Loading vehicle data from NHTSA...
NHTSA recalls, safety ratings, and consumer complaints for the 2006 Lincoln Zephyr.
| Trim | City | Hwy | Combined | Annual fuel $ |
|---|---|---|---|---|
| 3.0L 6 cyl Automatic 6-spd | 17 | 26 | 20 | $3,000 |
| Overall Rating | Not Rated |
| Frontal Crash | Not Rated |
| Side Crash | Not Rated |
| Rollover | Not Rated |
Component: AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE
Ford Motor Company (Ford) is recalling certain 2007-2011 Ranger, 2006-2012 Fusion, Lincoln Zephyr, Lincoln MKZ, 2006-2011 Mercury Milan, 2007-2010 Ford Edge, and Lincoln MKX vehicles. The driver's side air bag inflator may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will replace the driver-side airbag inflator or module with an alternate one, free of charge. Owner notification letters were mailed on April 9, 2021 for the passenger side, and November 14, 2022 for the driver side. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S12.
Component: SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE
Ford Motor Company (Ford) is recalling certain 2006-2010 Ford Fusion, Mercury Milan, Lincoln Zephyr and MKZ vehicles. The valves within the ABS Hydraulic Control Units (HCU) may react with brake fluids containing specific corrosion preventative additives. This reaction may cause the valves to not close properly.
Consequence: If the valves do not properly close, additional brake pedal travel may be required to stop the vehicle, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will flush the brake system with DOT 4 fluid and install a new brake fluid reservoir cap. In addition, the HCU will be tested to detect a possible stuck valve condition, replacing the HCU as necessary. All services will be performed free of charge. The recall began April 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S54.
I tool my car in for a recall, they said they could not fix the recall cux it was too rusted. They said the wouldn't even put it on a lift cuz of the rust, however it was just on a lift a week ago at an auto shop. Also when I dropped off my car the air conditioner blower worked, I go to pick it up and turn it on and nothing, I call and ask and they tell me they only touched the steering wheel, I said to him then why was power cux to my vehicle? You didn't disconnect the battery or anything he said no, however when I left the car with then it was on 9.83 fm radio and when I got it back it was on a 500 station from am radio. So I know power was cut somehow. I need to know what to do. I can't keep driving with my brakes like this.
The airbag sensor light is indicating a sensor needs replacement. I have replaced airbags on both the driver and passenger side due to recall. Diagnostics state it is the sensor, passenger side. I have attempted to have repaired, and after 5 weeks and 4 mechanics, no one can seem to get the new sensor to connect to the system and work properly. I did not have a vehicle for weeks! PLEASE HELP!
The contact owns a 2006 Lincoln Zephyr. The contact received notification of NHTSA Campaign Number: 19V904000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
The 2006 Lincoln Zephyr has 5 NHTSA recalls and 229 consumer complaints on file. It received an overall safety rating of Not Rated out of 5 stars in NHTSA crash testing. The high number of complaints suggests potential reliability concerns — review the complaint details above before purchasing. For the most detailed information about a specific vehicle, decode its VIN using our free decoder above.
Enter a specific VIN to get the full report — specs, recalls, safety ratings, complaints, investigations, and technical service bulletins.
Component: AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE
Ford Motor Company (Ford) is recalling certain 2012 Ford Fusion and Mustang and Lincoln Zephyr and MKZ vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Ford is recalling certain 2009 Ford Ranger, Edge, Fusion and Mustang, Lincoln MKX, MKZ and Zephyr and Mercury Milan vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia and West Virginia, or "Zone B." Additionally, unless included in "Zone A" or "Zone B" above, Ford is recalling certain 2007-2008 Ford Ranger, Edge and Lincoln MKX, 2006-2008 Ford Fusion, Mercury Milan, Lincoln Zephyr and MKZ, 2005-2008 Ford Mustang and 2005-2006 Ford GT vehicles originally sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin and Wyoming. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the repair has been performed. Ford will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. Interim letters informing owners of the recall and that parts are not yet available began mailing March 1, 2017. Owners will receive a second notice when remedy parts become available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S01.
Component: AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE
Ford Motor Company (Ford) is recalling certain model year 2007-2011 Ford Ranger vehicles, 2006-2011 Ford Fusion, Mercury Milan and Lincoln Zephyr/MKZ vehicles, 2007-2010 Ford Edge, Lincoln MKX vehicles, 2005-2006 Ford GT vehicles, and 2005-2011 Ford Mustang vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Ford is recalling certain model year 2007-2008 Ford Ranger, Edge and Lincoln MKX vehicles, 2006-2008 Ford Fusion, Mercury Milan and Lincoln Zephyr/MKZ vehicles, 2005-2006 Ford GT vehicles and 2005-2008 Ford Mustang vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Any vehicle not included in "Zone A", or "Zone B" is not included in the safety recall. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the repair has been performed. Ford will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. Ford mailed interim letters informing owners that parts are not yet available on July 15, 2016. Owners will receive a second notice when remedy parts become available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S01.
Component: EQUIPMENT
Ford Motor Company (Ford) is recalling certain all weather driver side accessory floor mats sold for use in model year 2006-2011 Ford Fusion and Mercury Milan, 2006 Lincoln Zephyr, and 2007-2011 Lincoln MKZ vehicles manufactured November 9, 2007, through October 31, 2010. The affected floor mats may move and possibly interfere with the accelerator pedal.
Consequence: The floor mat could shift such that it could interfere with the accelerator pedal, preventing its return to an idle position, which could result in unintended vehicle speeds, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will install new replacement mats, free of charge. The recall began in July 2014. Owners may contact Ford's customer service at 1-800-392-3673. Ford's number for this recall is 14S07. NOTE: Vehicles built after October 31, 2010, while potentially equipped with the same floor mats, are equipped with a Brake Over Accelerator (BOA) feature that prevents simultaneous accelerator and brake application, allowing the vehicle to be safely stopped by pressing firmly and steadily on the brake pedal.
The contact owns a 2006 Lincoln Zephyr. The contact stated that while driving approximately 10 mph and making a turn, an unknown truck crashed head-on into the vehicle. There were no warning indicator lights illuminated. The vehicle was able to be driven after the crash. A police report was filed. The contact sustained injuries to his tongue and neck but medical attention was not provided. There were no reported fire or air bag deployments. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted.The contact received notification of NHTSA Campaign Number: 21V158000 ( Air bags) after the failure. The approximate failure mileage was 75,000.
The contact owned a 2006 Lincoln Zephyr. The contact received notification NHTSA Campaign Number: 21V158000 (Air Bags) and would like to be removed from the recall distribution list as he no longer owns the vehicle. The local dealer and manufacturer were not contacted.
The contact owns a 2006 Lincoln Zephyr. The contact received notification of NHTSA campaign number: 19V904000 (Service Brakes, Hydraulic). The vehicle was then taken to a local dealer where it was diagnosed with the brake caliper needing to be replaced. The dealer informed the contact that unless the caliper was fixed, the recall repair would not be performed. The vehicle was not repaired. The manufacturer had been informed of the failure but provided no further assistance. The failure mileage was approximately 38,000.
on May 17, 2021 I was involved in a wreck which the airbags did not deploy after impact. There is a police report and an insurance claim pending on the wreck.
ON APRIL 21, 2021 I TOOK MY CAR TO BOB THOMAS LINCOLN, 310 W COLISEUM BLVD, FORT WAYNE, INDIANA 46805 PHONE (260) 482-9876 INVOICE# 687347 FOR NHTSA SAFETY RECALL 19V-904 WHICH CALLS FOR THE BRAKE SYSTEM TO BE PRESSURE FLUSHED WITH DOT 4 BRAKE FLUID, THIS DID NOT HAPPEN AS WHEN WE GOT THE CAR BACK THE BRAKE SYSTEM RESERVOIR WAS OVER FILLED AND THE BRAKE FLUID WAS VERY RUST COLORED WITH NUMEROUS BLACK PARTICLES SUSPENDED IN THE FLUID NOT THE CLEAR OR TRANSLUCENT FLUID THAT WOULD INDICATE THE FLUID HAD BEEN PRESSURE FLUSHED, I CALLED BOB THOMAS LINCOLN AND GOT THE BIG RUN AROUND.
DASHBOARD ON VEHICLE IS WARPED DEFROSTER VENT IS OUT WINDSHIELD DOES NOT DEFROST PROPERLY OBSTRUCTS VISION WHILE DRIVING
MANUFAC RECALL #19S54 NHTA RECCALL #19V904 MASTER CYLINDER VALVE. MY VEHICLE HAS NOT BEEN REPAIRED YET AND FIRST INFORMATION WAS THAT IT WAS EXPECTED TO BE DONE IN LATE 2020 NOW 3RD MONTH IN2021. WHAT IS THE TIME FRAME FOR REPAIRS AT THIS DATE. IS THERE PROGRESS BEING MADE? AT THIS TIME BRAKES ARE WORKING OK
I HAVE AN EMAIL SAYING MY CAR HAS A POSSIBLE DRIVER AIR BAG DEFECT.GIVE MORE INFORMATION PLEASE
I CAME TO A STOP ON THE SIDE OF A GROCERY STOREAND APPLIED THE BRAKE BEFORE TURNING THE CAR OFF. THE NEXT THING I K NEW THE CAR WAS HEADED TOWARD WALL. THE CAR HIT THE WALL B WITH FORCE THAT EMPLOYED MY AIR BAG.AND DAMAGED THE FRONT OF MY CAR. THIS IS NOT THE ONLY INCIDENT I HAVE HAD WITH THE BRAKES . I ALWAYS TRY TO DRIVE A CAR LENGTH FROM THE CAR IN FRONT OF ME FOR FEAR OF THE BRAKES MALFUNCTING....
I HAVE AN AIRBAG LIGHT THAT COMES ON IN THIS CAR, THERE IS SUPPOSED TO BE EXTENDED COVERAGE FROM WHEN THEY REPLACED IT THE FIRST TIME UNDER WARRANTY FOR 1ST RECALL, DEALER TRYING TO SAY I MIGHT HAVE TO PAY TO DIAG IT BECAUSE IT COULD BE UNRELATED, BUT ALSO I JUST READ AN ARTICLE DATED 1/22/2021 STATING THERE IS ANOTHER AIRBAG RECALL FOR 2006 ZEPYHR BUT MY VIN ISNT SHOWING UP. HTTPS://WWW.CARANDDRIVER.COM/NEWS/A35283747/FORD-AIRBAG-RECALL-3-MILLION/
THE CAR HAS 82,000 MILES ON IT. THE THROTTLE POSITION SENSOR SEEMS TO BE ACTING UP. AFTER RESEARCHING THIS ISSUE ON THE NET, IT APPEARS THIS HAS BEEN AN ISSUE SINCE 04 WITH FORDS. IN ADDITION, THEY ARE ON THE 3RD GENERATION SENSOR. I WAS DRIVING NORMAL SPEEDS, THEN THE WARNING LIGHT CAME ON, KILLING THE POWER TO THE ENGINE, PUT ME IN A PRECARIOUS SITUATION ON A 45 50 MILE AN HR ROAD. SINCE THIS KNOWN ISSUE SINCE 04, SEEMS LIKE FORD SHOULD REPLACE THIS. IT'S A 20 DOLLAR PART, RETAIL, BUT WITH THIS MOTOR, YOU HAVE TO BUY A TOTALLY REBUILT THROTTLE BODY FOR 200+. IT IS DANGEROUS BECAUSE IT CAN SLOW THE CAR RIGHT DOWN AS YOU ARE DRIVING. IF YOU SHUT THE MOTOR OFF, IT 'REPAIRS' ITSELF AND WORKS NORMALLY.
Showing 15 of 229 complaints