2010 Mitsubishi Lancer Evolution

Component: VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:FAN/MOTOR

Mitsubishi Motors North America, Inc. (Mitsubishi) is recalling certain model year 2009-2011 Lancer vehicles manufactured March 16, 2009, to March 30, 2011, 2010-2011 Lancer Sportback vehicles manufactured June 17, 2009, to December 1, 2010, 2010-2011 Lancer Evolution vehicles manufactured July 14, 2009, to January 7, 2011, 2009-2011 Outlander vehicles manufactured February 10, 2009, to June 22, 2011, and 2011 Outlander Sport vehicles manufactured August 26, 2010, to November 19, 2010. In the affected vehicles, the blower motor may fail.

Consequence: Failure of the blower motor may reduce the performance of the windshield defroster, diminishing the driver's visibility and increasing the risk of a crash.

Remedy: Mitsubishi will notify owners, and dealers will replace a suspect blower motor, free of charge. The recall began on June 15, 2015. Owners may contact Mitsubishi customer service at 1-888-648-7820. Mitsubishi's number for this recall is SR-15-003.

Component: POWER TRAIN:MANUAL TRANSMISSION

Mitsubishi Motors North America, Inc. (Mitsubishi) is recalling certain model year 2008-2013 Lancer Evolution vehicles manufactured from December 12, 2007, through March 5, 2013. In the affected vehicles, the clutch master cylinder can fail.

Consequence: Failure of the clutch master cylinder reduces the ability to shift the vehicle into or out of gear, increasing the risk of a crash.

Remedy: Mitsubishi will notify owners, and dealers will replace the affected clutch master cylinders free of charge. The recall began on November 12, 2013. Owners may contact Mitsubishi at 1-888-648-7820. Mitsubishi's campaign number for this recall is SR-13-009.

WARNING MESSAGE "TOO HOT SLOW DOWN" APPEARS WHEN INCLINING UPHILL IN ABOVE 70 DEGREES (F) AT 45MPH OR MORE. TRANSMISSION BEGINS TO LOSE POWER, DECELERATION OCCURS, TEMPERATURE GAUGE READS NORMAL ON DASHBOARD MENU, VEHICLE TRANSMISSION RUNS ON HIGH RPM ABOVE 3000, TRANSMISSION SOUNDS ARE LOUDER THAN NORMAL, AND WHEN VEHICLE REACHES COMPLETE STOP, VEHICLE WARNING MESSAGE DOES NOT GO AWAY. WHEN VEHICLE IS MANUALLY SHUT OFF, MESSAGE WILL STILL APPEAR. WHEN THE VEHICLE IS TURNED ON TO ELECTRICAL ONLY, MESSAGE WILL STILL APPEAR. AFTER 5 MINUTES OR MORE IN POWER OFF, VEHICLE WILL RESTART LIKE NORMAL, MESSAGE IS CLEARED, AND GAUGES FOR TEMPERATURE AND OIL PRESSURE IS NORMAL RANGE. NO ERROR CODES ARE DISCOVERED WHEN PULLING CODES WHEN ISSUE OCCURS. EMISSIONS IS OKAY AND VEHICLE IS REGULARLY MAINTAINED ACCORDING TO VEHICLE'S SUGGESTED MAINTENANCE PLANS. ISSUE HAS BEEN A RECURRING ISSUE FOR THE LAST 4 YEARS AND THE DEALERSHIP HAS NOT RESPONDED WITH A SUGGESTED RESOLUTION OR ADVISEMENT ON THE ISSUE. *TR

THE MITSUBISHI DEALER TOLD ME THEY COULDN'T FIX ONE OF THE RECALLS BECAUSE IT WAS AN "AFTER MARKET PART". *TR

MY ABS AND ASC LIGHTS HAVE BEEN ON FOR A WHILE. TOOK IT TO A MECHANIC AND WAS TOLD IT WASNT A PROBLEM, JUST A FAULTY ELECTRICAL SYSTEM. ONE DAY, I WAS COMING OFF AN EXIT RAMP TRYING TO BRAKE SO I COULD TURN BUT MY BRAKES WOULDNT ENGAGE SO I SLAM ON MY BRAKE AND THEY LOCKED UP AND MY CAR SLID AND CRASHED INTO A MEDIAN. TIRED TO STEER AWAY BUT IT WOULDNT TURN.

I HAD SOME WARNING LIGHTS COME ON FOR THE ASC AND ABS SYSTEMS BEING DISABLED. I TOOK IT TO THE DEALER AND THEY SAID THE ABS PUMP WAS FAULTY AND NEEDED TO BE REPLACED FOR OVER $3000. I LOOKED ONLINE AND FOUND SEVERAL OTHER PEOPLE WITH THE SAME ISSUE OF THE BRUSHES IN THE ABS PUMP STICKING. THAT SAME ABS PUMP IS USED IN SOME BMW AND JEEP MODELS WITH NUMEROUS PEOPLE REPORTING THE SAME ISSUE. THE ASC AND ABS SYSTEMS SEEM LIKE CRITICAL SAFETY SYSTEMS THAT SHOULD BE COVERED FOR REPAIRS DUE TO THE FAILURE OF A DEFECTIVE COMPONENT. I WOULD APPRECIATE SOMEONE LOOKING INTO THIS OBVIOUS SAFETY ISSUE. THANK YOU.

TL* THE CONTACT OWNS A 2010 MITSUBISHI LANCER EVOLUTION. WHILE DRIVING HIGHWAY SPEEDS ABOVE 40 MPH, THE VEHICLE BECAME VERY UNSTABLE AND 'FOUR WHEEL DRIVE DISABLED' DISPLAYED. THE VEHICLE WAS TAKEN TO NIMAY MITSUBISHI (1011 KENNEDY AVE, KILOMETER 2.5, 787-622-0200) WHERE IT WAS DIAGNOSED THAT THE ALL WHEEL CONTROL HYDRAULIC UNIT FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE, BUT NO ASSISTANCE WAS OFFERED. THE FAILURE MILEAGE WAS 41,000.

HELLO NHTSA, I HAVE A 2011 MITSUBISHI LANCER RALLIART SPORTBACK. I HAVE JUST CAME ACROSS A CRACK IN MY EXHAUST MANIFOLD WHICH IS CAUSING EXHAUST FUMES TO ENTER THE CABIN OF THE VEHICLE IF MY WINDOWS ARE UP. I DON'T SEEM TO BE THE ONLY PERSON WITH THIS TYPE OF CAR/ENGINE THAT HAS A CRACK IN THE EXHAUST MANIFOLD. MY CAR IS NOT MODIFIED IN ANY WAY THAT EFFECTS THE PERFORMANCE THAT COULD CAUSE SUCH A CRACK TO HAPPEN. THIS ALSO APPEARS TO BE THE CASE FOR SEVERAL THOUSAND OTHERS. I HAVE BROUGHT MY VEHICLE INTO MITSUBISHI WHO HAS CONFIRMED THE CRACK AND HAS NOT BEEN ABLE TO EXPLAIN TO ME WHY OR HOW THIS HAPPENED. I HAVE BEEN TOLD FROM MY LOCAL MITSUBISHI DEALERSHIP AND THE NEXT CLOSEST ONE THAT THEY CAN REPLACE THE MANIFOLD FOR $2K. I HAVE CONTACTED MITSUBISHI USA WHO HAS TOLD ME THE EXHAUST MANIFOLD SHOULDN'T CRACK AND HAS GOTTEN NO OTHER COMPLAINTS ABOUT THE ISSUE. THERE ARE SEVERAL THOUSAND POSTS WITH PHOTO PROOF THAT I AM NOT ALONE WITH THIS ISSUE. MITSUBISHI HAS HAD A SIMILAR ISSUE WITH THEIR ALL WHEEL DRIVE PUMP WHERE THERE WAS A DEFECT OF SOME SORT AND EXTENDED THE WARRANTY TO 100,000K. I HAVE ALREADY HAD MY ALL WHEEL DRIVE PUMP FAIL AND REPLACED UNDER THAT WARRANTY. WHEN I SPOKE WITH MITSUBISHI USA A SUPERVISOR NAMED JENNIFER INFORMED ME TO PUT IN A COMPLAINT HERE. SINCE MITSUBISHI HAS NOT HAD ANY INTERNAL TESTING ON THE MANIFOLD GOING THIS ROUTE MAY SPEED THE PROCESS UP. THIS ISSUE IS QUITE SERIOUS SINCE WITH THE CRACK - PHOTO ATTACHED: IT CAUSES CARBON MONOXIDE TO ENTER THE CABIN IF THE WINDOWS ARE UP OR IF THE AC IS ON AND THE CAR IS AT A STAND STILL. THANK YOU FOR YOUR TIME.

MY COMPLAINT IS ON THE ANTI LOCK BRAKE PUMP/MOTOR ON 2010 MITSUBISHI LANCERS. IV READ ALOT AND TALKED TO ALOT OF PEOPLE ABOUT THIS ISSUE WHERE AT ANYTIME THE CAR ENDS UP HAVING A LOW OR BAD BATTERY, AND OR ANY OTHER ISSUES CAUSING LOWER THEN NORMAL VOLTAGE. IT SENDS A CODE TO THE ABS MODULE CAUSING IT TO FAIL. MAKING YOUR ABS AND ENGINE LIGHT COME ON THE DASH. WITH THAT FAILURE IT STORES THE CODE AND EVEN AFTER THE ELECTRICAL PROBLEMS ARE FIX YOU STILL CAN NOT CLEAR THE ABS/BRAKE CODE. THE ONLY FIX TO GET RIDE OF THE LIGHTS AND TO GET YOUR ABS PUMP/MOTOR WORKING AGAIN IS TO REPLACE IT WITH A BRAND NEW UNIT COSTING ALMOST $3,000 DOLLARS TO MITSUBISHI. HEARING FROM OTHER PEOPLE WITH THIS ISSUE, IT IS A DEFECT FROM MITSUBISHI. THIS PROBLEM OCCURED TO ME WHEN MY CAR WAS IS PARK RUNNING, BUT HAVE SEEN IT HAPPEN TO OTHER PEOPLE JUST DRIVING DOWN THE ROAD OR HIGHWAY ( IN MOTION & STATIONARY ) ALSO WITH OUT THIS FIX YOU CANT NOT GET YOUR VEHICAL PASSED IN A STATE INSPECTION

TL* THE CONTACT OWNS A 2010 MITSUBISHI LANCER. WHILE DRIVING HIGHWAY SPEEDS, THE SUN ROOF ASSEMBLY FRACTURED WITHOUT WARNING. THERE WERE NO INJURIES. THE MANUFACTURER WAS NOTIFIED. THE DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2010 MITSUBISHI LANCER. WHILE DRIVING APPROXIMATELY 70 MPH, THE VEHICLE SUDDENLY SHUT OFF. THE VEHICLE WAS EXAMINED BY AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE BOLTS TO THE I-BEAM CONNECTING ROD BECAME LOOSE AND DAMAGED THE ENGINE BLOCK. THE VEHICLE WAS NOT REPAIRED. THE LOCAL DEALER (KELLY MITSUBISHI, 536 STATE AVE, EMMAUS, PA) WAS NOTIFIED OF THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 186,000.

TL* THE CONTACT OWNS A 2010 MITSUBISHI LANCER. WHILE DRIVING VARIOUS SPEEDS, THE ABS AND ACS WARNING INDICATORS ILLUMINATED. THE CONTACT WAS CONCERNED FOR HER SAFETY AND CALLED WANTAGH MITSUBISHI AT (516) 785-4300 (LOCATED AT 3460 SUNRISE HWY, WANTAGH, NY 11793) AND AN APPOINTMENT WAS SCHEDULED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 6,409. *TT

ON-DASH WARNING LIGHT OF "4WD SYSTEM SERVICE REQUIRED" CAME ON. THIS WARNING IS INDICATIVE OF A ACTIVE CENTER DIFFERENTIAL (ACD) PUMP FAILURE, GENERALLY DUE TO CORROSION FROM TREATED WINTER ROAD SURFACES AND/OR THE INABILITY TO HANDLE COLD-WEATHER CLIMATES. CAR WAS PREVIOUSLY SERVICED UNDER A TECHNICAL SERVICE BULLETIN (TSB) TO DELAY ACTIVATION OF THE ACD PUMP FOR THIS EXACT REASON 2 YEARS PRIOR TO FAILURE. MITSUBISHI HAS YET TO CORRECT THIS MANUFACTURING DEFECT AND IS CURRENTLY REFUSING TO HONOR WARRANTY SERVICE OF FAILED PUMPS UNDER THEIR 5-YEAR / 36,000-MILE POWERTRAIN WARRANTY, STATING THAT THE PUMP IS NOT REQUIRED FOR THE VEHICLE TO OPERATE SAFELY AND PROPERLY. IN CONTRAST, A WORKING ACD PUMP DIRECTLY EFFECTS THE VEHICLE'S HANDLING, TRACTION & STEERING - AND ALL 3 DRIVING PARAMETERS IMMEDIATELY BEHAVE DIFFERENTLY WHEN THE PUMP SHUTS DOWN IN SELF-PROTECTION MODE OR HAS FAILED COMPLETELY. THIS VEHICLE HAS A DRIVER-SELECTED SETTING FOR TARMAC (PAVEMENT), GRAVEL/RAIN & SNOW CONDITIONS - THESE SETTINGS ARE COMPLETELY DISABLED WHEN THE ACD PUMP HAS FAILED, OR IS FAILING (ON-DASH WARNING WITH PUMP IN SELF-PROTECTION MODE). THIS ISSUE EFFECTS SEVERAL MODELS (LANCER, LANCER EVOLUTION, RALLIART, ETC.) FROM MODEL YEAR 2008 TO 2014, AND HUNDREDS OF INSTANCES OF THIS ISSUE HAVE BEEN DOCUMENTED IN ONLINE FORUMS (AND PROBABLY SEVERAL-FOLD THAT AMOUNT THAT HAVEN'T BEEN DISCUSSED ONLINE). PLEASE LOOK INTO THIS ISSUE IMMEDIATELY, THANK YOU.

BAD INJECTOR CAUSED CYLINDER FAILURE OR VALVR CONSTANT VALVE TICK. BLOWN SPARK PLUGS CAUSED PISTON MELTDOWN CAUSING FOR THE PISTONG ROD TO SHOOT THROUGHT THE BLOCK CAUSE A FIRE TO THE ENGINE.. LUCKLY I STOP THE FIRE TOOK IT TO A DELAERSHIP TO VERIFY THE CAUSE OF THE DAMAGE BUT THE TECHNICINAS TOLD ME THAT THERES NOTHING THEY COULD DO BECAUSE THE BATTERY DIE THERE FOR IT RESET THE COMPUTER MODULE ERASING ALL THE DATA WITH THE PROBABLE CAUSE AND NOTHING WAS DONE AFTER THAT.. BOUGHT A NEW ENGINE AND NOW AFTER 20,000 MILES I GET THE SAME ISSUE BUT MITSUBISHI DOSE NOT WANNA BE RESPOSIBLE FOR A REPLACE ENGINE TO WHICH THEY REPLACE.