Loading vehicle data from NHTSA...
NHTSA recalls, safety ratings, and consumer complaints for the 2012 Hyundai Sonata.
Component: ENGINE
Hyundai Motor America (Hyundai) is recalling certain 2011-2014 Sonata and 2013-2014 Santa Fe Sport vehicles previously repaired under recall numbers 15V-568 and 17V-226. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned, or improperly torqued during the engine replacement procedure, allowing fuel to leak from the pipe.
Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Hyundai will notify owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began March 1, 2019. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's recall number for this recall is 180.
Component: SEAT BELTS:PRETENSIONER
Hyundai Motor America (Hyundai) is recalling certain 2011-2014 Sonata and 2011-2015 Sonata Hybrid vehicles previously repaired under recall campaign 17V-152. The seat belt linkages for both front seat belts may detach from the seat belt anchor pretensioners.
Consequence: If the seat belt linkage detaches from the seat belt anchorage, it can not properly restrain the occupant in the event of a crash, increasing the risk of injury.
Remedy: Hyundai will notify owners, and dealers will again verify the connection between the seat belt linkage and the pretensioner and additionally install a warning label to prevent future seat belt linkage detachment, free of charge. The recall began November 6, 2017. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 169.
Component: SEAT BELTS:PRETENSIONER
Hyundai Motor America (Hyundai) is recalling certain 2011-2013 Sonata and 2011-2012 Sonata Hybrid vehicles. On February 27, 2018, Hyundai Motor Company (Hyundai) notified NHTSA that they were recalling 154,753 model year 2011 Sonata vehicles. On April 18, 2018, Hyundai expanded the recall to include an additional 425,305 model year 2012-2013 Sonata and 2011-2012 Sonata Hybrid vehicles. In the event of a crash, the air bag control unit (ACU) may short circuit, preventing the frontal air bags, seat belt pretensioners, and side air bags from deploying.
Consequence: If the frontal air bags, seat belt pretensioners, and side air bags are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.
Remedy: Hyundai will notify owners, and dealers will install an external wire filter kit, free of charge. The recall began October 15, 2018. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 174.
Component: SEAT BELTS:FRONT:ANCHORAGE
Hyundai Motor America (Hyundai) is recalling certain 2011-2014 Sonata and 2011-2015 Sonata Hybrid vehicles. In the affected vehicles, the seat belt linkages for both front seat belts may detach from the seat belt anchor pretensioners.
Consequence: In the event of a crash, if the seat belts detach from the anchor pretensioners, it can increase the risk of injury.
Remedy: Hyundai will notify owners and dealers will inspect the connection between the seat belt linkages and the seat belt anchor pretensioners, repairing them as necessary, free of charge. The recall is expected to begin April 7, 2017. Owner's may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for the recall is 160.
Component: EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH
Hyundai Motor America (Hyundai) is recalling certain model 2011-2012 Sonata vehicles. The brake pedal stopper pad can deteriorate allowing the brake light switch plunger to remain extended when the brake pedal is released.
Consequence: If the brake light switch plunger does not retract as it should when the brake pedal is not being pressed, the brake lights may stay illuminated preventing accurate communication to rearward following vehicles that the vehicle is slowing or stopping. Additionally, if the brake switch plunger is not retracted, then the transmission can be shifted out of PARK without depressing the brake pedal. Either condition increases the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will replace the brake pedal stopper pad with an improved part, free of charge. The recall began on January 6, 2016. Owners may contact Hyundai customer service at 1-855-671-3059. Hyundai's number for this recall is 136.
Component: ENGINE
Hyundai Motor America (Hyundai) is recalling certain model year 2011-2012 Sonata vehicles manufactured December 11, 2009, to April 12, 2012 at Hyundai Motor Manufacturing Alabama and equipped with either a 2.0 liter or 2.4 liter Gasoline Direct injection engine. In the affected vehicles, metallic debris may not have been fully removed during manufacturing of the engine crankshaft. If the debris was not completely removed, oil flow may be restricted through the connecting rod bearings, causing connecting rod damage. A worn connecting rod bearing will produce a metallic, cyclic knocking noise from the engine and possible engine failure.
Consequence: Engine failure would result in a vehicle stall, increasing the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will inspect the vehicles and replace the engine assembly, as necessary, free of charge. Additionally, Hyundai Motor America will increase the warranty for the engine sub-assembly (short block) to 10 years/120,000 miles for both original and subsequent owners of 2011 and 2012 Sonatas manufactured at Hyundai Motor Manufacturing Alabama equipped with 2.0 liter and 2.4 liter Gasoline Direct injection engines. Interim notifications were mailed to owners starting on October 8, 2015. A second notification will be mailed when parts are available. Owners may contact Hyundai customer service at 1-855-671-3059 or by visiting www.HyundaiUSA.com/Campaign132. Hyundai's number for this recall is 132.
Component: POWER TRAIN:AUTOMATIC TRANSMISSION
Hyundai Motor Company (Hyundai) is recalling certain model year 2011-2014 Sonata vehicles manufactured December 11, 2009, through May 29, 2014. In the affected vehicles, the transmission shift cable may detach from from the shift lever pin.
Consequence: If the transmission shift cable detaches, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver parks the vehicle, despite selecting the 'PARK' position, the transmission may not be in 'PARK.' If the vehicle is not in the 'PARK' position and the parking brake is not applied, there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Hyundai will notify owners, and dealers will inspect and, as necessary, repair the connection between the shift cable and shift lever, free of charge. The recall began in September 2014. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 123.
Component: AIR BAGS:SIDE/WINDOW
Hyundai is recalling certain model year 2012-2013 Hyundai Sonata passenger cars, manufactured from January 24, 2012, through June 21, 2012. The curtain side airbags on these vehicles may inflate without deployment command due to an error during manufacturing.
Consequence: The curtain airbag may inflate without deployment command and increase the risk of injury to occupants of the vehicle. Additionally, an unexpected deployment would be a significant driver distraction and would limit the driver's visibility, increasing the risk of a crash.
Remedy: Hyundai dealers will notify owners, and dealers will replace the curtain side airbags free of charge. This recall began on August 31, 2012. Owners may contact Hyundai at 1-800-633-5151.
Vehicle: 2012 Hyundai Sonata Incident Date: August 14, 2024 Location: [XXX] Description of the Problem: The vehicle experienced a sudden and catastrophic fire without warning while in normal use. There were no prior warning lights, messages, or symptoms before the incident. The failure appears to have originated from the electrical system and/or engine (exact cause UNKNOWN), which resulted in the vehicle igniting unexpectedly. Safety Risk: This failure created an immediate and life-threatening safety hazard to all occupants. The vehicle caught fire suddenly, leaving no time to react or prevent injury. There was no crash or external cause associated with this fire. The incident required emergency response from Butts County Fire and Emergency Services, who generated an official report. Injuries and Trauma: My son suffered burn injuries to his fingers, requiring emergency medical treatment. There is neurological damage to the fingertips, indicating lasting physical injury. In addition, my son experienced significant psychological trauma due to sudden exposure to a life-threatening vehicle fire, including acute emotional distress during the incident and ongoing fear associated with vehicle safety. This demonstrates the extreme danger posed by a sudden, unpreventable vehicle fire. Inspection / Confirmation: The incident was documented by Butts County Fire and Emergency Services. At this time, manufacturer inspection is UNKNOWN, dealer inspection is UNKNOWN, and insurance inspection is UNKNOWN. Warning Signs Prior to Failure: There were no warning lights, messages, or symptoms prior to the fire. The failure occurred suddenly and without notice. Defect Pattern Concern: This incident is consistent with known issues involving Hyundai Sonata vehicles, including engine and electrical system failures and reports of vehicle fires. This complaint is submitted to request a formal investigation. Prior Hyundai fire defects reported for this model. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
I purchased a used 2012 Hyundai Sonata. Within about 2 weeks it broke down while I was in the far left lane of the freeway. The car suddenly stopped accelerating and made a very loud knocking noise. Thankfully I was able to put on my hazards and make it to the right shoulder without getting into an accident but as soon as I pulled over it shut off and the panel lights all came on. Evidently there was a recall on an engine rod and the previous owners advised they were not aware of it. Hyundai has declined the repair on the recalled engine several times and their reasons keep changing. First they said I was missing records (admittedly I was missing one record but then provided it to them), then they stated excessive neglect due to the condition of the valve train (I saw pics of the valve train and is in good condition), and now they state because the KSDS wasn't installed. From what I understand, being the second owner, if I can prove the upkeep of the vehicle the extended waranty should cover the repair. I even have the letter from the car mechanic stating the vehicle was maintained and in good condition. It seems a lot of good people are getting declined for repairs on these faulty engines. I have many more documents I could provide showing all of the services done and communications with the company. Due to the size limit I included these ones for your review. Thank you so much for any help you can provide.
The 2012 Hyundai Sonata has 8 NHTSA recalls and 1542 consumer complaints on file. The high number of complaints suggests potential reliability concerns — review the complaint details above before purchasing. For the most detailed information about a specific vehicle, decode its VIN using our free decoder above.
Enter a specific VIN to get the full report — specs, recalls, safety ratings, complaints, investigations, and technical service bulletins.
The airbag warning light came on, so we took it in to see about a recall on the airbag control unit issue that required a wire filter kit as out lined in a recall in 2011-2013 Sonatas and Sonata Hybrids. In fact, upon reading the invoice filling out this form, I think that is exactly the issue, and Potamkin Hyundai is ignoring the recall. The invoice states that "AIRBAG MODULE NEED FIXING caused by the DTC for the driver airbag resistance is too high, and has liquid leaking out of it through the connector into the clock spring, and need to replace the air bag incongruent with clock spring to perform repair correctly" The technician explained to my son that driving the car in it's current state, the air bag could go off at any moment, possibly killing him. Their airbag could kill my child. The repair is quoted at $1588 and the solution was to turn off the airbag until a decision could be made if my son wanted to drive the car home, which he did, so not it is disabled. It is a Hyundai manufactured airbag, a safety feature installed into this vehicle that should not degrade over time. It is actually the reason my aunt bought the car for her child and why my son bought the car from her. The car has never been wrecked, the airbag had never been deployed or otherwise molested, has been dealer maintained, and had an extended warranty. I spoke to a Hyundai representative and am awaiting a call back, I do not think that he should be responsible for repair of a defective, degrading safety feature built and manufactured by Hyundai, installed a vehicle built and manufactured by Hyundai. I believe other people should be warned that their Sonata airbags might also have this dangerous issue and it should be immediately investigated. Attached is the invoice given to my son.
While driving, the vehicle experienced sudden engine malfunction. The car entered limp mode, lost power, and produced a loud knocking noise from the engine. The failure occurred without warning and created a safety risk because the vehicle could not accelerate properly in traffic. This increased the risk of being rear-ended or unable to move out of dangerous situations. The issue appears to involve the engine (possible internal failure). The vehicle is currently at an authorized dealership and is available for inspection upon request. The problem has been confirmed by the dealership during inspection. The vehicle has been under diagnosis for over three weeks. There were no prior major warning signs before the failure. At the time of the incident, the vehicle suddenly lost performance, entered limp mode, and began making abnormal engine noise. This issue is consistent with widely reported engine defects in similar vehicles. Despite this, the manufacturer has denied coverage and attributed the issue to maintenance, even though regular maintenance was performed. This is a serious safety concern due to sudden loss of power while driving.
While I was driving my car wouldn’t go no higher than 60mph and kept dropping speed but I came to a stop and when I stopped the car was smoking. I heard knocking noise and rumbling noise on the passenger side. It wouldn’t start again
Painting chipping on front top car... Seatbelt don't fasten all the time...Lights are dim.
The warning light for the airbags is on on my dashboard with no airbags ever been deployed.
Odometer Fraud. The contact purchased a 2012 Hyundai Sonata. It was discovered that there was a mileage discrepancy after the purchase. The vehicle was a private sale. The contact stated that the mileage on the title was discovered to be 98,000. At the time of purchase, the vehicle mileage was 99,000; however, a Carfax Report indicated that the mileage was 237,532.
My 2012 Hyundai Sonata recently had an engine replacement completed under a Hyundai recall. Immediately after the recall repair, the vehicle began shaking while driving, produced a burning smell, and the air conditioning stopped working, none of which occurred prior to the recall repair. These symptoms started immediately after the engine replacement, indicating a possible improper or unsafe installation. I believe the vehicle is unsafe to drive due to the burning smell and shaking. I contacted Hyundai Customer Service and was told the issue must be resolved with the dealership. However, the dealership has refused timely inspection, has dismissed my safety concerns, and has declined to provide a rental or loaner vehicle, leaving me without safe transportation. This is a post-recall safety issue, and I am concerned about the risk of fire or mechanical failure due to the burning smell and vehicle instability. I am requesting this issue be formally investigated.
The contact owns a 2012 Hyundai Sonata. The contact stated while driving 70 MPH, the check brake and "Hybrid System Warning Safely Stop - Do Not Drive" messages were displayed on the instrument panel, and the vehicle went into LIMP Mode. The vehicle was towed to the residence, and the contact replaced the hydraulic pressure units and hydraulic unit assemblies (HECU/ABS modules). The contact stated that after the repairs, the failure returned approximately 30,000 miles later. The dealer was notified of the failure, and the contact was provided with an estimate for the repair. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 130,000.
Unknown, my ESP KEEPS Coming trying to see if it’s recall
The contact owns a 2012 Hyundai Sonata. The contact stated that the vehicle was experiencing excessive oil consumption, which required the oil reservoir to be refilled after 3-4 weeks. Additionally, there was no warning light illuminated. The contact stated that upon taking the vehicle to Jiffy Lube for a top off, the mechanic would inform the contact that the oil reservoir was empty and needed to be refilled. The vehicle was not taken to the dealer. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 158,000.
The vehicle dashboard is severely cracked. It doesn’t appear to be from wear and tear.
The contact owned a 2012 Hyundai Sonata. The contact stated that while driving to her residence at unknown speeds, the vehicle suddenly caught fire while making a U-turn. The brakes and emergency brake were inoperable. The seatbelt was inoperable. The driver jumped out of the window. A pedestrian attempted to alert her of the fire. The vehicle exploded after exiting the vehicle. The contact sustained an injury to her leg, but no medical attention was provided. The fire department extinguished the fire. A police report was filed. There was no report of a crash or airbag deployment. The vehicle was towed to a tow lot. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 136,000. The vehicle was auctioned off by the towing company.
Based on what I experienced, the fire appears to have resulted from an internal mechanical or electrical failure that occurred without warning while the vehicle was in motion. No prior issues or dashboard alerts were present at the time, and there was no external impact or damage that could explain the fire.
Showing 15 of 1542 complaints