2021 Kia Forte

I am writing to report a serious safety concern involving my Kia vehicle. Shortly after getting an oil change, my car began making unusual noises and then suddenly stopped working in the middle of a busy intersection. This unexpected stall created a dangerous situation for both myself and other drivers. After having it towed to the dealership, it comes down to an engine malfunction which was not covered by my warranty since it just hit 70,000 miles. I have since learned that other Kia owners have experienced similar issues, and I am concerned this may be related to a larger defect or recall issue. I wanted to report this incident to ensure it is properly documented and investigated.

So i took my car to sands kia in surprise az about my seat belts. Both the front driver and passenger belts come unlatched while driving. They said out of warranty so i would have to pay or they will do nothing. This should be a Kia issue. Obviously a defect in the seat belts. I can be driving on freeway and multiple times they will come unlatched while driving. So instead of having both hands on the steering will. I have to fiddle around to get it to latch again. It is a legal requirement to have working seat belts and u feel kia should fix this issue. I told them this and that i didn't feel this was something i should have to pay for and the service writer just asked me if i was leaving then. Hope there is no accident because seat belts won't work and there will be a lawsuit.

2021 Kia Forte VIN# [XXX] 107,000 miles While driving my Kia Forte on [XXX] i experienced a sudden noise without warning just 2 months to the exact date after an oil change. The vehicle became unsafe to operate and could not accelerate properly. In some cases it would no have it would feel like it was losing power and creating a scary and dangerous situation. A certified mechanic diagnosed there was no oil in my vehicle which matches the oil consumption defect identified in Kia's Theta II GDI engine recalls and nationwide class action settlement. Kia has acknowledged in public filing that is defect poses a risk of engine seizing and fire. Although my VIN is not currently listed under any active recall, my vehicle exhibits the exact same defect pattern as recalled vehicles, including sudden loss of power at highway speeds which is a significant safety hazard. Manufactures Response: I contacted Kia Corporate to request an engine replacement consistent with the recall and the settlement remedies and they refused to cover the repair solely because my VIN is not included in the recall list despite the defect being identical. Safety Concern: The sudden loss of power creates a risk of rear-end collisions, loss of control and potential fire. This defect can be life threatening and should not be excluded from recall coverage simply due to VIN range. Requested Action: I am requesting that NHTSA investigate why vehicles with identical engine defects, including mine have been excluded from recall coverage and compel Kia to provide a no-cost repair. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My 2021 Kia forte GT is currently sitting in my driveway, undriveable. It started about 3months or so ago I had realized I was getting more and more frequent oil changes to the point where the car would be consuming a quart of oil in at least a week or less. Fast forward to this previous week, I now had a hard knock/rattle within my engine. The engine gave way on my way home which is a significant safety issue to myself and those who were driving around me. I have contacted Kia customer as they have had previous complaints as well as a lawsuit on the engine for the excessive engine oil consumption leading to possible engine failure. There’s no reason why an only 4 year old car should have a blown motor. I am thankful that I am personally ok and didn’t hurt anyone else while in the midst of driving my vehicle home.

HVAC blower motor connector got so hot it has melted the plactic

The contact owns a 2021 Kia Forte. The contact stated while driving 65 MPH, there was an abnormal rattling sound coming from the engine compartment before the vehicle lost motive power. There was no warning light illuminated. The vehicle was towed to the dealer, where it was diagnosed and determined that the cylinders and pistons had failed, and the engine needed to be repaired or replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 93,532.

Transmission, yes it’s available. I was driving on the highway and the vehicle began jerking and revving, slowing down and then speeding up. It is at a service center now. Now lamps

Component/System Involved: Electric Power Steering (EPS) – specifically, a potential malfunction with the assist motor response timing. Description of Incident: While driving, primarily on the highway, I have experienced a recurring issue with the power steering system. The steering assist appears to delay activation after periods of inactivity—such as when driving straight. When I attempt a small correction (even a movement as small as 1/16 of an inch), there is unusually high resistance, followed by a sudden release. This results in an overcorrection and can create a cycle of steering instability as the same pattern repeats with each correction. Safety Risk: This malfunction poses a safety risk because the delay in steering assist and sudden release can lead to unintended sharp corrections or lane drifting, especially at highway speeds. The issue requires both hands on the wheel to maintain control, and the unpredictable nature of the steering increases the chance of losing control or colliding with another vehicle. Warning Lamps/Symptoms Prior to Failure: There are no warning lights, error messages, or chimes preceding or accompanying the issue. Mileage & Vehicle Info: Several people seem to be having the same issue and it happens at different stages of the vehicles life, but no one seems to have found a solution or source of the problem.

On Saturday, March 1, 2025, I took my 2021 Kia Forte LXS for a routine oil change. I had NO PRIOR issues, warning lights or anything with my vehicle. The oil change was performed. I then drove my vehicle less than 20 miles, the vehicle would then not accelerate and started to bog down. I was able to get my vehicle off the major I-4 interstate, however eventually the vehicle then shut down. The vehicle now will still start however is making this terrible clicking noise. I have had video of the engine running looked at by several mechanics who states the engine is blown. I have contacted Kia who clearly has known engine issues on several of their Fortes however Kia continues to state since mine is not currently on recall, they are not taking responsibility. Kia know they have several recalls due to engine issues. I cannot get a mechanic to work on my vehicle due to the recalls as mechanics only want to put in brand new engines due to Kia engine recalls. A new engine will cost upwards of $10,000. Again, Kia knows and had several recalls with engine issues

The transmission went out while driving, entering the highway. It was intermittently missing a gear or slipping in about 2nd or 3rd gear. I first noticed it going about 40 mph and trying to accelerate to highway speeds. It was during a winter storm and other vehicles behind me had to brake unexpectedly. I wasn't sure if I felt for sure, so I continued to drive through many inclines and declines. The inclines became more difficult and the inability to maintain consistent speeds. I drove gently to the nearest Kia dealership which was in Salt Lake City about 60 miles away, where they informed me that I needed a new transmission. The car had about 75,000 miles on it and I bought it as a certified Pre-owned Kia with about 4,000 miles on it. The dealership plugged in the diagnostic code reader. But there were no codes detected. The service tech drove the car and felt the issue. A warranty representative inspected it about a week later. There were no warning lamps while I drove (mostly coasting downhill) from Rock Springs, WY. When I arrived to Salt Lake City, the triangle warning light came on. I drove about 10 more miles and the engine light came on. Almost all mileage has been on highways and at highways speeds as I commuted 75 miles each way for work on a turnpike between eastern Oklahoma and Fayetteville, Arkansas. There was little city driving. I lived in a small town. So, I had to travel state highways for most all errands (groceries, medical, etc.). There were no mechanical issues with the car ever until this.

Passenger air bag/seat belt goes off like someone is sitting in passenger seat but no one is. Have to do seat belt for the alert stops