NHTSA recalls, safety ratings, and consumer complaints for the 2025 Toyota Grand Highlander.
| Overall Rating | |
| Frontal Crash | |
| Side Crash | |
| Rollover |
| Overall Rating | Not Rated |
| Frontal Crash | Not Rated |
| Side Crash | Not Rated |
| Rollover | Not Rated |
Component: ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2023-2024 Toyota Venza, 2023-2025 RAV4 Prime, RAV4, Highlander, GR Corolla, Crown, 2024-2025 Lexus TX, LS, Toyota Tacoma, Grand Highlander, and 2025 Lexus RX, Toyota Crown Signia, Camry, RAV 4 Plug-in Hybrid (PHEV), and 4 Runner vehicles. Due to an error in the instrument panel software at vehicle startup, the instrument panel may fail to display vehicle speed, brake system, and tire pressure warning lights.
Consequence: An instrument panel display that does not show critical information can increase the risk of a crash or injury.
Remedy: Dealers will update the instrument panel software over-the-air (OTA) for non-PHEV vehicles, free of charge. For PHEV vehicles, dealers will inspect the instrument panel assembly, and either replace it, or update the software, free of charge. Owner letters were mailed December 5, 2025. Additional letters will be sent, anticipated in May 2026. This is a phased recall. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 25TB08 and 25TA08. Lexus' numbers for this recall are 25LB05 and 25LA05.
Component: BACK OVER PREVENTION:DISPLAY FUNCTION
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2022-2026 Toyota, Lexus, and Subaru Solterra vehicles equipped with a Panoramic View Monitor (PVM) system. Please see the recall report for a complete list of models. A software error may cause the rearview camera to freeze or display a blank screen when the vehicle is in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
A rearview camera that fails to display an image can reduce the driver's view behind the vehicle, increasing the risk of a crash.
The 2025 Grand Highlander XLS front sun roof exploded. Will be taken to dealer upon appointment. Had the interior cover not been closed, we would have been showered with glass particles. According to many articles this is a known defect by Toyota. Lemberg Law phenom. Vehicle will be inspected by Toyoto dealer on Apr 29, 2026. There were no warnings. Outside temp was 64 degrees F. Traveling at 45 mph at 2:30 EDT, Apr 27, 2026. Massive exploding sound, like a gunshot. Pulled over to check vehicle and noticed front sun roof center blown outward and rest of glass fractured.
Due to the design of the grill located at the front end of the 2025 toyota grand highlander the vehicle poses vulnerability for multiple debris items to fly up into exposed air conditioning condensor. The damage caused by the debris is not covered by the warranty because it is considered an outside occurrence. However the design creates the vulnerability for the ac to become damaged. It is also sitting below the radiator posing an additonal risk for damage and should have additonal protection to help prevent damage. I am currently having to dispute the refusal to cover the damage to my own ac condensor done by a rock flying into the grill space causing damage and losing freon, because they state it is an outside occurrence regardless of the fact that the design is faulty. There are multiple people who have experienced this happening to their vehicles some not even at the 2000 mile mark and are responsible for the financial cost. Upon doing research the 2026 toyota grand highlander model was created with an even lower setting bumper that provides better coverage and protection for the air conditioning condensor and all other important mechanical components. Suggesting that Toyota is aware of the issue if they created an additonal part to help protect that area from damage. I am literally at risk each time I drive my car just for the fact that rocks are on every road way as well as other debris. I have called the customer relations department with no resolution given only to be told I am responsible for the cost of the repair. I believe this is something that needs to be addressed as well as fixed for the sake of the buyer and the already large cost of owning and maintaining a vehicle. If it happens more than a few times its not bad luck, it's a flaw in the creation of the product and consumers should not have to be held financially responsible for someone else mistake, whether individual or corporate entity. I have previously owned 4 other toyotas with no issues!
The 2025 Toyota Grand Highlander has 3 NHTSA recalls and 42 consumer complaints on file. It received an overall safety rating of 5 out of 5 stars in NHTSA crash testing. For the most detailed information about a specific vehicle, decode its VIN using our free decoder above.
Enter a specific VIN to get the full report — specs, recalls, safety ratings, complaints, investigations, and technical service bulletins.
Remedy: Dealers will update the parking assist software, free of charge. Owner letters were mailed January 2, 2026. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 25TB13 and 25LB06. Subaru's number for this recall is WRE25.
Component: EQUIPMENT:OTHER:LABELS
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2024-2025 Toyota Tundra, Tacoma Hybrid, Tacoma, RAV4 Hybrid, Land Cruiser Hybrid, Lexus GX550, 2024-2026 Tundra Hybrid, 2025 Sequoia Hybrid, Crown Signia, Grand Highlander, Lexus TX500 Hybrid, Lexus NX350 Hybrid, 2025-2026 Grand Highlander Hybrid, and Lexus TX350 vehicles. The load carrying capacity modification label may display inaccurate added weight values. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."
Consequence: A vehicle with an incorrect maximum capacity weight value may be overloaded, which can increase the risk of a crash.
Remedy: Dealers will replace the load carrying capacity modification label, free of charge. Owner notification letters are expected to be mailed in late Q2 2026. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 26LB04, 26LA04, 26TB07, and 26TA07.
We have two forward facing car seats in the third row. When buckled according to the car seat user manuals - the seatbelts do not stay buckled. The seatbelts unbuckle while driving, creating an extremely dangerous situation for our toddlers. We take out and redo their car seats daily due to them being unbuckled while the vehicle is in motion. Our toddlers are not able to unbuckle them - so we know it is a vehicle defect. The car has been taken to the dealership where they simply tell us they can’t find an issue. We do not feel safe in this vehicle and do not want our children in there. No safety lights appear on the dash to notify us that the seats have become unbuckled.
Transmission slipping, holding high RPM, Jerky shifts, back seat not locking at times, infotainment freezing up
Driving when it sounded like a gunshot went off in the car. I looked to the back of my car to see what was around me (nothing), and saw no damage to any windows. I could hear glass cracking so I went to open my moonroof screen to check the glass and I could hear glass on the screen so I closed it right back. I pulled over and was able to confirm the sunroof had busted across the back of the glass. It did not look like it was hit by anything, but like it blew out then spidered across the remainder of the glass.
Sunroof spontaneously exploded leaving an 8” hole and a completely shattered sunroof. The sunroof is flexed upwards like it was under extreme pressure. The high temperature was 70 degrees in Tuscaloosa today with cloudy skies and misty rain. So there shouldn’t have been any concerns from heat or cold. This left shattered glass every above the sunshade. Fortunately the shade was closed to catch most of the shattered glass.
The front panel of the sunroof shattered while the vehicle was parked in our garage. Glass shards are inside the car. The dealership submitted a claim to Toyota who denied any material defect and refused to repair under warranty.
Dear National Highway Traffic Safety Administration, I am submitting this complaint to formally report a serious safety issue involving the left front axle of my Toyota Grand Highlander Hybrid XLE. The vehicle was first diagnosed by my local Toyota dealer on January 14, 2026, at which time the left front axle issue was identified. I contacted **Toyota Motor Corporation**, and I was initially informed that the required replacement part would arrive on February 6, 2026. After that date passed, I was told the part would arrive in early March. I have now been told it will not arrive until late March. Based on these repeated delays, I am concerned that “late March” could easily become late April or even later, with no firm commitment or guaranteed repair date. I have contacted Toyota dealership multiple times and made several phone calls seeking assistance, updates, or a definitive timeline. Unfortunately, no one has been able to provide a clear solution, firm delivery date, or alternative support while the part remains on back order. Due to the axle issue, I do not feel safe operating the vehicle, as I believe it presents a significant safety risk. This vehicle is essential for my work and daily financial responsibilities. Because I do not feel it is safe to drive, I am unable to use the car to earn my day-to-day income and meet my financial obligations. As a result, I am currently losing wages, and the prolonged delay is causing financial hardship and significant inconvenience. Given the safety implications and the ongoing lack of resolution, I respectfully request that the National Highway Traffic Safety Administration review this matter. I would appreciate guidance on the appropriate next steps, including whether this issue warrants further investigation, inspection, or potential recall action. I also seek clarification regarding what protections or remedies may be available to consumers when critical safety components are unavailable for extended periods.
outside temperature reading is 2 to 7 degrees high, which is not good when it makes the difference between freezing temps and not freezing temps
The car was running perfect, 9 months after I bought this car, before 20,000 miles Front Left Axle become defective, and therefore, the dealer promised to reemplaced it, but I am still waiting from the dealer. It is a big risk to runs the car like that.
At a complete stop my car started shaking violently back and forth. It felt like we were in an earthquake. It has happened before but not as violently and not as long. No warning lights or anything. It has had problems with lurching and stuttering since we bought it. The dealership said they fixed it once (the stuttering) but it’s still happening. They cannot duplicate it and it’s not throwing any codes.
The entire life of the car from initial purchase the fuel gauge is incorrect. The car has a 17 gallon gas tank and the fuel gauge is calibrated to around 13 gallons. The car thinks it is out of gas around 13 gallons when there is actually 4 more gallons left.
The contact owns a 2025 Toyota Grand Highlander. The contact received notification of NHTSA Campaign Number: 25V744000 (Back Over Prevention); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted and diagnosed the vehicle and determined that the camera had failed, and that the contact would be notified when the remedy was available. The contact stated that after leaving the vehicle with the dealer, the back over camera started to fail. The back over prevention camera no longer switched the screen for the camera while in reverse, but remained on the home screen or radio instead. The contact had not heard from the dealer regarding the parts availability for the repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 29,000.
2025 Toyota Grand Highlander Hybrid AWD, with about 16000 miles. While driving, the brakes failed. The brakes would only work if the pedal was pushed all the way to the floor. A "Low Brake Power" warning light came on the dash. The following warnings came on at the same time. Parking Brake System, Advanced Ultrasonic Detection, Vehicle Stability Control, Check Engine, Smart Stop System, Brake System, Electronically controlled Brake, Secondary Collision Brake, Anti-lock Brake System. I was lucky to have been traveling on a road that was not busy and was traveling at less than 30 mph very close to my home. Had I been driving on the interstate, on a busy road, or near pedestrians, the event could have injured or killed myself, my family, or others. The car was towed into the dealership. The dealership said that the issue was not current and the car operated normally when after it was towed in. The following DTC codes where present (P05E000, P05E062). This indicates an issue in wiring or brake pedal stroke sensor. They suspect its an intermittent issue with the sensor. The sensor was replaced (P/N, 89510-0R010 and 62112-0E040-C1). They also said the car battery was low and replaced it (P/N 00544-H5061-540). The dealership said that they would send the affected part to Toyota for inspection, but I have not heard anything back. The dealership experience was poor (Mark Jacobson Toyota, Durham, NC).
The vehicle takes an excessively long time to make heat, I know NHTSA only has requirements related to defrosting the windshield and it's clear Toyota is aware of the heating issue because they added an electronic defrost to be able to pass the defrost test. The vehicle when it is less than 20f outside takes 40+minutes to warm the cabin to a reasonable temperature. The dealership let the vehicle warm up in their 80deg F shop and said it took 20minutes to get heat out of the vents and claimed that this was normal behavior. I have owned several new cars and also work as an engineer in testing so I've driven countless new vehicles to do various tests and have never had it even take 20 minutes to have heat in a vehicle.
Showing 15 of 42 complaints