Loading vehicle data from NHTSA...
NHTSA recalls, safety ratings, and consumer complaints for the 2023 Toyota Bz4x.
| Overall Rating | |
| Frontal Crash | |
| Side Crash | |
| Rollover |
| Overall Rating | |
| Frontal Crash |
Component: WHEELS:HUB
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2023 Subaru Solterra and Toyota BZ4X vehicles. The hub bolts on the wheels may loosen, causing a wheel to detach from the vehicle after low-mileage use.
Consequence: A wheel detaching from a moving vehicle can result in a loss of vehicle control, increasing the risk of a crash.
Remedy: Owners are advised not to drive their vehicles until they are repaired. Dealers will replace the hub bolts and wheels, free of charge. Letters notifying owners of the safety risk were mailed June 27, 2022. A second letter will be sent once the remedy is available. Owners may contact Toyota's customer service at 1-800-331-4331.
Component: EQUIPMENT:OTHER:LABELS
Gulf States Toyota, Inc. (GST) is recalling certain Toyota 2023 GR Supra, 2024 4 Runner, Corolla, Grand Highlander, Grand Highlander Hybrid, Land Cruiser Hybrid, Tacoma, Tacoma Hybrid, 2023-2024 BZ4X, Corolla Cross Hybrid, GR Corolla, GR86, Highlander, Highlander Hybrid, Prius, Prius Prime, Sequoia Hybrid, Tundra, Tundra Hybrid, Venza Hybrid, 2023-2025 Crown, and 2025 Camry Hybrid vehicles equipped with GST accessories. The load carrying capacity modification label may display inaccurate added weight values. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."
Consequence: A vehicle with an incorrect maximum capacity weight value may be overloaded, which can increase the risk of a crash.
Remedy: GST will mail new labels to owners, free of charge. Owner notification letters were mailed September 16, 2024. Owners may contact GST customer service at 1-800-444-1074. GST's number for this recall is 24R2.
Component: VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM
The contact owns a 2023 Toyota BZ4X. The contact stated that the vehicle was awaiting a recall repair. The dealer informed the contact that the electrical HVAC compressor needed to be replaced as part of the recall repair; however, the part was on back order. The vehicle was taken to the dealer, but the recall repair was not completed. The manufacturer was notified of the failure. The approximate failure mileage was 117,000.
The contact owns a 2023 Toyota BZ4X. The contact had attempted to use the defroster; however, the blower was not blowing hot air onto the windshield. The contact had received notification of NHTSA Campaign Number: 25V577000 (Visibility); however, when the dealer was contacted to schedule a recall repair, the contact was informed that the part to do the recall repair was on national back order. The contact called another dealer and the manufacturer, and was informed by both that the part was on national back order. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The failure mileage was approximately 55,000.
The contact owns a 2023 Toyota BZ4X equipped with Goodyear Tires, Tire Line: Electric Drive 2, Tire Size: 215/50/R20, DOT Number: (N/A). The contact stated that while driving at various speeds above 50 MPH, the vehicle experienced severe shaking and abnormal vibration. The vehicle was taken to the local service center who determined that the foam pad inside the tire had malfunctioned. The foam was replaced, and the tires were balanced, but later the same failure reoccurred on the rear passenger’s side tire. The vehicle was taken to the local dealer for repair. No further information was available. The manufacturer was not notified of the failure. The failure mileage was unknown. The VIN was not available.
The 2023 Toyota Bz4x has 4 NHTSA recalls and 4 consumer complaints on file. It received an overall safety rating of 5 out of 5 stars in NHTSA crash testing. For the most detailed information about a specific vehicle, decode its VIN using our free decoder above.
Enter a specific VIN to get the full report — specs, recalls, safety ratings, complaints, investigations, and technical service bulletins.
| Side Crash |
| Rollover |
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2023-2025 bZ4X, Lexus RZ, and Subaru Solterra vehicles. During certain HVAC system faults, such as electrical compressor failure, the defroster and defogger system may become inoperative.
Consequence: An inoperative defroster and defogger system can decrease the driver's visibility under certain driving conditions, increasing the risk of a crash.
Remedy: Dealers will update the HVAC control ECU software, free of charge. Dealers will also inspect the electrical compressor, and replace it, if necessary, free of charge. Owner notification letters were mailed October 17, 2025. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 25TB07 and 25TA07. Lexus' numbers for this recall are 25LB04 and 25LA04. Subaru's number for this recall is WRD-25.
Component: BACK OVER PREVENTION:DISPLAY FUNCTION
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2022-2026 Toyota, Lexus, and Subaru Solterra vehicles equipped with a Panoramic View Monitor (PVM) system. Please see the recall report for a complete list of models. A software error may cause the rearview camera to freeze or display a blank screen when the vehicle is in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence: A rearview camera that fails to display an image can reduce the driver's view behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will update the parking assist software, free of charge. Owner letters were mailed January 2, 2026. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 25TB13 and 25LB06. Subaru's number for this recall is WRE25.
Premature and abnormal tire wear on my 2023 Toyota bZ4X, confirmed by two independent tire shops, despite consistent Toyota dealer maintenance every 6,000 miles. Beaverton Toyota dealer dismissed the condition as “normal,” but both [XXX] and Discount Tire documented unsafe tire wear caused by alignment. --- Details of Problem: Vehicle serviced exclusively at Toyota dealer (Beaverton Toyota, OR) every 6,000 miles, with multipoint inspections and rotations. On 9/22/25, Toyota dealer inspected the vehicle and reported that alignment and tires were “normal.” On 9/25/25, [XXX] inspected the vehicle and documented severe outside shoulder wear on the right-side tires. They recommended immediate tire replacement for safety. Alignment was also adjusted at that time to bring values into balance (report attached). On 9/27/25, Discount Tire replaced all four tires at 27,562 miles. Their written notes confirm edges were worn on all four tires due to alignment (right side more prominent). They declared the tires unsafe for continued use and recommended full replacement. Safety Concern: This abnormal alignment-related wear created unsafe driving conditions well before the rated tire life (55,000 miles). Uneven edge wear and shoulder failure increase the risk of blowouts, hydroplaning, or sudden loss of control. Attachments available: Toyota dealer report stating “normal” Les Schwab alignment printout and written safety note Discount Tire invoice with technician safety comments Tire photos (all four corners) Full Toyota dealer service history INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)