Loading vehicle data from NHTSA...
NHTSA recalls, safety ratings, and consumer complaints for the 2004 Hyundai Santa FE.
| Overall Rating | Not Rated |
| Frontal Crash | Not Rated |
| Side Crash | Not Rated |
| Rollover | Not Rated |
Component: SUSPENSION:FRONT:SPRINGS:COIL SPRINGS
Hyundai Motor Company (Hyundai) is recalling certain model Year 2001-2006 Santa Fe vehicles manufactured from March 31, 2000, through February 15, 2006, that are registered and operated, or which were originally sold and registered, in the following 20 salt belt" states and the District of Columbia: Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, and Wisconsin. The affected vehicles may experience front coil spring corrosion from road salt, causing the coil spring to fracture and make contact with the tire.
Consequence: If the front coil spring fractures due to corrosion it could cause the coil spring to make contact with the tire, possibly puncturing the tire and increasing the risk of a vehicle crash.
Remedy: Hyundai will notify owners, and dealers will inspect and if necessary replace the coil spring, free of charge. The recall began on October 24, 2014. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 124.
Component: EQUIPMENT:OTHER:LABELS
CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
Consequence: THE TIRE PRESSURE LABELS DO NOT CONTAIN THE INFORMATION REQUIRED BY THE STANDARD.
Remedy: OWNERS WILL BE PROVIDED WITH A CORRECT LABEL AND INSTALLATION INSTRUCTIONS. OWNER NOTIFICATION BEGAN ON OCTOBER 29, 2003. OWNERS SHOULD CONTACT HYUNDAI AT 1-800-633-5151.
The contact owns a 2004 Hyundai Santa Fe. The contact stated that on six separate occasions, the vehicle had independently accelerated without warning. On one occasion, the vehicle had accelerated through a red light with the brake pedal depressed to the floorboard. On a separate occasion, the vehicle accelerated through the contact's garage door upon entering the driveway. The air bags did not deploy and no injuries were reported. A police report was not filed; the garage door was replaced after the crash. The vehicle was taken to an independent mechanic who could not determine the cause of the failure. The manufacturer had yet to be notified of the failure. The vehicle had yet to be repaired. The failure mileage was approximately 37,000
In transit, it began smoking and the engine light came on. After pulling to the side, flames erupted and it became fully engulfed, followed by a small explosion. The vehicle and it’s contents were a total loss.
The contact owned a 2004 Hyundai Santa Fe. The contact stated that while the son was driving approximately 25 MPH the braking system malfunctioned and when depressing the brake pedal the vehicle did not reduce speed or stop causing the vehicle to crash into the rear of a second vehicle. During the crash, the rear driver-side passenger sustained a lacerated bottom lip and dental and oral injuries. A police report was taken at the scene and the vehicle was towed and later deemed destroyed by the insurance company. The cause of the failure was not determined. The manufacturer was notified of the failure. The local dealer was not contacted. The contact indicated that the vehicle was previously serviced for the same failure by the local mechanic. No further information was available. The failure mileage was 150,000.
The 2004 Hyundai Santa FE has 3 NHTSA recalls and 303 consumer complaints on file. It received an overall safety rating of Not Rated out of 5 stars in NHTSA crash testing. The high number of complaints suggests potential reliability concerns — review the complaint details above before purchasing. For the most detailed information about a specific vehicle, decode its VIN using our free decoder above.
Enter a specific VIN to get the full report — specs, recalls, safety ratings, complaints, investigations, and technical service bulletins.
Component: SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 3.5 LITER V-6 ENGINES, 4-WHEEL DRIVE AND ANTILOCK BRAKING SYSTEMS (ABS), IF THE BRAKE PEDAL IS DEPRESSED AT SPEEDS BETWEEN 3 AND 12 MPH WHEN THE BRAKE PAD FRICTION SURFACES ARE WET, A VIBRATION MAY OCCUR BETWEEN THE BRAKE DISCS AND PADS CAUSING ABS SENSOR ELECTRONIC SIGNAL NOISE TO DEVELOP. AT SPEEDS BELOW 5 MPH, THE ABS SENSOR SIGNAL NOISE MAY CAUSE THE ABS ELECTRONIC CONTROL UNIT (ECU) TO ACTIVATE THE ABS, EXTENDING THE STOPPING DISTANCE.
Consequence: IF AN EXTENDED STOPPING DISTANCE OCCURS, IT COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPROGRAM THE ABS ECU. OWNER NOTIFICATION BEGAN ON MARCH 24, 2004. OWNERS SHOULD CONTACT HYUNDAI AT 1-800-633-5151.
driving in the rain hit brakes they locked up
This was a recall for hundai santa fe vehicles from 2001-2006. For unknown reasons I was not aware of recall. It was for 15 years or 150 miles. It is a danger as my car leaks gas. I am at 135,000 miles. But my car is a 2004. I purchased the vehicle in the last 2 years. I believe the recall should extend till the repair is complete for the reasons as follows. 1. it can explode. 2. it is a polluter 3. Hyundai acknowledges it as faulty equipment. 4. Corporations must be resonsible or they are irresponsible. 5. Cars are expensive they must maintain as least minimum safety requirements.
LAST NIGHT MY MOTHERS 2004 HYUNDAI SANTA FE CAUGHT FIRE THE CAR HAD BEEN PARKED FOR HOURS, THE KEYS WERE NOT IN THE CAR IT WAS COMPLETELY OFF. IT MADE ABSOLUTELY NO SINCE UNTILL I DONE SOME RESEARCH AND SEEN THE LAWSUIT FOR THIS SAME THING AND I WONDERED WHY THIS MODEL WAS NOT INCLUDED. I ALSO SEEN MULTIPLE PEOPLE WONDERING THE SAME THING ABOUT THEIR 2004 HYUNDAI SANTA FE. MY FATHER WAS THE ONLY ONE IAT THE HOUSE AND IN THE HOUSE HE COULD HAVE LOST HIS LIFE AND EVERYTHING THEY OWN THE ONLY WAY HE KNEW IT WAS ON FIRE WAS A NEIGHBOR SAW AND STARTED SCREAMING AND STARTED BACKING UP TO THE VEHICLE TO PULL IT AWAY FROM THE HOUSE A POLICE REPORT WAS MADE BUT WHAT IS SHE SUPPOSED TO DO FOR A VEHICLE? WHEN NO ONE EVEN STARTED THE FIRE.
I HAVE A 2004 HYUNDIA SANTA FE AND THE ENGINE STARTED WITH LOUD KNOCKING SOUNDS IN MY DRIVEWAY. I HAD IT TOLL TO AVONDALE EARNHARDT HYUNDIA'S DEALERSHIP. THE DIAGOSTIC WAS "FOUND ENGINE KNOCK CAN BE HEARD AT BOTTOM END OF ENGINE. FAILURE IN ROD BEARINGS IS CAUSING EXCESSIVE NOISE IN BOTTOM END. ENGINE REQUIRED" REPLACEMENT. THE CAR HAS 125,000 MILES WHICH EXCEEDS THE 100,000 POWERTRAIN WARRANTY. HOWEVER, MY ENGINE FAILURE IS THE SAME AS THE CURRENT "ENGINE FAILURE RECALLS (THETA II ENGINES) CAUSED BY MANUFACTURING PROCESSES. EXCEPT THE 2004 HYUNDIA SANTA FE WAS NOT INCLUDED ON THE RECALL LIST. I SPOKE AND SUBMITTED TWICE A COMPLIANT TO HYUNDIA CUSTOMER CARE DEPARTMENT TO REPLACE MY ENGINE AND WAS DENIED AN ENGINE REPLACEMENT. I HAVE BEEN WITHOUT A CAR SINCE NOVEMBER 20, 2020. TODAY, CUSTOMER CARE DEPARTMENT NOTIFIED ME BY PHONE OF THE SECOND REJECTION. I AM AN ELDERLY WOMAN AND RETIRED, SO FINANCES ARE LIMITED. I FEEL THAT THE ENGINE SHOULD BE REPLACED BECAUSE THAT THE "FAIR THING TO DO". THE ENGINE SHOULD NOT HAVE FAILED SO EARLY IN ITS LIFE-CYCLE. I WOULD APPRECIATE YOUR REVIEW AND A SOLUTION TO THIS PROBLEM. PERHAPS A RECALL ON MY VEHICLE.
TL* THE CONTACT OWNS A 2004 HYUNDAI SANTA FE. THE CONTACT STATED THAT WHILE DRIVING AT 70 MPH, THE SUNROOF DETACHED FROM THE VEHICLE WITHOUT WARNING. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED NOR REPAIRED. NEITHER THE DEALER NOR THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 119,000.
IT HAD 124 RECALL NHTSA 14V43500 I CALL HYUNDAI OFF GOVERNMENT SITE TOLD THEM ABOUT 124 AND BROKEN SPRING THEY SET UP APPOINTMENT SO THEY ONLY PUT ON BRACKETS BUT NO SPRING WANTED $1004 FOR THE STRUT SPRING ON THEY TOLD ME ON CALL CENTER THEY REPLACE SPRING AS IT SAID ON NHTSA SITE THEY WOULD NOT DO IT CALL BACK TO HYUNDIA AS NUMBER ON GOVERNMENT SITE THEY MADE A CASE NUMBER 16604156 AMBER AT 714 594 1764 SHE SAID SPRING WAS NOT IN RECALL I SEND PICTURE OF IT BEFORE UP THERE TO DEALER SHE HAD NO CLUE WHAT WAS SO I DONT WHO RIGHT ON RECALL SHE SAID GOVERNMENT NHTSA SITE ARE NOT CORRECT BROWN LEESBURG HYUNDAI LEESBURG VA 20176
BOUGHT AN USED 2004 SANTA FE IN AUGUST FROM A DEALER. TWO WEEKS AGO I STARTED NOTICING A STRONG SMELL OF GAS AROUND MY VEHICLE AND LAST WEEK I BEGAN SEEING A SMALL DISCOLORED AREA ON THE CEMENT IN THE GARAGE. MOM CHECKED MY VEHICLE AND FOUND THAT THE MY FUEL TANK IS LEAKING. THE DISCOLORATION OF THE CEMENT UNDER MY VEHICLE IS IN FACT LEAKING GAS. TANK IS CORRODED AND I WILL NEED A NEW TANK INSTALLED.
I JUST GOT IT A FEW MONTHS AGO AND HAPPENED TO LOOK UP RECALLS,AND SEEN 3 I TOOK IT TO A HYUNDAI DEALERSHIP AND THEY SAID THERE WERE JUST 2 BUT ONE WAS SUSPENSION AND THEY HAVEN'T CALLED ME ABOUT IT IN AROUND A MONTH NOWB
MY AIR SBAG LIGHT IS ALWAYS ON. IT WON'T TURN OFF.I DON'T IF IT IS A PROBLEM WITH MY AIR BAGS OR JUST THE LIGHT.IT HAS BEEN THIS WAY FOR YEARS.THERE WAS NOT REASON FOR IT TO TURN ON. I'VE NEVER HAD AN ACCIDENT,SO I DON'T IF IT WILL WORK WHEN NEEDED. I DON'T THINK I SHOULD FOR IT. I THINK THIS A MALFUNCTION AND SHOULD CHECKED BY A DEALER AT NO COST.
AIR BAG LIGHT KEEP ON THIS VEHICLE 15 YEARS OLD BRAKES ALSO NOT LIKE USE TO BE I AM OWN THIS SUV LAST 15 YEARS I NEED YOUR HELP AND SUPPORT I AM WORRY NEED TO BE FIXED FOE MY SAFETY [XXX] OWNER, C [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
VEHICLE WAS SOLD WITHOUT TITLE OR DISCLOSURE DEALERSHIP TOOK MONEY REFUSE TO HEAR COMPLAINTS. CONTACT ME AS I AM HANDICAPPED AND HAVE NO TITTLE TRYING TO RETURN VEHICLE IT VEERED TOWARD DITCH AS THE VEHICLE IS INOPERABLE AND DANGEROUS PER DMV
AIR BAG WARNING LIGHT WOULD COME ON DURING THE MORNING DRIVE THEN SHUT OFF NEXT TIME THE CAR WAS STARTED. ON/OFF PERODICALLY FOR ABOUT A WEEK. NOW THE AIR BAG WARNING LIGHT IS ON ALL THE TIME. A GLIMSPE ONLINE HINT SIMLAR OWNERS HAVEING THE SAME PROBLEM AND THEY ARE SAYING IT HAS SOMETHING TO DO WITH THE WIRING.
Showing 15 of 303 complaints