Loading vehicle data from NHTSA...
NHTSA recalls, safety ratings, and consumer complaints for the 2002 Toyota Tundra.
| Overall Rating | Not Rated |
| Frontal Crash | Not Rated |
| Side Crash | Not Rated |
| Rollover | Not Rated |
| Overall Rating | Not Rated |
| Frontal Crash | Not Rated |
| Side Crash | Not Rated |
| Rollover | Not Rated |
Component: EXTERIOR LIGHTING:HEADLIGHTS
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Remedy: DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Component: STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS
TOYOTA IS RECALLING MODEL YEAR 2000-2003 TUNDRA VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGINIA, WISCONSIN AND THE DISTRICT OF COLUMBIA. EXCESSIVE CORROSION OF THE REAR CROSS MEMBER MAY CAUSE THE SEPARATION OF THE SPARE TIRE STOWED UNDER THE TRUCK BED WHICH WOULD PRESENT A ROAD HAZARD THAT COULD CAUSE A CRASH. ALSO, CORROSION OF THE REAR CROSS MEMBER COULD AFFECT THE REAR BRAKE LINES AND THE PROPORTIONING VALVE RESULTING IN DIMINISHED BRAKING CAPABILITY.
Consequence: SEPARATION OF THE SPARE TIRE AND DIMINISHED BRAKE CAPACITY COULD INCREASE THE RISK OF A CRASH.
Remedy: TOYOTA IS ASKING OWNERS OF THE AFFECTED VEHICLES TO REMOVE THE SPARE TIRE FROM UNDER THE VEHICLE UNTIL A REMEDY CAN BE OBTAINED. DEALERS WILL INSPECT THE REAR CROSS MEMBER AND RELATED COMPONENTS, INCLUDING THE BRAKE LINES, AND REPLACE THEM IF NECESSARY. IF THE CROSS MEMBER DOES NOT NEED TO BE REPLACED, IT WILL BE SPRAYED WITH A CORROSION PROTECTION COMPOUND. THESE SERVICES WILL BE PERFORMED FREE OF CHARGE, HOWEVER MULTIPLE VISITS TO THE DEALER MAY BE REQUIRED. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT APRIL 30, 2010. OWNER MAY CONTACT TOYOTA AT 1-800-331-4331.
Frame and crossmember is rusting. Has one hole on each side of the frame where the cross member is attached inside the frame.
Frame failed inspection for holes in frame. Had part of frame welded and got inspected.11/01/2022. Had been turned down by Toyota dealer previously. Now with less than 10,000 miles added, has another location where frame has rusted thru , making inspection passing impossible. And driving dangerous. Needs a new frame nd Toyota said no, according to the dealer. New Country Toyota, Saratoga NY. Can I sue Toyota? Is there statute of limitations on frame defects? What are my options. Thank you for your time and consideration. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Toyota won’t cover the safety recalls on my truck
Excessive frame corrosion and corrosion holes involving even rear subframe
Frame needs replacement
The 2002 Toyota Tundra has 6 NHTSA recalls and 510 consumer complaints on file. It received an overall safety rating of Not Rated out of 5 stars in NHTSA crash testing. The high number of complaints suggests potential reliability concerns — review the complaint details above before purchasing. For the most detailed information about a specific vehicle, decode its VIN using our free decoder above.
Enter a specific VIN to get the full report — specs, recalls, safety ratings, complaints, investigations, and technical service bulletins.
Component: EXTERIOR LIGHTING
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence: LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
Remedy: AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Component: EXTERIOR LIGHTING
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Remedy: PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Component: SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT
ON CERTAIN SPORT UTILITY VEHICLES, DUE TO A MANUFACTURING ISSUE IN THE FRONT SUSPENSION LOWER BALL JOINT, THERE IS A POSSIBILITY THAT THE SURFACE OF THE BALL OF THE JOINT MAY HAVE BEEN SCRATCHED. THE BALL JOINT MAY EVENTUALLY EXPERIENCE EXCESSIVE WEAR AND LOOSENESS, RESULTING IN INCREASED STEERING EFFORT.
Consequence: THE LOWER BALL JOINT MAY SEPARATE FROM THE KNUCKLE CAUSING LOSS OF STEERING CONTROL AND A CRASH COULD OCCUR.
Remedy: DEALERS WILL REPLACE THE FRONT SUSPENSION LOWER BALL JOINTS FREE OF CHARGE. THE RECALL BEGAN ON JULY 5, 2005. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Component: WHEELS
ON CERTAIN 4X2 VEHICLES EQUIPPED WITH AN ALLOY WHEEL TIRE UPGRADE (OPTIONS WM4, WM8, ZL1-ZL4, DH4, OR DH5) INSTALLED BY THE PROCESSING CENTERS IN JACKSONVILLE, FLORIDA OR COMMERCE, GEORGIA, A LABEL IDENTIFYING THE SPARE TIRE AS A TEMPORARY USE SPARE TIRE WAS NOT INSTALLED. THE UPGRADE INCLUDES 4 LARGER SIZE TIRES WITH ALLOY WHEELS. THE ORIGINAL SPARE TIRE/STEEL WHEEL IS NOT PART OF THE UPGRADE AND WAS NOT CHANGED.
Consequence: DIFFERENT OPERATING CHARACTERISTICS CAN BE EXPERIENCED WHEN THE SPARE TIRE IS INSTALLED ON THE VEHICLE.
Remedy: OWNERS WILL BE PROVIDED WITH A CAUTION LABEL AND AN INSERT FOR THEIR OWNER'S MANUAL. OWNER NOTIFICATION BEGAN JULY 15, 2002. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
The date it started happening was probably late March now into April to present day as the receptacle on the driver side doesn’t click always and comes undone while on the road and can not get the seatbelt to go back in and has not been assessed or replaced by my local Toyota Dealer and the issue is getting worse these are Stock parts
The headlights and high beams are dim . When the high beams are on other cars oncoming are not affected as they never flash their lights because my high beams seem as though they are just headlights. Also the fact that the high beams shine like headlights, there is no option for brighter lighting which makes it hard to see far ahead. I live in a rural location off of a narrow highway with down slopes with water at the bottom on both sides of the highway where large wildlife such as deer are plentiful . Insufficient high beam lighting imposes unsafe travel conditions since the headlights are dim and the high beams are how the headlights should be leaving no option for brighter visibility. I noticed the lighting being dim years ago but I thought it was just something to do with my trucks lighting until I began searching online again for a remedy and found many other owners of the same year make and model with exactly the same issue. Therefore in conclusion perhaps is a manufacturer defect. My truck is the most reliable vehicle I have ever owned, it still runs great, I keep it well maintained and I intend to keep using it for as long as we both shall live. I am [XXX] and obviously my truck is over 20 years old and runs great, it would be terribly upsetting if an accident were to occur due to insufficient exterior lighting. I cannot remember exactly what it was I had previously contacted NHTSA regarding my truck , though the exterior lighting is of greater concern now. I noticed the dimness of the exterior lighting since I have been living in this location a lot because there are no street lights along the freeway nor highway as opposed to where I lived prior. Thank you very much for giving me the opportunity to express my concerns as I appreciate your time and consideration in this matter. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Was told about the recall awhile ago and they said that my frame was ok. But now I have a perfectly good truck in good condition other than a rusted frame. Had some work done and mechanic said it is unsafe to drive due to rusted frame. They know of the defect and only replace a few and it looks like others are dealing with what I am.
The contact owns a 2002 Toyota Tundra. The contact, who is an independent mechanic, stated that the fuel tank had detached. The contact stated that the subframe was extremely rusted. There were no warning lights illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 09V444000 (Structure). The contact called the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 190,000.
My original owner 2002 Toyota Tundra Truck was being backed up in reverse with a utility trailer attached up a very, very moderate incline on a driveway pushing the trailer onto a gravel pad ALONGSIDE (parallel) the driveway. As it started to spin gravel the truck was put into a 4 wheel Drive LOW RANGE. This is in keeping with the TOYOTA owners manual publication 0M34417U Part Number 01999-34417 Print date 02-0109-01. We followed the manual instruction on 4 WD operation. Within a few feet the truck stopped as if the wheels had hit a curb and there was no further movement no matter the accelerator pedal position and the engine speed was unchanged as if it was in a stall. All of a sudden there was a loud bang underneath the truck and the truck raced rearward 8-10 feet jackknifing the trailer into a tree and upending the truck and trailer. We contacted Toyota on the incident and they had a third party look at the truck for brake condition, floor mat placement and throttle freedom at the body shop & Toyota closed the complaint file. Toyota IGNORED the circumstances and description of the incident in closing the complaint. We have been a very long time TOYOTA truck family and have owned SIX Toyota 4 wheel drives plus a Lexus all-wheel drive. In doing our own evaluation and investigation we have found that the truck went into a 4-wheel drive "wind-up" or "bind" and found information related on it from ASE Certification sites. NO MENTION of this potential issue is provided in the owners manual! We found that the torque from this can be over 4,000 ft/lb. and possible magnified even more by low range. When this bind suddenly is released the movement can be violent as happened here. Why is this not talked about in the owner manual? Why does Toyota ignore this reality? Indeed, the Toyota Rep. Mr. Ronald Inton said "he never heard of anyone backing up in 4 Wheel Drive"! WHAT?? We have the vehicle, photos, Toyota denial all available for review,.
The contact owns a 2002 Toyota Tundra. The contact stated that the frame and the front bumper were severely rusted. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 117,000.
The contact owns a 2002 Toyota Tundra. The contact stated that after taking the vehicle to be checked for corrosion to the subframe, the contact was advised that there was significant corrosion on the subframe and the supports underneath the truck bed. The contact was informed that the vehicle was unsafe to drive with any type of load in the truck bed. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 180,000.
My frame have a big hole
I was doing maintenance on front and lifted splash guard for access to bolt. On top of the frame, near the firewall, was severe rust. It looks as if the frame could crack at any time. If this happened in highway speed or in traffic, severe risk of injuries. These are known to have issues in salt states (had recalls) and I thought I checked it pretty good before buying. I think this may be from the air conditioning drain system.
There are several issues with these seatbelts. They either lock before we can get them buckled or once we unbuckle them, they do not retract and hang out the door, thus draining the battery. They get twisted and stuck in the plastic guide toward the top of the door. The last time this happened, I could not get the seatbelt unstuck despite working on it for almost an hour. I ended up cutting the seatbelt to get it unstuck. Now it is EXTREMELY difficult to use. I need to get it replaced ASAP at my own expense. Very unsafe not to mention frustrating. Also, worth noting is this has been an ongoing problem for years.
Showing 15 of 510 complaints