2002 Pontiac Montana

Component: FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES

CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.

Consequence: FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.

Remedy: DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.

Full recall detail →

Component: LATCHES/LOCKS/LINKAGES:DOORS:LATCH

ON CERTAIN MINIVANS EQUIPPED WITH SECOND-ROW BUCKET SEATS OR CAPTAIN'S CHAIRS AND A POWER SLIDING DOOR ON THE PASSENGER SIDE OF THE VEHICLE, A PASSENGER USING THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR COULD BE INJURED.

Consequence: IF A PASSENGER USES THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR AND HOLDS ONTO THE HANDLE WHILE IT IS BEING OPENED BY THE MOTOR, THE PASSENGER'S ARM MAY BE PUSHED INTO THE SEAT BACK OR ARMREST AND A WRIST OR LOWER ARM INJURY MAY RESULT.

Remedy: DEALERS WILL REPLACE THE POWER SLIDING DOOR INTERIOR HANDLE ON THE PASSENGER-SIDE. IF THE VEHICLE IS EQUIPPED WITH A POWER OR MANUAL SLIDING DOOR ON THE DRIVER-SIDE, THE INTERIOR HANDLE WILL ALSO BE REPLACED FOR APPEARANCE REASONS. NOTE: BEFORE THE VEHICLE IS SERVICED, GM ADVISES OWNERS TO NOT USE THE INTERIOR DOOR HANDLE TO OPEN THE DOOR. THE DRIVER CAN OPEN AND CLOSE THE DOOR FROM SWITCHES AT THE DRIVER'S POSITION OR BY USING THE REMOTE KEY FOB. THE DRIVER SHOULD TELL PASSENGERS TO USE THE SWITCH LOCATED IN FRONT OF THE DOOR TO OPEN OR CLOSE IT. THE DRIVER SHOULD USE THE OVERRIDE SWITCH TO PREVENT OPERATION OF THE POWER DOOR BY CHILDREN OR BY OTHERS WHO ARE NOT FAMILIAR WITH ITS USE. THE OWNER NOTIFICATION LETTER MAILING WILL BE CONDUCTED IN PHASES WITH THE FIRST PHASE BEGINNING ON MAY 31, 2005. THE SECOND PHASE MAILING BEGAN ON JULY 18, 2005. THE RECALL BEGAN ON MAY 31, 2005. PHASE 2 BEGAN ON JULY 18, 2005. PHASE 3 (FINAL PHASE) BEGAN ON AUGUST 24, 2005, TO ALL REMAINING CUSTOMERS. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; PONTIAC AT 1-800-620-7668; OR OLDSMOBILE AT 1-800-630-6537.

Full recall detail →

Component: AIR BAGS:FRONTAL

CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.

Consequence: PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.

Remedy: DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.

Full recall detail →

2002 PONTIAC MONTANA. WHILE THE VEHICLE WAS PARKED IN THE GARAGE, I SMELLED A STRONG ODOR OF FUEL OUTSIDE THE VEHICLE. I NOTICED A SMALL AMOUNT OF FUEL SPILLING FROM THE LOWER PORTION OF THE FUEL TANK. THERE WERE NO WARNINGS PRIOR TO THE FAILURE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR A DIAGNOSTIC. THE FAILURE WAS RELATED TO A CRACK IN THE FUEL TANK INLET CHECK VALVE. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 07V349000 (FUEL SYSTEM, GASOLINE:STORAGE), ALTHOUGH THE FAILURES WERE IDENTICAL. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 93,426. ALSO SINCE THIS HAPPENING THE GAS TANK DOES NOT READ THE GAS AMOUNT CORRECTLY,ITS EITHER FULL OR LOW ON FUEL AND LIGHT COMES ON. *TR

TL* THE CONTACT OWNS A 2002 PONTIAC MONTANA. THE CONTACT STATED THAT THERE WAS AN ABNORMAL FUEL ODOR COMING FROM THE REAR OF THE VEHICLE. UPON INSPECTION, THE CONTACT NOTICED THAT THE FUEL TANK WAS FRACTURED AT THE INLET. THE VEHICLE WAS PREVIOUSLY REPAIRED; HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 07V349000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 120,949.

TL* THE CONTACT OWNS A 2002 PONTIAC MONTANA. THE CONTACT STATED THAT THE FUEL GAUGE ON THE VEHICLE DOES NOT REFLECT THE ACTUAL AMOUNT OF FUEL IN THE TANK. IN ADDITION, THE FUEL WARNING LIGHT FLASHED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 151,763.

REALIZED EXCESS USE OF BRAKE FLUID. TRACED PROBLEM TO LEAKING REAR BRAKE LINE - STEEL LINE CORRODED THROUGH AT AXLE CLIP LOCATION. *TR

PASSENGER SIDE WHEEL BEARING FAILURE - GRINDING. *TR

LOWER/UPPER INTAKE MANIFOLD GASKET FAILED AT 87160 MILES HEAD GASKET FAILED AT 142,500 MILES LOWER INTAKE MANIFOLD GASKET FAILED AT 183170 MILES. *TR

THE DRIVER AND PASSENGER SIDE BRAKE LIGHTS CONSTANTLY GO OUT. I HAVE SPOKEN TO A MECHANIC AND HE TOLD ME THAT IT IS VERY COMMON FOR GM VEHICLES IN THIS MODEL YEAR RANGE TO HAVE TO REPLACE THE LIGHTING BANK IN THE REAR OF THE VEHICLES ON BOTH SIDES. THE BANK WHICH CONTAINS THE BRAKE LIGHTS, THE BACK-UP LIGHTS, AND THE RUNNING LIGHTS FAILS AND THE BRAKE LIGHTS SEEM TO BE MOST AFFECTED. I HAVE HAD TO REPLACE MY BRAKE LIGHTS APPROXIMATELY ONCE A MONTH FOR MULTIPLE YEARS. THERE HAVE BEEN MANY NEAR-COLLISIONS DUE TO BRAKE LIGHTS NOT OPERATING. THE THIRD BRAKE LIGHT AT THE TOP OF THE VEHICLE APPEARS TO NOT BE AFFECTED BY THIS. *TR

EARLY SATURDAY MORNING ON SEPTEMBER 8, 2012, I SMELLED STRONG GAS FUMES IN MY KITCHEN WHICH IS BY MY CARPORT. I WENT OUTSIDE TO CHECK AND SEE WHERE THE OVERWHELMING SMELL WAS COMING FROM. TIME I STEPPED OUT THE DOOR TO MY CARPORT WHERE MY VAN IS PARKED, I WENT TO MY 2002 PONTIAC MONTANA MINIVAN AND BEGAN LOOKING AND SNIFFING AROUND AND UNDER IT. TO MY SHOCK AND SURPRISE THERE WAS A PUDDLE OF GAS ON THE GROUND FROM GAS LEAKING OUT OF THE FUEL TANK WHERE THE INLET CONNECTS TO THE FUEL TANK. I BEGAN TO PANIC AND CRY BECAUSE I WAS AFRAID OF ANYTHING THAT COULD IGNITE OR START A FIRE AND THE EXPOSURE TO THE FUMES THAT WOULD ENDANGER MY FAMILY. I IMMEDIATELY CALLED MY MECHANIC FOR HELP AND HE CAN OVER TO LOOK AT THE PROBLEM. HE INFORMED ME THAT THE VALVE CONNECTION BETWEEN THE INLET AND TANK WAS LEAKING. HE THEN WENT ONLINE TO CHECK ON A POSSIBLE PART FOR THE FUEL TANK AND CAME ACROSS A RECALL CHECK. WE BOTH READ THE INFORMATION AND I CALLED PONTIAC ON MONDAY SEPTEMBER 10,2012 AND EXPLAINED TO THEM MY DEEPEST CONCERN ABOUT THE LEAK FROM MY FUEL TANK. THEY CONTACTED A DEALER AND HE TALKED WITH A AREA REPRESENTATIVE, SHE SAID MY SPECIAL WARRANTY EXPIRED JULY 27, 2012 FOR 10 YEARS OR 150,000 MILES CLAIMING THEY SENT IT OUT IN JANUARY 30, 2008 IN WHICH I NEVER RECEIVED AT ALL. AT THE DEALER I GOT A ESTIMATED REPLACEMENT FUEL TANK PRICE AT $800.00 INCLUDING LABOR COST. THE AREA REPRESENTATIVE OFFERED AT FIRST $1500.00 TOWARD A NEW CAR, THEN OFFERED TO PAY HALF THE COST OF A FUEL TANK AND LABOR. I NOW NEED ADVICE TO MOVE FORWARD WITH THIS MATTER AS SOON AS POSSIBLE. *TR

2002 PONTIAC MONTANA. CONSUMER STATES PROBLEM WITH VEHICLE WINDSHIELD *TGW LAST NOVEMBER, THE WINDSHIELD CRACKED DIAGONALLY TOWARD THE LEFT LOWER CORNER. UPON INSPECTION, IT WAS APPARENT THE WINDSHIELD HAD RELEASED FROM THE UPPER RIGHT CORNER. THE VEHICLE WAS INSPECTED BY A GLASS REPAIR SHOP AND THEY INFORMED THE CONSUMER THAT THE ROOF/GLASS OPENING WAS RUSTED AND HAD TO BE REPAIRED/REPLACED BEFORE THEY WOULD REPLACE THE GLASS. THE DEALER INFORMED THE CONSUMER THERE WAS A SERVICE BULLETIN SPECIFYING THAT THE ROOF WAS TO BE REPLACED TO FIX THE CONDITION. *JB

TL* THE CONTACT OWNS A 2002 PONTIAC MONTANA. THE CONTACT STATED THAT WHILE HAVING THE WINDSHIELD REPAIRED BY AN INDEPENDENT GLASS COMPANY, THE TECHNICIAN STATED THAT THE FRAME NEAR THE TOP OF THE WINDSHIELD WAS RUSTED. DUE TO THE RUST, THE TECHNICIAN WAS UNABLE TO PROPERLY INSTALL THE NEW WINDSHIELD BECAUSE IT WOULD INCREASE THE CHANCES OF THE WINDSHIELD SHATTERING OR SEPARATING. THE DEALER AND MANUFACTURER WERE NOTIFIED, BUT DENIED ANY ASSISTANCE WITH REPAIRS OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 188,000.

TL* THE CONTACT OWNS A 2002 PONTIAC MONTANA. THE CONTACT WAS DRIVING 30 MPH WHEN SMOKE EMITTED FROM THE SEAT WARMERS IN THE FRONT PASSENGERS SEAT. THE VEHICLE WAS NOT DESTROYED. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP AND THE MANUFACTURER WAS CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 141,000.

I OWN A 2002 PONTIAC MONTANA AND THE FUEL GAUGE IS NO LONGER WORKING PROPERLY. IT NOW GIVES ME A READING OF EITHER HAVING A FULL TANK OF GAS OR AN EMPTY TANK OF GAS. THERE WAS NO PREVIOUS WARNING TO THE FUEL GAUGE GOING BAD. THE INCORRECT FUEL READING OCCURS AT EVERY START UP, AND THE CONSEQUENCES OF HAVING AN INCORRECT GAUGE IS THE POSSIBILITY OF RUNNING OUT OF GAS. I HAVE NOT MADE A REPAIR AS OF THIS TIME. PLEASE LOOK INTO THIS ISSUE, AS MANY OTHER OWNERS ARE HAVING THIS SAME ISSUE, AND IT IS APPARENT THAT THE FUEL GAUGE IS FAULTY. FAILURE OCCURRED IN FEBRUARY, 2011. *TR