NHTSA recalls, safety ratings, and consumer complaints for the 2004 Porsche Cayenne.
| Trim | City | Hwy | Combined | Annual fuel $ |
|---|---|---|---|---|
| 3.2L 6 cyl Automatic 5-spd | 14 | 18 | 15 | $4,600 |
| Overall Rating | Not Rated |
| Frontal Crash | Not Rated |
| Side Crash | Not Rated |
| Rollover | Not Rated |
Component: POWER TRAIN:AUTOMATIC TRANSMISSION
CERTAIN SPORT UTILITY VEHICLES MAY HAVE HAD A TRANSFER CASE INSTALLED THAT COULD, DUE TO CHANGES IN THE HOUSING CASTING, RESULT IN THE OIL PUMP ROTATION. SHOULD THIS OCCUR, OIL STARVATION OF THE INTERNAL GEARS MIGHT RESULT.
Consequence: CONTINUED OPERATION OF THE VEHICLE COULD RESULT IN A FRACTURE OF THE TRANSFER CASE HOUSING. INCORRECT TORQUE WOULD THEN BE APPLIED TO THE DRIVEN WHEELS OR OIL COULD LEAK AND CONTACT THE TIRES.
Remedy: DEALERS WILL INSPECT THE TRANSFER CASE HOUSING AND, IF NECESSARY, REPLACE THE TRANSFER CASE. OWNER NOTIFICATION BEGAN ON MAY 3, 2004. OWNERS SHOULD CONTACT PORSCHE AT 1-800-545-8039.
Component: SEAT BELTS:REAR/OTHER
ON CERTAIN PASSENGER VEHICLES, THE REAR SEAT BELT LATCH ATTACHMENT BOLT IS INSUFFICIENT RIVETED.
Consequence: IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL INSPECT THE BELT BUCKLE LATCH AND, IF NECESSARY, REPLACE THE LATCH. OWNER NOTIFICATION BEGAN ON JUNE 1, 2004. OWNERS SHOULD CONTACT PORSCHE AT 1-800-545-8039.
Component: POWER TRAIN:AUTOMATIC TRANSMISSION:GEAR POSITION INDICATION (PRNDL)
Strong odor of gasoline traveling through the vents injected into vehicle. Fuel filter has a crack. Underhood electrical problems that may cause a fire
The contact is a car seat technician. The contact worked with a family who owns a Maxi-Cosi Pria 85 Max Convertible Car Seat, as the technician was inspecting the car seat she noticed the chest clip was not working as needed. The magnetic piece that clips on the chest area comes out easily.
The contact owns a 2004 Porsche Cayenne. The contact stated that while the vehicle was taken to the dealer for a recall repair appointment, he noticed that the steering wheel had a quarter inch of play. The U-Joint connection was severely corroded. The dealer diagnosed that the steering column and steering shaft needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was 266,969.
There is a significant smell of gasoline inside the cabin of the vehicle. There was a recall on the same make, model, and year for fuel pump filter flange leaks, which are indicative of a strong smell of gas inside the car. This can potentially cause the car to start on fire. The dealer stated due to the VIN, the vehicle was not covered under the existing recall.
The 2004 Porsche Cayenne has 6 NHTSA recalls and 101 consumer complaints on file. It received an overall safety rating of Not Rated out of 5 stars in NHTSA crash testing. The high number of complaints suggests potential reliability concerns — review the complaint details above before purchasing. For the most detailed information about a specific vehicle, decode its VIN using our free decoder above.
Enter a specific VIN to get the full report — specs, recalls, safety ratings, complaints, investigations, and technical service bulletins.
Porsche Cars North America, Inc. (Porsche) is recalling certain 2003-2006 Cayenne S, Cayenne Turbo, 2004-2010 Cayenne, 2006 Cayenne Turbo S, 2010-2016 Panamera S, Panamera 4 S, Panamera Turbo, 2011-2016 Panamera, Panamera 4, 2012-2013 Panamera Turbo S, 2013-2016 Panamera 4 GTS, 2014-2016 Panamera 4 S Executive, Panamera Turbo Executive, Panamera Turbo S G1 II, Panamera Turbo S Executive, 2013 Panamera 4 Platinum Edition, Panamera Platinum Edition, 2016 Panamera 4 Edition, Panamera Edition, Panamera Turbo S Executive Luxury Sports vehicles. The bushing that attaches the gear selector lever to the gearbox may degrade over time, causing the bushing to detach. This condition could allow the driver to move the shift lever to Park and remove the ignition key, while the transmission may not be in Park, with no warning message or audible chime.
Consequence: If the vehicle is exited without the transmission being in Park and without the parking brake being applied, the vehicle may unexpectedly move, increasing the risk of a crash.
Remedy: Porsche will notify owners, and dealers will replace the shifter cable bushing, free of charge. Owners are instructed to use the parking brake until their vehicle is repaired. The recall began August 9, 2019. Owners may contact Porsche customer service at 1-800-767-7243. Porsche's number for this recall is AKB1.
Component: FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
Porsche Cars North America, Inc. (Porsche) is recalling certain 2003-2006 Cayenne S and Cayenne Turbo vehicles, 2004-2006 Cayenne vehicles, and 2006 Cayenne S "Titanium" Edition vehicles. These gasoline-powered vehicles have a fuel pump flange that may crack, allowing fuel to leak.
Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Porsche will notify owners, and dealers will replace the fuel filter flanges with new filter flanges that have a protective film, free of charge. The recall began July 6, 2018. Owners may contact Porsche customer service at 1-800-767-7243. Porsche's number for this recall is AH10.
Component: SEAT BELTS
CERTAIN PASSENGER CARS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." ALL THREE REAR SEAT POSITIONS AND THE FRONT PASSENGER POSITION ARE EQUIPPED WITH SEAT BELT RETRACTORS THAT HAVE A LOCKING FEATURE WHICH CONVERTS THE RETRACTOR FROM AN EMERGENCY LOCKING RETRACTOR (ELR) MODE TO AN AUTOMATIC LOCKING RETRACTOR (ALR) MODE FOR THE PURPOSES OF CHILD RESTRAINT INSTALLATION. THE BELT MAY DEACTIVATE THE ALR MODE WITH CERTAIN CHILD RESTRAINTS.
Consequence: WHEN INVOLVED IN A CRASH, THE CHILD RESTRAINTS MAY NOT BE PROPERLY SECURED INCREASING THE RISK OF INJURY OR DEATH TO THE SEAT OCCUPANT.
Remedy: DEALERS WILL PERMANENTLY INSTALL A CLIP IN EITHER OF THE AFFECTED REAR OUTBOARD SEAT BELTS AND PROVIDE AN OWNER'S MANUAL INSERT. THE CLIPS WILL PREVENT UNWARRANTED CONVERSION FROM ALR TO ELR MODE WITH CHILD SEAT INSTALLATION. THE RECALL BEGAN MAY 17, 2005. OWNERS SHOULD CONTACT PORSCHE AT 1-800-545-8039.
Component: EXTERIOR LIGHTING:HEADLIGHTS
Porsche Cars North America, Inc. (Porsche) is recalling certain 2003-2020 Porsche Macan, Cayenne, Panamera, and Cayman S, 2001-2004 Boxster, Boxster S, 2004 Boxster 50 JAHRE SPYDER 550 vehicles. Please see the recall report for a complete list of all affected models and model years. The caps that cover the low-beam headlight horizontal adjustment screws are missing, which can allow the headlights to be improperly adjusted. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence: Improperly adjusted headlights may not illuminate the road properly, or cause a glare to oncoming drivers, which can increase the risk of a crash.
Remedy: Dealers will inspect the headlights for sealing caps and install missing caps as necessary, free of charge. Owner notification letters were mailed October 28, 2022. Owners may contact Porsche's customer service at 1-800-767-7243. Porsche's number for this recall is ANB4.
The contact owns a 2004 Porsche Cayenne. The contact received notification of NHTSA Campaign Numbers: 22V656000 (Exterior Lighting), 19V446000 (Power Train), and 17V576000 (Fuel System, Gasoline) however, the parts to do the recall repairs were unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that the fuel gauge failed to read accurately. The headlamp wiring had been deteriorating causing the headlights to malfunction. The manufacturer was made aware of the failure and a case was opened. The approximate failure mileage was 170,000. Parts distributions disconnect.
I returned after being away for a few weeks, in May 2021. The solar panel had been on the inner windshield of the car following installation a few months prior. I found the car's 12V battery was almost dead (about 4 Volts), and the solar panel's plastic frame was severely melted, causing it to deform and lift away from the glass solar panel. Photos uploaded below. From reading reviews on this product on the Harbor Freight website, I now see that this is a common problem. I don't know what the cause is. Could be that the cheap plastic is just not made to withstand summer heat (although I have 2 more of these in my other cars, with no problems), and that the severe deformation of the frame somehow shorted something electical inside the panel that caused the car's 12V battery to discharge, heating the glass panel and melting all the surrounding plastic. Or it could be that an electrical problem was the trigger, causing the battery to discharge, etc. Harbor Freight is so far making it extremely difficult to try to raise the problem with them. I think this could be a serious issue, perhaps leading to a car fire. And if it is indeed an electrical fault that triggers this, then it could happen when parked in a garage (no solar heating needed), possibly leading to worse.
The cam shaft actuator has gone out.. Recalled on newer vehicles mine is 2004. Front airbag is also non operational
TL* THE CONTACT OWNS A 2004 PORSCHE CAYENNE S. THE CONTACT STATED THAT WHILE ATTEMPTING TO START THE VEHICLE, THE CONTACT HEARD A LOUD "BOOM" NOISE AND FIRE STARTED COMING FROM THE GLOVE BOX IN THE INTERIOR OF THE VEHICLE. FIRE MARSHALS WERE CALLED ONTO THE SCENE TO ATTEMPT TO EXTINGUISH THE FIRE, AFTER 3 HOURS THE FIRE WAS EXTINGUISHED. A REPORT WAS MADE WITH THE FIRE MARSHALS. THE CONTACT STATED NO INJURIES WERE SUSTAINED AT THE SCENE. THE VEHICLE WAS NOT TOWED AND REMAINS ON CONTACTS PROPERTY. UPON INVESTIGATION, THE CONTACT ASSOCIATED THE FAILURE WITH, NHTSA CAMPAIGN NUMBER: 04V069000 (ELECTRICAL SYSTEM) HOWEVER THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS INFORMED OF FAILURE AND TOLD THE CONTACT THAT SINCE THEY DID NOT PURCHASE THE VEHICLE FROM A PORSHE DEALER THERE WAS NOTHING THEY COULD TO DO ASSIST THE CONTACT. THE FAILURE MILEAGE WAS APPROXIMATELY 115,000.
TL* THE CONTACT OWNS A 2004 PORSCHE CAYENNE. THE CONTACT STATED HE PARKED THE VEHICLE IN HIS DRIVE WAY WITHOUT THE EMERGENCY BREAK ENGAGED AND LEFT TO ENTER HIS RESIDENCE. THE CONTACT STATED WITHIN 2-3 MINUTES LATER, WHEN EXITING HIS RESIDENCE, THE VEHICLE INADVERTENTLY SHIFTED GEARS TO REVERSE AND ROLLED AWAY FROM HIS RESIDENCE. THE CONTACT STATED THE VEHICLE HIT TWO TREES, A FENCE, CONTINUED TO ROLL AWAY AND HIT A SECOND FENCE WHICH DETAINED THE VEHICLE. AIR BAGS DID NOT DEPLOY. THE CONTACT STATE NO ONE WAS INJURED. THE CONTACT STATED HE HAD TO BREAK THE REAR PASSENGER SIDE WINDOW TO ENTER AND TURN OFF THE VEHICLE. THE VEHICLE WAS TAKEN TO A BODY SHOP FOR BODY DAMAGE REPAIRS. THE CONTACT STATE AT THAT MOMENT HE DID NOT CONTACT THE DEALER TO HAVE THE VEHICLE DIAGNOSED. THE CONTACT STATES HE RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 19V446000 (POWER TRAIN) IN SEPTEMBER OF 2019. THE VEHICLE WAS TAKEN PORSCHE OF OMAHA (6625 L ST, OMAHA, NE 68117) WHERE THE RECALL REPAIRS WERE SERVICED. THE MANUFACTURER HAD BEEN INFORMED OF FAILURE. THE FAILURE MILEAGE WAS 90,000.
2004 PORSCHE CAYENNE. CONSUMER WRITES IN REGARDS TO TRANSMISSION SHIFT LEVER SAFETY RECALL. *LD THE CONSUMER STATED THE VEHICLE WAS PARKED AND ROLLED INTO ANOTHER VEHICLE WHICH, THEN CRASHED INTO A VEHICLE. THE TRANSMISSION SHIFT LEVER FAILED AND WAS REPLACED. THE CONSUMER REQUESTED TO BE REIMBURSED FOR THE REPAIRS TO THE VEHICLES. *JS *JS - (RECALL RELATED INCIDENT) TS
TRANSMISSION TRANSFER CASE ISSUES IMMEDIATELY AFTER ACCELERATION BETWEEN 3 GEARS... CAR TRANSMISSIONS "STUMBLES" (TRANSMISSION LOCKING). WELL KNOWN ISSUE IN THE PORSCHE COMMUNITY AND PORSCHE SOLUTION IS DOES NOT FIX THE ISSUE. NO ENGINE ERROR CODES ISSUED AS WELL. PORSCHE SAYS CANNOT DUPLICATE PROBLEM. THIS HAS BEEN HAPPENING FOR QUITE A WHILE UNTIL I RESEARCHED THE ISSUES ONLINE. PREVIOUSE RECALL # 03V351000 - PORSCHE WILL NOT CURRENTLY HONOR THIS RECALL.
I RECEIVED A RECALL LETTER IN NOVEMBER OF 2017 NHTSA CAMPAIGN NUMBER: 17V576000. FUEL PUMP FLANGE MAY CRACK CAUSING FUEL LEAK A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE INCREASES THE RISK OF A FIRE. MY LOCAL DEALER KEEPS TELLING ME NO PARTS AVAILABLE. I FIND THE TIMELINE UNACCEPTABLE AND I WANT THE RECALL REMEDIED IMMEDIATELY. WE ARE PUSHING TWO YEARS WITH NO REPAIR.
I HEARD SOME KNOCKING FROM THE AREA OF THE FRONT LEFT WHEEL WHILE DRIVING ON A CITY STREET ABOUT 30 MILES PER HOUR. I STOPPED AND INSPECTED UNDER THE CAR AND SAW NOTHING. SO I DECODED TO BRING IT TO MY SERVICE PROVIDER. I DROVE ABOUT 3 MILES AT SLOW SPEEDS TO GET TO THE SERVICE PROVIDER. AFTER ABOUT AN HOUR THEY FOUND THE PROBLEM. ONE OF THE BOLTS THAT HOLDS THE KNUCKLE TO THE WHEEL HAD BACKED OUT AND WAS BANGING AROUND THE BREAK SYSTEM. THEY SAID I COULD NOT DRIVE THE CAR UNTIL IT WAS FIXED.
TL* THE CONTACT OWNS A 2004 PORSCHE CAYENNE. WHILE DRIVING AND ACCELERATING, THE DRIVESHAFT MALFUNCTIONED, WHICH CAUSED THE VEHICLE TO WOBBLE AND SHAKE. THE CONTACT CALLED MOMENTUM PORSCHE (10155 SOUTHWEST FWY, HOUSTON, TX 77074, (844) 894-5470) AND WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN A RECALL. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 180,000.
2004 PORSCHE CAYENNE S. CONSUMER WRITES IN REGARDS TO REIMBURSEMENT FOR VEHICLE FIRE DAMAGES. *AS *JS
Showing 15 of 101 complaints