GEARBOX.

Consequence: IF THE VEHICLE IS MOVING WHEN THIS HAPPENS, THE DETACHED DRIVESHAFT COULD CAUSE DAMAGE THE GEARBOX HOUSING. A DAMAGE GEARBOX HOUSING COULD LEAK GEARBOX OIL ONTO THE STREET AND CREATE A RISK OF A VEHICLE CRASH FOR BOTH THE DRIVER AND OTHER MOTORISTS.

Remedy: DEALERS WILL INSPECT THE DRIVESHAFT SCREWS AND REPLACE THE SCREWS FREE OF CHARGE. THE RECALL BEGAN ON JUNE 24, 2009. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

Full recall detail →

Component: EXTERIOR LIGHTING:HEADLIGHTS

CERTAIN VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." SOME VEHICLES MAY NOT HAVE HAD A REQUIRED CAP INSTALLED WHICH DISABLES THE HEADLIGHT HORIZONTAL AIM AND SOME VEHICLES MAY CONTAIN A CAP THAT DISABLES THE VERTICAL AIMING SCREW.

Consequence: NONCOMPLIANCE CAN INHIBIT PROPER HEADLAMP AIM ADJUSTMENT FOR ROADWAY ILLUMINATION, IMPROPERLY AIMED HEADLAMPS COULD CAUSE REDUCED ROAD VISIBILITY, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT FOR THE PRESENCE OF A CAP IN THE SOCKET OF THE LOW BEAM HORIZONTAL AIMING SCREW AND INSTALL ONE IF MISSING, AND INSPECT FOR THE PRESENCE OF A CAP IN THE SOCKET OF THE VERTICAL AIMING SCREW AND IF PRESENT, THE CAP WILL BE REMOVED. THE RECALL WILL BEGIN ON OCTOBER 31, 2007. OWNERS MAY CONTACT VW AT 1-800-822-8987.

Full recall detail →

Component: VISIBILITY:WINDSHIELD WIPER/WASHER

CERTAIN VEHICLES EQUIPPED WITH 2.5L GASOLINE ENGINES MAY HAVE A SMALL PLASTIC TAB LOCATED ON THE WINDSHIELD WASHER FLUID RESERVOIR THAT MAY CHAFE AGAINST THE UNDERHOOD FUEL SUPPLY LINE.

Consequence: IF THIS HAPPENS, THE CHAFING HAS THE POTENTIAL TO CAUSE A FUEL LEAK OVER TIME. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

Remedy: DEALERS WILL REMOVE THE PLASTIC TAB FROM THE WINDSHIELD WASHER FLUID RESERVOIR AND WILL ALSO INSPECT AND, IF NECESSARY, REPLACE THE UNDERHOOD FUEL SUPPLY LINE. THE RECALL BEGAN ON AUGUST 24, 2007. OWNERS MAY CONTACT VW AT 1-800-893-5298.

Full recall detail →

The contact owns a 2006 Volkswagen Jetta. The contact stated while driving at various speeds, the transmission shuddered without warning. The vehicle was taken to an independent mechanic to be diagnosed. The contact was informed that the transmission was faulty and needed to be replaced. The manufacturer was notified of the failure and informed the contact that the VIN was not under recall. The contact was referred to the NHTSA for assistance. The vehicle was not yet repaired. The failure mileage was approximately 156,000.

ANTI-LOCK BRAKE LIGHT ON INDICATING REPAIR IS NEEDED.

THERE IS VACUUM PUMP DEFECT, MECHANICAL ENGINE MOUNTING BRACKETS, BREAKS, HOSES/PUMPS, WINDSHIELD FLUID MOUNTED HOUSES NEAR WINDSHIELD (FLUID SPRAYS THROUGH THESE HOUSES ON TO THE WINDSHIELD) AND KEY IGNITION INTERLOCK. PLEASE CALL AUDI FOR THE FULL DESCRIPTION OF DEFECTIVE PARTS AND REQUIRED MAINTENANCE. WAS DRIVING VEHICLE HEARD A LOUD POP OR BREAKING NOISE AND THE VEHICLE WOULD NOT OPERATE STIFFENING THE STEERING WHEEL. AUTO WAS STOLEN AND CAME BACK WITH LOUD SCREECHING NOISE. UNKNOWN.

THERE ARE SOME MOUNTING BRACKETS, SUSPENSION BRACKETS, NUTS AND BOLTS ASSOCIATED TO THE OPERATION OF THE VEHICLE THAT HAVE BROKE MORE THAN ONCE PLEASE CONTACT ME AND I WILL GIVE U FURTHER DETAIL.[XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).. *TR

THERE HAS BEEN TAMPERING DONE TO MY VEHICLE HOW DO I ASSURE SAFETY AND HAVE IT INVESTIGATED AND HAVE A REPAIR MAN LOOK OVER THE VEHICLE AFTER THE THEFT?

THE DRIVER'S SIDE WINDOW STOPPED WORKING. THE PROBLEM WAS TRACED BACK TO A FAULTY WIRING HARNESS IN THE DOOR HINGE. THIS IS A VERY COMMON VW ISSUE, AND MANY OTHER ONLINE COMPLAINTS REFERENCE A WIRE HARNESS THAT IS TOO SHORT. I REPAIRED THE SEVERED WIRES WITH BUTT CONNECTORS. AFTER THE REPAIR WAS COMPLETED, THE AIRBAG LIGHT CAME ON. I INSPECTED THE WHOLE AIRBAG SYSTEM (CONNECTORS, WIRING, FUSES, ETC.) TO NO AVAIL. THE AIRBAG LIGHT IS STILL ILLUMINATED ON THE DASHBOARD. AGAIN, OTHERS HAVE COMPLAINED OF THIS SAME ISSUE WHEN FIXING A VW'S WINDOW (I.E., FIX THE WINDOW AND THE AIRBAG LIGHT ILLUMINATES). THE TWO ISSUES SHOULD NOT BE CONNECTED, AND THIS IS A MAJOR SAFETY CONCERN FOR ME.

I HAVE A 2006 JETTA THAT I JUST GOT FROM A FRIEND, THEY STATED THAT IT NEEDED SOME SENSORS LIKE THE MAF REPLACED. I SPENT THE 39.99 AND BOUGHT THE CARFAX REPORT AS WELL TO ENSURE IT WAS A GOOD CAR. EVERYTHING WAS GREAT UNTIL I DROVE IT FOR THE FIRST TIME LONGER THAN 20 OR 30 MINUTES. I STARTED TO EXPERIENCE THE TRANSMISSION SLIPPING WHEN IT GOT HOT AND THE GEARS NOT SHIFTING. AS I BEGAN TO LOOK UP THESE SYMPTOMS TO VERIFY WHAT THE ISSUE WAS I RAN INTO SOME VERY CONCERNING STATEMENTS. MULTIPLE SOURCES SAY THE CARS ARE KNOWN FOR HAVING BAD TRANSMISSIONS/ VALVE BODY ISSUES. HUNDREDS OF PEOPLE DRIVING 2006 VW JETTA 2.5 LITER AUTOMATIC CARS WERE HAVING THE SAME ISSUE WITH THE HARD SHIFTING AND SLIPPING AND SOME WERE WORSE THAN THAT. MY CAR ONLY HAS 103,000 MILES ON IT AND MANY OF THESE OTHER VEHICLES WERE BETWEEN 75K AND 140K. HAVING TO HAVE ENTIRE TRANSMISSIONS REPLACED. I HAVE NOT HAD ANY ISSUES WHEN I'M ON THE HIGHWAY AND NOT NEEDING TO SWITCH GEARS BUT STOP AND GO TRAFFIC IS IMPOSSIBLE TO DRIVE IN. IT DISCOURAGES ME THAT SO MANY PEOPLE ARE HAVING THIS ISSUE AND A RECALL HAS NEVER BEEN ISSUED FOR IT. THERE IS NO WARRANTY ANYMORE . MULTIPLE MECHANICS HAVE LOOKED AT THE CAR AND IMMEDIATELY STATED THAT THE 09G VALVE COVER THAT VW USED WAS NOTORIOUS FOR THESE ISSUES AND THEY ARE STILL PRETTY COMMON. HTTPS://WWW.TRANSMISSIONREPAIRCOSTGUIDE.COM/VOLKSWAGEN-JETTA-TRANSMISSION-PROBLEMS/ HTTPS://M.CARCOMPLAINTS.COM/VOLKSWAGEN/JETTA/2006/TRANSMISSION/TRANSMISSION_FAILURE.SHTML HTTPS://YOUTU.BE/IMPMDINGZOG HTTPS://YOUTU.BE/GLITVICEKFC HTTPS://YOUTU.BE/QEGQ0D2NMOM HTTPS://YOUTU.BE/5KVGSJAXATO HTTPS://YOUTU.BE/SCJ0FMNCNNM HTTPS://WWW.JETTAFORUMS.COM/FORUM/VOLKSWAGEN-JETTA-GENERAL-DISCUSSION/571-2006-JETTA-AUTOMATIC-TRANSMISSION-PROBLEMS.HTML#/TOPICS/571 HTTPS://WWW.CARPROBLEMZOO.COM/VOLKSWAGEN/JETTA/TRANSMISSION-GEAR-SLIPPING-PROBLEMS.PHP. *TR

AIRBAG/SEATBELT LIGHT CAME ON RANDOMLY WHILE CAR WAS OCCUPIED AND IN PARK. NO ACCIDENTS.

TRANSMISSION GOES INTO LIMP MODE ONCE VEHICLE REACHES NORMAL OPERATING TEMPERATURE. CODES ARE P1689 AND P0746. WHEN THIS HAPPENS THE CAR WILL ONLY FUNCTION IN 2ND GEAR AND NOTHING ELSE. THIS IS VERY DANGEROUS ON INTERSTATES WHERE THE MINIMUM SPEED LIMIT CAN NOT BE REACHED. RESEARCHING ONLINE, THIS IS A KNOWN PROBLEM AND THE MECHATRONIC NEEDS TO BE REPLACED.

CAR WILL NOT TURN OFF - KEY GETS STUCK IN IGNITION WHEN TURNING OFF THE ENGINE. HAVE TO PUSH THE STEERING WHEEL IN FORCEFULLY TO BE ABLE TO TURN KEY AND ENGINE OFF.

TL* THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THE VEHICLE'S BATTERY WAS REPLACED THREE TIMES WITHIN A YEAR. THE NEW BATTERY WAS REPLACED WITHIN A MONTH. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DETERMINED THAT THE RADIO CAUSED THE BATTERY TO FAIL. THE VEHICLE WAS NOT REPAIRED. THE CONTACT CALLED YORK VOLKSWAGEN (3475 E MARKET ST, YORK, PA 17402, (717) 755-1015) AND WAS INFORMED THAT THERE WAS NO GUARANTEE THAT THEY COULD REPAIR THE VEHICLE. IN ADDITION, THE CONTACT STATED THAT HE COULD NOT DRIVE THE VEHICLE BECAUSE THE KEY FAILED TO INSERT INTO THE IGNITION SWITCH. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR THE IGNITION FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS APPROXIMATELY 54,000. THE VIN WAS NOT AVAILABLE.

THE AIRBAG DRIVER IS NO WOKS..THE AIR BAG IS ON CHECK ALL TIME.