Loading vehicle data from NHTSA...
NHTSA recalls, safety ratings, and consumer complaints for the 2003 Saturn ION.
| Trim | City | Hwy | Combined | Annual fuel $ |
|---|---|---|---|---|
| 2.2L 4 cyl Automatic (variable gear ratios) | 21 | 29 | 24 | $2,500 |
| 2.2L 4 cyl Automatic 5-spd | 21 | 29 | 24 | $2,500 |
| 2.2L 4 cyl Manual 5-spd | 22 | 30 | 25 | $2,400 |
| Overall Rating | Not Rated |
| Frontal Crash | Not Rated |
| Side Crash | Not Rated |
| Rollover | Not Rated |
Component: ELECTRICAL SYSTEM:IGNITION
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
After I did the recall several years ago, the problem came back. The key will not come out of the ignition. It's happened many times.
The contact owns a 2003 Saturn Ion. The contact stated that less than a minute after starting the vehicle, the steering wheel seized. The contact stated that the vehicle lost power steering functionality, with the power steering failure message was displayed. The contact stated that after shifting to park(P), the contact would wiggle the key around in the ignition before being able to remove the key from the ignition switch. The vehicle had not been taken to the dealer to be diagnosed or repaired. The manufacturer had not been made aware of the failure. The failure mileage was 111,350.
The contact owns a 2003 Saturn Ion. The contact stated that occasionally the key failed to turn while in the ignition. The vehicle was slow to start. The contact had to avoid bumps in the roadway while driving. The lock symbol was displayed. There were no warning lights illuminated. The contact received notification of NHTSA Campaign Numbers: 14V171000 (Electrical System) and 14V047000 (Air Bags, Electrical System); however, the parts to do the recall repairs were not yet available. The local dealer was contacted. The vehicle was taken to the local dealer, who declined to service the recall repairs due to an insurance issue. The vehicle was not diagnosed or repaired. The contact called another unknown local dealer, who informed the contact to place the vehicle in park(P) and restart the vehicle, and the symbol turned off. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The manufacturer was contacted and opened a claim and informed the contact that a technician would be sent to the residence, but the technician failed to show up. The failure mileage was approximately 60,000. Parts distribution disconnect.
The 2003 Saturn ION has 7 NHTSA recalls and 766 consumer complaints on file. It received an overall safety rating of Not Rated out of 5 stars in NHTSA crash testing. The high number of complaints suggests potential reliability concerns — review the complaint details above before purchasing. For the most detailed information about a specific vehicle, decode its VIN using our free decoder above.
Enter a specific VIN to get the full report — specs, recalls, safety ratings, complaints, investigations, and technical service bulletins.
Component: ELECTRICAL SYSTEM:IGNITION:SWITCH
UCI-FRAM Group is recalling certain LS1328 ignition Switches sold as Wells LS1328, Duralast LS1328, Airtex 1S6097, and Carquest 53-27479, and LS1497 Ignition Switches sold as Wells LS1497, Duralast LS1497, Airtex 1S10961, and Carquest 53-27967, for use on various General Motors model and model year vehicles during repair and replacement of the original ignition switch. The weight on the key ring and/or road conditions or some other jarring event may cause the affected ignition switches to move out of the run position, turning off the engine and disabling the air bags.
Consequence: If the ignition switch moves from the run position to accessory, the car would stall and the air bags will not deploy in the event of a crash, increasing the risk of personal injury to the occupants.
Remedy: UCI-FRAM Group has notified its purchasers to quarantine and return all inventory. Any switches already installed in vehicles will be replaced by GM dealers as part of NHTSA recall 14V-047, free of charge. UCI-Fram's purchasers should contact UCI-FRAM Group at 1-800-890-2075. GM vehicle owners requiring additional information on that recall campaign should contact GM at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac) or 1-800-553-6000 (Saturn).
Component: AIR BAGS
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Component: EXTERIOR LIGHTING
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Remedy: SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Component: EXTERIOR LIGHTING:TURN SIGNAL
CERTAIN PASSENGER VEHICLES HAVE A CONDITION IN WHICH THE TURN SIGNAL LAMP AND DAYTIME RUNNING LAMP (DRL) ON EITHER FRONT SIDE CAN STOP WORKING BECAUSE OF LOSS OF CONTACT BETWEEN THE BULB AND SOCKET.
Consequence: IF A FRONT TURN SIGNAL LAMP IS INOPERATIVE, OTHERS MAY REACT MORE SLOWLY TO A TURNING VEHICLE AND A CRASH COULD OCCUR.
Remedy: DEALERS WILL REPLACE THE DRL/TURN SIGNAL BULB ON BOTH THE LEFT AND RIGHT FRONT SIDE AND INSPECT FOR AND ADD A DRL JUMPER KIT IF NOT PRESENT. THE RECALL BEGAN NOVEMBER 17, 2004. OWNERS SHOULD CONTACT SATURN AT 1-800-972-8876.
Component: VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 118, "POWER-OPERATED WINDOW, PARTITION, AND ROOF PANEL SYSTEMS." THE POWER WINDOWS AND/OR SUNROOF MAY BE OPERABLE AFTER THE IGNITION HAS BEEN TURNED TO THE "OFF" POSITION AND THE FRONT PASSENGER DOOR IS OPENED.
Consequence: IF UNSUPERVISED CHILDREN ARE LEFT UNATTENDED IN THE VEHICLE AND OPERATE THE POWER WINDOWS OR SUNROOF, THERE IS AN INCREASED RISK OF INJURY TO THE CHILD.
Remedy: DEALERS WILL UPGRADE THE BODY CONTROL MODULE (BCM) CALIBRATION. OWNER NOTIFICATION BEGAN ON DECEMBER 30, 2003. OWNERS SHOULD CONTACT SATURN AT 1-800-972-8876.
Component: FUEL SYSTEM, GASOLINE
CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.2L 4-CYLINDER (L61) ENGINES WERE BUILT WITH A FUEL FILTER THAT COULD CORRODE PREMATURELY ON THE EXTERIOR SURFACE.
Consequence: IF CORROSION ON THE EXTERIOR SURFACE OF THE FUEL FILTER PROGRESSES TO THE POINT OF CREATING A HOLE IN THE SHELL, FUEL DROPLETS COULD FORM AND DROP TO THE GROUND. IF AN IGNITION SOURCE IS PRESENT, A FIRE COULD RESULT.
Remedy: DEALERS WILL REPLACE THE FUEL FILTER ASSEMBLY. OWNER NOTIFICATION BEGAN ON DECEMBER 30, 2003. OWNERS SHOULD CONTACT SATURN AT 1-800-972-8876.
I have the power steering column issue that still needs to be fixed as advised by GMC of Port Richey, FL where I was promised my replacement vehicle even 10 or 20 yrs later if I bought another one. If on my walking tape recorders and contact lens, I pull off my brake peddle flat lining at least twice without crashing however he would grant me whatever 2 vehicles on the lots I chose as long as I had insurance. However, I do not have the money for the tow and corporates to include the police will not listen too. Please, contact me immediately for a more rapid communication please at [XXX] or [XXX] . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The contact owns a 2003 Saturn Ion. The contact stated that while driving at an undisclosed speed, the vehicle experienced a loss of power steering assist. The contact restarted the vehicle to correct the failure. The vehicle was taken to the dealer, and the dealer confirmed that there was no recall associated with the VIN. The vehicle was not diagnosed nor repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 173,000.
2003 SATURN ION, CONSUMER WRITES IN REGARDS TO BROKEN TIMING CHAIN. THE CONSUMER STATED WHILE DRIVING THE TIMING CHAIN BROKE, NEARLY CAUSING A CRASH IN THE MIDDLE OF AN INTERSECTION.
Rack and pinion is going bad, my mechanic said it's a common issue in these vehicles. When going around a corner it will want to float the opposite way, the steering will eventually get tight my mechanic said until I loose all steering. I am a single mother and have already replaced the whole front end on this vehicle pretty much. I know I've read so many others experiencing the same issues with their Saturn Ion, so I wanted to make it aware that this should be a recall and fixed before someone who knows nothing about vehicles ends up in a severe accident due to this big issue. Also the Key don't want to come out most of the time. An there is an issue with the car not wanting to come out of park sometimes. Not to mention it eats ball joints like crazy every other month I'm replacing the ball joints in this car. If I could afford another vehicle trust me I would but I can't even save for a new car due to all the repairs I've made. It's just frustrating that so many people are having this issue and no mechanic wants to do the rack and pinion job with out charging a fortune.
MY POWER STEERING KEPT CUTTING OUT. (BEEN DOING THIS FOR ABOUT 2 YEARS NOW) WHILE I WAS DRIVING TODAY THE WORST SITUATION HAPPENED. I WENT TO TURN AT AN INTERSECTION AND MID TURN THE POWER STEERING MESSAGE APPEARED AND MY STEERING WHEEL TIGHTENED AND STRAIGHTENED BACK OUT A LITTLE BIT. I WAS TRYING TO GET INTO THE TURN LANE BUT TO AVOID AN ACCIDENT I SPED UP TO MERGE WITH THE FARTHEST LANE AND UNFORTUNATELY I POPPED A TIRE AND BENT THE RIM. THIS NEEDS TO BE ADDRESSED BEFORE SOMEONE GETS KILLED. TO BE HONEST IM SCARED TO DRIVE MY OWN CAR AFTER TODAY.
INTERMITTENT ELECTRIC POWER STEERING LOSS DURING DRIVING, CAUSING MAJOR SAFETY ISSUE AS WELL AS DAMAGE TO STEERING COLUMN. VEHICLE LOST POWER STEERING WHILE I WAS DRIVING AND THE STEERING SHAFT SNAPPED CAUSING COMPLETE LOSS OF CONTROL.
MY IGNITION WAS RECALLED BUT THE MECHANICS AT GM CRESTVIEW DIDN'T KNOW HOW TO RESET THE COMPUTER SO ALL MY LIGHTS STAYED ON FOR CHECK ENGINE. NOW MY IGNITION IS ACTING UP AND MY CAR WON'T TURN ON. IS IT STILL COVERED UNDER THE RECALL?
TL* THE CONTACT OWNS A 2003 SATURN ION. THE CONTACT STATED THAT THE KEY REMAINED SEIZED IN THE IGNITION WHEN THE VEHICLE WAS SHIFTED INTO PARK. THE CONTACT STATED THAT THE KEY SEIZED MIDWAY WHILE ATTEMPTING TO START THE VEHICLE. THE VEHICLE LOST ELECTRICAL POWER AND TOOK 15 TO 20 MINUTES BEFORE STARTING. THE CONTACT STATED THAT THERE WAS A CLICK BEFORE THE KEY WAS RELEASED. THE BATTERY AND ENGINE WARNING LIGHTS WERE ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO A DEALER OR AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE CONTACT CALLED SATURN OF MEMPHIS (2420 COVINGTON PIKE, MEMPHIS, TN 38128) AND INFORMED THE DEALER OF THE FAILURE. THE CONTACT WAS INFORMED TO TAKE THE VEHICLE TO JIM KERAS AUTOMOTIVE (2000 COVINGTON PIKE, MEMPHIS, TN 38128). THE VEHICLE WAS NOT TAKEN TO A DEALER AND WAS NOT YET REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 66,000.
TL* THE CONTACT OWNS A 2003 SATURN ION. THE CONTACT STATED WHILE DRIVING AT SLOW SPEEDS, WHEN THE VEHICLE BEGAN TO STALL AND ANOTHER VEHICLE REAR ENDED HER. THE CONTACT STATED NO WARNING LIGHT WAS ILLUMINATED. THE AIR BAGS DID NOT DEPLOY. THE CONTACT SUSTAINED A CONCUSSION AND BACK INJURIES. THE CONTACT WAS TAKEN BY AN AMBULANCE TO SEEK MEDICAL ATTENTION AND ALSO SEEK PHYSICAL THERAPY. A POLICE REPORT WAS FILED. THE VEHICLE WAS NOT DRIVABLE. THE VEHICLE WAS TOWED TO REPAIR SHOP AND WAS NOT REPAIRED AT THAT MOMENT. THE CONTACT STATED THE VEHICLE HAD THE BATTERY WAS REPLACED PRIOR TO THE ACCIDENT. A DEALER WAS NOT CONTACTED. THE MANUFACTURER HAD NOT BEEN INFORMED OF FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.
TL* THE CONTACT OWNS A 2003 SATURN ION. THE CONTACT STATED THAT THE KEY SEIZED IN THE IGNITION. THE CONTACT CALLED A LOCKSMITH WHO REMOVED THE KEY AND STATED THAT THE VEHICLE WAS SUBJECTED TO AN UNKNOWN RECALL. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED IN 2014 FOR AN UNKNOWN RECALL, FOR A SIMILAR FAILURE, AT THE WESELOH CHEVROLET DEALER LOCATED AT 5335 PASEO DEL NORTE, CARLSBAD, CA 92008. THE CONTACT CALLED THE SAME DEALER AND WAS INFORMED THAT THE RECALL WAS EXPIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 75,000.
MY KEY SWITCH DOESN'T ALLOW ME TO REMOVE MY KEY WHEN I'M IN PARKED AND MY TRANSMISSION STRANDS AT TIMES AND MY CAR DOESN'T START ALL THE TIME WHEN I TRY TO START IT I HAVE TO SIT AND WAIT AWHILE BEFORE IT STARTS AGAIN I COULD BE SITTING IN THE DRIVE THRU ON PARKED WAITING TO TRAVEL AGAIN ON TH HE MAIN ROADWAY
TL* THE CONTACT OWNS A 2003 SATURN ION. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED UNDER GM RECALL NUMBER: 14632 (SPECIAL COVERAGE ADJUSTMENT-UNABLE TO REMOVE KEY FROM IGNITION), NHTSA CAMPAIGN NUMBER: (N/A), IN DECEMBER OF 2013 AT SERRA CHEVROLET SAGINAW LOCATED AT 4200 BAY RD, SAGINAW, MI 48603, (989) 790-0800 HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO MCDONALD GMC LOCATED AT 5155 STATE ST, SAGINAW, MI 48603, (989) 319-4136, WHERE THE VEHICLE WAS DIAGNOSED AND IT WAS DETERMINED THAT THE IGNITION LOCK CYLINDER, HOUSING AND KEYS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT INFORMED OF FAILURE. THE FAILURE MILEAGE WAS 68,000.
Showing 15 of 766 complaints